TECHNICAL MANUAL OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FOR

Transcription

1 *TM &P-17 TECHNICAL MANUAL OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FOR WATER PURIFICATION BARGES (NSN ) WORKBOAT, LIFESAVING AND FIREFIGHTING EQUIPMENT This technical manual is an authentication of the manufacturer's commercial literature and does not conform with the format and content requirements normally associated with the Army technical manuals. This technical manual does, however, contain all essential information required to operate and maintain the equipment DISTRIBUTION STATEMENT A: Approved for public release; distribution Is unlimited *This manual supersedes TM &P-17, 30 January HEADQUARTERS, DEPARTMENT OF THE ARMY 15 OCTOBER 1992

2 *TM &P-17 TECHNICAL MANUAL NO &P-17 HEADQUARTERS DEPARTMENT OF THE ARMY, WASHINGTON D.C., 15 OCTOBER 1992 TECHNICAL MANUAL OPERATORS', UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FOR WATER PURIFICATION BARGES (NSN ) WORKBOAT, LIFESAVING AND FIREFIGHTING EQUIPMENT REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form located in the back of this manual direct to: Commander, US Army Troop Support Command, ATTN: AMSTR-MMTS, 4300 Goodfellow Blvd., St. Louis, MO A reply will be furnished directly to you. Approved for public release; distribution is unlimited. * Supersedes TM &P-17, 30 January, 1989 A/(B BLANK)

3 TABLE OF CONTENTS CHAPTER 1 INTRODUCTION Purpose Scope Warranties and guarantees Maintenance forms and records Destruction of Army materiel to prevent enemy use Storage CHAPTER 2 WORKBOAT Section I. Description and data Purpose Description and components Capabilities Special limitations Performance characteristics Equipment specifications Items furnished Items required but not furnished Tools and test equipment Section II. Operating instructions Controls and indicators Searchlight Operator's electrical control panel Windshield wiper Boat horn Bilge pump switches and indicators Outboard drive controls Magnetic compass Steering pump filler Engine hourmeter Fuel gauge Volvo engine instrument panel Master switch Ignition/electrical switch Throttle and clutch controls Marine band VHF/FM radio Depthfinder controls and controls i

4 TABLE OF CONTENTS (Continued) Engine maintenance controls and indicators Prestart procedures Starting procedures Operating procedures Radio operations Depthfinder operations Workboat operations Emergency procedures General Fire prevention Firefighting techniques Running aground prevention Recovery procedures when aground Operations under unusual conditions General Being towed by another boat Towing another boat Shutdown procedures Deployment and recovery General Bow crane procedures Bow crane operating procedures Bow crane prestart procedures Workboat deployment procedures Workboat recovery procedures Bow crane shutdown procedures Operations under extreme conditions Operations in extreme heat Operations in high humidity conditions Operations in extreme cold Section III. Maintenance instructions Maintenance concept Preventive maintenance checks and services Troubleshooting Maintenance instructions ii

5 TABLE OF CONTENTS (Continued) Section IV. Storage Short-term storage Administrative storage Administrative storage procedures Administrative storage inspection Long-term storage Section V. Manufacturers' manuals/instructions General Section VI. Warranties/guarantees General CHAPTER 3 LIFESAVING EQUIPMENT Section I. Description and data Description Liferafts Lifevests Lifesaving ring buoys Capabilities Special limitations Performance characteristics Equipment specifications Items furnished Items required but not furnished Tools and test equipment Section II. Operating instructions Manual operation of eight-person liferaft Automatic deployment of eight-person liferaft Using life buoys Using lifevests Section III. Maintenance instructions General Maintenance concept Maintenance instructions Preventive maintenance checks and services iii

6 TABLE OF CONTENTS (Continued) Section IV. Storage Short-term storage Administrative storage Administrative storage procedures Long-term storage Section V. Warranties/guarantees General CHAPTER 4 FIREFIGHTING EQUIPMENT Section I. Description and data Description Halon 1301 system C02 hose/reel units Marine smoke detector system Portable fire extinguishers C02 fire extinguishers Dry chemical fire extinguishers Self-contained breathing apparatus (SCBA) Portable firefighting pump, PE Capabilities Halon 1301 system CO2 hose/reel units Marine smoke detector system Portable fire extinguishers Self-contained breathing apparatus (SCBA) Portable firefighting pump, PE Special limitations Halon 1301 system C02 system Marine smoke detector system Portable fire extinguishers Hazardous fumes and chemicals from fires iv

