Technical instructions
|
|
- Milton Osborne
- 5 years ago
- Views:
Transcription
1 Énergie Transfert Thermique Technical instructions A different climate Environmental control solutions Version
2
3 IMPORTANT The warranty of ETT units depends on the respect of these technical instructions as stipulated in ETT's General Terms of Sales. The maintenance shall be done by a specialized company. Please change and clean filters as often as possible. Our equipments will surely meet your expectations. We hope you will enjoy using them.
4 Energie Transfert Thermique ummary A. Maintenance and frequency B. Specific maintenance recommendations C. Specific use recommendations D. Use of the controller... 0 E. Assistance for diagnostic and repairing... 11
5 Technical instructions A. Maintenance and frequency Please remember: > ETT provides you the maintenance book of the unit to follow and organize maintenance operations described thereafter. > The use of ETT warranty necessitates a total respect of maintenance and use recommendations indicated in this document. > Units service life and efficiency depends on the respect of all maintenance and use recommendations. Frequency: Q (Quarterly), H (Half-yearly), A (Annually) Benefits: Q H A General control: Casing control Drainage and condensates evacuation cleaning Operating time report Securities control Ventilation: Filters replacement or cleaning (4 mm thickness filters) Filters replacement or cleaning (6 mm thickness filters) Servomotors and dampers control Control and cleaning of fans turbines Fans and motors pulleys control and tightening (if concerned) Fans bearings control (if concerned) Fans rotation speed and air flow rates control Ventilation motors control Control of belts and their tension (if unit with belts) Change of belts (if unit with belts) Fans motors intensities report Propellers fans control (if concerned) Propellers fans motors intensities report (if concerned) Refrigerant circuits: Circuit tightness control (Unit load >2kg A >30kg H >300kg Q ) Refrigerant load control & adjustment if necessary Compressor control Compressor(s) parameters settings Compressor(s) intensities control Pressures control: HP and LP Temperatures control: gas and liquid Refrigerant to air exchangers cleaning and control Control of expansion valves 4-way valve(s) control (if concerned) Heating (if concerned) Hot water coil control Water quality in the hot water coil control 3-way valve operation control Electric heaters control Warm air heaters control (50 to 400 kw capacity) Warm air heaters control (more than 400 kw) 5
6 Technical instructions Frequency: Q (Quarterly), H (Half-yearly), A (Annually) Benefits: Q H A Electricity / Control: Controller control Clock hand settings points control Electrical connections tightening Temperature sensors control Gas probe Pressure probe Coalescing filters cleaning Control of firestop valves Ducts Control of ducts Control of screw-down flanges Gaskets tightness control Check of the equipotential bondings Smoke detector head (DAD) cleaning Smoke detector head replacement Nota: This period is given as an example and can be shorter in case of polluted atmosphere. Replacement of the smoke detection box battery Hygrometry probes replacement (if concerned) CO 2 probes replacement (if concerned) Every 2 years Every 2 years Every 2 years Every 2 years B. Specific maintenance recommendations 1/ Exchangers cleaning Clean them using a bristle scrub brush, a vacuum or a compressed air jet if necessary. Rinse with cold and low pressure water, avoiding spatters on the fan motor. Clean in counter flow of the air flow way. 2/ Filtration Be careful, a bad filtration or an important fouling can damage the unit efficiency and refrigerant circuit. Nota: Those filters cannot be cleaned more than 2 or 3 times. After that, they are less efficient. Do not keep a filter after 3 regenerations. If a filter cannot be regenerated, change it. Metal filters regeneration > Clean them with warm water and liquid detergent. > Rinse them after cleaning and dry them using compressed or current air. > Coat again the filtering equipment with "filter-coat" or something similar, to give its properties back. > Check that filtering elements are correctly installed while reassembling them. "Tissue" filters regeneration > Use the same method than metal filters to clean and dry them. > Reassemble them in the support frame. 6
