General Remarks First figure in the 4 digit code system is used for identification of the unit type. Figure/Unit type: 1 StarCool 2 Daikin 3 ThermoKingCF-II 4 Hi-Vent/StarVent 5 Carrier 6 ThermoKing TNE508/CRR40/Magnum 8 ThermoKing CRR40-DF (Super Freezer units) Important Notice The Man-hours per piece listed in this section of the Standard Time System (STS) are the Maximum allowable time for the respective repair jobs. However, it is an important duty of the repair management to ensure the number of STS hours applied, against each repair job, is minimized and that no conflicting STS codes are applied. For all repair jobs involving replacement of parts it is accept able to apply the maximum allowable time. However, for all jobs with repair in text, the actual time consumed must apply. If the actual time consumed should exceed the maximum allowable time, the latter shall apply. For your guidance, repair codes with repair in text, usually refers to repair work requiring no spare parts, troubleshooting, leak check, cleaning of components and wiring. Common to all of these repair jobs is that they will vary in complexity and time consumption, from time to time. 1
Mode Repair Code Maersk STS Mode 43 Repair Name Max Quantity Man Hour 43 0615 CORE CHARGE FOR MISSING RELAY BOARD 1 0.00 43 0619 CORE CHARGE FOR MISSING MPC 1 0.00 43 0711 CORE CHARGE FOR MISSING COMPRESSOR 1 0.00 43 0940 PRE-TRIP INSPECTION (PTI) 1 0.40 43 0942 SHORT PTI 1 0.30 43 0943 PTI FOR STARVENT CONTAINER 1 0.20 43 0944 PRE-TRIP INSPECTION (PTI) SUPER FREEZER & AQUALIFE UNITS 1 0.80 43 0945 RUNNINGTEST REEFERS 1 0.20 43 0946 SUPER FREEZER RUNNING TEST 2 0.20 43 0948 RAPS VISUAL INSPECTION 1 0.20 43 1111 Straighten frame 4 1.00 43 1112 Retainer, Cable 1 0.20 43 1113 Resecure / Reinstall screws-bolts 1 0.10 43 1114 Repair/Replace Handle 2 0.20 43 1115 BROKEN BOLT EXTRACTION 10 0.10 43 1122 Rear panel, Upper / Lower, Replace 2 0.20 43 1131 Re-foaming of unit 20 0.10 43 1141 R & R REEFER UNIT COMPLETE 1 2.00 43 1151 REPAIR / REPLACE EVAP. ACCESS DOOR 2 0.20 43 1153 Repair / Replace Door Hinge 3 0.20 43 1161 Replace Grill Screen / Grill Door 1 0.20 43 1162 Repair Grill Screen / Grill Door 5 0.10 43 1163 Replace Guard Condenser coil 1 0.50 43 1164 REPLACE FRONT PLATE CABLE 1 0.10 43 1166 CONDENSER MOTOR BRACKET REPLACEMENT (SB0032) 1 1.60 43 1171 REPLACE CONTROL BOX COMPLETE 1 3.00 43 1172 REPLACE CONTROL BOX DOOR 1 0.20 43 1173 REPAIR CONTROL BOX DOOR 3 0.10 43 1174 Replace control box Door Hinges 2 0.10 43 1175 Replace Door Latch 2 0.10 43 1176 Repair / Replace Bracket Control Box 10 0.10 43 1210 Repair pipe, Economizer side 10 0.10 43 1211 Repair pipe, Suction side 10 0.10 43 1212 REPAIR PIPE, DISCHARGE SIDE 10 0.10 43 1215 Replace Filter Drier 1 0.50 43 1218 LEAK CHECK 5 0.10 43 1221 Replace Suction service Valve 1 1.00 43 1222 Replace Discharge service Valve 1 0.70 43 1223 Replace Liquid Line Valve 1 0.70 43 1224 Replace Valve Caps 1 0.10 43 1225 Replace Schrader Valve 1 0.10 43 1226 Replace Economizer service Valve 1 0.70 43 1229 Replace Service Valve Gasket 2 0.30 43 1242 Replace Economiser Heat Exchanger 1 1.00 43 1251 Replace Thermal Expansion Valve Evap 1 1.00 43 1253 Replace Economizer TX Valve 1 0.80 43 1267 Replace Hotgas Solenoid Valve 1 0.80 43 1274 Replace any Solenoid Coil 1 0.20 2
43 1280 Replace Drain Pan Heater 1 0.50 43 1281 Replace One Heater 1 0.50 43 1282 Replace Two Heaters 1 0.70 43 1283 Replace Three Heaters 1 0.90 43 1284 Replace Four Heaters 1 1.10 43 1285 Replace Five Heaters 1 1.30 43 1286 Replace Six Heaters 1 1.50 43 1288 Replace Heater Bar Bracket 1 0.30 43 1289 Replace Wiring for Heaters 10 0.10 43 1291 Repair / Replace Air Vent 10 0.10 43 1292 Replace Drain Hose 10 0.10 43 1295 Replace Potentiometer Airvent. (VPS) 1 0.20 43 1310 Replace Any Sensor Housing 1 0.50 43 1311 Replace Supply Air Sensor 2 0.30 43 1312 Replace Return Air Sensor 1 0.30 43 1313 Replace Evap. coil sensor 1 0.30 43 1316 REPLACE EQONOMIZER SUPERHEAT SENSOR 1 0.30 43 1317 REPLACE EVAPORATOR SUPERHEAT SENSOR 1 0.30 43 1318 Replace Ambient Sensor 1 0.20 43 1319 Repair / Replace Wiring any Sensor 5 0.10 43 1331 Repair Cargo (USDA) Sensor 3 0.10 43 1332 