Replacement Parts List No. 055237900 Revision R 12/2017 McQuay Seasonmaker ThinLine Horizontal Fan Coil TSH, TSC 031-121 Vintage F FTSH, FTSC 03-12 Designs A(1), B(2) Last Manufactured: 2008 To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.daikinapplied.com
Contents About the Model Number Changes... 2 Parts List Revision History... 3, 4 Nomenclature Serial Number... 5 Model Number- TSC, TSH... 6-7 Model Number- FTSC, FTSH until 3/11... 8 Model Number- FTSC, FTSH 3/11 & later... 9-12 Unit Assembly Diagram... 13 Components... 14 Coils... 15-17 Fan Deck Assembly Diagram... 18 Components... 19 Fan Motor, Capacitor, Motor Mount... 20-23 Cabinet Assembly- TSC/FTSC Diagram... 24 Components... 25-26 Electric Heaters- TSC/TSH F Vintage... 27 Electric Heater Control Components- TSC/TSH "F"... 28 Valves and Air Vent Kits-TSC/TSH "F"... 28 Field Installed Accessories- TSC/TSH "F" Units... 29 Field Installed Accessories- FTSC/FTSH Units... 30-34 Critical Parts List TSH, TSC... CPL1 FTSH, FTSC... CPL2 About the Model Number Changes In 1999 the model numbering nomenclature for the Horizontal Thinline Fan Coil changed: The TSC "F" Vintage unit is now the FTSC Design "B" unit. The TSH "F" Vintage unit is now the FTSH Design "B" unit. The unit's components did not change when the nomenclature did (a few engineering changes have taken place since this RPL was last issued, and the part number changes are noted). The complete model number nomenclature currently used has been added to this revision. Unless otherwise noted, all components listed in this revision apply to both the current and the original model numbered units. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 2
Parts List Revision History Revision Date Description A 6/98 Updated to On-Line format. Added Revision History page. Page 22- Corrected Circuit Breaker p/n. B 10/99 Page 11 -Updated information for all Motors and Motor Mounts. C 2/00 Page 22 -Automatic Changeover Clip-#031011800 & Assembly-#061361801 were added. D 7/01 Page 7 - Added Secondary Drain Pan, RH #061287501 & LH #061287502, both N/S. E 10/02 Page 11 - Shifted some type that was misaligned / no change to content. F 10/02 Added new model nomenclature for FTSC and FTSH units. All part numbers converted to current McQuay Mitrol format. Page 5 - Added Serial Number Nomenclature for units built after 2/99. Page 6 - Added new. Page 8 - Added foot notes for fan panel (Ref# 20), coils (Ref# 30) and raceway (Ref# 84). Ref# 85 P/N for size 04 changed to 061372401. Page 9 - Ref# 93 added P/N for units built 9/02 and later. Ref# 98 all P/N changed to "K" version. Page 10 - Reformatted entire page and added Design "B" coils for FTSC and FTSH units. Corrected p/n for TSC & TSH water coils. Added TSC & TSH size 121F steam coil. Pages 11, 12 - Added new. Page 13 - Rearranged diagram and added reference numbers for fan panel and housings for each size grouping. Page 14 - Added notes explaining composition of Fan Deck Assy, application of Standard/ Hi-Static motors and the 230/50/1 motor. Merged complete assemblies and the individual components into one chart. Removed motors from component chart and put them in a separate chart on the following pages, and added note. Page 15 - Removed motor mounts and capacitors for the component chart and put them in a separate chart. Added motor/capacitor/motor mount charts. Pages 16, 17, 18 - Added new. Page 22 - Added notes regarding application of insulated cabinet parts, stamped grille and FTSC return air codes. Ref# 203 P/N for sizes 03/04 & 06/08 changed to 106179801 & 106179601 respectively. Ref# 211 P/N for sizes 03/04 duct opening changed to 106341301. P/N for sizes 06/08 & 10/12 stamped grille panel changed to 107256401 & 106179701. Ref# 212 P/N for all variations changed. Page 23 - Ref# 214 P/N for the insulated panel changed to 107259801. Ref# 215 P/N for insulated panel sizes 03/04, 06/08 & 10/12 changed to 106184201, 106180101 & 106185901 respectively. P/N for standard panel sizes 03/04 & 10/12 changed to 106301901 & 107174101 respectively. Ref# 216 P/N for all variations changed. Page 24 - Note added in heading referencing application of referenced electric heaters. Combined size 101F and 121F heaters from subsequent page. Page 25 - Size 101F and 121F heaters moved to previous page. Added 'Valves and Air vent Kits' from subsequent page (which was removed). P/N for 120V 2-way valve changed to 107179601 + 107179802. P/N for 120V 3-way valve changed to 107179701 + 107179802. P/N for 277V 2-way valve changed to 107179601 + 107179804. P/N for 277V 3-way valve changed to 107179701 + 107179804. Page 26 - TSC/TSH "F" Field Accessories combined onto one page (removed 1 page) P/N for Types 1,2,3 and 7 3-Speed Switch changed to 107112101. P/N for Type 2 subbase changed to 039398400. P/N for Type 5 T-Stat changed to 047939500. P/N for Trim Flange Kits for sizes 031/041, 061/081 & 101/121 changed to 061336701, 061336702 & 061336703 respectively. P/N for ACO switch changed to 061313601. Pages 27 thru 31 Added new. Continued on next page. Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 3