7 Technical instructions 3/ Fans bearings Many ETT units centrifugal fans have ball bearings, life-greased, without need of maintenance. However, a clearance control in bearings is necessary. > We advise you to control and add grease each quarterly period for fans with grease fitting. > Our fans bearings have generally a hours lifetime. 4/ Particularities of corrosive / salt areas > Bearings and fans shafts greasing each month (whatever the type). > Control and cleaning of fans each month. > Exchangers cleaning with clear water each month. > Coalescing filters cleaning. 5/ Cleaning of the DAD head It is necessary to control periodically the operation according to the regulation in force for the building. For type 1 DAD (DAD S6), a control of the secondary source must be done monthly by pressing the "secondary source test" button during at least 5 seconds. The "Under voltage" indicator must stay switched on. 6/ Coalescing filters cleaning (DSH) Please consult the equipments specifications (HVA13). C. Specific use recommendations 1/ Cooling system register (EN 37-2) When there are more than 3 kg of refrigerant, a register concerning the cooling system must be created and updated by the concerned party. A register must be prepared during the installation of the system by the installer. As indicated in the EN 37-4, it must be constantly updated after maintenance. The register indicates those information: A. Details concerning all maintenance and repairing interventions B. Quantities and nature (new, reused, recycled) of the refrigerant loaded during each intervention. Refrigerant quantities transferred during each intervention (it is also possible to consult the EN 37-4) C. If the reused refrigerant is analysed, it is necessary to keep the results in the register D. The reused refrigerant origin E. The system components changes and replacements F. All routine periodic tests results G. Times during which it is not used. 7
8 Technical instructions 2/ Use of refrigerant It is necessary to respect the EC No.42/2006 Directive while using refrigerants: - Operators must be trained and authorized to manipulate refrigerants. - The company employing the operator must have a certificate of competency giving the right to its staff to manipulate refrigerants. - It is important to control and declare refrigerants leakages according to the installation load.! Warning: Please respect the security rules given by the refrigerant suppliers concerning the use of refrigerants. 3/ Unit temporary stop A. Stop the unit. B. Keep the evaporator reheater (air to water, water to water PAC (heat pump)) and the pipelines reheaters under voltage if it is not automatic and if the unit is in a place in which there might be temperatures under 0 C. 4/ Starting after a temporary stop There is no particular precautions. The unit starts by reversing the actions in the paragraph: "Unit temporary stop". 5/ Unit seasonal stop A. If the heat pump has water circuits, drain them. If the unit is in a place in which there might be temperatures under 0 C, drain the connection pipelines. B. Open the main switch. Remove the fuse block or lock the main switch in opened position. C. If the heat pump is in an area in which there can be condensation, it is necessary to put oil on mechanical pieces that can become oxidized (fan bearings, rollings, pulleys, etc.). 6/ Seasonal start A. Respect the actions written in the "Annually" paragraph, in the "Maintenance" chapter. B. If necessary, fill up the water circuits and drain the air inside them. C. Open completely the compressor backflow valve. D. Open the stop valve of the liquid line (eventually). E. Check the whole refrigerant circuit tightness. F. Switch on the system main disconnector. G. Fix the control unit (if concerned). H. Wait for the compressor crankcase heaters preheating (72 hours). I. Start the system. J. Check the operation of the equipments connected together. K. Check the oil level and the service pressures after the operation of the system during 15 to 20 minutes. The refrigerant flow rate must be regular. There must not be bubbles.