REPLACE CARGO (USDA) SENSOR 4 0.10 43 1333 Repair / Replace Cargo Sensor Socket 1 0.30 43 1335 REPLACE HUMIDITY SENSOR 1 0.40 43 1342 Replace Discharge Pressure Transduce 1 0.20 43 1343 Replace Suction Pressure Transducer 1 0.20 43 1351 Replace HP-switch 1 0.30 43 1361 REPLACE ON-OFF SWITCH 1 0.20 43 1371 Replace Power Cable 1 1.00 43 1372 REPAIR POWER CABLE ( SPLICE WITH KIT ) 1 0.30 43 1373 Replace Power Plug 1 0.30 43 1374 REPLACE GASKET POWER PLUG 1 0.10 43 1382 REPAIR / REPLACE BURNED OUT WIRING 2 0.10 43 1383 Cleaning Wiring 5 0.10 43 1384 Replace Connecting Cables CTRL-MRB 1 0.10 43 1386 TROUBLE SHOOTING 2 0.10 43 1411 Replace Evaporator Coil, Incl. R&R o 1 8.00 43 1412 Repair of Evaporator Coil 20 0.10 43 1413 CLEANING OF EVAPORATOR COIL 3 0.10 43 1414 Repair / Replace Grill/Grating at re 10 0.10 43 1431 REPLACE CONDENSER COIL, INCL. WIRING 1 3.00 43 1432 Repair Condenser Coil 20 0.10 43 1433 Cleaning of Condenser Coil / Frame 1 0.20 43 1452 Replace Receiver Tank, Incl. R&R of 1 2.50 43 1453 Replace Coupling WCC Receiver Tank. 2 0.20 43 1454 REPLACE DUST CAPS ON WATER COOLED CONDENSER 1 0.10 43 1455 Replace Receiver Sight Glass 1 0.20 43 1456 Replace HP relief valve/fusible plug 1 0.20 43 1511 Replace Evaporator motor inc. Fan 2 0.40 43 1512 Replace bearings pr. evap Fan Motor 2 0.40 43 1514 Replace Evap Fan 3 0.30 3
43 1515 Replace Wiring for Evap Fan Motor 10 0.10 43 1516 Repair / Replace Evap Fan Motor Foun 10 0.10 43 1521 Replace Condenser Fan Motor, incl. F 1 0.70 43 1522 Replace bearings Condenser Fan Motor 1 0.40 43 1524 Replace Condenser Fan 1 0.30 43 1525 Repair / Replace Wiring Harness for 5 0.10 43 1611 REPLACE DISPLAY/KEYPAD 1 0.50 43 1613 REPLACE CONTROLLER HATCH COMPLETE, STARCOOL 1 0.50 43 1614 REPLACE DISPLAY/LED PCB 1 0.40 43 1615 Replace Power MEAS PCB 1 0.50 43 1618 Replace terminal block I/O PCB 1 0.50 43 1619 REPLACE CONTROLLER MODULE INCL. SOFTWARE 1 0.50 43 1621 RCD TELEMETRY DEVICE REPLACEMENT 1 0.10 43 1622 RCD CELL GPS WLAN ANTENNA REPLACEMENT 1 0.10 43 1623 GENERIC BRACKET REPLACEMENT 1 0.10 43 1631 Replace Main Circuit Breaker 1 0.30 43 1633 Replace Any Control Fuse 1 0.10 43 1641 REPLACE EVAP., COND OR HEAT CONTACT 3 0.20 43 1642 Replace Compressor Contactor 2 0.20 43 1643 Replace Phase Direction Contactor 2 0.20 43 1651 Replace Control Transformer 1 0.30 43 1711 Replace Compressor, Incl. Wiring / D 1 2.50 43 1712 Replace Frequency converter incl. wi 1 1.00 43 1714 Repair Compressor Foundation 5 0.10 43 1715 INSPECTION OF VALVE PLATE 1 0.50 43 1716 REPLACE VALVE PLATES INC PUMPDOWN, AND REMOVE & RE- INSTALL COMPRESSOR ETC. 2 3.20 43 1719 REPLACE COMPRESSOR TERMINAL BLOCK 1 1.00 43 1720 REPLACE MOTOR CABLE, FC / COMPRESSOR 1 0.50 43 1728 REPLACE COMPRESSOR SIGHT GLASS 1 0.20 43 1922 REPLACE ANY BATTERY ON DATALOGGER 1 0.10 43 1924 Replace Retriever Receptacle Datalog 1 0.50 43 1931 ADD. REFRIGERANT R134A TO SYSTEM 1 0.30 43 1933 Add. Compressor Oil 5 0.10 43 1935 CONTAMINATED SYSTEM 1 6.50 43 1936 EVACUATE, RECYCLE & RECHARGE SYSTEM 10 0.10 43 1937 Reclaim & Evacuate 1 0.30 43 1939 Acid Test 3 0.20 43 1999 UPGRADE SOFTWARE ANY MPC CONTROLLER 1 0.30 43 2111 STRAIGHTEN FRAME 4 1.00 43 2112 RETAINER, CABLE 1 0.20 43 2113 RESECURE / REINSTALL SCREWS-BOLTS 1 0.10 43 2114 REPAIR/REPLACE GRAB HANDLE 1 0.20 43 2115 BROKEN BOLT EXTRACTION 10 0.10 43 2122 REAR PANEL, UPPER / LOWER, REPLACE 2 0.20 43 2131 RE-FOAMING OF UNIT. 20 0.10 43 2141 R & R, REEFER UNIT COMPLETE 1 2.00 43 2151 REPAIR / REPLACE EVAP. ACCESS DOOR UPPER 2 0.20 43 2161 REPLACE GRILL SCREEN / GRILL DOOR. 1 0.20 43 2163 REPLACE GUARD CONDENSER COIL 1 0.50 43 2164 REPLACE FRONT PLATE CABLE 1 0.10 4
