INSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
|
|
- Joseph Paul Montgomery
- 5 years ago
- Views:
Transcription
1 Bulletin 82 August, 208 INSTALLATION ADJUSTMENT SERVICE HIGHLOW THERMOSTATIC WATER MIXING VALVE SERIES, -LF,, -LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!!! WARNING: This product can expose you to chemicals including lead, which is known to the State of California to cause cancer. For more information, go to INSTALLATION. Valve should be installed at a location where it can easily be cleaned, adjusted or repaired. 2. The inlets are clearly marked on the valve body. Union angle strainer checkstops furnished must be installed on both supply lines as shown above. 3. A shutoff valve must be installed on the outlet pipe. Type XL valves do not have a built-in shutoff. 4. Use solder, or thread sealant sparingly. Supply pipes should be flushed before the valve is connected. Flush outlet pipe and valve as soon as it is connected. 2 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE CAUTION All thermostatic water-mixing valves have limitations. They will not provide the desired accuracy outside of their flow capacity range. Consult the flow capacity chart on page. Minimum flow must be no less than as shown. REMEMBER! THIS IS A CONTROL SYSTEM WHICH MUST BE CLEANED AND MAINTAINED ON A REGULAR BASIS (SEE MAINTENANCE GUIDE AND RECORD MGR-000). 360 Elmwood Avenue, Cranston, RI 0290 USA Phone: Fax: info@leonardvalve.com Web Site:
2 INSTALLATION REQUIRED METHODS OF PIPING XL SERIES METHOD # Required when TEMPERED WATER is NOT CIRCULATED. Only the hot water supply to the mixing valve can be circulated with this piping arrangement. FIXTURES, SUPPLIED BY TEMPERED WATER THERMOMETER T HOT WATER SUPPLY COLD WATER SUPPLY METHOD W CIRCULATE HOT WATER FROM END OF LINE BACK TO TANK Required when TEMPERED WATER IS CIRCULATED. FIXTURES, SUPPLIED BY TEMPERED WATER THERMOMETER T C CIRCULATOR A HEAT TRAP AQUASTAT HOT WATER SOURCE COLD SUPPLY BALANCE VALVE OPERATION. Verify that the temperature of the hot water source is properly set and maintained. Shutoff and isolate the circulator pump. 2. Loosen LTR set screw located on temperature adjustment knob with allen wrench. 3. Turn on enough fixtures to flow approximately GPM, turn knob clockwise until it stops (full cold) then counterclockwise until it stops (full hot), three times to exercise the thermostatic element. 4. Set mixing valve to the desired temperature, (See warning tag for temperature set point). Tighten LTR set screw.. Shut off all fixtures. Setup is complete. 6. Turn on circulator. With all fixtures still off, (no water flowing) observe the circulation temperature until it stabilizes. 7. If temperature rises, close balance valve until desired temperature is reached 2
3 INSTALLATION CONTINUED WARNING WARNING! This Thermostatic Mixing Valve has an Locking Temperature Regulator (LTR) which must be checked. If the temperature is too high, the installer MUST RESET this adjustment immediately. Always check the temperature of the mixed water after installation. Excessively hot water is DANGEROUS AND MAY CAUSE SCALDING! The LTR is factory set at approximately 20 F (49 C) with an incoming hot water supply temperature of 0 F (6 C) If the incoming hot water supply for your installation is higher than 0 F (6 C), the valve may deliver water in excess of 20 F (49) and the LTR MUST BE RESET BY THE INSALLER. SERVICE Leonard Type XL Thermostatic Water Mixing Valves are simple in design and may be easily cleaned, adjusted and repaired. If the installation is accessible, servicing may be completed without disconnecting the valve. NOTE: Thermostatic Water Mixing Valves are REGULATING mechanisms, which must be regularly maintained to provide best performance. Frequency of cleaning depends on quality of local water conditions and usage. (See Maintenance Guide and Record MGR-000). TROUBLESHOOTING INSTRUCTIONS ITEM: PROBLEM: RECOMMENDED REPAIR KITS: RECOMMENDED REPAIR KITS: PACKINGS & GASKETS. Leak at stem. 2. Leak between valve cover and base KIT /XL32 KIT /XL82 SHUTTLE ASSEMBLY 3. Valve delivers either all hot or all cold water, or will not mix consistently. KIT R/XL32 KIT R/XL82 CHECKSTOPS 4. Hot water bypass into cold line.. Supplies cannot be shut off completely. 6. Leak at checkstop bonnet. KIT 2/0 KIT 2/0 REMEMBER! THIS IS A CONTROL DEVICE WHICH MUST BE CLEANED AND MAINTAINED ON A REGULAR BASIS. (SEE MAINTENANCE GUIDE AND RECORD, MGR-000). 3