9 Technical instructions 7. Generating sets A "clean" stop of the unit is necessary if the unit is supplied using a generating set (please consult "Unit temporary stop" for more information). It can be managed manually or by programming a BMS according to the information given by the energy supplier, in case of peak-day load reductions. The unit can be damaged and components broken (electric components, compressors) in case of non respect of this point. In this case, the ETT warranty cannot be used. D. Use of the controller 1/ Starting-up or stopping the unit 5 seconds. Press "ENTER" during 2/ Faults fixing Press "ALARM" to see the fault. Correct the fault on the component concerned (DAD reset, fire thermostat or freezestat reset, start of thermal protection, etc.) Press "ALARM" during 5 seconds to fix the fault. 3/ Access to level 0 - User settings Access to menus: - points - Operating hours - Clock settings Press the arrows simultaneously during 2 seconds Password = 0 Choose the desired menu by using the arrows Choose the desired mask by using the arrows Press "ENTER" to access to the setpoints Choose the setpoint that needs to be changed by using the arrows Press "ENTER" to the desired menu Press "ENTER" to access to this setpoint
10 Technical instructions -up the setpoint by using the arrows to the main mask Press "ESC" to come back 4/ Access to level 1 - Maintenance - Maintenance Access to menus: - Communication - Alarm History - Energy meter - Inputs - Outputs - Counter reset Press the arrows simultaneously during 2 seconds Password = 1 Press "ENTER" to the desired menu Choose the desired menu by using the arrows the desired mask by using the arrows Choose to the setpoints Press "ENTER" to access Choose the setpoint that needs to be changed by using the arrows Press "ENTER" to access to this setpoint -up the setpoint by using the arrows Press "ESC" to come back to the main mask 10
11 Technical instructions E. Assistance for diagnostic and repairing 1/ Smoke fault Smoke detection Detection head fouling Saving battery out of service - Control of presence of smokes or dusts - Head cleaning - Change of head - Fault fixing (Consult D.2) - Control of presence of smokes or dusts - Head cleaning - Change of head - Fault fixing (Consult D.2) - Change of battery 2/ Filter fault Fouled filters Fouled exchangers - Filters cleaning - Change of filters - Exchangers cleaning according to the recommendations 3/ Air flow rate fault Fouled filters Leakage on air network Transmissions problem Air network fouled - Filters cleaning - Change of filters - Air distribution network fixing - Transmissions settings - Air distribution network cleaning 4/ Fire fault Lack of air flow rate Transmission problem Thermostat problem - Check filters - Check the fan and its motor - Check the transmission - Check the thermostat 11
12 Technical instructions 5/ Antifrost fault Lack of air flow rate Transmission problem Thermostat problem Lack of hot water - Check filters - Check the fan and its motor - Check the transmission - Check the thermostat - Check the boiler house and the pump 6/ Inverters faults Fault with intensity - Check the eventual presence of micro cuts on the power supply system 7/ Low pressure fault Bad air flow rate Low pressure switch malfunction Fouled filters Expansion valve malfunction Bad defrosting Problem of load of refrigerant - Consult air flow rate faults actions (Consult E.3) - Pressure switch operation control - Pressure switch connections control - Filters cleaning - Change of filters - Expansion valve control (status, settings, operation) - Check the refrigerant circuit probes - Check the 4-way valve - Check the defrosting settings - Tightness control / High pressure fault Bad air flow rate High pressure switch malfunction Fouled filters Outside T out of application range Bad air distribution - Consult air flow rate faults actions (Consult E.3) - Pressure switch operation control - Pressure switch connections control - Filters cleaning - Change of filters - No action - Air distribution network control 12
13 Technical instructions / Refrigerant circuit fault A. The compressor does not start. Electrical protection faults Control security Abnormal supply voltage Propeller fault - Protections control - Control parameters control - Securities control - Controller reset if authorized - Phases control - Control of the voltage drop during the unit start-up - Control of the power supply chain (wire, connections, contactor, etc.) - Propellers control B. The compressor stops. Low pressure faults - Consult E.7 High pressure fault - Consult E. Ipsotherm fault Thermal fault Power supply chain broken Propeller fault - Control of the compressor cooling - Control of the ipsotherm probe - Filters fouling control - Compressor absorbed current control - Control of the starting voltage drop - Control of the power supply chain (wire, connections, contactors, etc.) - Propellers control C. The compressor makes noise. Knocks Sluggings Grunts - Control the compressor suction pressure - Control valves status - Overheating control - Control of expansion valve bulb fixation - Control of the supply voltage - Phases control - Galling => broken part D. The compressor does not stop. point temperature too much different from the advised temperatures Glued contactor - point temperatures control - Contactor control 13
14 Technical instructions E. Lack of capacity. The expansion valve whistles Important overheating Pre-expansion Wrong flow rates - Expansion valve settings control - Load control - Expansion valve settings control - Load control - Drier filter control - Flow rates control 10/ Please consult the unit FA for the other faults. 14
15
16 T r a n s f e r t T h e r m i q u e Design: ETT - Document printed by an environmentally friendly printer using vegetable based ink on PEFC paper created from sustainably-managed forest. É n e r g i e A different climate Environmental control solutions 56 route de Brest - CS Ploudalmézeau - France Phone number: +33 (0) Fax: +33 (0) Export contact: +33 (0) ETT Services: +33 (0)
Technical instructions
Energie Transfert Thermique Technical instructions A different climate Environmental control solutions Version IMPORTANT The validity of our guarantee is conditional upon compliance with these technical
More informationTechnical instructions
Énergie Transfert Thermique Technical instructions Double fl ow dehumidifi er DESHU Energie Transfert Thermique Contents A. Equipment performance... 3 B. Maintenance intervals... 3 C. Regulatory requirements...