43 2165 REPLACE BLANK PANEL/GUARD 1 0.10 43 2171 REPLACE CONTROL BOX COMPLETE 1 3.00 43 2172 REPLACE CONTROL BOX DOOR 1 0.20 43 2173 REPAIR CONTROL BOX DOOR 3 0.10 43 2174 REPLACE CONTROL BOX DOOR HINGES 2 0.10 43 2175 REPLACE CONTROL BOX DOOR LATCH 1 0.20 43 2211 REPAIR PIPE, SUCTION SIDE, SYSTEM #1 10 0.10 43 2212 REPAIR PIPE, DISCHARGE SIDE, SYSTEM #1 10 0.10 43 2215 REPLACE FILTER DRIER 1 0.50 43 2216 REPLACE MOISTURE & LIQUID INDICATOR 1 0.50 43 2218 LEAK CHECK 3 0.10 43 2221 REPLACE SUCTION SERVICE VALVE 1 1.00 43 2222 REPLACE DISCHARGE SERVICE VALVE 1 0.70 43 2224 REPLACE VALVE CAPS 1 0.10 43 2225 REPLACE SCHRADER VALVE 4 0.10 43 2229 REPLACE SERVICE VALVE GASKET(S) 2 0.30 43 2236 REPLACE ANY TRANSDUCER LINE 2 0.20 43 2242 REPLACE ECONOMISER HEAT EXCHANGER 1 1.00 43 2247 ADJUSTMENT OF DISCHARGE PRESSURE REGULATOR 10 0.10 43 2248 REPLACE DISCHARGE PRESSURE REGULATOR 1 1.50 43 2250 DAIKIN EEV MODIFICATION MWCU/PONU 1 3.20 43 2251 REPLACE ELECTRONIC EXPANSION VALVE 1 1.00 43 2253 REPLACE TXV, ECONOMISER SCROLL UNITS 1 0.70 43 2254 CLEAN/ADJUST TXV 10 0.10 43 2261 REPLACE LIQUID LINE SOLENOID VALVE 1 0.70 43 2262 REPAIR/REPLACE DEFROST SOLENOID VALVE 1 0.70 43 2263 REPLACE SMV, STEPPER MOTOR TYPE 1 1.00 43 2264 LIQUID INJECTION SOLENOID VALVE 1 0.70 43 2265 SUCTION BY-PASS VALVE 1 1.00 43 2266 REPLACE REHEAT SOLENOID VALVE 1 0.70 43 2267 HOTGAS BY-PASS VALVE (HSV) 1 0.70 43 2268 ECONOMIZER SOLENOID VALVE (ESV) 1 0.70 43 2269 CAPILLARY SOLENOID VALVE (CSV) 1 0.70 43 2271 REPLACE STEPPER MOTOR ELECTRONIC EXPANSION VALVE 1 0.30 43 2272 REPLACE STEPPER MOTOR, SMV 1 0.30 43 2274 REPLACE ANY SOLENOID COIL 1 0.20 43 2291 REPAIR / REPLACE AIR VENT 10 0.10 43 2292 REPLACE DRAIN HOSE 10 0.10 43 2295 REPLACE VENTILATION OPENING DETECTOR 1 0.20 43 2311 REPLACE SUPPLY AIR SENSOR 2 0.20 43 2312 REPLACE RETURN AIR SENSOR 2 0.20 43 2313 REPLACE EVAP. COIL INLET/OUTLET SENSOR 1 0.20 43 2314 REPLACE EVAP. COIL OUTLET SENSOR 1 0.20 43 2315 REPLACE COMPRESSOR DISCHARGE SENSOR 1 0.20 43 2317 REPLACE COMPRESSOR SUCTION SENSOR 1 0.20 43 2318 REPLACE AMBIENT SENSOR 1 0.20 43 2319 REPLACE/REPAIR WIRING ANY SENSOR 5 0.10 43 2331 REPAIR CARGO SENSOR 3 0.10 43 2332 REPLACE CARGO SENSOR 3 0.10 43 2333 REPAIR / REPLACE CARGO SENSOR SOCKET 1 0.30 43 2335 REPLACE HUMIDITY SENSOR 1 0.30 5
43 2342 REPLACE DISCHARGE PRESSURE TRANSDUCER 1 0.20 43 2343 REPLACE SUCTION PRESSURE TRANSDUCER 1 0.20 43 2351 REPLACE HP-SWITCH 1 0.30 43 2363 REPLACE WATER COOLING PRESSURE SWITCH 1 0.20 43 2371 REPLACE POWER CABLE FROM CB IN CTR BOX 1 1.00 43 2372 REPAIR POWER CABLE ( SPLICE WITH KIT ) 1 0.30 43 2373 REPLACE POWER PLUG 1 0.30 43 2374 REPLACE GASKET, POWER PLUG 1 0.10 43 2381 REPLACE TERMINAL BLOCK 1 0.40 43 2382 REPAIR/REPLACE BURNED OUT WIRING 2 0.10 43 2383 CLEANING OF WIRING 5 0.10 43 2384 REPLACE CONNECTING CABLES,CONTROLLER 1 0.10 43 2386 TROUBLE SHOOTING 2 0.10 43 2411 REPLACE EVAP. COIL, INCL R&R OF UNIT 1 8.00 43 2412 REPAIR OF EVAPORATOR COIL 20 0.10 43 2413 CLEANING OF EVAPORATOR COIL 3 0.10 43 2414 REPAIR/REPLACE GRILL/GRATING AT REAR 10 0.10 43 2431 REPLACE CONDENSER COIL, INCL WIRING/DRIE 1 3.00 43 2432 REPAIR CONDENSER COIL 20 0.10 43 2433 CLEANING CONDENSER COIL / FRAME 1 0.20 43 2452 REPLACE WCC RECEIVER TANK, INCL R&R FITT 1 2.50 43 2453 REPLACE COUPLING WCC RECEIVER 2 0.20 43 2454 REPLACE ANY DUST CAP WCC COUPLING 2 0.10 43 2456 REPLACE HP RELIEF VALVE/FUSIBLE PLUG 1 0.20 43 2511 REPLACE EVAPORATOR FAN MOTOR 2 0.70 43 2512 REPLACE BEARINGS PR. EVAP FAN MOTOR 2 1.10 43 2514 REPLACE EVAP FAN 2 0.40 43 2515 REPLACE WIRING FOR EVAP FAN MOTOR 10 0.10 43 2516 REPAIR / REPLACE EVAP FAN MOTOR FOUNDATION 10 0.10 43 2521 REPLACE CONDENSER FAN MOTOR, INCL FAN 1 0.70 43 2522 REPLACE BEARINGS COND. FAN MOTOR. 1 0.40 43 2524 REPLACE CONDENSER FAN 1 0.30 43 2525 REPLACE WIRING HARNESS FOR COND. MOTOR 5 0.10 43 2611 REPLACE KEYPAD / DISPLAY 1 0.20 43 2612 REPLACE PC/CT BOARD 1 0.20 43 2615 REPLACE TERMINAL STRIP BOARD 1 1.00 43 2618 REPLACE TERMINAL BOARD 1 0.50 43 2619 REPLACE CONTROLLER DECOS IIID 1 0.30 43 2621 RCD TELEMETRY DEVICE REPLACEMENT 1 0.10 43 2622 RCD CELL GPS WLAN ANTENNA REPLACEMENT 1 0.10 43 2623 GENERIC BRACKET REPLACEMENT 1 0.10 43 2631 REPLACE MAIN CIRCUIT BREAKER 1 0.30 43 2633 REPLACE ANY CONTROL FUSE 1 0.10 43 2641 REPLACE EVAP, COND, CONTACTOR 2 0.20 43 2642 REPLACE COMPRESSOR CONTACTOR 1 0.20 43 2643 REPLACE PHASE CONTACTOR 2 0.20 43 2651 REPLACE CONTROL TRANSFORMER 1 0.30 43 2711 REPLACE COMPRESSOR, INCL. WIRING/DRIER 1 2.50 43 2714 REPAIR COMPRESSOR FOUNDATION 5 0.10 43 2921 REPLACE BATTERY CHARGER ASSY 1 0.20 43 2922 REPLACE ANY BATTERY ON DATALOGGER 1 0.10 6
