INSTRUCTIONS FOR OPERATION AND CARE OF

INSTRUCTIONS FOR OPERATION AND CARE OF LITTLE Therm Compact Thermaator Mode LT-4 P.O. Box 3527 City of Industry, CA, 91744-0527, U.S.A. 800-782-7706 626-968-6681 www.whitehamfg.com 6900-192-001 Division of Acorn Engineering Company Revised: October 2018

BEFORE CONNECTING, READ INSTRUCTIONS AVANT DE CONNECTER, LIRE LES INSTRUCTIONS!! FOR PROFESSIONAL USE ONLY CAUTION Grounding reiabiity can ony be achieved when the equipment is connected to an equivaent receptace marked Hospita Ony or Hospita Grade. Medica Equipment: With respect to eectric shock, fire and mechanica hazards ony in accordance with UL 60601-1 and CSA C22.2 No. 601.1 POUR USAGE PROFESSIONEL SUELEMENT ATTENTION La mise à terre ne fonctionne de facon efficace que si équipment est connecté à une prise marquee Hopita Seuement ou Categorie Hopita. Équipement Médica: Concernant es risques de chocs éectriques de feu et autres dangers mecaniques seuement conformément a UL 60601-1 et a CSA C22.2 No. 601.1 DANGER Risk of exposion if used in the presence of fammabe anesthetics DANGER Risque d exposion si utiisé en présence d anesthisques infammabes WARNING AVERTISSMENT REPLACE fuse as marked Outer Surface is Hot AVOID Proonged skin contact. AVOID resting objects on or against the tank. REMOVE a packaging, accessories and iterature from inside of unit prior to using. PROPERLY GROUND your unit. Pug unit into a Ground Faut Circuit Interrupter (GFCI) receptace for safety. Faiure to propery ground unit can increase the risk of ELECTRICAL SHOCK HAZARD! For patient protection, periodicay check the water temperature of this heating unit. The water temperature shoud not exceed 165ºF (74ºC). Use adequate toweing or terry cover, add extra towe ayers if heat is too intense for patient. Do not use with bams or iniments on patients with poor circuation or sensitive skin nor with patients ying on heat pack. Note: Infants and edery patients require specia care. REMPLACER es fusibes te qu indiqué La surface extérieure est chaude ÉVITER tout contact proongé avec a peau. ÉVITER de deposer des objets sur e reservoir ou de es appuyercontre ceui-ci. RETIRER tout embaage, accessoire et feuiet se trouvant à 'intérieur de votre nouve apparei avant de 'utiiser. EFFECTUER LA MISE À LA TERRE de votre apparei DE FAÇON APPROPRIÉE. Brancher 'apparei dans une prise à disjoncteur différentie de fuite à a terre (DDFT), ce qui offre une protection au cas où 'eau et a paraffine entreraient en contact avec 'éectricité. Si 'apparei n'est pas bien mis à a terre, cea augmente es RISQUES DE DÉCHARGES ÉLECTRIQUES! Afin de protéger e patient, vérfier réguiérement a température de 'eau decet apparei de chauffage. La température de 'eau ne doit pas dépasser 74 OC (165 OF) utiiser suffisamment de serviettes ou de tissus éponge. Ajouter des couches suppémentaires si a chaeur est trop intense pour e patient. Ne pas utiiser avec des baumes ou des iniments sur des patients ayant une mauvaise circuation ou une peau sensibe. Ni sur un patient couché sur un dispositif chauffant. Remarque: Les nourrissons et es patients àgés nécessitent des soins spéciaux. a Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Instructions for Operation and Care of Litte Therm Compact Thermaator Introduction... 2 Mode Descriptions... 2 Operating Skis and Training... 3 Inspecting the Thermaator... 3 Setting Up... 3 Fiing Your Unit... 4 Emptying Your Unit... 5 Using the Therma Pack... 6-8 Using the Wire Rack... 8 Maintenance... 9 Ceaning and Sanitizing... 9 Storage... 9 Troubeshooting... 10 Repair of Unit... 10 Parts Diagram and Parts List... 11 Schematic and Accessories... 12 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 1