Parts List Revision History Revision Date Description G 04/05 Page 26 - Added Note ***Thermostat can be used for only one mode at a time. Not a combination (either heating only OR cooling only). H 12/05 Page 9-Added zeros infront of p/n's. Page 14-Bub. #1 Fan Deck Panel 061/081 p/n changed from 061081202 to 061081201. Page 25-Valve/Balancing, Valve/Ball T-handle, Valve/Water- Manual; added 2/04 &Later Page 27 - Added Hard Ball Valve for 5/8" Sweat '2/04 and Later to Manual Valve table Page 28 - Footnote #10 re-worded. J 11/08 Page 23 - Note change from SMG Parts Tech to McQuay Parts. Page 24 - Change pn from 061149608 to 061149607 for unit size 121F 208V/4 KW. K 9/09 Page 9- Ref#95 Change Qty for p/n 061295905 size 101F to 0 and for size 121F to 1. Change Qty for p/n 061295910 size 101F to 0 and for size 121F to 1. L 7/10 Reformat document from PageMaker to CS4. Page 10- Size S03 p/n 107338101 change from 3 Row to 2 Row. Size S04 p/n 107338301 change from 3 Row to 2 Row. Page 11- Size S06 p/n 107338601 change from 3 Row to 4 Row. Size S08 p/n 107338601 change from 3 Row to 4 Row. Page 12- Size S10 p/n 107338801 change from 3 Row to 4 Row. Size S12 p/n 107339001 change from 3 Row to 4 Row. M 4/12 Page 9- Add Secondary Drain Pan LH p/n 061287511 & RH p/n 016287512. Page 29- Add Secondary Drain Pans Stainless Steel, LH p/n 910124907 & RH p/n 910124913. CPL1- Add Critical Parts List. N 9/13 Numerous changes done. Sheet metal deleted and note added. Delete Plenum diagram and components pgs 20-21. Pages 6-10 Add new code string- Model Number 6/11 & later. Pages 19-22 Change capacitor p/ns 037516401 to 910120040, 037516402 to 910120041, 037516403 to 910120042, and 037516409 to 910120039. Change motor p/n 106163005 description from high static to standard on S04 & S10 units. Change mount p/n 028844603 to 028844607 on unit 061F/S06 for motor p/n 106163004. Page 24- Ref# 212 Change standard panel assy p/n 039029610 to 039029601 S06/S08. CPL1- Split CPL into two pages. This CPL page is for TSC, TSH units. CPL2- Split CPL into two pages. This CPL page is for FTSC, FTSH units. Change motor p/n 106163005 description from high static to standard on S04 & S10. O 2/15 Pages 19,20,21 Change capacitor for motor p/n 106163006 from p/n 055237900 to 802007046. CPL1-2 Change CPL Master. P 03/16 Rebrand Daikin. Numerous changes. Page 11- Change switch Bubs 95 & 96. Page 12- Change Ref# 95 Description to Drain Pan Assy aand use DP Assy p/ns. Change Ref# 96 Description to Drain Pan, Outer. Page 14- Change Coil size 06 & 08 p/n 107338501 to 107338510. Page 17- Update the chart format. CPL1, CPL2- Rebrand Daikin. Q 08/16 Page 26- Change footnote #15 From "Duct Opening" to "Stamped grille". Change footnote #16 From "Blank (stamped grille) to "Blank panel". CPL1-CPL2 Update revision. R 12/17 Title Page- Add Last Manufactured : 2008. Page 19- Change Hub Clamp p/n 668113013 to 066534601. CPL1-CPL2 Update revision. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 4
Nomenclature Serial Number (until 2/1999) 7 6A 12345 01 Factory Engineering Revision 7= Auburn, NY 5= Staunton, VA Serial Number Year and Month of Manufacture: Year Month Q= 1985 5= 1995 A= Jan. G= Jul. R= 1986 6= 1996 B= Feb. H= Aug. S= 1987 7= 1997 C= Mar. J= Sep. T= 1988 8= 1998 D= Apr. K= Oct. U= 1989 9= 1999 E= May L= Nov. V= 1990 F= Jun. M= Dec. W= 1991 X= 1992 Y= 1993 Z= 1994 Serial Number (2/1999 to present) AUB U 09 05 00148 Plant Identification Abbreviation AUB = Auburn Serial Number (build sequence) U= Unit Week of Manufacture Year of Manufacture 08= 2008 09= 2009 etc. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 5
Nomenclature Model Number- TSC, TSH TSC 121F R A A 1 A B 1 A Y A100 YY 01EV 21EV 1 Code 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 Code 01: Unit Type TSC= Seasonmaker, Ceiling Unit TSH= Seasonmaker, Ceiling Hideaway Code 02: Unit Size (in 100's cfm) 031F= 300 cfm 041F= 400 cfm 061F= 600 cfm 081F= 800 cfm 101F= 1000 cfm 121F= 1200 cfm Code 03: Unit Hand R= Right Hand L= Left Hand Code 04: Coil Type A= Standard Coil C= High Capacity Coil Separate 1-Row Htg D= Std. Coil, Opp Hand Conn. F= Hi Cap Coil, Opp Hand Conn. H= Std. Coil, Same Hand Conn. Separate 1-Row Water Htg K= Hi Cap Coil, Same Hand Conn. M= Std. Coil, Opp Hand Conn. Separate 1-Row Steam Htg P= Hi Cap Coil, Opp Hand Conn. Q= Std. Coil, Same Hand Conn. S= Hi Cap Coil, Same Hand Conn. Code 05: Voltage A= 115/60/1 P= 265/60/1 J= 230/50/1 Code 06: Motor Type 1= Standard 2= High Static Code 07: Cabinet Plenum Options A= Standard Cabinet B= Insulated Cabinet C= Factory Installed Plenum w/duct Collar & TA Filter Y= No Plenum or Filter Code 08: Discharge Air Arrangements B= Stamped Grille C= Duct Opening w/o Collar Y= Duct Collar Code 09: Air Return 1= Bottom Stamped Opening 4= Back Duct Opening 5= Both 1 & 4 Code 10: Filter A= Throwaway B= Cleanable Code 11: Always Y Code 12: Electric Heat E 200 YYY Unit Size 031F 041F 061F 081F 101F 121F Voltage Wattage 120V 208V 240V 265V KW Code KW Code KW Code KW Code 1.0 A100 1.0 E100 1.0 K100 1.0 P100 2.0 A200 2.0 E200 2.0 K200 2.0 P200 3.0 E300 3.0 K300 3.0 P300 1.0 A100 1.0 E100 1.0 K100 1.0 P100 2.0 A200 2.0 E200 2.0 K200 2.0 P200 3.0 E300 3.0 K300 3.0 P300 2.0 A200 2.0 E200 2.0 K200 2.0 P200 4.0 E400 4.0 K400 4.0 P400 6.0 E600 6.0 K600 6.0 P600 2.0 A200 2.0 E200 2.0 K200 2.0 P200 4.0 E400 4.0 K400 4.0 P400 6.0 E600 6.0 K600 6.0 P600 4.0 E400 4.0 K400 4.0 P400 6.0 E600 6.0 K600 6.0 P600 8.0 P800 4.0 E400 4.0 K400 4.0 P400 6.0 E600 6.0 K600 6.0 P600 8.0 P800 Continued on next page. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 6
Nomenclature Model Number- TSC, TSH- Continued Code 13: Control System 05= 2 Pipe, Valve Cycle, MCO, TStat & 3-Spd Switch 06= 2 Pipe, Valve Cycle, ACO, TStat & 3-Spd Switch 07= 2 Pipe, Valve Cycle, Htg only, TStat & 3-Spd Switch 08= 2 Pipe, Valve Cycle, Clg only, TStat & 3-Spd Switch 09= 2 Pipe, Valve Cycle, MCO, Comb- TStat & 3-Spd Sw 10= 2 Pipe, Valve Cycle, ACO, Comb- TStat & 3-Spd Sw 11= 2 Pipe, Valve Cycle, Htg only, Comb- TStat & 3-Spd Sw 12= 2 Pipe, Valve Cycle, Clg only, Comb- TStat & 3-Spd Sw 17= 2 Pipe, Fan Cycle, MCO, TStat & 3-Spd Switch 18= 2 Pipe, Fan Cycle, ACO, TStat & 3-Spd Switch 19= 2 Pipe, Fan Cycle, Htg only, TStat & 3-Spd Switch 20= 2 Pipe, Fan Cycle, Clg only, TStat & 3-Spd Switch 21= 2 Pipe, Fan Cycle, MCO, Comb- TStat & 3-Spd Sw 22= 2 Pipe, Fan Cycle, ACO, Comb- TStat & 3-Spd Sw 23= 2 Pipe, Fan Cycle, Htg only, Comb- TStat & 3-Spd Sw 24= 2 Pipe, Fan Cycle, Clg only, Comb- TStat & 3-Spd Sw 27= 2 Pipe, Elect Ht & 2 Pipe Clg, TStat & 3-Spd Sw 30= 2 Pipe, Elect Ht & 2 Pipe Clg, Comb- TStat & 3-Spd Sw 32= 2 Pipe, Elect Ht, Comb- TStat & 3-Spd Sw 35= 4 Pipe, Valve Cycle, DPDT TStat & 3-Spd Sw 37= 4 Pipe, Valve Cycle, Comb- DPDT