43 2923 REMOVE EMPTY/DEFECTIVE RECORDER BATTERY FOR DATALOGGER 1 0.10 43 2924 REPLACE RETRIEVER RECEPTACLE 1 0.50 43 2931 ADD REFRIGERANT TO SYSTEM 1 0.30 43 2933 ADD. COMPRESSOR OIL 3 0.10 43 2935 CONTAMINATED SYSTEM 1 6.50 43 2936 EVACUATE, RECYCLE AND RECHARGE SYSTEM 10 0.10 43 2937 RECLAIM AND EVACUATE 1 0.30 43 2939 ACID TEST 3 0.20 43 2999 UPGRADE SOFTWARE MPC CONTROLLER 1 0.50 43 5111 STRAIGHTEN FRAME 4 1.00 43 5112 RETAINER, CABLE 1 0.20 43 5113 RESECURE / REINSTALL SCREWS-BOLTS 1 0.10 43 5114 REPAIR/REPLACE GRAB HANDLE 3 0.20 43 5115 BROKEN BOLT EXTRACTION 10 0.10 43 5122 REAR PANEL, REPAIR / REPLACE 2 0.20 43 5131 RE-FOAMING OF UNIT. 20 0.10 43 5141 R & R, REEFER UNIT COMPLETE 1 2.00 43 5151 REPAIR / REPLACE EVAP. ACCESS DOOR UPPER 1 0.30 43 5152 REPAIR / REPLACE HEATER ACCESS DOOR. 1 0.20 43 5158 CTR-SER03-04, P176 1 0.30 43 5159 CTR-SER03-04, P176A 1 0.30 43 5161 REPLACE GRILL SCREEN / GRILL DOOR. 1 0.20 43 5162 REPAIR COND. GRILL SCREEN / GRILL DOOR 5 0.10 43 5163 REPLACE GUARD CONDENSER COIL 1 0.50 43 5164 REPLACE GUARD COMPRESSOR. 1 0.10 43 5165 REPLACE BLANK PANEL 1 0.10 43 5171 REPLACE CONTROL BOX COMPLETE 1 3.00 43 5172 REPLACE CONTROL BOX DOOR 1 0.20 43 5173 REPAIR CONTROL BOX DOOR 3 0.10 43 5174 REPLACE CONTROL BOX DOOR HINGES 2 0.10 43 5175 REPLACE CONTROL BOX DOOR LATCH 2 0.10 43 5176 REPAIR/REPLACE BRACKET CONTROL BOX 10 0.10 43 5177 REPLACE VOLTAGE SHIELD 1 0.10 43 5211 REPAIR PIPE, SUCTION SIDE, SYSTEM #1 10 0.10 43 5212 REPAIR PIPE, DISCHARGE SIDE, SYSTEM #1 10 0.10 43 5213 CARRY OUT BACK PANEL MOD CAR0005, (CARRIER PRIMELINE ONLY) 1 0.50 43 5215 REPLACE FILTER DRIER 1 0.50 43 5216 REPLACE MOISTURE & LIQUID INDICATOR 1 0.50 43 5218 LEAK CHECK 5 0.10 43 5219 CTR-SER-00-05, LIQUID LINE SUPPORT 1 0.50 43 5221 REPLACE SUCTION SERVICE VALVE 1 1.00 43 5222 REPLACE DISCHARGE SERVICE VALVE 1 1.00 43 5223 REPLACE LIQUID LINE VALVE 1 0.70 43 5224 REPLACE VALVE CAPS 1 0.10 43 5225 REPLACE SCHRADER VALVE 1 0.10 43 5229 REPLACE SERVICE VALVE GASKET(S) 2 0.30 43 5241 REPLACE SUCTION GAS HEAT EXCHANGER 1 1.00 43 5242 REPLACE ECONOMISER HEAT EXCHANGER 1 1.00 43 5247 ADJUSTMENT DISCHARGE PRESSURE REGULATOR 10 0.10 7
43 5248 REPLACE DISCHARGE PRESSURE REGULATOR 1 1.50 43 5251 REPLACE THERMAL EXPANSION VALVE 1 1.00 43 5252 REPLACE QUENCH EXPANSION VALVE 1 0.70 43 5253 REPLACE TXV, ECONOMISER SCROLL UNITS 1 0.70 43 5254 CLEAN / ADJUST TXV 10 0.10 43 5261 REPLACE UNLOADER SOLENOID VALVE 1 0.70 43 5263 REPLACE COMPLETE SMV, STEPPER MOTOR TYPE 1 1.00 43 5264 LIQUID INJECTION (QUENCH) SOLENOID VALVE 1 0.70 43 5265 SUCTION BY-PASS VALVE, REPAIR KIT 1 1.00 43 5268 REPLACE ECONOMIZER SOLENOID VALVE (ESV) 1 0.70 43 5269 REPLACE DIGITAL CONTROL VALVE 1 0.50 43 5272 REPLACE STEPPER MOTOR POWER PACK ON SMV 1 0.30 43 5273 REPLACE POWER PACK FOR STEPPER MOTOR 1 0.20 43 5274 REPLACE ANY SOLENOID COIL 2 0.20 43 5281 REPLACE ONE HEATER 1 0.50 43 5282 REPLACE TWO HEATERS 1 0.70 43 5283 REPLACE THREE HEATERS 1 0.90 43 5284 REPLACE FOUR HEATERS 1 1.10 43 5285 REPLACE FIVE HEATERS 1 1.50 43 5286 REPLACE SIX HEATERS 1 1.50 43 5288 REPLACE HEATER BAR BRACKET 1 0.30 43 5289 REPLACE WIRING FOR HEATERS 10 0.10 43 5291 REPAIR / REPLACE AIR VENT 10 0.10 43 5292 REPLACE DRAIN HOSE 10 0.10 43 5295 REPLACE POTENTIOMETER AIRVENT (LVPS) 1 0.20 43 5310 REPLACE ANY SENSOR HOUSING 1 0.50 43 5311 REPLACE SUPPLY AIR SENSOR 2 0.20 43 5312 REPLACE RETURN AIR SENSOR 2 0.40 43 5313 REPLACE DEFROST TERMINATION SENSOR, DTS 1 0.30 43 5315 REPLACE COMPRESSOR DISCHARGE SENSOR 1 0.20 43 5317 REPLACE COMPRESSOR SUCTION SENSOR 1 0.20 43 5318 REPLACE AMBIENT SENSOR 1 0.20 43 5319 REPLACE/REPAIR WIRING ANY SENSOR 5 0.10 43 5321 REPLACE KLIXON, 130F, HTT 1 0.30 43 5322 REPLACE KLIXON, DEFROST TERMINATION, DTT 1 0.20 43 5331 REPAIR CARGO SENSOR 3 0.10 43 5332 REPLACE CARGO SENSOR 3 0.10 43 5333 REPAIR / REPLACE CARGO SENSOR SOCKET 1 0.30 43 5335 REPLACE HUMIDITY SENSOR 1 0.30 43 5341 REPLACE CONDENSER PRESSURE TRANSDUCER 1 0.20 43 5342 REPLACE DISCHARGE PRESSURE TRANSDUCER 1 0.20 43 5343 REPLACE SUCTION PRESSURE TRANSDUCER 1 0.20 43 5351 REPLACE HP-SWITCH 1 0.30 43 5361 REPLACE ON-OFF SWITCH 1 0.20 43 5362 REPLACE MANUAL DEFROST SWITCH 1 0.20 43 5363 REPLACE WATER COOLING PRESSURE SWITCH (COND FAN ON/OFF) 1 0.20 43 5364 EPT/SPT RELOCATION REWORK INC REPLACING TRANSDUCERS 1 0.80 43 5371 REPLACE POWER CABLE FROM CB IN CTR BOX 1 1.00 43 5372 REPAIR POWER CABLE ( SPLICE WITH KIT ) 1 0.30 8