Instructions for Operation and Care of Litte Therm Compact Thermaator Congratuations on receiving your compact Litte Therm Thermaator. Litte Therm is a simpe and troube-free unit to operate. The tank body, bottom and id are a made from type 304 stainess stee with a thermostat on the rear to contro the water temperature. Unit shoud be set for 165 F for norma operating temperature. Side handes and a knob on the id minimize contact with the hot surface. The unit has Therma Packs with coored tabs and an exposed heating eement with a conceaed temperature sensor. Unit rating is 120V, 8.3A, 50/60 Hz. White Tabs Therma Pack Wire Rack Back or Bue Tabs Lid Tank Body Indicator Light Hospita Grade Power Cord 2 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Skis: Instructions for Operation and Care of Litte Therm Compact Thermaator Operators using the Thermaator need a working knowedge of occupationa therapy procedures.! WARNING Ony trained personne to operate the Thermaator. Untrained operators can cause injury or be injured. OPERATOR SKILLS AND TRAINING This Whiteha product has been carefuy packaged at the factory to minimize the possibiity of damage during shipping. Inspect the packaging for externa signs of damage. Inspect the contents for damage. If there is visibe damage to the instrument upon receipt, inform the shipping company and Whiteha immediatey. TRAINING Operator trainees need to: be trained in occupationa therapy protocos. read and understand this manua. INSPECTING THE THERMALATOR! WARNING Do not attempt to operate this equipment if there is evidence of shipping damage or you suspect the unit is damaged. Damaged equipment may present additiona hazards to you. Contact Whiteha technica support for advice before attempting to pug in and operate damaged equipment. Inspection Checkist Is the Thermaator free of excessive wear? Is a propery-grounded and votage-matched receptace avaiabe? Is the outet equipped with a functioning GFI? 1. Your new Thermaator incudes the foowing: 1 Thermaator Mode LT-4 4 Therma Packs (4 Standard) 1 Wire Rack - Sma, Viny Coated 1 Rack Adapter 1 Thermostat Knob 1 Warranty Registration Card 1 Instructions for Operation and Care If you are missing anything, pease ca the phone number isted on the back page. 2. Unpacking your Thermaator Remove a the shipping materia. Remove Therma Packs and wire rack from inside the tank. Remove a packaging from inside the tank, especiay from under the heating eement inside the tank. Cean the unit thoroughy before using. 3. Device Pacement Pace the Thermaator at a convenient eve, such as on a tabe or a scratch resistant counter top. Before moving the Thermaator, unpug and coo the unit. Ony move the unit to empty or fi it. Aways use the handes. The unit may be hot to the touch. SETTING UP Avoid operating this unit in cose proximity of materias subject to damage from moisture. 4. Pre-Soaking Therma Packs Presoak therma packs (Critica, if not presoaked propery, the tank may deveop surface rust during use). Inspect the packs for any tears and damaged or oose threads before starting the presoak process. If packs are damaged, do not use. Before the first use, you must condition each Therma Pack. 1- Take the Therma Pack by the corner oops - one white and one bue or back - so the sections are horizonta. 2- Genty shake the pack back and forth to eveny distribute the fier materia. Shake to distribute the dry materia Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 3

Instructions for Operation and Care of Litte Therm Compact Thermaator 3- Pace the therma packs in a arge pastic, stainess stee or ename container (do not use auminum). DO NOT use the Thermaator for presoaking packs. 4- Fi the container with enough tap water to competey cover the Therma Packs. 5- Soak the packs for two hours minimum, more is recommended. If the presoak water turns coudy, change the presoak water and soak packs again. Repeat unti water is cear. 6- Turn packs to upright position. The packs are now ready to use. Turn the packs to upright as shown The Thermaator is to operate ony in ambient temperatures of 5ºC to 40ºC. Make sure the unit is unpugged and a packaging has been removed. FILLING YOUR UNIT 1 2 Fi unit about 3/4 fu with tap water. 3/4 3 4 Pace the wire rack inside the unit. Be carefu of the heating eement. Put the Pre-Soaked Therma Packs on the wire rack. Pace a the bue or white tabs up. 4 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Instructions for Operation and Care of Litte Therm Compact Thermaator 5 6 Add more water, if necessary, to cover the Therma Packs. Uncovered packs may be damaged during heating. Cose the id. Caution! Lid can pinch fingers. 7 Pug the power cord into an AC outet. A Ground Faut Circuit Interrupter is recommended because it wi give additiona protection from eectric shock. Facing the front of the unit, indicator ight shoud be iuminated showing that the unit is heating. AC 8 EMPTYING YOUR UNIT 1 Unpug the unit. 2 Let the water coo to room temperature. Remove the Therma Packs and the wire rack. Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 5

Instructions for Operation and Care of Litte Therm Compact Thermaator 3 Pick up the unit by the handes and pour out into a sink or foor drain. 1- For each use: USING THE THERMAL PACK 1 Open the id. 2 Using tongs, carefuy remove the Therma Pack. Caution: the Therma Pack can cause skin burns. 3 Wrap the pack in a 4 Put the wrapped Therma Pack Cover pack on the area to or 5 to 6 ayers of be treated for a terry toweing. pre-set treatment time.! WARNING Use the Thermaator ony as directed in this manua. Any other use can cause injury. 6 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Instructions for Operation and Care of Litte Therm Compact Thermaator 5 Remove the Therma Pack from the patient. Remove the Therma Pack Cover or toweing. Hang Cover or toweing to dry or aunder. 6 7 Return the pack to 8 Cose the id. The the Thermaator. Therma Pack wi be reheated within If the bue tab was 15 minutes and up, put the white tab ready for use. up now. Work your way from first to ast, reversing tabs each time. 2- Daiy use: 1 Add more water, if necessary, to cover the Therma Packs. Uncovered packs may be damaged during heating. 2 Pace a the bue tabs in the same reference (either a up or a down) to start the day. BLUE Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 7