TStat & 3-Spd Sw 61= 2 Pipe, Int Elec Ht, 2 ACO, DPDT TStat & 3-Spd Sw 62= 2 Pipe, Int Elec Ht, 2 ACO, Comb- DPDT TStat & 3-Spd Sw 71= 2 Pipe, Fan & Valve Cycle, MCO, TStat & 3-Spd Sw 72= 2 Pipe, Fan & Valve Cycle, ACO, TStat & 3-Spd Sw 73= 2 Pipe, Fan & Valve Cycle, Htg only, TStat & 3-Spd Sw 74= 2 Pipe, Fan & Valve Cycle, Clg only, TStat & 3-Spd Sw 75= 2 Pipe, Fan & Valve Cycle, MCO, Comb- TStat & 3-Spd Sw 76= 2 Pipe, Fan & Valve Cycle, ACO, Comb- TStat & 3-Spd Sw 77= 2 Pipe, Fan & Vlv Cycle, Htg only, Comb- TStat & 3-Spd Sw 78= 2 Pipe, Fan & Vlv Cycle, Clg only, Comb- TStat & 3-Spd Sw Y Code 14: Water Cooling Coil Valve Package YYY 01EV= 2-Way Electric Valve, LH 02EV= 3-Way Electric Valve w/o Bypass Bal Valve, LH 03EV= 3-Way Electric Valve w/bypass Bal Valve, LH 11EV= 2-Way Electric Valve, RH 12EV= 3-Way Electric Valve w/o Bypass Bal Valve, RH 12PN= 3-Way Pnuematic, RH 13EV= 3-Way Electric Valve w/bypass Bal Valve, RH Code 15: Water Heating Coil Valve Package YYY 21EV= 2-Way Electric Valve, LH 22EV= 3-Way Electric Valve w/o Bypass Bal Valve, LH 23EV= 3-Way Electric Valve w/bypass Bal Valve, LH 31EV= 2-Way Electric Valve, RH 32EV= 3-Way Electric Valve w/o Bypass Bal Valve, RH 33EV= 3-Way Electric Valve w/bypass Bal Valve, RH Code 16: Disconnect 1= Unit Mntd Disc Switch 2= Circuit Breaker Disc Switch Code 17: Packaging Code 18: Agency Code 19: Miscellaneous Code 20: Always Y Code 21: Warranties Code 22: Always A Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 7
Nomenclature Model Number- FTSC, FTSH until 3/11 F TSC 1 S03 A A 70 E 00 AY 18 G I Code 01 02 03 04 05 06 07 08 09 10 11 12 13 Code 01: Unit Type F= Fan Coil Code 02: Product Identifier TSC= Thinline Horizontal Fan Coil TSH= Thinline Horizontal Fan Coil, Hideaway Code 03: Design Series 1= A Design 2= B Design Code 04: Unit Size (in 100's cfm) S02= 200 cfm H02= 200 cfm S03= 300 cfm H03= 300 cfm S04= 400 cfm H04= 400 cfm S06= 600 cfm H06= 600 cfm S08= 800 cfm H08= 800 cfm S10= 1000 cfm H10= 1000 cfm S12= 1200 cfm H12= 1200 cfm Code 05: Voltage A= 115/60/1 J= 265/60/1 Code 06: Coil Otions A= Standard Coil (Not With Steam Heat) H= High Capacity Code 07: Heating Options 00= None 70= 1-Row Heating Coil (HW) 72= 2-Row Heating Coil (Steam) Code 08: Hand Orientation A= Same Hand Left* B= Same Hand Right* E= Left Hand Heat/Right Hand Cooling F= Right Hand Heat/Left Hand Cooling *(valve kits will not fit on these units) Code 09: Controls 00= None Code 10: Discharge AY= Front (FTSC) AX= Top (FTSH) Code 11: Return Air/Outside Air 17= Rear Ducted w/ Filter (FTSH) 18= Bottom Return, Stamped Grille (FTSC) 20= Rear Return Code 12: Power Connection G= Box w/ Switch Z= None Code 13: Color I= Antique Ivory (FTSC) Z= None (FTSH) Code 14: SKU Type Code 15: Style Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 8
Nomenclature Model Number- FTSC, FTSH 03/11 & later FT SC 2 S10 A A G M Y YY W412LYS YY00YYY YY W112LYS Y 000 Code 01 02 03 04 05 06 07 08 09 10 11-16 17-21 22 23-27 28 29 YY G PSC S 3 Y YY YY YYY D Y Y Y Y Y YY YYY Y YYYY Code 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 YYYY YYYY Y Y C YYYY YYY S 18 B I 00 S 0000 YYY FS BS Y Code 49 50 51 52 53 54-57 58-60 61 62 63 64 65 66 67-68 69 70 71 72 YYY Y 2 Code 73 74 75 Code 01 & 02= Unit Type FTSC= Thinline Horizontal Fan Coil FTSH= Thinline Horizontal Fan Coil, Hideaway Code 03= Design Series 1= A Design 2= B Design Code 04= Unit Size (in 100's cfm) S03= 300 cfm H03= 300 cfm S04= 400 cfm H04= 400 cfm S06= 600 cfm H06= 600 cfm S08= 800 cfm H08= 800 cfm S10= 1000 cfm H10= 1000 cfm S12= 1200 cfm H12= 1200 cfm Code 10= Always YY Code 05= Voltage A= 115/60/1 J= 265/277/60/1 Coil Options Code 06= Coils- Fin Type A= Aluminum Code 07= Coils- Casing Material G= Galvanized Code 09= Coils- Coating Code 10= Always YY Primary Coil Code 11 to 16= Primary Coil C 3 12 R Y S Connection Type S= Sweat T= Threaded Piping Package F= Factory Installed Connection Location L= Left Hand R= Right Hand Fins-per-inch 12= 12 FPI Rows 1= 1-Row (Horizontal heaters only) 2= 2-Row 3= 3-Row 4= 4-Row Coil Type C= Chilled Water Only H= Hot Water Only W= CW/HW 2- Pipe S= Steam Code 08= Coils- Air Vent A= Auto M= Manual Continued on the next page. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 9
Nomenclature Model Number- FTSC, FTSH 3/11 & later Continued Preheat Coil Code 17 to 21= Preheat Coil YY 00 Y Y Y Connection Type S= Sweat T= Threaded Code 22= Always YY Piping Package F= Factory Installed Connection Location L= Left Hand R= Right Hand Fins-per-inch 12= FPI 00= None Coil Type E1= Electric Single Stage M1= Intermediate Electric Heat Single Stage W1= 1-Row Water W2= 2-Row Water S1= 1-Row Steam S2= 2-Row Steam Y Reheat Coil Code 23 to 27= Secondary Reheat Coil W1 12 2 Y S Connection Type S= Sweat T= Threaded Piping Package F= Factory Installed L= Ship Loose Connection Location L= Left Hand R= Right Hand Fins-per-inch 12= 12 FPI 00= None Coil Type W1= 1-Row Water (CW) W2= 2-Row Water (CW) S1= 1-Row Steam (CW) Y (CW/HW) Code 28= Electric Heat Power Supply A= 115/60/1 G= 230/60/1 C= 208/60/1 J= 265/60/1 E= 208/230/60/1 L= 230/50/1 Code 29= Electric Heat Wattage 005= 0.5 kw 040= 4.0 kw 010= 1.0 kw 050= 5.0 kw 015= 1.5 kw 060= 6.0 kw 020= 2.0 kw 070= 7.0 kw 025= 2.5 kw 080= 8.0 kw 030= 3.0 kw 100= 10.0 kw 000= None Code 30= Always YY Code 31= Drain Pan Material G= Galvanized P= Plastic S= Stainless Steel Code 32= Blower Motor Type PSC= PSC Motor ECM= DC Motor Type Code 33= Discharge Conditions S= Standard Static H= High Static Code 34= Motor Speed 3= 3 Speed Code 35= Motor Connections Q= Quick Connect Code 36= Always YY Code 37= Fresh Air Damper 1st Digit- Fresh Air Opening Location R= Rear T= Top 2nd Digit- Damper Type M= Manual 2= Auto, 2-Position (Field Install Only) E= Auto, Economizer Code 38= Cabinet Size YYY= Standard Cabinet AYY= Small Cabinet Code 39= Unit Disconnect Switch D= Disconnect Switch- Toggle Continued on the next page. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 10