4 9 0 KIT # KIT # TYPE KIT INCLUDES KIT R/XL32 KIT R/XL82 REPAIR KIT -7 KIT /XL32 KIT /XL82 O-RING 2,3,6,7 KIT 2/0 KIT 2/0 CHECK -6 NOTE: DO NOT REMOVE 8 SNAP RING ON STEM KIT R/XL32 KIT R/XL ITEM # DESCRIPTION QTY. PART # / KIT # PART # / KIT # SPRING, RETURN KIT R/XL32 KIT R/XL82 2 O'RING, LOWER SHUTTLE KIT /XL32, KIT R/XL32 KIT /XL82, KIT R/XL82 3 O'RING, UPPER SHUTTLE KIT /XL32, KIT R/XL32 KIT /XL82, KIT R/XL82 4 SHUTTLE ASSEMBLY KIT R/XL32 KIT R/XL82 RETAINING RING, COVER 74, KIT R/XL32 76, KIT R/XL82 6 O'RING, COVER KIT /XL32, KIT R/XL32 KIT /XL82, KIT R/XL82 7 O'RING, STEM KIT /XL32, KIT R/XL32 KIT /XL82, KIT R/XL82 8 STEM ASSEMBLY (DO NOT REMOVE SNAP RING) COVER KNOB ASSEMBLY PACKING, STRAINER CAP 2 04, KIT 2/0 04, KIT 2/0 2 SCREEN 2 03, KIT 2/0 03, KIT 2/0 3 LOWER STEM & PACKING 2 03, KIT 2/0 03, KIT 2/0 4 SPRING,CHECK 2 0, KIT 2/0 0, KIT 2/0 PACKING, BONNET 2 0, KIT 2/0 0, KIT 2/0 6 O'RING, UPPER STEM 2 MU-A, KIT 2/0 MU-A, KIT 2/0 7 STEM, UPPER CHECK 2 MU-4A MU-4A 8 BONNET STRAINER CAP SWIVEL /0 2 SWIVEL NUT 2 09/0 09/0 4
5 FLOW CAPACITIES VALVE MIN FLOW PRESSURE DROP PSI BAR GPM l/min GPM l/min FLOW RATE GPM (l/min) 6 (246) 60 (227) (208) 0 (89) 4 (70) 40 () 3 (32) 30 (4) 2 (9) 20 (76) (7) 0 (38) (9) (0.3) (0.7) (.0) (.4) (.7) (2.) (2.4) (2.8) (3.) (3.4) (3.8) PRESSURE DROP PSI(BAR) LIMITED WARRANTY Leonard Valve Company warrants the original purchaser that products manufactured by them (not by others) will be free from defects in materials and workmanship under normal conditions of use, when properly installed and maintained in accordance with Leonard Valve Company's instructions, for a period of one year from date of shipment. During this period the Leonard Valve Company will at its option repair or replace any product, or part thereof, which shall be returned, freight prepaid, to the Leonard factory and determined by Leonard to be defective in materials or workmanship. There are no warranties, express or implied, which extend beyond the description contained herein. There are no implied warranties of merchantability or of fitness for a particular purpose. In no event will Leonard be liable for labor or incidental or consequential damages. Any alteration or improper installation or use of the product will void this limited warranty. 208 Leonard Valve Company Printed in USA 360 Elmwood Avenue, Cranston, RI 0290 USA Phone: Fax: info@leonardvalve.com Web Site:
INSTALLATION ADJUSTMENT SERVICE HIGHLOW THERMOSTATIC WATER MIXING VALVE SERIES XL-32, XL-82
Bulletin XL-38 March 00 INSTALLATION ADJUSTMENT SERVICE HIGHLOW THERMOSTATIC WATER MIXING VALVE SERIES XL-3, XL-8 IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!!
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin XL-150 February 2015 INSTALLATION ADJUSTMENT SERVICE HIGHLOW THERMOSTATIC WATER MIXING VALVE SERIES XL-150, XL-150-LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin GLV-101 Old Rev. LV-101 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE SERIES LV-983, LV-983-LF & LV-984, LV-984 -LF IMPORTANT! Provide valve serial number, (located on valve
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
. Bulletin XL-200 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE SERIES XL-200, XL-200-LF, XL-200-SW, XL-200-SW-LF IMPORTANT! Provide valve serial number, (located on valve cover) when
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin GLV-98 Old Rev. LV-98 February 1 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE SERIES, LV981-LF &, -LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering
More informationINSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE SERIES LV-981 & LV-982
Bulletin LV-98 March 010 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE SERIES & LV-98 IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!! ASSE 1017
More informationINSTALLATION ADJUSTMENT SERVICE
Bulletin XL-670 July 201 INSTALLATION ADJUSTMENT SERVICE HIGHLOW THERMOSTATIC WATER MIXING VALVE MODEL XL-670-LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!! ECO-MIX
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin GLV-0 September 01 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE LV-0, LV-0-LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!! INSTALLATION
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin GLV- January 014 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE LV-, LV--LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!! INSTALLATION
More informationINSTALLATION 125 PSI (8.6 BAR) MAXIMUM OPERATING PRESSURE