43 5373 REPLACE POWER PLUG 1 0.30 43 5374 REPLACE GASKET, POWER PLUG 1 0.10 43 5381 REPLACE TERMINAL BLOCK 1 0.40 43 5382 REPAIR/REPLACE BURNED OUT WIRING 2 0.10 43 5383 CLEANING OF WIRING 5 0.10 43 5384 REPLACE RIBBON CABLE, ML2/ML2I CTRL 1 0.10 43 5386 TROUBLE SHOOTING 2 0.10 43 5411 REPLACE EVAP. COIL, INCL R&R OF UNIT 1 8.00 43 5412 REPAIR OF EVAPORATOR COIL 20 0.10 43 5413 CLEANING OF EVAPORATOR COIL 3 0.10 43 5414 REPAIR/REPLACE GRILL/GRATING AT REAR 10 0.10 43 5430 REMOVE CONDENSER FIXING BOLT (THINLINE UNITS ONLY), AS PER TECH BULLETIN CAR0004 1 0.10 43 5431 REPLACE CONDENSER COIL, INCL WIRING/DRIE 1 3.10 43 5432 REPAIR CONDENSER COIL 20 0.10 43 5433 CLEANING CONDENSER COIL / FRAME 1 0.20 43 5451 REPLACE RECEIVER TANK. 1 1.00 43 5452 REPLACE WCC RECEIVER TANK, INCL R&R FITT 1 2.50 43 5453 REPLACE COUPLING WCC RECEIVER 2 0.20 43 5454 REPLACE ANY DUST CAP WCC COUPLING 1 0.10 43 5455 REPLACE RECEIVER SIGHT GLASS 2 0.20 43 5456 REPLACE HP RELIEF VALVE/FUSIBLE PLUG 1 0.20 43 5511 REPLACE EVAPORATOR FAN MOTOR 2 0.70 43 5512 REPLACE BEARINGS PR. EVAP FAN MOTOR 3 1.10 43 5513 REPLACE CAPACITOR EVAP FAN MOTOR 2 0.20 43 5514 REPLACE EVAP FAN 2 0.40 43 5515 REPLACE WIRING FOR EVAP FAN MOTOR 10 0.10 43 5516 REPAIR/REPLACE EVAP MOTOR MOTOR FOUNDATI 10 0.10 43 5517 REPL. INTERNAL RELAY, EVAP MOTOR CARRIER 2 0.20 43 5521 REPLACE CONDENSER FAN MOTOR, INCL FAN 1 0.70 43 5522 REPLACE BEARINGS COND. FAN MOTOR. 1 0.40 43 5523 REPLACE CAPACITOR COND FAN MOTOR 1 0.20 43 5524 REPLACE CONDENSER FAN 1 0.30 43 5525 REPLACE WIRING HARNESS FOR COND. MOTOR 5 0.10 43 5610 TEST OF MPC - WITH TESTER 1 0.20 43 5611 REPLACE TEMPERATURE SELECTOR / KEYPAD 1 0.20 43 5614 REPLACE DISPLAY ASSY 1 0.40 43 5619 REPLACE MPC, CARRIER ML2, ML2I & AND ML3 UNITS 1 0.30 43 5621 RCD TELEMETRY DEVICE REPLACEMENT 1 0.10 43 5622 RCD CELL GPS WLAN ANTENNA REPLACEMENT 1 0.10 43 5623 GENERIC BRACKET REPLACEMENT 1 0.10 43 5631 REPLACE MAIN CIRCUIT BREAKER 1 0.30 43 5632 REPLACE ANY CONTROL CIRCHIT BREAKER 1 0.20 43 5633 REPLACE ANY CONTROL FUSES 1 0.10 43 5641 REPLACE EVAP, COND, HEAT CONTACTOR 2 0.20 43 5642 REPLACE COMPRESSOR CONTACTOR 2 0.20 43 5643 REPLACE PHASE DIRECTION CONTACTOR 2 0.20 43 5644 REPLACE SOCKET RELAYS 3 0.10 43 5651 REPLACE CONTROL TRANSFORMER 1 0.30 43 5652 REPLACE CURRENT LIMIT TRANSFORMER, 3 PCS 1 0.30 43 5653 REPLACE POTENTIAL TRANSFORMER. 1 0.30 9
43 5654 REPLACE HI-VOLTAGE MODULE ML2-ML2I 1 0.30 43 5711 REPLACE COMPRESSOR, INCL. WIRING/DRIER 1 2.50 43 5713 REPAIR/REPLACE TERMINAL BOX COMPRESSOR 1 0.30 43 5714 REPAIR COMPRESSOR FOUNDATION 5 0.10 43 5718 REPLACE OIL PUMP/BEARING ASSY. GASKET 1 1.00 43 5719 REPLACE COMPRESSOR TERMINAL BLOCK 1 1.00 43 5721 REPLACE CARRIER SCROLL COMPRESSOR 1 2.50 43 5728 REPLACE COMPRESSOR SIGHT GLASS 1 0.20 43 5913 REPLACE RECORDER POWER ELEMENT 1 1.00 43 5921 REPLACE RTC BATTERY CONTROLLER 1 0.50 43 5922 REPLACE BATTERY ON DATALOGGER/CONTROLLER 1 0.10 43 5923 REMOVE EMPTY/DEFECTIVE RECORDER BATTERY FOR DATALOGGER 1 0.10 43 5924 REPLACE RETRIEVER RECEPTACLE 1 0.50 43 5931 ADD REFRIGERANT TO SYSTEM 1 0.30 43 5933 ADD COMPRESSOR OIL 5 0.10 43 5935 CONTAMINATED SYSTEM 2 6.50 43 5936 EVACUATE, RECYCLE AND RECHARGE SYSTEM 10 0.10 43 5937 RECLAIM AND EVACUATE 1 0.30 43 5939 ACID TEST 3 0.20 43 5951 REPLACE FRESHMIST ATOMIZER 1 0.50 43 5999 UPGRADE SOFTWARE MPC CONTROLLER 1 0.10 43 6111 STRAIGHTEN FRAME 4 1.00 43 6112 RETAINER, CABLE 1 0.20 43 6113 RESECURE / REINSTALL SCREWS-BOLTS 1 0.10 43 6114 REPAIR/REPLACE GRAB HANDLE 1 0.20 43 6115 BROKEN BOLT EXTRACTION 10 0.10 43 6122 REAR PANEL, REPAIR / REPLACE 2 0.20 43 6131 RE-FOAMING OF UNIT. 20 0.10 43 6141 R & R, REEFER UNIT COMPLETE 1 2.00 43 6151 REPAIR / REPLACE EVAP. ACCESS DOOR UPPER 1 0.30 43 6152 REPAIR / REPLACE HEATER ACCESS DOOR. 1 0.30 43 6153 REPAIR / REPLACE DOOR HINGE. 3 0.20 43 6154 REPAIR / REPLACE DOOR LATCH. 3 0.20 43 6155 REPAIR / REPLACE CATCH FOR DOOR LATCH. 3 0.10 43 6161 REPLACE GRILL SCREEN / GRILL DOOR. 1 0.20 43 6162 REPAIR GRILL SCREEN / GRILL DOOR. 5 0.10 43 6164 REPLACE GUARD COMPRESSOR. 1 0.10 43 6165 REPLACE BLANK PANEL 1 0.10 43 6171 REPLACE CONTROL BOX COMPLETE 1 3.00 43 6172 REPLACE CONTROL BOX DOOR 1 0.20 43 6173 REPAIR CONTROL BOX DOOR 3 0.10 43 6174 REPLACE CONTROL BOX DOOR HINGES 2 0.10 43 6175 REPLACE CONTROL BOX DOOR LATCH 2 0.10 43 6176 REPAIR/REPLACE BRACKET CONTROL BOX 10 0.10 43 6211 REPAIR PIPE, SUCTION SIDE, SYSTEM #1 10 0.10 43 6212 REPAIR PIPE, DISCHARGE SIDE, SYSTEM #1 10 0.10 43 6215 REPLACE FILTER DRIER 1 0.50 43 6216 REPLACE MOISTURE & LIQUID INDICATOR 1 0.50 43 6218 LEAK CHECK 5 0.10 43 6221 REPLACE SUCTION SERVICE VALVE 1 1.00 10