Nomenclature Model Number- FTSC, FTSH 3/11 & later- Continued Code 40= Site Control Voltage L= 24V (low) Voltage H= Line Voltage Code 41= Control Type D= Digital L= Low Voltage interface Board & 3 Speed Switch P= Analog TStat R= Low Voltage Interface Board S= 3 Speed Switch Code 42= Network Communication Card Code 43= Changeover Type A= Auto Sensor M= Manual S= Auto Switch U= User Selectable Code 44= Programmability C= 7 Days Code 45= Setpoint Adjustment 1st Digit- Location I= Remote Mounted IR R= Remote Mounted Hardwired 2nd Digit- Type F= Full Range L= +/- 5 Degrees Code 46= Fan Speed Control Digit 1: Speed Adjustment Type A= Auto (Staged) M= Manual Digit 2: Available Fan Speeds B= Off/ Low/Med/High D= Off/ Low/High Digit 3: Mounting Location R= Remote (Wall mounted w/mt3) U= Unit Mounted Code 47= Timed Override R= Remote U= Unit Mounted Code 48= Primary Coil Valve Y Y Y Y Actuator Input F= 3 Wire Floating Point L= Low Voltage (24V)- EOC P= 0-10V Proportional- Mod U= Unit Voltage- EOC/Mod Control Type E= EOC M= Modulating Unpowered Position C= Closed O= Open Primary Coil Valve Type 2= Two Way 3= Three Way Code 49= Preheat Coil Valve Y Y Y Y Actuator Input F= 3 Wire Floating Point L= Low Voltage (24V)- EOC P= 0-10V Proportional- Mod U= Unit Voltage- EOC/Mod Control Type E= EOC M= Modulating Unpowered Position C= Closed O= Open Preheat Coil Valve Type 2= Two Way 3= Three Way Code 50= Reheat Coil Valve Y Y Y Y Actuator Input F= 3 Wire Floating Point L= Low Voltage (24V)- EOC P= 0-10V Proportional- Mod U= Unit Voltage- EOC/Mod Control Type E= EOC M= Modulating Unpowered Position C= Closed O= Open Reheat Coil Valve Type 2= Two Way 3= Three Way Continued on the next page. Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 11
Nomenclature Model Number- FTSC, FTSH 3/11 & later Continued Code 51= Return Air Thermostat Code 52= Low Temperature Protection A= Auto Code 53= Condensate Overflow Protection C= Condensate Overflow Protection Code 54= Discharge Air Thermistor Code 55= Smoke Input S= Smoke Input Code 56= Occ/Vacant Control Input V= Vacant/Occupied Control Code 57= Filter Status Code 58= Fan Status A=Continuous Fan Operation C= Operation Cycles w/demand Code 59= Entering Water Thermistor E= Entering Water Thermistor Code 60= Always Y Code 61= Cabinet Style S= Standard T= Tamperproof Code 62= Cabinet Guage 16= 16 Guage 18= 18 Guage Y Code 63= Cabinet Coating Type B= Powder Coat Code 64= Cabinet Color B=Putty Beige C= Cupola White G= Soft Gray I= Antique Ivory W= Off White N= None Code 65= Cabinet Depth Extension 04= 4 Inch Extended Depth (Field Installed) 08= 8 Inch Extended Depth (Field Installed) 00= None Code 66= Unit Lineup Position S= Standalone Code 67= Left Hand End Pocket Extension 00= None Code 68= Right Hand End Pocket Extension 00= None Code 69= Subbase Digit 1:Height 35= Standard Subbase (Approx, 3.3") Y Digit 2: Leveling Feet F= Leveling Feet Code 70: Discharge Air- Outlet Digit 1: D/A Location F= Front T= Top Digit 2: Type A= Double Deflection Adjustable Grille D= Duct Collar S= Stamped Louver P= Open Code 71: Return Air Inlet Digit 1: R/A Location B= Bottom F= Front T= Top Digit 2: Type R= Open Return S= Stamped Louver T= Toe Space Code 72: Filter 1= 1" Throwaway MERV 3 2= 1" Throwaway Pleated MERV 8 3= 1" Throwaway + (1) Extra 5= Washable Filter 7= 1" MERV 13 HIgh Efficiency Code 73= Alway YYY Code 74= Cabinet/Plenum Insulation F= Fiberglass 1/2" C= Closed Cell 1/4" Code 75: Agency Listing Code 76: Packaging Code 77: Warranty Code 78: Product Style/Quick Ship Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 12
Unit Assembly Diagram 83 81 90 82 80 95 84 97 96 85 93 98 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 13
Unit Assembly Components Unit Size Ref Description Part No. Number 80 Plate- Base 1 1 1 1 1 1 1 81 Plate- Left Hand 1 1 1 1 1 1 1 82 Plate- Right Hand 1 1 1 1 1 1 1 83 Plate- Top 1 1 1 1 1 1 1 84 Raceway- Electrical Wire 1 1 1 1 1 1 1 85 Access Panel- Bottom 1 1 1 1 1 1 1 90 Seal Strip- Adh. Back 060661811 1 Seal Strip- Adh. Back 060661812 1 Seal Strip- Adh. Back 060661813 1 1 Seal Strip- Adh. Back 060661814 1 Seal Strip- Adh. Back 060661815 1 93 Drip Pan- Motor until 8/02 061335401 1 1 1 1 2 2 Drip Pan- Motor 9/02 & later 061335411 1 1 1 1 2 2 95 Drain Pan Assy LH 061163201 1 Drain Pan Assy RH 061163101 1 Drain Pan Assy LH 061163202 1 Drain Pan Assy RH 061163102 1 Drain Pan Assy LH 061163203 1 1 Drain Pan Assy RH 061163103 1 1 Drain Pan Assy LH 061163204 1 Drain Pan Assy RH 061163104 1 Drain Pan Assy LH 061163205 1 Drain Pan Assy RH 061163105 1 96 Assy, Drain Pan, Outer LH 061295901 1 Assy, Drain Pan, Outer RH 061295906 1 Assy, Drain Pan, Outer LH 061295902 1 Assy, Drain Pan, Outer RH 061295907 1 Assy, Drain Pan, Outer LH 061295903 1 1 Assy, Drain Pan, Outer RH 061295908 1 1 Assy, Drain Pan, Outer LH 061295904 1 Assy, Drain Pan, Outer RH 061295909 1 Assy, Drain Pan, Outer LH 061295905 1 Assy, Drain Pan, Outer RH 061295910 1 97 Insulation- Fiberglass 1 1 1 1 1 1 1 98 Gasket- Adhesive Backed 033513371K 1 Gasket- Adhesive Backed 033513383K 1 Gasket- Adhesive Backed 039806501K 1 1 Gasket- Adhesive Backed 039806517K 1 Gasket- Adhesive Backed 039806553K 1 N/S Secondary Drain Pan, Galv. RH 061287501 1 1 1 1 1 1 N/S Secondary Drain Pan, Galv. LH 061287502 1 1 1 1 1 1 N/S Secondary Drain Pan, SS RH 061287511 1 1 1 1 1 1 N/S Secondary Drain Pan, SS LH 061287512 1 1 1 1 1 1 N/S = Not Shown on diagram. 1 Please contact Daikin with unit model and serial number for part numbers on Cabinet components. 031F/S03 041F/S04 061F/S06 081F/S08 101F/S10 121F/S12 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 14