7 TABLE OF CONTENTS (Continued) Self-contained breathing apparatus (SCBA) Portable firefighting pump, PE Equipment specifications Halon 1301 system CO2 hose/reel unit Marine smoke detector system Portable fire extinguisher, CO Portable fire extinguisher, dry chemical Fireman's axe Self-contained breathing apparatus in carrying case Self-contained breathing apparatus (SCBA) Portable firefighting pump, PE Smoke detector alarm bell Items furnished Items required but not furnished Tools and test equipment Section II. Operating instructions Halon 1301 system C02 hose/reel units Marine smoke detector system Prestart procedures Normal operations Emergency procedures for smoke Emergency procedures for malfunctions Portable fire extinguishers General Dry chemical portable extinguishers CO2 portable extinguishers Self-contained breathing apparatus (SCBA) Preparing and putting on SCB Using SCBA Removing SCBA Portable firefighting pump, PE Recovery from fire Operations under extreme conditions v

8 TABLE OF CONTENTS (Continued) Section III. Maintenance instructions General Maintenance concept Maintenance instructions Preventive maintenance checks and services Troubleshooting Maintenance procedures Section IV. Storage Short-term storage Administrative storage Administrative storage procedures Long-term storage Section V. Manufacturers' service manuals/instructions General Section VI. Warranties/guarantees General LIST OF APPENDICES A REFERENCES... A-1 B MANUFACTURERS' SERVICE MANUALS/INSTRUCTIONS... B-1 C PREVENTIVE MAINTENANCE CHECKS AND SERVICES... C-1 NOTE The following appendices, common to all TM's in this series, are in TM &P-18. MAINTENANCE ALLOCATION CHART (MAC) TOOLS AND TEST EQUIPMENT LIST (TTEL) EXPENDABLE /DURABLE SUPPLIES AND MATERIALS LIST (ESML) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) REPAIR PARTS LIST TO FIGURE NUMBER CROSS-REFERENCE LIST NOTE The following appendices, common to all TM's in this series, are in TM &P-20. COMPONENTS OF END ITEM LIST (COEIL) AND BASIC ISSUE ITEMS LIST (BIILL) ADDITIONAL AUTHORIZED ITEMS LIST (AAL) vi

9 TABLE OF CONTENTS (Continued) TM &P-17 LIST OF ILLUSTRATIONS Figure 1-1 Major ROWPU Barge Components - Deckhouse Roof (Sheet 1 of 3) Major ROWPU Barge Components - Deckhouse (Sheet 2 of 3) Major ROWPU Barge Components - Voids (Sheet 3 of 3) Workboat Profile Location of Workboat Components Typical Workboat Operator Controls and Indicators Workboat Instrument Panel and Operating Controls Ignition/Electrical Switch Operating Positions VHF/FM Marine Radio Control Panel Depthfinder Controls and Indicators Engine Maintenance Controls and Indicators Messenger Line Reel Unit Bow Crane in Traveling (Stowed) Configuration Bow Crane Control Panel (Barges 2 and 3) Bow Crane Control Panel (Barge 1) Standard Military Hand Signals for Controlling Cranes Workboat Cradle Tie-Down with Ratchet Bow Crane Lifts Workboat with Three-Point Suspension Harness Location of Lifesaving Equipment Eight-Man Liferafts - Manual and Automatic Operation Location of Firefighting Equipment Halon 1301 System Weighing Bar Sketch of Halon Manifold Assembly CO2 Hose/Reel Units Front Panel of Marine Smoke Detector Cabinet Self-Contained Breathing Apparatus (SCBA) Portable Firefighting Pump, PE Halon System Remote Control Box Halon System Cylinder Activation Station Operation of CO2 Hose/Reel Unit vii

10 TABLE OF CONTENTS (Continued) LIST OF TABLES Figure 2-1 Frequency/Channel Chart for Commercial Marine Radio in USA viii

11 CHAPTER 1 INTRODUCTION 1-1 Purpose. This technical manual (TM) describes operation and maintenance of the workboat, lifesaving, and firefighting equipment for Water Purification Barges. Information on other systems onboard is in TM &P-1 thru P-16. TM &P-18 and TM &P-20 contain appendices common to all TM's. Location of major barge components is shown in Figure Scope. This information is discussed in each chapter providing information on that item. 1-3 Warranties and guarantees. Warranties and guarantees are listed in chapters pertaining to equipment covered by that warranty or guarantee. 1-4 Maintenance forms and records. These are explained in DA PAM , The Army Maintenance Management System (TAMMS). 1-5 Destruction of Army materiel to prevent enemy use. Perform as directed in TM Storage. For storage of this equipment, refer to chapter providing information on that item. 1-1

12 (Figure 1-1 Sheet 1 of 3) (Figure 1-1 Sheet 2 of 3) (Figure 1-1 Sheet 3 of 3) Figure 1-1. Major Components of ROWPU Barge Systems and Equipment - Deckhouse Roof (Sheet 1 of 3) 1-2