43 6222 REPLACE DISCHARGE SERVICE VALVE 1 0.70 43 6223 REPLACE LIQUID LINE VALVE 1 0.70 43 6224 REPLACE VALVE CAPS 1 0.10 43 6225 REPLACE SCHRADER VALVE 1 0.10 43 6229 REPLACE SERVICE VALVE GASKET(S) 2 0.30 43 6241 REPLACE SUCTION GAS HEAT EXCHANGER 1 1.00 43 6242 REPLACE ECONOMISER HEAT EXCHANGER 1 1.00 43 6249 REPLACE DISCHARGE CHECK VALVE 1 1.00 43 6251 REPL TXV, INCL REMOVE AND REFIT LH EVAP MOTOR 1 1.00 43 6253 REPLACE TXV, ECONOMISER SCROLL UNITS 1 0.70 43 6254 CLEAN / ADJUST TXV 10 0.10 43 6261 REPLACE LIQUID LINE SOLENOID VALVE 1 0.70 43 6262 FIT SMV/MV KIT IN PLACE OF KVQ. 1 2.50 43 6263 REPLACE KVQ VALVE 1 1.00 43 6264 LIQUID INJECTION (QUENCH) SOLENOID VALVE 1 0.70 43 6266 REPLACE HMC SOLENOID VALVE 1 0.70 43 6269 DIGITAL CONTROL VALVE, MAGNUM 1 0.50 43 6272 REPLACE KVQ ACTUATOR 1 0.30 43 6274 REPLACE ANY SOLENOID COIL 1 0.20 43 6275 REPLACE DIGITAL CONTROL SOLENOID COIL 1 0.20 43 6281 REPLACE ONE HEATER 1 0.50 43 6282 REPLACE TWO HEATERS 1 0.70 43 6283 REPLACE THREE HEATERS 1 0.90 43 6284 REPLACE FOUR HEATERS 1 1.10 43 6285 REPLACE FIVE HEATERS 1 1.30 43 6286 REPLACE SIX HEATERS 1 1.50 43 6288 REPLACE HEATER BAR BRACKET 1 0.30 43 6289 REPLACE WIRING FOR HEATERS 10 0.10 43 6291 REPAIR / REPLACE AIR VENT 10 0.10 43 6292 REPLACE DRAIN HOSE 10 0.10 43 6295 REPLACE AVL UNIT 1 0.20 43 6310 REPLACE ANY SENSOR HOUSING 1 0.50 43 6311 REPLACE SUPPLY AIR SENSOR 2 0.20 43 6312 REPLACE RETURN AIR SENSOR 1 0.20 43 6313 REPLACE EVAP. COIL SENSOR 1 0.20 43 6314 REPLACE CONDENSER COIL SENSOR 1 0.20 43 6315 REPLACE COMPRESSOR DISCHARGE SENSOR 1 0.20 43 6318 REPLACE AMBIENT SENSOR 1 0.20 43 6319 REPLACE/REPAIR WIRING ANY SENSOR 5 0.10 43 6321 REPLACE KLIXON, 130F, HTT 1 0.30 43 6331 REPAIR CARGO SENSOR 3 0.10 43 6332 REPLACE CARGO SENSOR 3 0.10 43 6333 REPAIR / REPLACE CARGO SENSOR SOCKET 4 0.30 43 6335 REPLACE HUMIDITY SENSOR 1 0.30 43 6336 AFAM+ GAS ANALYSER 1 0.30 43 6342 REPLACE DISCHARGE PRESSURE TRANSDUCER 1 0.20 43 6343 REPLACE SUCTION PRESSURE TRANSDUCER 1 0.20 43 6351 REPLACE HP-SWITCH 1 0.30 43 6354 REPLACE LP-SWITCH, MAGNUM UNIT 1 0.30 43 6361 REPLACE ON-OFF SWITCH 1 0.20 43 6363 REPLACE CONDENSER FAN OFF(WATER COOLING) 1 0.20 11
43 6364 REPLACE SWITCH BOOT 1 0.10 43 6371 REPLACE POWER CABLE FROM CB IN CTR BOX 1 1.00 43 6372 REPAIR POWER CABLE ( SPLICE WITH KIT ) 1 0.30 43 6373 REPLACE POWER PLUG 1 0.30 43 6374 REPLACE GASKET, POWER PLUG 1 0.10 43 6382 REPAIR/REPLACE BURNED OUT WIRING 2 0.10 43 6383 CLEANING OF WIRING 5 0.10 43 6384 REPLACE CONNECTING CABLES,CTRL-RLB CRR40 1 0.10 43 6386 TROUBLE SHOOTING 2 0.10 43 6411 REPLACE EVAP. COIL, INCL R&R OF UNIT 1 8.00 43 6412 REPAIR OF EVAPORATOR COIL 20 0.10 43 6413 CLEANING OF EVAPORATOR COIL 3 0.10 43 6414 REPAIR/REPLACE GRILL/GRATING AT REAR 10 0.10 43 6431 REPLACE CONDENSER COIL, INCL WIRING/DRIE 1 3.00 43 6432 REPAIR CONDENSER COIL 20 0.10 43 6433 CLEANING CONDENSER COIL / FRAME 1 0.20 43 6451 REPLACE RECEIVER TANK. 1 1.00 43 6452 REPLACE WCC RECEIVER TANK, INCL R&R FITT 1 2.50 43 6453 REPLACE COUPLING WCC RECEIVER 2 0.20 43 6454 REPLACE ANY DUST CAP WCC COUPLING 1 0.10 43 6455 REPLACE RECEIVER SIGHT GLASS 1 0.20 43 6456 REPLACE HP RELIEF VALVE/FUSIBLE PLUG 1 0.20 43 6511 REPLACE EVAPORATOR FAN MOTOR 3 0.70 43 6512 REPLACE BEARINGS PR. EVAP FAN MOTOR 3 1.10 43 6514 REPLACE EVAP FAN CRR-40 3 0.30 43 6515 REPLACE WIRING FOR EVAP FAN MOTOR 10 0.10 43 6516 REPAIR/REPLACE EVAP MOTOR MOTOR FOUNDATI 10 0.10 43 6517 REPLACE KLIXON SWITCH TK MOTOR 1 1.10 43 6521 REPLACE CONDENSER FAN MOTOR, INCL FAN 1 0.70 43 6522 REPLACE BEARINGS COND. FAN MOTOR. 