Coils TSC/TSH 031F Coil Part Description Number Cooling Coil, Standard- 2 Row, 12 FPI- 8¾" x 19" 061083801 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 19" 061090301 Reheat Coil- 1 Row Water- 7" x 15¾" 062844701 Reheat Coil- 1 Row Steam- 7½" x 15" 047780600 FTSC/FTSH S03 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 2 Row 8¾" x 19" 1 (Des. A) A 00,70,72 061083801 Cooling Coil, Standard- 2 Row 8¾" x 19" 2 (Des. B) A 00,70,72 107338101 Cooling Coil, High Cap.- 3 Row 8¾" x 19" 1 (Des. A) C 00,70,72 061090301 Cooling Coil, High Cap.- 3 Row 8¾" x 19" 2 (Des. B) C 00,70,72 107338201 Heating Coil- 1 Row Water- 7" x 15¾" 1, 2 A or C 70 062844701 Heating Coil- 1 Row Steam- 7½" x 15" 1, 2 C 72 047780600 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). TSC/TSH 041F Coil Part Description Number Cooling Coil, Standard- 2 Row, 12 FPI- 8¾" x 25" 061083901 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 25" 061090401 Reheat Coil- 1 Row Water- 7" x 21¾" 062844801 Reheat Coil- 1 Row Steam- 7½" x 21" 047780500 FTSC/FTSH S04 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 2 Row 8¾" x 25" 1 (Des. A) A 00,70,72 061083901 Cooling Coil, Standard- 2 Row 8¾" x 25" 2 (Des. B) A 00,70,72 107338301 Cooling Coil, High Cap.- 3 Row 8¾" x 25" 1 (Des. A) C 00,70,72 061090401 Cooling Coil, High Cap.- 3 Row 8¾" x 25" 2 (Des. B) C 00,70,72 107338401 Heating Coil- 1 Row Water- 7" x 21¾" 1, 2 A or C 70 062844801 Heating Coil- 1 Row Steam- 7½" x 21" 1, 2 C 72 047780500 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 15
Coils TSC/TSH 061F Coil Part Description Number Cooling Coil, Standard- 2 Row, 12 FPI- 8¾" x 34" 061084001 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 34" 061090501 Reheat Coil- 1 Row Water- 7" x 30¾" 062844901 Reheat Coil- 1 Row Steam- 7½" x 30" 047780300 FTSC/FTSH S06 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 2 Row 8¾" x 34" 1 (Des. A) A 00,70,72 061084001 Cooling Coil, Standard- 3 Row 8¾" x 34" 2 (Des. B) A 00,70,72 107338510 Cooling Coil, High Cap.- 3 Row 8¾" x 34" 1 (Des. A) C 00,70,72 061090501 Cooling Coil, High Cap.- 4 Row 8¾" x 34" 2 (Des. B) C 00,70,72 107338601 Heating Coil- 1 Row Water- 7" x 30¾" 1, 2 A or C 70 062844901 Heating Coil- 1 Row Steam- 7½" x 30" 1, 2 C 72 047780300 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). TSC/TSH 081F Coil Part Description Number Cooling Coil, Standard- 3 Row, 9 FPI- 8¾" x 34" 061084003 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 34" 061090501 Reheat Coil- 1 Row Water- 7" x 30¾" 062844901 Reheat Coil- 1 Row Steam- 7½" x 30" 047780300 FTSC/FTSH S08 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 3 Row 8¾" x 34" 1 (Des. A) A 00,70,72 061084003 Cooling Coil, Standard- 3 Row 8¾" x 34" 2 (Des. B) A 00,70,72 107338510 Cooling Coil, High Cap.- 3 Row 8¾" x 34" 1 (Des. A) C 00,70,72 061090501 Cooling Coil, High Cap.- 4 Row 8¾" x 34" 2 (Des. B) C 00,70,72 107338601 Heating Coil- 1 Row Water- 7" x 30¾" 1, 2 A or C 70 062844901 Heating Coil- 1 Row Steam- 7½" x 30" 1, 2 C 72 047780300 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 16
TSC/TSH 101F Coils Coil Part Description Number Cooling Coil, Standard- 3 Row, 9 FPI- 8¾" x 42" 061084101 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 42" 061090601 Reheat Coil- 1 Row Water- 7" x 38¾" 062845001 Reheat Coil- 1 Row Steam- 7½" x 38" 047780200 FTSC/FTSH S10 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 3 Row 8¾" x 42" 1 (Des. A) A 00,70,72 061084101 Cooling Coil, Standard- 3 Row 8¾" x 42" 2 (Des. B) A 00,70,72 107338701 Cooling Coil, High Cap.- 3 Row 8¾" x 42" 1 (Des. A) C 00,70,72 061090601 Cooling Coil, High Cap.- 4 Row 8¾" x 42" 2 (Des. B) C 00,70,72 107338801 Heating Coil- 1 Row Water- 7" x 38¾" 1, 2 A or C 70 062845001 Heating Coil- 1 Row Steam- 7½" x 38" 1, 2 C 72 047780200 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). TSC/TSH 121F Coil Part Description Number Cooling Coil, Standard- 3 Row, 9 FPI- 8¾" x 58" 061084201 Cooling Coil, High Capacity- 3 Row, 12 FPI- 8¾" x 58" 061090701 Reheat Coil- 1 Row Water- 7" x 54¾" 062845101 Reheat Coil- 1 Row Steam- 7½" x 54" 047780100 FTSC/FTSH S12 Designs A & B Coil FTSC/FTSH FTSC/FTSH FTSC/FTSH Part Description 3 C03= C06= C07= Number Cooling Coil, Standard- 3 Row 8¾" x 58" 1 (Des. A) A 00,70,72 061084201 Cooling Coil, Standard- 3 Row 8¾" x 58" 2 (Des. B) A 00,70,72 107338901 Cooling Coil, High Cap.- 3 Row 8¾" x 58" 1 (Des. A) C 00,70,72 061090701 Cooling Coil, High Cap.- 4 Row 8¾" x 58" 2 (Des. B) C 00,70,72 107339001 Heating Coil- 1 Row Water- 7" x 54¾" 1, 2 A or C 70 062845101 Heating Coil- 1 Row Steam- 7½" x 54" 1, 2 C 72 047780100 3 The approximate date for the design (vintage) change was Oct., 2000. Consult Nameplate or G.O. to determine design (see nomenclature page for full unit definition). Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 17
Fan Deck Assembly Diagrams 1 2 1 Unit Sizes 061F & 081F/ S06 & S08 2 3 3 Unit Sizes 031F & 041F/ S03 & S04 7 4 6 10 9 12 8 Fan Detail (sizes 06/08 shown) 2 1 1 2 3 3 Unit Size 101F/ S10 Unit Size 121F/ S12 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 18
Fan Deck Assembly Components Unit Size/ Quantity Ref. No. Part Description Part Number 031F/S03 041F/S04 061F/S06 081F/S08 101F/S10 121F/S12 1 Fan Deck 061372102 1 Fan Deck 061372202 1 Fan Deck 061081202 1 1 Fan Deck 061081302 1 Fan Deck 061081402 1 2 Fan Housing, Discharge Half 022930900 1 1 1 1 1 1 3 Fan Housing, Access Half 022931000 1 1 1 1 1 1 4 Motor See chart on next pages. 6 Cap, Capacitor 040157200 1 1 1 1 2 2 7 Motor Mount See chart on next pages. 8 Clamp, Motor Mount 000134500 2 2 2 2 4 4 9 Clamp, Wheel Hub Mounting 066534601 1 1 2 2 3 4 10 Wheel, Blower 062218301 1 1 2 2 3 4 12 Capacitor See chart on next pages. N/S Cabinet/Chassis Components 1 1 1 1 1 1 1 1 Please contact Daikin with unit model and serial number for part numbers on Cabinet components. Complete Fan Deck Assy 4 Part Description Fan Deck Assembly, Standard Motor 5 4 Assembly contains all components illustrated in the diagrams on the previous page. 5 The fan motors were offered as "Standard" or "Hi-Static" on the older models. The FTSC/FTSH units are all "standard motors". 6 230/50/1 is not offered on the FTSC/FTSH units. N/A= Not Applicable. Unit Sizes 031F/S03 041F/S04 061F/S06 081F/S08 101F/S10 121F/S12 115/60/1V 106151101 107174135 107174136 107248401 061155105 106182301 230/50/1V 6 061155107 106340801 061155109 106340901 06115000 061155112 265/60/1V 061155113 061155114 107340015 061155116 061155117 107340018 Fan Deck Assembly, High Static Motor 5 115/60/1V N/A 107258501 107262301 061155121 106340301 061155123 265/60/1V N/A 061155124 061155125 061155126 061155127 061155128 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 19