Instructions for Operation and Care of Litte Therm Compact Thermaator 3- Periodic use: The water temperature for norma operating conditions is about 165 F (74 C). The thermostat is very sensitive; even a sma adjustment can raise or ower the temperature severa degrees. The thermostat has an adjustabe temperature range of 65 F (18 C) to 175 F (79 C) ±5 F (-15 C). To adjust the temperature, you need a Thermometer capabe of 180 F (83 C). 5 Facing the back of the unit, find the meta temperature stem between the 2 screws in the ower midde of the unit. Attach knob. Using the knob, turn cockwise to increase the temperature. Aow the temperature to stabiize, and measure the water temperature with the thermometer. CAUTION: Sensitive thermostat - a sma adjustment changes severa degrees. Temperature range of 65 F (18 C) to 175 F (79 C) ±5 F (-15 C). 6 TEMPERATURE USING THE WIRE RACK Your Litte Therm uses many different sizes of Therma Packs. For Haf, Cervica or Myofacia sizes, a sma rack adapter is provided. For Standard, Knee/Shouder, 10" x 18" and 10" x 24" sizes, use ony the stainess stee wire rack provided. Haf Sma Rack Adapter (Optiona) Cervica Myofacia Knee/Shouder 10" x 18" 10" x 24" Standard 8 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Instructions for Operation and Care of Litte Therm Compact Thermaator MAINTENANCE The Litte Therm design is neary maintenance-free. It shoud, under most conditions, give many years of reiabe service. Cean and repace the Therma Packs as described beow. 1. Routine Maintenance (As Needed) See Ceaning and Sanitizing Aways keep the Therma Packs under water. Repace any water that has evaporated. 2. Monthy Maintenance Destroy or discard any contaminated Therma Packs. See Ceaning and Sanitizing Cean wire rack and insert using mid soap. Rinse thoroughy with cean tap water. Dry with soft coth. Scrub your Therma Packs with warm soap and water. Keep the ph (a measure of acidity of the water) between 7.4 and 7.8 to reduce the scaing and residue buid-up. 3. Yeary Maintenance Repace worn out Therma Packs. When The packs begin to wear out, the non-toxic fier oozes through the fabric and seams. The individua ces seem empty. These packs don't hod the heat. Throw away worn Therma Packs. Have a professiona eectrician thoroughy check the foowing: 1- Test for eakage current, dieectric strength, and receptace poarity and ground. If you need test need test detais, ca the number isted on the back page. 2- Check the power cord and pug. They shoud be free of cuts, abrasion and other damage. Repace the power cord assemby if it is damaged. Use ony factory repacement parts. 3- Remove the cover and check a eectrica components and connections. Repace any parts that are in questionabe condition. Use ony factory authorized repacement parts. CLEANING AND SANITIZING Ceaning of the tanks can best be accompished with a very mid, non-scratching househod ceaner and a very ow abrasion pastic scouring pad ighty appied. On a stainess stee tank, never use a meta scouring pad as it is too abrasive and may eave carbon meta deposits on the stainess, which wi rust. Again, disinfection and steriizing procedures are different from faciity to faciity, and we have found that acoho is sti the best (but expensive) ceaning and steriizing soution. Beaches and iodine shoud not be used. Use of beach or iodine wi resut in pin hoes in the stainess stee tank which wi eak and void the warranty. STORAGE 1. Storing the Litte Therm See Ceaning and Sanitizing Pace the Litte Therm upright in a dry area away from any chemicas. 2. Storing the Therma Packs Scrub your Therma Packs with warm soap and water. Moist and Cod 1- Put the moist Therma Pack in a pastic bag. 2- Sea the bag. 3- Store the bag in the freezer (recommended) or refrigerator. Dry 1- Air dry the Therma Pack competey in a we ventiated area. The fier wi become hard and caked. This doesn't hurt the bags; more Pre- Soaking time is then necessary. 2- Store in a dry area away from any chemicas. Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 9