Bulletin GLV-99 July, 01 INSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE LV-981A, LV-981A-LF IMPORTANT! Provide valve serial number, (located on valve cover) when ordering parts!! INSTALLATION
More informationOUTLET HOT INLET COLD INLET INSTALLATION
Bulletin G-29 December 2007 INSTALLATION ADJUSTMENT SERVICE TYPE TM-28 IMPORTANT! Provide valve serial number (stamped on cover of valve) when ordering parts!! Valve manufactured after July 2007 starting
More informationINSTALLATION ADJUSTMENT SERVICE TYPE TM-15, TM-20, TM-20-LF (As furnished with models TM-554, TM-356, TM-356-W/HA)
ASSE 1017 INSTALLATION ADJUSTMENT SERVICE TYPE TM-15, TM-20, TM-20-LF (As furnished with models TM-554, TM-356, TM-356-W/HA) BULLETIN P-15A January, 2014 IMPORTANT! Provide valve serial number when ordering
More informationTA-300, TA-300-LF, TA-350, TA-350-LF
Bulletin G-5 INSTALLATION SETUP AND OPERATING INSTRUCTIONS EMERGENCY MIXING VALVE SYSTEM TA-300, TA-300-LF, TA-350, TA-350-LF IMPORTANT! Provide valve serial number (located on valve body) when ordering
More informationINSTALLATION ADJUSTMENT SERVICE
ASSE 1017 INSTALLATION ADJUSTMENT SERVICE TYPE TM-26, TM-26-LF BULLETIN G-26 January 2014 IMPORTANT! Provide valve serial number (stamped on cover of valve) when ordering parts!! Valve manufactured after
More informationINSTALLATION SETUP AND OPERATING INSTRUCTIONS THERMOSTATIC WATER MIXING VALVE SYSTEM TM-500, TM-550
C BULLETIN G-6A January 2012 INSTALLATION SETUP AND OPERATING INSTRUCTIONS WATER SYSTEM TM-500, TM-550 IMPORTANT! Provide valve serial number (located on valve body) when ordering parts!! Starting with
More informationMODEL TA. TA-SB 117.5mm mm HOT INLET. TA mm mm mm mm
WATER MIXER WATER MIXER TRERMOSTATIC WATER MIXER TRERMOSTATIC C TRERMOS TA TIC WA TER MIXER MODEL TA Bulletin P-7A-4 May 2011 (NEW STYLE) THERMOSTATIC WATER MIXING VALVES INSTALLATION SETUP AND OPERATING
More informationINSTALLATION SETUP AND OPERATING INSTRUCTIONS THERMOSTATIC WATER MIXING VALVE SYSTEM * TM-500A, TM-550A
C ASSE 1017 BULLETIN G-6B March 2009 INSTALLATION SETUP AND OPERATING INSTRUCTIONS WATER SYSTEM * TM-500A, TM-550A IMPORTANT! Provide valve serial number (located on valve body) when ordering parts!! *ASSE
More informationMEGATRON MODEL 2, 3, 4, and 5
MEGATRON MODEL 2, 3, 4, and 5 BULLETIN M-1020A 2/02 INSTALLATION ADJUSTMENT SERVICE COMPLETE WATER TEMPERATURE CONTROL STATION DOMESTIC OUTLET TEST/SETUP CONNETION RETURN LINE FROM BUILDING RETURN LINE
More informationINSTALLATION ADJUSTMENT SERVICE TYPE TM-15, TM-20* (As furnished with models TM-554, TM-356, TM-356-W/HA Valve is ASSE 1017 listed
ASSE 1017 INSTALLATION ADJUSTMENT SERVICE TYPE TM-15, TM-20* (As furnished with models TM-554, TM-356, TM-356-W/HA Valve is ASSE 1017 listed *Valve is CUPC listed IMPORTANT! Provide valve serial number
More informationInstallation, Operation and Maintenance Guide AP3900 Series Thermostatic Mixing Valves
Note: Please provide valve serial number (stamped on cover of valve) when ordering parts. Hot Water Tempered Water Outlet Cold Water Tempered Water Outlet Redundant Thermostatic Mixing Valve Hot Water
More informationNote: Please provide valve serial number (stamped on cover of valve) when ordering parts. Tempered Water Outlet. Hot Water Inlet.
Note: Please provide valve serial number (stamped on cover of valve) when ordering parts. Tempered Water Outlet Angle Checkstop Angle Checkstop Hot Water Inlet G3700LF Cold Water Inlet Installation 1.
More informationInstallation, Operation and Maintenance Guide G3600 Series Thermostatic Mixing Valves
Note: Please provide valve serial number (stamped on cover of valve) when ordering parts. Tempered Water Outlet Cold Water Thermometer Hot Water Inline Check Redundant Thermostatic Mixing Valve Angle Checkstops
More informationNote: Please provide valve serial number (stamped on cover of valve) when ordering parts. Thermometer. Hot Water Inlet. Cold Water Inlet G3600LF
Note: Please provide valve serial number (stamped on cover of valve) when ordering parts. Thermometer 1/2" OD Copper Tube Inlets Hot Water Inlet Cold Water Inlet G3600LF Installation 1. Install valve in
More informationINSTALLATION ADJUSTMENT SERVICE TYPE TM-15, TM-20 (As furnished with models TM-554, TM-356, TM-356-W/HA, TM PRV, 8015, 12520, 15020)
OT BULLETIN P-15 June, 2006 INSTALLATION ADJUSTMENT SERVIE TYPE TM-15, TM-20 (As furnished with models TM-554, TM-356, TM-356-W/HA, TM-186-5015-PRV, 8015, 12520, 15020) IMPORTANT! Provide valve serial
More informationOUTLET LEONARDH THERMOSTATIC INSTALLATION