TSC/TSH 031F Fan Motor, Capacitor, Motor Mount Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 115/60/1 106163010 910120040 8 028844601 9 Single Shaft- Standard 277/60/1 106163013 910120040 8 028844602 9 8 The original motor used capacitor 037516402. If ordering a new motor the 910120040 capacitor should also be ordered. 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. FTSC/FTSH S03 Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 115/60/1 106163010 910120040 028844601 Single Shaft- Standard 277/60/1 106163013 910120040 028844602 TSC/TSH 041F Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 115/60/1 106163005 910120041 028844624 9 Single Shaft- Standard 277/60/1 106163018 910120041 028844602 9 Single Shaft- Standard 230/50/1 106163018 910120042 028844602 9 Single Shaft- High Static 115/60/1 106163005 910120041 028844624 9 Single Shaft- High Static 277/60/1 044691000 910120041 028844602 9 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. FTSC/FTSH S04 Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 115/60/1 106163005 910120041 028844624 Single Shaft- Standard 277/60/1 106163018 910120041 028844602 Single Shaft- High Static 10 115/60/1 106163005 910120041 028844624 Single Shaft- High Static 10 277/60/1 044691000 910120041 028844602 10 High Static is not a standard option. These units are specials and noted as such in the nomenclature (a standard unit would be FTSC2S04..., a Hi-Stat special is FTSC2H04...) Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 20
TSC/TSH 061F Fan Motor, Capacitor, Motor Mount Continued Motor Description Voltage Motor Capacitor Mount Double Shaft- Standard 115/60/1 106163011 910120041 028844605 9 Double Shaft- Standard 277/60/1 106163012 910120042 028844602 9 Double Shaft- Standard 230/50/1 106163012 910120042 028844602 9 Double Shaft- High Static 115/60/1 106163004 910120042 8 028844607 9 Double Shaft- High Static 277/60/1 106163015 910120042 8 028844603 9 8 The original motor used capacitor 037516404 (115V) or 037516402 (277V). If ordering a new motor the 910120042 capacitor should also be ordered. 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. FTSC/FTSH S06 Motor Description Voltage Motor Capacitor Mount Double Shaft- Standard 115/60/1 106163023 910120042 028844602 Double Shaft- Standard 277/60/1 106163024 910120039 028844602 Double Shaft- High Static 10 115/60/1 106163004 910120042 028844607 Double Shaft- High Static 10 277/60/1 106163015 910120042 028844603 10 High Static is not a standard option. These units are specials and noted as such in the nomenclature (a standard unit would be FTSC2S06..., a Hi-Stat special is FTSC2H06...) TSC/TSH 081F Motor Description Voltage Motor Capacitor Mount Double Shaft- Standard 115/60/1 106163006 910120042 028844605 9 Double Shaft- Standard 277/60/1 061266402 910120042 028844603 9 Double Shaft- Standard 230/50/1 061266402 910120042 028844603 9 Double Shaft- High Static 115/60/1 106163004 910120042 028844603 9 Double Shaft- High Static 277/60/1 106163015 910120042 8 028844603 9 8 The original motor used capacitor 037516404. If ordering a new motor the 910120042 capacitor should also be ordered. 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. FTSC/FTSH S08 Motor Description Voltage Motor Capacitor Mount Double Shaft- Standard 115/60/1 106163006 910120042 028844605 Double Shaft- Standard 277/60/1 106163024 910120039 028844602 Double Shaft- High Static 10 115/60/1 106163004 910120042 028844603 Double Shaft- High Static 10 277/60/1 106163015 910120042 028844603 10 High Static is not a standard option. These units are specials and noted as such in the nomenclature (a standard unit would be FTSC2S08..., a Hi-Stat special is FTSC2H08...) Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 21
Fan Motor, Capacitor, Motor Mount Continued TSC/TSH 101F Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 11 115/60/1 106163010 910120040 028844601 9 Single Shaft- Standard 11 277/60/1 106163013 910120040 028844602 9 Single Shaft- Standard 11 230/50/1 106163013 910120041 028844602 9 Single Shaft- Standard 12 115/60/1 106163005 910120041 028844602 9 Single Shaft- Standard 12 277/60/1 106163018 910120041 028844602 9 Single Shaft- Standard 12 230/50/1 106163018 910120042 028844602 9 Single Shaft- Standard 12 115/60/1 106163005 910120041 8A 028844601 9 Single Shaft- High Static 277/60/1 044691000 910120041 8A 028844602 9 Double Shaft- Standard 115/60/1 106163006 910120042 028844605 9 Double Shaft- Standard 277/60/1 061266402 910120042 028844603 9 Double Shaft- Standard 230/50/1 061266402 910120042 028844603 9 Double Shaft- High Static 115/60/1 106163004 910120042 028844603 9 Double Shaft- High Static 277/60/1 106163015 910120042 8 028844603 9 8 The original motor used capacitor 037516404. If ordering a new motor the 910120042 capacitor should also be ordered. 8A The original motor used capacitor 037516404 (115V) or 037516401 (277V). If ordering a new motor the 910120040 capacitor should also be ordered. 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. 11 These motors used on units built before Revision Level 02. 12 These motors used on units built Revision Level 02 and later. FTSC/FTSH S10 Motor Description Voltage Motor Capacitor Mount Single Shaft- Standard 115/60/1 106163005 910120041 028844624 Single Shaft- Standard 277/60/1 106163018 910120041 028844602 Single Shaft- High Static 10 115/60/1 106163005 910120041 028844624 Single Shaft- High Static 10 277/60/1 044691000 910120042 028844603 Double Shaft- Standard 115/60/1 106163006 910120042 028844605 Double Shaft- Standard 277/60/1 106163017 910120042 028844603 Double Shaft- High Static 10 115/60/1 106163004 910120042 028844603 Double Shaft- High Static 10 277/60/1 106163015 910120042 028844603 10 High Static is not a standard option. These units are specials and noted as such in the nomenclature (a standard unit would be FTSC2S10..., a Hi-Stat special is FTSC2H10...) Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 22