1 0.40 43 6524 REPLACE CONDENSER FAN 1 0.30 43 6525 REPLACE WIRING HARNESS FOR COND. MOTOR 5 0.10 43 6609 REPLACE TK MPD POWER MODULE 1 0.20 43 6610 TESTING OF TK MPC OR MRB WITH TESTER 1 0.40 43 6611 REPLACE KEYPAD MPC2000 / MP-3000 1 0.50 43 6612 REPLACE TK MPD PHASE SENSOR 1 0.20 43 6614 REPLACE DISPLAY ASSY 1 0.40 43 6615 REPLACE MAIN RELAY BOARD 1 1.00 43 6617 REPLACE MP-D I/O MODULE 1 0.30 43 6618 REPLACE DATALOGGER MPC2000 1 0.20 43 6619 REPLACE MPC2000/MP-3000 CTRL INCL PIGGY 1 0.40 43 6621 RCD TELEMETRY DEVICE REPLACEMENT 1 0.10 43 6622 RCD CELL GPS WLAN ANTENNA REPLACEMENT 1 0.10 43 6623 TK BRACKET INCL HARNESS & POWER SUPPLY REPLACEMENT 1 0.10 43 6631 REPLACE MAIN CIRCUIT BREAKER 1 0.30 43 6632 REPLACE ANY CONTROL CIRCUIT BREAKER 1 0.20 43 6633 REPLACE ANY CONTROL FUSES 1 0.10 43 6641 REPLACE EVAP., COND OR HEAT CONTACTOR, TK MPD 2 0.20 43 6642 REPLACE COMPRESSOR CONTACTOR 1 0.20 43 6643 REPLACE PHASE CONTACTOR, TK MPD 1 0.20 12
43 6644 REPLACE SOCKET RELAYS 3 0.10 43 6651 REPLACE CONTROL TRANSFORMER 1 0.30 43 6681 REPL.MPD CONTR.BOX WITH MPC2000 TRIU860-1 9.00 43 6711 REPLACE COMPRESSOR, INCL. WIRING/DRIER 1 2.50 43 6713 REPAIR/REPLACE TERMINAL BOX COMPRESSOR 1 0.30 43 6714 REPAIR COMPRESSOR FOUNDATION 5 0.10 43 6715 INSPECTION OF VALVE REEDS 1 1.00 43 6716 REPLACE VALVEPLATE / REEDS COPELAND COMP 1 1.30 43 6718 REPLACE OIL PUMP/BEARING ASSY. GASKET 1 1.00 43 6719 REPLACE COMPRESSOR TERMINAL BLOCK 1 1.00 43 6728 REPLACE COMPRESSOR SIGHT GLASS 2 0.20 43 6831 REPL. COND.MWCU6025001-6069993+GESU90X 1 3.00 43 6918 REPLACE PARTLOW MECHANISM (TRLW J-903) 1 0.50 43 6924 REPLACE RETRIEVER RECEPTACLE 1 0.50 43 6930 ADD REFRIGERANT R404A TO SYSTEM 1 0.30 43 6931 ADD REFRIGERANT TO SYSTEM 1 0.30 43 6933 ADD COMPRESSOR OIL 5 0.10 43 6935 CONTAMINATED SYSTEM 1 6.50 43 6936 EVACUATE, RECYCLE AND RECHARGE SYSTEM 10 0.10 43 6937 RECLAIM AND EVACUATE 1 0.30 43 6939 ACID TEST 3 0.20 43 6999 UPGRADE SOFTWARE MPC CONTROLLER 1 0.30 43 8111 STRAIGHTEN FRAME 4 1.00 43 8112 RETAINER, CABLE 1 0.20 43 8113 RESECURE / REINSTALL SCREWS-BOLTS 1 0.10 43 8114 REPAIR/REPLACE GRAB HANDLE 1 0.20 43 8115 BROKEN BOLT EXTRACTION 10 0.10 43 8122 REAR PANEL, REPAIR / REPLACE 2 0.20 43 8131 RE-FOAMING OF UNIT. 20 0.10 43 8141 R & R, REEFER UNIT COMPLETE 1 2.00 43 8151 REPAIR / REPLACE EVAP. ACCESS DOOR UPPER 1 0.30 43 8152 REPAIR / REPLACE HEATER ACCESS DOOR. 1 0.30 43 8153 REPAIR / REPLACE DOOR HINGE. 3 0.20 43 8154 REPAIR / REPLACE DOOR LATCH. 3 0.20 43 8155 REPAIR / REPLACE CATCH FOR DOOR LATCH. 3 0.10 43 8161 REPLACE GRILL SCREEN / GRILL DOOR. 1 0.20 43 8162 REPAIR GRILL SCREEN / GRILL DOOR. 5 0.10 43 8164 REPLACE GUARD COMPRESSOR. 1 0.10 43 8165 REPLACE BLANK PANEL 1 0.10 43 8171 REPLACE CONTROL BOX COMPLETE 1 3.00 43 8172 REPLACE CONTROL BOX DOOR 1 0.20 43 8173 REPAIR CONTROL BOX DOOR 3 0.10 43 8174 REPLACE CONTROL BOX DOOR HINGES 2 0.10 43 8175 REPLACE CONTROL BOX DOOR LATCH 2 0.10 43 8176 REPAIR/REPLACE BRACKET CONTROL BOX 10 0.10 43 8211 REPAIR PIPE, SUCTION SIDE, SYSTEM #1 10 0.10 43 8212 REPAIR PIPE, DISCHARGE SIDE, SYSTEM #1 10 0.10 43 8213 REPAIR PIPE, SUCTION SIDE, SYSTEM #2 10 0.10 43 8214 REPAIR PIPE, DISCHARGE SIDE, SYSTEM #2 10 0.10 43 8215 REPLACE FILTER DRIER, R-134A SYSTEM 1 0.50 43 8217 REPLACE FILTER DRIER, R-23 SYSTEM 1 1.00 13
43 8218 LEAK CHECK 5 0.10 43 8219 CARRY OUT BUFFER TANK MOD ON SF UNIT (R23). 1 8.00 43 8220 R23 PIPE CLAMPS MODIFICATION 3 0.30 43 8221 REPLACE SUCTION SERVICE VALVE 1 1.00 43 8222 REPLACE DISCHARGE SERVICE VALVE 1 0.70 43 8223 REPLACE LIQUID LINE VALVE 1 0.70 43 8224 REPLACE VALVE CAPS 1 0.10 43 8225 REPLACE SCHRADER VALVE 1 0.10 43 8229 REPLACE SERVICE VALVE GASKET(S) 2 0.30 43 8231 REPLACE SUCTION PRESSURE GAUGE 1 0.20 43 8232 REPLACE DISCHARGE PRESSURE GAUGE 1 0.20 43 8235 REPLACE GAUGE BRACKET, INCLUDING GAUGES 2 0.50 43 8236 REPLACE ANY GAUGE LINE 2 0.20 43 8243 REPLACE CASCADE HEAT EXCHANGER 1 1.50 43 8245 ADJUSTMENT OF SUCTION PRESSURE REGULATOR 10 0.10 43 8246 REPLACE SUCTION PRESSURE REGULATOR 1 3.00 43 8247 ADJUSTMENT DISCHARGE PRESSURE REGULATOR 10 0.10 43 8248 REPLACE DISCHARGE PRESSURE REGULATOR 1 1.50 43 8249 REPLACE DISCHARGE CHECK VALVE 1 1.00 43 8251 REPLACE THERMAL EXPANSION VALVE 1 1.00 43 8253 REPLACE THERMAL EXPANSION VALVE R-23 1 1.00 43 