Instructions for Operation and Care of Litte Therm Compact Thermaator TROUBLESHOOTING Probem Cause Soution Water doesn't get hot, even though unit is pugged in Circuit breaker is off Thermostat is not working Heating eement is burned out Adjust the thermostat Repace the thermostat Repace the heating eement Water is coudy The Thermo Packs are worn out (seeping) Too ong between ceaning Repace the Therma Packs Drain, cean and refi Therma Packs too hot The thermostat is set too high The thermostat is broken Adjust the thermostat Repace the thermostat Therma Packs too hot and then too coo The thermostat is broken Repace the thermostat Therma Packs too coo The thermostat is set too ow The thermostat is broken There is a power faiure Adjust the thermostat Repace the thermostat Check the circuit and turn on the breaker Rust in unit Contact with ferrous meta Remove the ferrous meta item from the unit -usuay a stape, paper cip, safety pin, etc. Cean thoroughy. REPAIR OF UNIT It may be necessary or you may desire to return the Litte Therm unit for service. In that case, we woud appreciate you contacting Whiteha Manufacturing directy. We wi make arrangements for the unit to be returned to our production ocation. When the unit is received by us, an estimate of repairs wi be made and you wi be contacted. Pease- we appreciate warranty repair or any other repair be arranged directy with Whiteha Manufacturing. If you are not satisfied with our service, then and ony then, contact your deaer. 10 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Instructions for Operation and Care of Litte Therm Compact Thermaator 3 2 14 15 9 13 11 12 4 16 10 6 7 8 1 5 ITEM # PART # DESCRIPTION 1 6505-546-000 Snap-In Power Outet 10A/15A 250VAC 2 6900-135-000 Indicator Light (Green), 125 VAC 3 6505-500-000 Heating Eement 1000W 120V Tubuar w/ Washers & Nuts 4 0710-446-000 1/2" Disc Thermostat, Manua Reset 5 0710-232-000 Fuse Hoder Assemby 6 6900-136-000 Fuse, 1/4 x 1-1/4, 15A, Time Deay, Ceramic 7 6903-153-000 Operating Thermostat 8 6900-140-000 Knob 9 6900-102-000 Camp- Stee Cabe 10 6503-111-199 Hod Down Pate for 1 /2" Disc Thermostat 11 0302-011-000 #6-32 UNC Stainess Stee Hex Nut 12 0322-003-000 #6 Pated Star Lock Washer (Externa) 13 6750-011-199 Bottom Cover 14 6750-012-000 Button Bumper (Foot) 15 0116-011-000 #10-32 x 5/16 S/S Phi Hd Screw 16 6505-056-000 Power Cord Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com 11

Instructions for Operation and Care of Litte Therm Compact Thermaator POWER INLET L N FUSE 1 MANUAL RESET OPERATING THERMOSTAT BLK BLK BLK BLK GRN/YLW WHT FUSE 2 INDICATOR LIGHT WHT BLK BLK WHT HEATING ELEMENT GND 3 1 2 Whiteha Part # Description 1 6750-002-001 Thermaator Assemby (LT-4) 2 6702-040-199 Viny Coated Insert Rack 3 6702-045-199 Cervica Rack Adapter 12 Phone (800) 782-7706 (626) 968-6681 Fax (626) 855-4862 Web: www.whitehamfg.com

Maiing Address: P.O. Box 3527 City of Industry, CA 91744-0527 U.S.A Physica Address: 15125 Proctor Avenue City of Industry, CA 91746 U.S.A Phone 800-782-7706 626-968-6681 Fax 626-855-4862 Web: www.whitehamfg.com E-mai: info@whitehamfg.com MANUFACTURER'S WARRANTY Whiteha Manufacturing Company warrants that its products are free from defects in materia or workmanship under norma use and service for a period of one year from date of shipment. Whiteha's iabiity under this warranty sha be discharged soey by repacement or repair of defective materia, provided Whiteha is notified in writing within one year from date of shipment, F.O.B. Industry, Caifornia. This warranty does not cover instaation or abor charges, and does not appy to materias which have been damaged by other causes such as mishanding or improper care or abnorma use. The repair or repacement of the defective materias sha constitute the soe remedy of the Buyer and the soe remedy of Whiteha under this warranty. Whiteha sha not be iabe under any circumstances for incidenta, consequentia or direct charges caused by defects in the materias, or any deay in the repair or repacement thereof. This warranty is in ieu of a other warranties expressed or impied. Product maintenance instructions are issued with each fixture, and disregard or noncompiance with these instructions wi constitute an abnorma use condition and void the warranty. Stainess stee must be protected on jobsites during construction and must be propery maintained after the water has been introduced into the fixture, or Whiteha's imited warranty is void. If you have any questions or require technica assistance, pease ca 800-743-8219. NOTICE TO KEEP ORIGINAL PACKAGING- Regarding warranty caims: customer must retain origina packaging for one year upon receipt of product. If packaging is discarded, it is the customer's responsibiity to provide adequate packaging. Any shipping caims that are a direct resut of customer-provided packaging materias wi be handed by the shipper. Member of