Bulletin G-AT June 2012 INSTALLATION ADJUSTMENT SERVIE ALLTERNATIVE TEMPERATURE TERMOSTATI WATER MIXING VALVES TYPE TM-50-AT, 80-AT, 150-AT, 200-AT IMPORTANT! Provide valve serial number, (stamped on cover
More informationINSTALLATION ADJUSTMENT SERVICE NEXT-GENERATION MANIFOLD SYSTEMS TM-520B-LF, TM-820B-LF, TM-920B-LF, TM-1520B-LF
2 6 4 1 O. RANSTON RI USA TYP TM U S. Pat en ts 2. 97, 3, 6 1,1 95 3.15 2,76 8 2 3 R 4 5-1 6 F 14 1 12 Bulletin G-12 August, 218 INSTALLATION ADJUSTMENT SERVIE NEXT-GENERATION MANIFOLD SYSTEMS TM-52B-,
More informationSS-7600 THERMOSTATIC MODEL INSTALLATION INSTRUCTIONS
LEONARD SS-7600 THERMOSTATIC MODEL ½ top inlets Valve is ASSE 06 Listed INSTALLATION INSTRUCTIONS Bulletin 7600-SS March 06 SHOWER HEAD O'RING (TM-6B) 6 8 0 HOT COLD 7 9. Remove item (), - #/-0 X / long
More informationHOT INLET COLD INLET INSTALLATION
EMERGENY VALVE F EMERGENY VALVE Bulletin G-4 INSTALLATION SETUP AND OPERATING INSTRUTIONS WATER SYSTEMS TYPE TM-600, TM-600-LF, TM-650, TM-800, TM-800-LF, TM-850, TM-850-LF TM-5100, TM-5100-LF, TM-5125,
More informationINSTALLATION SETUP AND OPERATING INSTRUCTIONS THERMOSTATIC WATER MIXING VALVE SYSTEMS TYPE *TM-600, TM-650, *TM-800, *TM-850, TM-5100, TM-5125
EMERGENY VALVE F EMERGENY VALVE INSTALLATION SETUP AND OPERATING INSTRUTIONS WATER SYSTEMS TYPE *TM-600, TM-650, *TM-800, *TM-850, TM-5100, TM-5125 IMPORTANT! Provide valve serial number, (stamped on valve
More informationOUTLET LEONARD THERMOSTATIC INSTALLATION
BULLETIN G-2B-TMS August, 2018 INSTALLATION ADJUSTMENT SERVIE STEAM AND WATER MIXING VALVE TYPE TMS-25, 50, 80, 125, 150 IMPORTANT! Provide valve serial number (stamped on cover of valve) when ordering
More informationINSTALLATION ADJUSTMENT SERVICE THERMOSTATIC WATER MIXING VALVE TM-200 (NEW STYLE) TMS-200 (VALVE ONLY)
Bulletin G-2D-1 September 2008 INSTALLATION ADJUSTMENT SERVIE TERMOSTATI WATER MIXING VALVE TM-200 (NEW STYLE) TMS-200 (VALVE ONLY) IMPORTANT! This Bulletin covers valves built after June 2001, starting
More informationINSTALLATION ADJUSTMENT SERVICE TM-1520A-DT, TM-2020A-DT PARALLEL SYSTEMS
ASSE 1 17 TERMOSTATI 4 1-1 F 3 R 8 14 4 5 1 1 ASSE 1 17 TERMOSTATI VALVE O. RANSTON RI USA TYP TM US. Patents 2.97, 3,61,195 3.152,7 4 1-1 F 3 R 8 5 14 4 1 1 VALVE O. RANSTON RI USA TYP TM US. Patents
More informationDOMESTIC OUTLET. kg/cm 2 11 psi LEONARD LEONARD -10 C F LEONARD R THERMOSTATIC LEONARD LEONARD C F C F 60 COLD INLET HOT INLET
4 1-1 3 R 8 14 4 5 4 1 2 1 4 8 6 kg/cm 2 11 psi 8 1 1 1 14 1 4 ASSE 117 1-1 3 R 8 14 4 5 THERMOSTATI H 1 1 4 1-1 3 R 8 14 4 5 1 1 4 1-1 3 R 8 14 4 5 1 1 M-122Z September 1 MEGATRON MODEL 6N INSTALLATION
More information30 R -10 C F H C INSTALLATION. Maximum Operating Pressure 125PSI (860 KPA) for Hot and Cold Water. CAUTION
ASSE 117 1-1 2 6 3 4 5 4 1-1 2 6 3 4 5 BULLETIN G-26-34 January 216 INSTALLATION ADJUSTMENT SEVICE TYPE TM-26-F-DT-34, TM-26-LF-F-DT-34 IMPOTANT! Provide valve serial number (stamped on cover of valve)
More informationMEGATRON MODEL 2NB-LF, 3NB-LF, 4NB-LF, 5NB-LF NEXT GENERATION MANIFOLD SYSTEMS TM-520B-LF, 820B-LF, 920B-LF, 1520B-LF
6 1-1 3 8 5 6 1 6 2 1 4 1 8 6 8 kg/cm2 11 psi 1 16 1 1 1 6 1 ASSE 117 VAL VE -1 CO. 3 6 8 5 1 THEMOSTATIC T YPE TM AN STON 1 1.I. U.S.A. 6 1-1 6 3 8 1 5 1 1 6 1-1 6 3 8 5 1 1 1 H C Bulletin M-115Z August,
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD SYSTEMS TM-520, TM-820, TM-920, TM-1520A TM-520-LF TM-820-LF, TM-920-LF, TM-1520A-LF
LEO ASSE R US. Patent 770 & 3,061,195 3.152,760 O. PE TM RAN STON R.I. Bulletin G11D April 2014 INSTALLATION ADJUSTMENT SERVIE HIGH-LOW MANIFOLD SYSTEMS TM-520, TM-820, TM-920, TM-1520A TM-520-LF TM-820-LF,
More informationMEGATRON MODEL TA, TA-LF
6 1-1 2 LEONAD 6 3 8 6 C H LEONAD 116 LEONAD VALVE CO. CANSTON I 291 8 2 3 1 LEONAD -1 6 MODEL 21 Water Mixer 117 1 6-1 2 3 LEONAD 6 8 6 8 2 3 1 LEONAD -1 6 MEGATON MODEL TA, TA-LF Bulletin G-1L August,
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD TM-2020B
2 4 1 11 7 6 8 2 3 4 5-1 6 F 14 TERMOSTATI 1 12 2 ASSE 117 6 4 1 8 2 3 4 5-1 6 F 14 TERMOSTATI 1 12 Bulletin G-11E June 29 INSTALLATION ADJUSTMENT SERVIE IG-LOW MANIFOLD TM-22B Valve assembly is ASSE 117
More informationMODEL 210, 210-LF THERMOSTATIC WATER MIXING VALVES INSTALLATION SETUP AND OPERATING INSTRUCTIONS
Bulletin G-210 January, 2014, 210-LF TERMOSTATI WATER MIXING VALVES INSTALLATION SETUP AND OPERATING INSTRUTIONS IMPORTANT! Provide valve serial number (begins with serial no. -1000) when ordering parts!!