TSC/TSH 121F (Qty.= 2 of each component) Motor Description Voltage Motor Capacitor Mount Double Shaft- Standard 115/60/1 106163006 910120042 028844605 9 Double Shaft- Standard 277/60/1 061266402 910120042 028844603 9 Double Shaft- Standard 230/50/1 061266402 910120042 028844603 9 Double Shaft- High Static 115/60/1 106163004 910120042 028844603 9 Double Shaft- High Static 277/60/1 106163015 910120042 8 028844603 9 8 The original motor used capacitor 037516404. If ordering a new motor the 910120042 capacitor should also be ordered. 9 The motors listed here are replacements for the now obsolete original motors. When ordering a new motor, a new mount should also be ordered. Fan Motor, Capacitor, Motor Mount Continued FTSC/FTSH S12 (Qty.= 2 of each component) Motor Description Voltage Motor Capacitor Mount Double Shaft 115/60/1 106163023 910120042 028844602 Double Shaft 277/60/1 106163024 910120039 028844602 Double Shaft- High Static 10 115/60/1 106163004 910120042 028844603 Double Shaft- High Static 10 277/60/1 044691000 910120041 028844602 10 High Static is not a standard option. These units are specials and noted as such in the nomenclature (a standard unit would be FTSC2S12..., a Hi-Stat special is FTSC2H12...) Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 23
Cabinet Assembly- TSC/FTSC Diagram 202 Bottom Return Shown 214 212 213 203 Base Unit 211 214 204 Ref. 203 205 216 215 Use for Sizes 03, 04, 101 only Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 24
Cabinet Assembly- TSC/FTSC Components Ref Description Part No. Number 202 Panel Assy- Top- Insulated 1 1 1 1 1 1 1 203 Transition Assy - Insulated 1 1 1 1 1 1 1 204 Clip, S-type 000877700 4 4 4 4 4 4 205 Baffle, Transition 1 2 2 2 211 Discharge Panel Assy, Insulated 14 039586700 1 1 Discharge Panel Assy - Standard 14 038567801 1 1 Discharge Panel Assy, Insulated 14 039586800 1 1 Discharge Panel Assy - Standard 14 039030301 1 1 Discharge Panel Assy, Insulated 14 039586900 1 1 Discharge Panel Assy - Standard 14 038567901 1 1 Back Panel Assy - Insulated 14 038568800 1 1 Discharge Panel Assy - Standard 14 038567601 1 1 Back Panel Assy - Insulated 14 038565400 1 1 Discharge Panel Assy - Standard 14 039029501 1 1 Back Panel Assy - Insulated 14 038568900 1 1 Discharge Panel Assy - Standard 14 038567701 1 1 212 Back Panel Assy - Insulated 15 061405701 1 1 Back Panel Assy - Standard 15 061401103 1 1 Back Panel Assy - Insulated 15 061405702 1 1 Back Panel Assy - Standard 15 061401203 1 1 Back Panel Assy - Insulated 15 106511901 1 1 Back Panel Assy - Standard 15 061401303 1 1 Back Panel Assy - Insulated 16 046454400 1 1 Back Panel Assy - Standard 16 038568101 1 1 Back Panel Assy - Insulated 16 046454500 1 1 Back Panel Assy - Standard 16 039029601 1 1 Back Panel Assy - Insulated 16 046879000 1 1 Back Panel Assy - Standard 16 038568701 1 1 213 Spring- Filter 001415000 2 2 2 2 4 4 214 End Panel Assy - Insulated 13 107259801 2 2 2 2 2 2 End Panel Assy - Standard 039029701 2 2 2 2 2 2 NOTE: Insulated Cabinets= Standard panels + insulation. Insulated cabinets used on TSC units only. NOTE: All part numbers listed in italics are NOT set up WDSII (not orderable). Please contact Daikin. 14 Stamped Grille is only option for the front discharge on FTSC units only (C10=AY). 15 Rear return- Duct Opening for FTSC until 3/11 Code11=20 and Code 37 for FTSC 3/11 & later. 16 Bottom return- Blank (stamped grille) for FTSC until 3/11 Code11=18. 031F/S03 041F/S04 Unit Size 061F/S06 081F/S08 101F/S10 121F/S12 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 25
Cabinet Assembly- TSC/FTSC Components, Continued Ref Description Part No. Number 215 Bottom Panel Assy - Insulated 044939200 1 1 Bottom Panel Assy - Standard 038562901 1 1 Bottom Panel Assy - Insulated 044937500 1 1 Bottom Panel Assy - Standard 039029801 1 1 Bottom Panel Assy - Insulated 044939100 1 1 Bottom Panel Assy - Standard 038563001 1 1 216 Access Panel Assy- Insulated 15 061280501 1 1 Access Panel Assy - Standard 15 061276611 1 1 Access Panel Assy- Insulated 15 061280504 1 1 Access Panel Assy - Standard 15 061276612 1 1 Access Panel Assy- Insulated 15 061280506 1 1 Access Panel Assy - Standard 15 061276613 1 1 Access Panel Assy- Insulated 16 047166800 1 1 Access Panel Assy - Standard 16 038563101 1 1 Access Panel Assy- Insulated 16 047166900 1 1 Access Panel Assy - Standard 16 039030801 1 1 Access Panel Assy- Insulated 16 047167000 1 1 Access Panel Assy - Standard 16 038563201 1 1 NS Nut, Spring- J Type 039449700 2 2 2 2 3 3 NS Hinge Pin 039031000 2 2 2 2 3 3 NS Filter, Throwaway 060604811 1 1 Filter, TA (12 pack of 060604811) 107109112 1 1 NS Filter, Throwaway 060604812 1 1 Filter, TA (12 pack of 060604812) 107109212 1 1 NS Filter, Throwaway 060604814 1 1 Filter, TA (12 pack of 060604814) 107109412 1 1 NS Filter, Cleanable- 26.88 x 9.88 x.875 060687012 1 1 NS Filter, Cleanable- 35.88 9.88 X.875 060687013 1 1 NS Filter, Cleanable- 59.88 X 9.88 X.875 060687015 1 1 031F/S03 041F/S04 Unit Size NOTE: Insulated panal assy= Standard panel assy + insulation. Insulated cabinets used on TSC units only. N/S= Not Shown on Diagram. 15 Rear return- Stamped grille for FTSC until 3/11 Code11=20 and Code 37 for FTSC 3/11 & later. 16 Bottom return- Blank panel for FTSC until 3/11 Code11=18. 061F/S06 081F/S08 101F/S10 121F/S12 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 26