More informationenvironmental climate control equipment & solutions AQUACOOL Water-to-water heat pump with passive energy recovery
environmental climate control equipment & solutions AQUACOOL Water-to-water heat pump with passive energy recovery made in France www.ett.fr energie transfert thermique c o n t e n t s General description...
More informationENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS PACARE HPE+ Double flow vertical heat pump with recovery wheel.
ENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS PACARE HPE+ Double flow vertical heat pump with recovery wheel www.ett.fr ENERGIE TRANSFERT THERMIQUE C O N T E N T S General description...03 Operating
More informationENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS AQUACOOL. Water-to-water heat pump with passive energy recovery.
ENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS AQUACOOL Water-to-water heat pump with passive energy recovery www.ett.fr ENERGIE TRANSFERT THERMIQUE C O N T E N T S General description... 3 Operating
More informationRoof top SPACE RPC 450Z R407C M011
Roof top SPACE RPC 450Z R407C M011 Page : 1 / 5 Independant roof mounted unit, cooling only, ready to be installed, designed for air conditioning of large volumes for industrial or commercial use. As per
More informationService Step by Step Trouble-Shooting Check-List
WARNING: Only Data Aire trained technician or experience technicians should be working on Data Aire Equipment. Protect yourself at all times and work safe. Date: Dates at the job site: From: to Job#: Serial#:
More informationRoof top SPACE RPC 315Z R407C MA00
Client : TIHE SERV Contact : Romeo Staicu Your reference : Your contact : Phone : E-mail : Page : 1 / 6 Roof top SPACE RPC 315Z R407C MA00 Independant roof mounted unit, cooling only, ready to be installed,
More informationSPECIFICATION GUIDE FLEXAIR. Possibility to add auxiliary heaters: Gas, Electrical Heater, Hot Water Coil Possibility to add Heat Recovery Module
SPECIFICATION GUIDE FLEXAIR Air-cooled packaged Rooftop unit Cooling only or Heat Pump Nominal cooling capacity: 85 to 234 kw Nominal heating capacity: 83 to 226 kw Possibility to add auxiliary heaters:
More informationWINDOW YORK TECHNICAL GUIDE. Single package Cooling only and Heat pump. Models YO-YM R407C YO V6 G YO V7 G
WINDOW TECHNICAL GUIDE Single package Cooling only and Heat pump Models YO-YM 09-24 R407C YM 09 V6 G YM 09 V7 G YO 12-19-24 V6 G YO 12-19-24 V7 G YORK List of Contents Page 1 - Safety...2 2 - Unit packaging...2
More informationCooling Unit for Producing Chilled Water. Envicooler. Operation and Maintenance Instructions. Air handling with the focus on LCC
Cooling Unit for Producing Chilled Water Air handling with the focus on LCC Address and telephone list for calling for service Supplier: IV Produkt Box 3103 SE-350 43 VÄXJÖ, Sweden Street address: Sjöuddevägen
More informationCENTRIFUGAL AIR CONDENSERS
OPERATING INSTRUCTIONS INSTALLATION COMMISSIONING OPERATING MAINTENANCE (must be given to the end user in order to complete the operating manual during the equipment service life) CAC and SIROCCO CENTRIFUGAL
More informationCondensing Unit Installation and Operating Instructions
Bulletin WCU_O&I 01 June 2003 Condensing Unit Installation and Operating Instructions WCU Air Cooled Condensing Unit Table of Contents Section 1. Section 2. Section 3. Section 4. Section 5. Section 6.