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD SYSTEMS TM-420A Valve assemblies are ASSE 1017 listed
4 2 AS SE 1 17 6 8 2 3 1 LEONAD 4 5-1 6 C F 14 1 12 4 2 1 17 6 8 2 3 1 LEONAD 4 5-1 6 C F 14 1 12 BULLETIN G-11F February 29 INSTALLATION ADJUSTMENT SEVICE HIGH-LOW MANIFOLD SYSTEMS TM-42A Valve assemblies
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD SYSTEMS TM-420A Valve assemblies are ASSE 1017 listed
4 AS SE 1 17 6 1-1 3 LEONAD C F 6 8 14 4 5 1 1 4 1 17 6 1-1 F 3 LEONAD C 6 8 14 4 5 1 1 INSTALLATION ADJUSTMENT SEVICE HIGH-LOW MANIFOLD SYSTEMS TM-4A Valve assemblies are 117 listed Valve assemblies are
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD TM-2020B, TM-2020B-LF
1 ASSE 117 3-1 F 8 5 1 TERMOSTATI 1 1 ASSE 117 1-1 F 8 3 5 1 TERMOSTATI 1 1 Bulletin G-11E August, 18 INSTALLATION ADJUSTMENT SERVIE IG-LOW MANIFOLD TM-B, TM-B-LF IMPORTANT! Provide serial numbers for
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD TM-2020B, TM-2020B-LF
2 4 1 11 7 8 2 3 4 5-1 F 14 1 12 2 4 1 ASSE 117 2 3 4 5-1 F 8 14 1 12 Bulletin G-11E April 214 INSTALLATION ADJUSTMENT SERVIE IG-LOW MANIFOLD TM-22B, TM-22B-LF IMPORTANT! Provide serial numbers for both
More informationINSTALLATION ADJUSTMENT SERVICE HIGH-LOW MANIFOLD TM-2020B, TM-2020B-LF
2 1 ASSE 117 2 3-1 F 8 5 1 TERMOSTATI 1 12 2 ASSE 117 1 2 3-1 F 8 5 1 TERMOSTATI 1 12 Bulletin G-11E April 217 INSTALLATION ADJUSTMENT SERVIE IG-LOW MANIFOLD TM-22B, TM-22B-LF IMPORTANT! Provide serial
More informationINSTALLATION ADJUSTMENT SERVICE MEGATRON MODEL 8N-LF. Valve assemblies are ASSE 1017 listed
4 6 2 8 6 4 8 kg/cm 2 11 psi 1 1 6 1 1 4 1 4 6 4 1-1 6 3 8 14 6 1-1 4 5 1 1 6 3 8 14 4 5 1 1 TERMOSTATI 4 6 1-1 6 3 8 14 4 5 1 1 TERMOSTATI 4 6 1-1 6 3 8 14 4 5 1 1 4 6 1-1 LE ON ARD 6 3 8 14 4 5 1 1 EO-MIX
More informationINSTALLATION ADJUSTMENT SERVICE 2P TM-2020B-2P, TM2020B-2P-LF PARALLEL SYSTEMS
OT ASSE 117 4 2 1-1 2 3 R F 8 14 4 5 1 12 ASSE 117 VALVE O. RANSTON RI USA AS SE 117 TYP TM US. Patents 2.97, 3,61,195 3.152,7 4 2 1-1 2 F 3 R 8 5 14 4 1 12 VALVE O. RANSTON RI USA ASSE 117 U S. Pate nt
More informationINSTALLATION ADJUSTMENT SERVICE 2PS TM-2020B-2P, TM2020B-2PS-LF PARALLEL SYSTEMS
OT ASSE 117 TERMOSTATI 4 2 1-1 2 3 R F 8 14 4 5 1 12 ASSE 117 TERMOSTATI LF VALVE O. RANSTON RI USA TYP TM LF 4 2 1-1 2 F 3 8 5 14 4 1 12 LF VALVE O. RANSTON RI USA TYP TM LF Bulletin G11N5 March 215 INSTALLATION
More informationINSTALLATION ADJUSTMENT SERVICE TM-1520A-2P, TM-1520A-2P-LF TM-2020B-2P, TM2020B-2P-LF PARALLEL SYSTEMS
OT ASSE 117 4 2 1-1 2 3 R F 8 14 4 5 1 12 ASSE 117 VALVE O. RANSTON RI USA AS SE 117 TYP TM US. Patents 2.97, 3,61,195 3.152,7 4 2 1-1 2 F 3 R 8 5 14 4 1 12 VALVE O. RANSTON RI USA A SSE 117 TYP TM U S.
More informationLEONARD -10 LEONARD VALVE CO. CRANSTON RI USA. TYP TM US. P aten ts 2.970, 3,06 1, , " Maximum Operating Pressure 125PSI (8.6 Bar).