8254 CLEAN / ADJUST TXV 6 0.10 43 8261 REPLACE LIQUID LINE SOLENOID VALVE 1 0.70 43 8274 REPLACE ANY SOLENOID COIL 1 0.20 43 8281 REPLACE ONE HEATER 1 0.50 43 8282 REPLACE TWO HEATERS 1 0.70 43 8283 REPLACE THREE HEATERS 1 0.90 43 8284 REPLACE FOUR HEATERS 1 1.10 43 8285 REPLACE FIVE HEATERS 1 1.30 43 8286 REPLACE SIX HEATERS 1 1.50 43 8287 REPLACE ALL HEATERS 1 2.00 43 8288 REPLACE HEATER BAR BRACKET 1 0.30 43 8289 REPLACE WIRING FOR HEATERS 10 0.10 43 8292 REPLACE DRAIN HOSE 10 0.10 43 8310 REPLACE ANY SENSOR HOUSING 1 0.50 43 8311 REPLACE SUPPLY AIR SENSOR 1 0.20 43 8312 REPLACE RETURN AIR SENSOR 1 0.20 43 8313 REPLACE EVAP. COIL SENSOR 5 0.30 43 8314 REPLACE CONDENSER COIL SENSOR 1 0.20 43 8315 REPLACE COMPRESSOR DISCHARGE SENSOR 1 0.20 43 8316 REPLACE COMPRESSOR DISCHARGE SENSOR R-23 1 0.20 43 8318 REPLACE AMBIENT SENSOR 1 0.20 43 8319 REPLACE/REPAIR WIRING ANY SENSOR 5 0.10 43 8321 REPLACE KLIXON, 130F, HTT 1 0.30 43 8331 REPAIR CARGO SENSOR 3 0.10 43 8332 REPLACE CARGO SENSOR 3 0.10 43 8333 REPAIR / REPLACE CARGO SENSOR SOCKET 1 0.30 43 8351 REPLACE HP-SWITCH 1 0.30 43 8353 REPLACE HP-SWITCH R-23, SUPERFREEZER 1 0.30 43 8354 REPLACE LP-SWITCH R-23, SUPERFREEZER 1 0.50 43 8361 REPLACE ON-OFF SWITCH 1 0.20 14
43 8364 REPLACE SWITCH BOOT 1 0.10 43 8371 REPLACE POWER CABLE FROM CB IN CTR BOX 1 1.00 43 8372 REPAIR POWER CABLE ( SPLICE WITH KIT ) 1 0.30 43 8373 REPLACE POWER PLUG 1 0.30 43 8374 REPLACE GASKET, POWER PLUG 1 0.10 43 8382 REPAIR/REPLACE BURNED OUT WIRING 2 0.10 43 8383 CLEANING OF WIRING 5 0.10 43 8384 REPLACE CONNECTING CABLES,CTRL-RLB CRR40 1 0.10 43 8386 TROUBLE SHOOTING 2 0.10 43 8411 REPLACE EVAP. COIL, INCL R&R OF UNIT 1 8.00 43 8412 REPAIR OF EVAPORATOR COIL 20 0.10 43 8413 CLEANING OF EVAPORATOR COIL 5 0.10 43 8414 REPAIR/REPLACE GRILL/GRATING AT REAR 10 0.10 43 8431 REPLACE CONDENSER COIL, INCL WIRING/DRIE 1 3.50 43 8432 REPAIR CONDENSER COIL 20 0.10 43 8433 CLEANING CONDENSER COIL / FRAME 1 0.20 43 8451 REPLACE RECEIVER TANK. 1 1.00 43 8455 REPLACE RECEIVER SIGHT GLASS 1 0.20 43 8456 REPLACE HP RELIEF VALVE/FUSIBLE PLUG 1 0.20 43 8511 REPLACE EVAPORATOR FAN MOTOR 3 0.70 43 8512 REPLACE BEARINGS PR. EVAP FAN MOTOR 3 1.10 43 8514 REPLACE EVAP FAN CRR-40 3 0.30 43 8515 REPLACE WIRING FOR EVAP FAN MOTOR 10 0.10 43 8516 REPAIR/REPLACE EVAP MOTOR MOTOR FOUNDATI 10 0.10 43 8517 REPLACE KLIXON SWITCH TK MOTOR 1 1.10 43 8521 REPLACE CONDENSER FAN MOTOR, INCL FAN 1 0.70 43 8522 REPLACE BEARINGS COND. FAN MOTOR. 1 0.40 43 8524 REPLACE CONDENSER FAN 1 0.30 43 8525 REPLACE WIRING HARNESS FOR COND. MOTOR 5 0.10 43 8610 TESTING OF TK MPC OR MRB WITH TESTER 1 0.40 43 8611 REPLACE KEYPAD MPC2000 / MP-3000 1 0.50 43 8614 REPLACE DISPLAY ASSY 1 0.40 43 8615 REPLACE MAIN RELAY BOARD 1 1.00 43 8618 REPLACE DATALOGGER MPC2000 1 0.20 43 8619 REPLACE MPC2000/MP-3000 CTRL INCL PIGGY 1 0.30 43 8621 RCD TELEMETRY DEVICE REPLACEMENT 1 0.10 43 8622 RCD CELL GPS WLAN ANTENNA REPLACEMENT 1 0.10 43 8623 TK BRACKET INCL HARNESS & POWER SUPPLY REPLACEMENT 1 0.10 43 8631 REPLACE MAIN CIRCUIT BREAKER 1 0.30 43 8632 REPLACE ANY CONTROL CIRCHIT BREAKER 1 0.20 43 8633 REPLACE ANY CONTROL FUSES 1 0.10 43 8640 CONTACTOR AND BREAKER RAIL MODIFICATION AND REPLACEMENT 3 0.30 43 8641 REPLACE HEAT CONTACTOR 1 0.20 43 8642 REPLACE COMPRESSOR CONTACTOR 2 0.20 43 8643 REPLACE PHASE CONTACTOR 2 0.20 43 8644 REPLACE SOCKET RELAYS 3 0.10 43 8651 REPLACE CONTROL TRANSFORMER 1 0.30 43 8711 REPL 134A COMPRESSOR, INCL. WIRING/DRIER 1 2.50 43 8714 REPAIR COMPRESSOR FOUNDATION 5 0.10 15
43 8715 INSPECTION OF VALVE REEDS BEF. REPLACEM 1 1.00 43 8716 REPLACE VALVEPLATE / REEDS COPELAND COMP 1 1.30 43 8719 REPLACE COMPRESSOR TERMINAL BLOCK 1 1.00 43 8721 REPLACE R-23 SCROLL COMPRESSOR 1 2.50 43 8728 REPLACE COMPRESSOR SIGHT GLASS 2 0.20 43 8922 REPLACE ANY BATTERY ON DATALOGGER 1 0.10 43 8924 REPLACE RETRIEVER RECEPTACLE 1 0.50 43 8931 ADD REFRIGERANT TO R-134A SYSTEM 1 0.30 43 8932 ADD R-23 TO SYSTEM, SUPERFREEZER 1 0.30 43 8933 ADD COMPRESSOR OIL 5 0.10 43 8935 CONTAMINATED SYSTEM 2 6.50 43 8936 EVACUATE, RECYCLE AND RECHARGE SYSTEM 15 0.10 43 8937 RECLAIM AND EVACUATE 2 0.30 43 8939 ACID TEST 3 0.20 43 8999 UPGRADE SOFTWARE MPC CONTROLLER 1 0.30 16