More informationMISSION CRITICAL Air Conditioning Systems. Maintenance Guide. ClimateWorx International Inc. 14 Chelsea Lane, Brampton, Ontario, Canada L6T 3Y4
MISSION CRITICAL Air Conditioning Systems Maintenance Guide ClimateWorx International Inc. 14 Chelsea Lane, Brampton, Ontario, Canada L6T 3Y4 Vertical Floor /Wall /Ceiling Mount - Maintenance Manual 2
More informationA/C-HEATER SYSTEM - MANUAL
A/C-HEATER SYSTEM - MANUAL 1986 Isuzu Trooper II 1986 A/C-HEATER SYSTEM Isuzu A/C-Heater Systems - Manual P UP, Trooper II * PLEASE READ THIS FIRST * CAUTION: When discharging air conditioning system,
More informationSplit-system cooling units and heat pumps SERIES. Outdoor unit. Indoor unit OPERATING LIMITS. Inlet air conditions Cooling Heating.
capacity: Heating capacity: 20,8 to 135,1 kw 22,6 to 144,7 kw Scroll compressors R-410A refrigerant Confi guration fl exibility Silent operation DESCRIPTION The AirDuo cooling units and are units which
More informationAssessment Schedule - TS8
The Assessor shall determine the business s commitment and support to good and safe working practices; also that it has a positive culture in all aspects of its work. In particular, the assessor shall
More informationPreventative Maintenance Tables
Preventative Maintenance Tables Table of Contents I. Table : Gas Fired Domestic Hot Water Heater II. III. IV. Table : Circulating Pump Table : Convectors Table 4: Grille and Diffusors V. Table 5: Unit
More informationLargo & Allegro. Air Compressors. Largo & Allegro 31-90
Largo & Allegro Air Compressors Largo & Allegro 31-90 ALUP Driven by technology. Designed by experience. ALUP Kompressoren has over 85 years of industrial experience. It is our ambition to offer compressed
More informationSELF CONTAINED HORIZONTAL AIR CONDITIONERS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER)
SELF CONTAINED HORIZONTAL AIR CONDITIONERS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER) SERIES: WCHZ MODELS: 201, 251, 271, 351, 401, 501, 701, 721, 751 COOLING CAPACITIES OF: 6,4
More informationBHW INSTALLATION, OPERATION AND MAINTENANCE MANUAL MEDIUM STATIC PRESSURE DUCTABLE TYPE. Models:
INSTALLATION, OPERATION AND MAINTENANCE MANUAL BHW MEDIUM STATIC PRESSURE DUCTABLE TYPE Models: 174 205 358 410 515 720 724 Cooling capacities from 3,1 to 25 KW Heating capacities from 4,5 to 55,5 KW Thank
More informationIndholdsfortegnelse. Danvent Air Handling Units SERVICE MANUAL
Indholdsfortegnelse Danvent Air Handling Units SERVICE MANUAL Service Servicing of the Air Handling Unit Your ventilation system is equipped with a Danvent Air Handling Unit (AHU) which will contribute
More informationDOLPHIN RADIATOR & COOLING SYSTEMS P.O.Box: 1424,Ph#: , Fax#: ,
DOLPHIN RADIATOR & COOLING SYSTEMS P.O.Box: 1424,Ph#: +971-6-5432526, Fax#: +971-6-5432415, Email: dolcool@emirates.net.ae, web site: www.dolphinheattransfer.com NOMENCLATURE: INTRODUCTION DOLCOOL branded
More informationCATALOGUES SUMMARY - WCHBZ Pages WCHZ Pages 19-42
SELF CONTAINED HORIZONTAL UNITS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER ) HEAT PUMP. WCHBZ COOLING ONLY. WCHZ SERIES: WCHBZ - Heat Pump MODELS: 201, 251, 271, 351, 401, 501 COOLING