2 0 2 4 6 80 kg/cm psi 2 11 LEO NARD 8 10 1 10 0 1 TERMOSTATI 1 10 0-10 0 R F VALVE O. RANSTON RI USA TYP TM US. P aten ts 2.970, 3,06 1,195 3.152,76 0 30 80 1 50 100 1 Bulletin G18E May 08 INSTALLATION
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION
1-1 3 1 5 1 kg/cm 11 1 1 1 1 1 1-1 3 1 5 1 1-1 3 1 5 1 1-1 3 5 1 COMPLETE WATE TEMPEATUE CONTOL STATION ECO-MIX Valve is ASSE 117 Certified Submittal S-11-1-LF August, 1 MEGATON LEAD FEE MODEL XLLF 1 HOT
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION
- 3 5 kg/cm C AS SE 7-3 5 THEMOSTATIC H - 3 5 3 5 - COMPLETE WATE TEMPEATUE CONTOL STATION ECO-MIX Submittal Data Sheet S-5Z-LF August, MEGATON LEAD FEE MODEL NB-LF HOT & COLD INLETS MIXED OUTLET ¼ ETUN
More informationInstallation Manual. Models 99168, 99169, 99170
Wet-Rated Globe Fitter Installation Manual Compatible with: 2xxxx Types A - Z 51000-58999 fan series 59500-59999 fan series Select Casablanca Fans Models 99168, 99169, 99170 BEFORE YOU BEGIN Read entire
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION
- 3 5 kg/cm ASSE 7 - CO. 3 5 THEMOSTATIC TYPE TM US. Patent 77 & 3,,95 3.5,7.I. - 3 5-3 5 COMPLETE WATE TEMPEATUE CONTOL STATION ECO-MIX Submittal Data Sheet S-5Z-LF August, MEGATON LEAD FEE MODEL 3NB-LF
More informationINSTALLATION & TESTING MANUAL
LP LOW PRESSURE UNIT ISO9001 CERTIFIED INSTALLATION & TESTING MANUAL ***CAUTION: Do not lift by yellow enclosure. Reference installation instructions for proper lifting and moving techniques. INSTALLATION
More informationSEISCO SUPERCHARGER EXTENDER/BOOSTER INSTALLATION GUIDE & OWNERS MANUAL
SEISCO SUPERCHARGER EXTENDER/BOOSTER INSTALLATION GUIDE & OWNERS MANUAL This manual is provided as a guide to installation. All installations must comply with any and all local and national electrical
More informationINSTALLATION, OPERATION AND MAINTENANCE
INLINE HEATER INSTALLATION, OPERATION AND MAINTENANCE MODELS: ILS SERIES 1.5kW 120V SINGLE PHASE BEFORE YOU BEGIN CHECK ALL ELECTRICAL CONNECTIONS TO ALL COMPONENTS WITHIN THE HEATER FOR TIGHTNESS. CONNECTIONS
More informationMEGATRON MODEL 2N, 3N, 4N, 5N HIGH-LOW MANIFOLD SYSTEMS TM-520, TM-820, TM-920, TM-1520A TM-520-LF, TM-820-LF, TM-920-LF, TM-1520A-LF
5-1 8 1 1 2 4 8 6 8 kg/cm 2 11 psi 1 1 1 LEO NAD 17 VAL VE - C O. THEMOSTATIC PE TM 8 5 1 CAN STON 1.I. U.S.A. - 8 1 5 1-8 5 1 1 H C Bulletin M-11Z January 14 MEGATON MODEL 2N, 3N, 4N, 5N HIGH-LOW MANIFOLD
More informationMODEL 270-LF ECO-MIX THERMOSTATIC MIXING LEAD FREE THERMOSTATIC POINT OF USE MIXING VALVE. Submittal Data Sheet S-827-LF February 2013
TERMOSTATI MIXING VALVE 5-1/2" 140mm EO-MIX Submittal Data Sheet S-827-LF February 2013 MODEL 270-LF LEAD FREE TERMOSTATI POINT OF USE MIXING VALVE MODEL ½ inlets, ½ outlet, (MIPS connections) MATERIALS:
More informationINSTALLATION & TESTING MANUAL
INSTALLATION & TESTING MANUAL ***CAUTION: Do not lift by yellow enclosure. Reference installation instructions for proper lifting and moving techniques. IMPROPER INSTALLATION MAY RESULT IN RISK OF SCALDING
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION MEGATRON MODEL 10NB-LF 4 HOT & COLD INLETS 4 MIXED OUTLET 2 RETURN PIPING
4 4 5-4 3 8 4 4 5-3 8 4 TERMOSTATI 4 3 4 5-8 4 TERMO STATI TERMOSTATI 4 4 5-3 8 4 4-3 8 4 4 5 OMPLETE WATER TEMPERATURE ONTROL STATION EO-MIX Valve assemblies are ASSE 7 listed Submittal S-596Z-LF August,
More informationModel NOTE TO INSTALLER: Please leave this information with the Maintenance Department. LIMITED WARRANTY
INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS 1455 Kleppe Lane Sparks, NV 89431-6467 (775) 359-4712 Fax (775) 359-7424 E-mail: haws@hawsco.com website: www.hawsco.com Model 9400 No. 2080243(7) NOTE
More informationFFP S700 SERIES. Pull-Out Spray Faucet. Installation guide
FFP S700 SERIES Pull-Out Spray Faucet Installation guide G 1782 G 1748.XX G 29016 G 1156 G R0239.XX G 13396.XX G R0637 G R1664 G 1636 G 1463 TECHNICAL DATA Minimum working pressure 0,5 bar Maximum working
More informationSubmittal S-NV-150-LF-M November, 2018 MEGATRON MODEL NV-150-LF DIGITAL TEMPERATURE CONTROL STATION
! APPROXIMATE DIMENSIONS A = 3-3 B = 3-10-1/2 C = 4 D = 9-1/2 *Image not to scale* WARNING: This product can expose you to chemicals including lead, which is known to the State of California to cause cancer.