Electric Heaters- TSC/TSH F Vintage (Electric Heat is a field installed option for the FTSC/FTSH Designs A & B. See the Field Installed Accessories section for kit and individual part numbers) Volts/ Heater Part 031F/ 061F/ 101F 121F Watts Description Number 041F 081F 120V/1 KW Heater, Electric - 1KW @ 120V 061149601 1 120V/2 KW Heater, Electric - 2 KW @ 120V 061149602 1 208V/1 KW Heater, Electric - 1KW @ 208V 061149608 1 208V/2 KW Heater, Electric - 2KW @ 208V 061149609 1 208V/3 KW Heater, Electric - 3KW @ 208V 061149607 1 240V/1 KW Heater, Electric - 1KW @ 240V 061149610 1 240V/2 KW Heater, Electric - 2KW @ 240V 061149611 1 240V/3 KW Heater, Electric - 3KW @ 240V 061149612 1 277V/1 KW Heater, Electric - 1KW @ 277V 061149603 1 277V/2 KW Heater, Electric - 2KW @ 277V 061149604 1 277V/3 KW Heater, Electric - 3KW @ 277V 061149605 1 120V/2 KW Heater, Electric - 1KW @ 120V 061149601 2 208V/2 KW Heater, Electric - 1KW @ 208V 061149608 2 208V/4 KW Heater, Electric - 2KW @ 208V 061149609 2 208V/6 KW Heater, Electric - 3KW @ 208V 061149607 2 240V/2 KW Heater, Electric - 1KW @ 240V 061149610 2 240V/4 KW Heater, Electric - 2KW @ 240V 061149611 2 240V/6 KW Heater, Electric - 3KW @ 240V 061149612 2 277V/2 KW Heater, Electric - 1KW @ 277V 061149603 2 277V/4 KW Heater, Electric - 2KW @ 277V 061149604 2 277V/6 KW Heater, Electric - 3KW @ 277V 061149605 2 Unit Size 208V/4 KW Heater, Electric - 1KW @ 208V 061149608 2 Heater, Electric - 2KW @ 208V 061149609 1 208V/6 KW Heater, Electric - 2KW @ 208V 061149609 3 240V/4 KW Heater, Electric - 1KW @ 240V 061149610 2 Heater, Electric - 2KW @ 240V 061149611 1 240V/6 KW Heater, Electric - 2KW @ 240V 061149611 3 277V/4 KW Heater, Electric - 2KW @ 277V 061149604 1 Heater, Electric - 1KW @ 277V 061149603 2 277V/6 KW Heater, Electric - 2KW @ 277V 061149604 3 277V/8 KW Heater, Electric - 2KW @ 277V 061149604 1 Heater, Electric - 3KW @ 277V 061149605 2 208V/4 KW Heater, Electric - 3KW @ 208V 061149607 4 208V/6 KW Heater, Electric - 1KW @ 208V 061149608 2 Heater, Electric - 2KW @ 208V 061149609 2 240V/4 KW Heater, Electric - 1KW @ 240V 061149610 4 240V/6 KW Heater, Electric - 1KW @ 240V 061149610 2 Heater, Electric - 2KW @ 240V 061149611 2 277V/4 KW Heater, Electric - 1KW @ 277V 061149603 4 277V/6 KW Heater, Electric - 1KW @ 277V 061149603 2 Heater, Electric - 2KW @ 277V 061149604 2 277V/8 KW Heater, Electric - 2KW @ 277V 061149604 4 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 27
Electric Heater Control Components- TSC/TSH "F" (The parts used and installed vary per unit. The vendor nomenclature on the actual part and/or the unit serial or GO number are required for part identification) Description Part No. 1PST Relay, 120V Coil, 18 Amp 027400700 1PST Relay, 230V Coil, 18 Amp 031319900 1PST Relay, 277V Coil, 18 Amp 031320000 Control, Limit Switch - 145 O F 061252801 Control, Limit Switch - 110 O F 061252802 Control, Limit Switch - 135 O F 061252803 Control, Limit Switch - 165 O F 061252804 Control, Limit Switch - 175 O F 061252805 Control, Limit Switch - 155 O F 061252806 Control, Limit Switch - 125 O F 061252807 Valves and Air Vent Kits- TSC/TSH "F" Unit Part Part Qty. Voltage Description Number 120V Control ValveBody- 2 Way 107179601 1 Actuator 107179802 1 120V Control Valve Body- 3 Way 107179701 1 Actuator 107179802 1 230V Control Valve (includes Motor), 2-Way 019550507 1 230V Control Valve (includes Motor), 3-Way 019550707 1 277V Control ValveBody- 2 Way 107179601 1 Actuator 107179804 1 277V Control ValveBody- 3 Way 107179701 1 Actuator 107179804 1 120V Valve Motor Only 037525002 1 240V Valve Motor Only 037525003 1 277V Valve Motor Only 037525004 1 - - - Valve- Balancing Until 2/04 001024600 1 - - - Valve- Balancing 2/04 & later 106906900 1 - - - Valve, Ball- T Handle Until 2/04 026111300 1 - - - Valve, Ball- T Handle 2/04 & later 106906700 1 - - - Valve, Water- Manual 019551000 1 - - - Vent Kit- Air 038532700 1 - - - Switch Assembly 039446700 1 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 28
Field Installed Accessories- TSC/TSH "F" Units Wall Mounted Thermostats & Speed Switches Themostat Description Part No. Type 1 3-Speed Switch, Wall Mounted 107112101 SPDT Wall Mounted 001181900 2 * Manual Changeover Subbase 039398400 3-Speed Switch, Wall Mounted 107112101 SPDT Wall Mounted 001181900 3 * * 3-Speed Switch, Wall Mounted 107112101 SPDT Wall Mounted Thermostat/ 4* * * 3-Speed Switch with Manual Changeover 047939500 SPDT Wall Mounted Combination Thermostat/ 5 3-Speed Switch 047939500 DPDT Wall Mounted - Dead Band 040796000 7 * * 3-Speed Switch, Wall Mounted 107112101 DPDT Wall Mounted Combination Thermostat/ 8 3-Speed Switch (Dead Band) 048445901 * Thermostat, Manual C/O, Subbase and Speed Switch must be ordered seprarately for control systems requiring T-stat Type 2. * * Both T-stat and 3-Speed Switch must be ordered separately for control systems requiring thermostat type 3 or 7. * * * Thermostat can be used for only one mode at a time. Not a combination (either heating only OR cooling only). Secondary Drain Pan Description Unit Hand Part Number Must be ordered separately when valves are field supplied. Left 061287502 For 2- and 3-Way Valves. Right 061287501 Trim Flange for TSC Units Description Unit Size Part No. Telescopically adjustable ceiling frame to provide finished look to 031F, 041F 061336701 perimeter of TSC units in drop ceiling applications 061F, 081F 061336702 101F, 121F 061336703 Automatic Air Vent Description Unit size Part No. Replaces standard manual air vent in chilled & hot water coils All 001292200 Automatic Changeover Description Assy Stat Only Clip Automatic Changeover (Strap-on Aquastat Type) 061361801 018482800 031011800 Switches and Circuit Breaker Description Assy Disconnect Switch- Toggle 039446700 Automatic Changeover Switch 061313601 Circuit Breaker- 115V only, units without Electric Heat 047135801 Fan Coil; TSH,TSC 031-121F/FTSH,FTSC 03-12, Des. A/B Rev. R 12/17 RPL 0552379 / Page 29