More informationFELIX STORCH, INC. SUMMIT APPLIANCE DIVISION
FELIX STORCH, INC. SUMMIT APPLIANCE DIVISION INSTRUCTION MANUAL FOR MODEL: FFAR-10 Thank you for your trust and for buying this appliance. It s designed to refrigerate your fresh foods, while adding an
More informationPackaged air conditioning unit condensed by air model RTC 07L to 30L. Technical information. Ref.: Y-R
Packaged air conditioning unit condensed by air model RTC 07L to 30L Ref.: Y-R70167 0707 Technical information I S O 9 0 0 1 ER-0028/1991 Johnson Controls Manufacturing España, S.L. is participating in
More informationContour TM Screw Compressors
Contour TM Screw Compressors Semi-Hermetic Compact Operating Instruction SCH1 High Temp Compressors Form No. 99-77 1. Introduction This series of semi-hermetic compact screw compressors is designed for
More informationE U R O V E N T CERTIFIED PERFORMANCE
Compact Horizontal Air-Air Heat Pump Model RTH 07L to 30L Ref.: Y-R70171 0707 Technical information E U R O V E N T CERTIFIED PERFORMANCE I S O 9 0 0 1 ER-0028/1991 Johnson Controls Manufacturing España,
More information.2 Section Waste Management and Disposal.
Issued 2005/06/01 Section 15624 Packaged Rotary Screw Water Chillers Page 1 of 5 PART 1 General 1.1 RELATED SECTIONS.1 Section 01330 Submittal Procedures..2 Section 01355 Waste Management and Disposal..3
More informationRollair. Air Compressors. Rollair 40 to 125 and Rollair 40 V to 125 V
Rollair Air Compressors Rollair 40 to 125 and Rollair 40 V to 125 V Worthington Creyssensac Driven by technology. Designed by experience. Worthington Creyssensac has over 145 years of industrial experience.
More informationSECTION PACKAGED ROOFTOP AIR CONDITIONING UNITS
SECTION 15732 - PACKAGED ROOFTOP AIR CONDITIONING UNITS PART 1 - GENERAL 1.1 SECTION INCLUDES A. Package roof top unit. B. Heat exchanger. C. Refrigeration components. D. Unit operating controls. E. Roof
More informationTECHNICAL GUIDE DESCRIPTION SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS MODELS: HF-07 FEATURES B-0703
TECHNICAL GUIDE SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS MODELS: HF-07 DESCRIPTION These Sunline 2000 units are completely assembled, piped and wired at the factory to provide one-piece shipment and rigging.
More informationCompact Horizontal Air-Air Heat Pump Model RTH 07L to 30L. Technical information. Ref.: N
Compact Horizontal Air-Air Heat Pump Model RTH 07L to 30L Ref.: N-27661 0608 Technical information Johnson Controls Manufacturing España, S.L. is participating in the EUROVENT Certification Program. Products
More informationPackaged air conditioning unit condensed by air model RTC 07L to 30L. Technical information. Ref.: N
Packaged air conditioning unit condensed by air model RTC 07L to 30L Ref.: N-27656 0608 Technical information Johnson Controls Manufacturing España, S.L. is participating in the EUROVENT Certification
More informationThis chapter is devided into two sections:
This chapter is devided into two sections: Page Installation requirements........................................................................ 127 The installation process..........................................................................