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION
- 3 5 ps i kg/cm ASSE 7 VAL VE - CO. 3 5 THEMOSTATIC TYPE TM US. Patent 77 & 3,,95 3.5,7.I. - 3 5-3 5 Submittal Data Sheet S-533Z-LF April, COMPLETE WATE TEMPEATUE CONTOL STATION ECO-MIX MEGATON LEAD FEE
More informationNachi Series TM Z6957-XL
Nachi Series TM Wall-Mounted Sensor-Operated Lavatory Faucets for Battery or Plug-In Installations. Installation, Operation, Maintenance, and Parts Manual Z6957-XL Wall-Mounted Sensor-Operated Battery-Powered
More informationInstallation Instructions PP-AS20 Anti-Scale System
Installation Instructions PP-AS20 Anti-Scale System THIS UNIT MUST BE INSTALLED BY A LICENSED PLUMBER TO VALIDATE THE WARRANTY. COMPONENTS PP-AS20 Filter Housing PP-AS20R Filter Cartridge Installation
More informationSubmittal S-NV-200-LF-M DIGITAL TEMPERATURE CONTROL STATION. Valve assembly is ASSE 1017 Certified. Valve assembly is cupc Certified
! APPROXIMATE DIMENSIONS A = 3-11 B = 3-9 C = 4-1/2 D = 1-1 *Image not to scale* WARNING: This product can expose you to chemicals including lead, which is known to the State of California to cause cancer.
More informationInstallation S
Installation S59-3080 Thermostatic High-Low Mixing Valve (HL80) with Optional Cabinet S59-3080RE (with Recess-Mounted Enamel Cabinet) S59-3080RS (with Recess-Mounted Stainless Steel Cabinet) S59-3080SE
More information5 (34) 10 (69) 45 (170) 64 (242) 65 (246) 92 (348) 90 (341) 127 (481) 85 (322) (227) 80 (303) 113 (428) 148 (560) 105 (397) 141 (534) 100 (379)
Based On The MV7 Master Mixing Valves APPLICATION: The Acorn SFMMV Series Multi-Valve Supply Fixtures can be accurately referred to as a High/Low Multi-Valve fixture, compliant with the temperature control
More informationInstallation S
Installation S59-2025 Thermostatic Mixing Valve (TMV25) with Optional Cabinet S59-2025RE (with Recess-Mounted Enamel Cabinet) S59-2025RS (with Recess-Mounted Stainless Steel Cabinet) S59-2025SE (with Surface-Mounted
More informationInstallation S
Installation S59-3045 Thermostatic High-Low Mixing Valve (HL45) with Optional Cabinet S59-3045 (Valve Only) S59-3045RE (with Recess-Mounted Enamel Cabinet) S59-3045RS (with Recess-Mounted Stainless Steel
More informationInstruction Sheet LTR - Low Water Cutoff for Hot Water Boilers
SUPERSEDES: Revision F Dated December 17, 2012 #5401179-REV G PLANT ID 001-3907 Instruction Sheet LTR - Low Water Cutoff for Hot Water Boilers Listings/Approvals EFFECTIVE: June1, 2017 102-338 UL GUIDE
More informationECCOTEMP. Point of Use Tankless Water Heaters EP-2.4 / EP-7.0. Installation and Operating Instruction Manual. Shop Online.
ECCOTEMP Point of Use Tankless Water Heaters EP-2.4 / EP-7.0 Installation and Operating Instruction Manual Product Support Eccotemp.com/help-desk Shop Online Eccotemp.com/products Store Locator Eccotemp.com/locator
More informationWhole House Filter Model: WH-LD
INSTALLATION, OPERATION AND MAINTENANCE MANUAL Save manual for future reference Whole House Filter Model: WH-LD! WARNING Please read carefully before proceeding with installation. Your failure to follow
More informationOwner s Manual. Pelican Custom Premium WHWF 1354/1665
Owner s Manual Pelican Custom Premium WHWF 1354/1665 Page 2 Copyright 2013 Enviro Water Solutions Inc. All rights reserved. All information contained herein is the property of Pelican Water Systems. Pelican
More informationTUB AND SHOWER FAUCET
ITEM #043465 TUB AND SHOWER FAUCET MODEL #F0E509CP Français / Español p. 4 Project Source ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing parts? Before returning to your
More informationINSTRUCTION MANUAL HS-229G
INSTRUCTION MANUAL HS-229G 510977 STEP 1 - Where to Install the Thermostatic Steam Trap Determine where to install the thermostatic steam trap based on the following information. a. The trap should be
More informationInstallation Instructions / Warranty
Installation Instructions / Warranty IP C 04210000 04211000 04212000 IP S 04203000 04204000 04205000 IP E 04199000 04200000 04201000 IP Trim Sets Valve trim only IP C 04212000 IP E 04201000 IP S 04205000
More informationModel TWBS.EW.H Tempered Water Blending System
INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS 1455 Kleppe Lane Sparks, NV 89431-6467 (775) 359-4712 Fax (775) 359-7424 E-mail: haws@hawsco.com website: www.hawsco.com Model TWBS.EW.H Tempered Water
More informationCLASSIC HIGH LOW MANIFOLD SYSTEMS
LASSI HIGH LOW MANIOLD SYSTEMS LEONARD LASSI HIGH LOW MANIOLD SYSTEMS control water temperature for domestic hot water systems, shower rooms and other commercial, institutional and industrial applications
More informationInstallation Instructions
IMPORTANT Installation and final temperature adjustment are the responsibility of the installer. Installation Instructions Thermostatic Mixing Valve for Sinks/Faucets Inlet Outlet Model Connection Connection
More informationAeroVent 3X Product Manual
Product Manual AeroVent 3X TABLE OF CONTENTS Precautionary Warning... Page 1 Assembly... Page 2 Assembly Drawing... Page 3 Parts List... Page 3 Operation... Page 4 Maintenance... Page 5 Cobalt Point Replacement...
More informationInstruction Manual. Nacho Cheese Dispenser and Warmer
Instruction Manual Nacho Cheese Dispenser and Warmer 10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA 2013 Gold Medal Products Co. Part No. 36060 SAFETY PRECAUTIONS Page 2 INSTALLATION INSTRUCTIONS
More informationInstallation & Operation Manual
Installation & Operation Manual Table of Contents Pre-Installation Information...2 Physical Dimensions...4 Rough-In Dimensions...5 Hardware Identification Chart...6 Installation Instructions...7 Step 1:
More informationInstallation Instructions / Warranty. PuraVida 15775XX1
Installation Instructions / Warranty PuraVida 15775XX1 Technical Information Recommended water pressure 15-75 psi Max. water pressure 145 psi Recommended hot water temp. 120-140 F* Max. hot water temp
More informationModel 8780 INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS. Tempering Skid General Area Classification & Class I Division 2. No.
INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS 1455 Kleppe Lane Sparks, NV 89431-6467 (775) 359-4712 Fax (775) 359-7424 E-mail: haws@hawsco.com Website: www.hawsco.com Model 8780 Tempering Skid General
More informationECO-MIX COMPLETE WATER TEMPERATURE CONTROL STATION
- 5 kg/cm 7 7-5 - 5-5 Submittal Data Sheet S-5Z-LF April, COMPLETE WATE TEMPEATUE CONTOL STATION ECO-MIX MEGATON LEAD FEE MODEL NB-LF ¾ HOT & COLD INLETS MIXED OUTLET ¾ ETUN PIPING. to GPM(.7 to 7 l/min)
More informationInstallation S
Installation S59-3080 Thermostatic Mixing Valve with Optional Cabinet S59-3080RE (with Recess-Mounted Enamel Cabinet) S59-3080RS (with Recess-Mounted Stainless Steel Cabinet) S59-3080SE (with Surface-
More informationInstallation, Operation, and Maintenance Manual
Installation, Operation, and Maintenance Manual Product Preservers Anti-Scale System Chemical-Free, Salt-Free Scale Prevention Introduction The Product Preservers Anti-Scale System will condition the tap
More informationTECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER TECHNICAL ASSISTANCE FAX:
ACORN SAFETY P.O. BOX 3527 CITY OF INDUSTRY, CA 91744-0527 UNITED STATES OF AMERICA WWW.ACORNSAFETY.COM INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS ELECTRIC ALARM WITH LIGHT AND HORN Model: S0000-AL2-C1D1-DB1
More informationTRU-TEMP VALVE. Tru-Temp Pressure Balance 1/2" Rough-In Valve Owner's Manual 3001-RIV-PB-ORB 3001-RIV-PB-BN 3001-RIV-PB-CH 3003-RIV-PB-ORB
TRU-TEMP VALVE 3001-RIV-PB-CH 3003-RIV-PB-CH Tru-Temp Pressure Balance 1/2" Rough-In Valve Owner's Manual 3001-RIV-PB-BN 3003-RIV-PB-BN 3001-RIV-PB-ORB 3003-RIV-PB-ORB Rough-In Valve Model #3001-RIV-PB
More informationAeroVent 1 Product Manual
Product Manual AeroVent 1 Manual / 4290.0416 TABLE OF CONTENTS Precautionary Warning... Page 1 Assembly.. Page 2 Operation. Page 3 Maintenance Page 4 Parts List... Page 4 Cobalt Point Replacement... Page
More informationSH-300, SH-900, SH-1500, SH-1600 and SH-1700 Bimetallic Steam Trap Installation and Operation Manual
SH-300, SH-900, SH-1500, SH-1600 and SH-1700 Bimetallic Steam Trap Installation and Operation Manual 111-EN SH-300 SH-900 SH-1500 SH-1600 SH-1700 Table of Content. General Safety Information. 3 Product
More informationInstruction Manual. Carmel Apple-Dip Warmer
Instruction Manual Carmel Apple-Dip 10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA Part No. 38065 SAFETY PRECAUTIONS Page 2 INSTALLATION INSTRUCTIONS Inspection of Shipment After unpacking, check
More informationInstallation Instructions / Warranty. Massaud
Installation Instructions / Warranty Massaud 18450001 Axor Massaud Free-Standing Tub Filler 18450001 Technical Information Max. incoming water pressure 145 psi Recommended water pressure 14.5-72 psi Max.
More informationInstallation S
Installation S59-3200 Thermostatic Mixing Valve (HL200) with Optional Cabinet S59-3200RE (with Recess-Mounted Enamel Cabinet) S59-3200RS (with Recess-Mounted Stainless Steel Cabinet) S59-3200SE (with Surface-Mounted
More informationTORRID MARINE YACHT QUALITY Since Owner s Manual
Marine Water Heaters Owner s Manual Plumbing Configuration Note: While Torrid Marine is always happy to offer advice, we highly recommend you choose a professional marine technician to install your new
More informationModel 9201EFE Tempered Water Blending System
INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS 1455 Kleppe Lane Sparks, NV 89431-6467 (775) 359-4712 Fax (775) 359-7424 E-mail: haws@hawsco.com website: www.hawsco.com Model 9201EFE Tempered Water
More informationINSTALLATION INSTRUCTIONS WARRANTY
QT FLOW CENTER INSTALLATION INSTRUCTIONS Fig. 1. Low Head Pump Center Flow Chart Fig. 2. High Head Pump Center Flow Chart NOTE: Read the entire instruction manual before starting the installation. WARRANTY
More informationSH-2000, SH-2500, AB-3000 Bimetallic Steam Traps Installation and Operation Manual SH-2000
SH-2000, SH-2500, AB-3000 Bimetallic Steam Traps Installation and Operation Manual 65 SH-2500 SH-2000 AB-3000 Table of Contents General Safety Information.............. 2 Product Information..................3
More information