More information30GH Air-Cooled Liquid Chillers 30GH Nominal cooling capacity kw
Air-Cooled Liquid Chillers Nominal cooling capacity 21-94 kw Carrier is participating in the Eurovent Certification Programme. Products are as listed in the Eurovent Directory of Certified Products. The
More informationComfort. savings. and energy. A different climate Environmental control solutions
Comfort and energy savings 1.1.1.3.1 DESHU Thermodynamic double fl ow dehumidifi er High Energy Performance range different climate Environmental control solutions March 2015 edition General description
More information442 Chapter 16. Figure 16-5 Gas leak detection
BRORANE BRORANEBRORANEBRORANEBRORANEBRORANEBRORANEBRORANE 442 Chapter 16 Tur n e r BRORANE FUEL EBRORANEBRORANEBRORANEBRORANEBRORANE Figure 16-5 Gas leak detection is easy. This sensitive halide detector
More information2 shp 13 lc 1 36 t - 1 a
HEAT PUMPs 2SHP3 PRODUCT SPECIFICATIONS Dry Charge Split System - 60 HZ Bulletin No. 20645 July 203 Supersedes June 202 3 to 5 Tons MODEL NUMBER IDENTIFICATION 2 shp 3 lc 36 t - a Refrigerant Type 2 =
More informationULTI+ ENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS
ENVIRONMENTAL CLIMATE CONTROL EQUIPMENT & SOLUTIONS Single flow heat pump Available options: - Dehumidification - Capacity variation (SRV) www.ett-hvac.com : A unit from the ULTIMA range ULTIMA is ETT
More informationEBAC MODEL CD425 ( ) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL CD425 (1018110) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL Ebac Industrial Products 704 Middle Ground Boulevard Newport News, VA 23606 Tel: 757 873 6800 Fax: 757 873 3632 Website: www.ebacusa.com
More informationWATER CHILLER UNITS AIR COOLED CONDENSER CENTRIFUGAL FANS HEAT PUMP. EWCBZ COOLING ONLY. EWCZ
WATER CHILLER UNITS AIR COOLED CONDENSER CENTRIFUGAL FANS HEAT PUMP. EWCBZ COOLING ONLY. EWCZ SERIES: EWCBZ - Heat pump MODELS: 70, 80, 00, 0, 60, 00, 40, 00, 50 COOLING CAPACITIES from 5,9 kw to 78,5
More information40LM Hz INSTALLATION, START-UP AND SERVICE INSTRUCTIONS CHILLED WATER FAN COIL UNIT
Carrier International Sdn. Bhd. Malaysia INSTALLATION, START-UP AND SERVICE INSTRUCTIONS CHILLED WATER FAN COIL UNIT 40LM 120-200 50Hz CONTENTS: Physical Data & Dimension 1-3 Safety Considerations 4 Rigging
More informationHT V2 HT Split
Scroll compressor Refrigerant R07C Aqu@Scop HT V Aqu@Scop HT Split High Temperature Air-to-Water Heat Pumps Models -, -7 and 8-9.0 to 7.9kW Aqu@Scop HT V / Aqu@Scop HT Split Installation examples - Single
More informationINSTALLATION AND USER MANUAL
Swimming Pool Heat Pump Swimming Pool Heat Pump INSTALLATION AND USER MANUAL Thank you for choosing our product and trusting our company. This manual is to provide you with necessary information for optimal
More informationInstruction Manual HWR MODEL RESISTO-FLO ELECTRIC BOILER
Page 1 of 16 Instruction Manual HWR MODEL RESISTO-FLO ELECTRIC BOILER Page 2 of 16 FOREWORD The HWR Resisto-Flo Electric Hot Water Boiler is designed to provide a compact packaged unit requiring a minimum
More informationREFRIGERAT A OR USE DF1-15 F ridge
REFRIGERATOR USE DF1-15 Fridge BEFORE USING THE APPLIANCE. Your new appliance is designed exclusively for domestic use. To ensure best use of your appliance, carefully read the operating instructions which
More informationEH0533 Indoor Climate Control
EH0533 Indoor Climate Control 2.8 kw of cooling, 2.9 kw of heating Air Conditioning Efficient heating (air-source heat-pump) Cooling Remote control Suitable for low-wall installation No external unit required
More informationKG 092 SHOWN READ ALL INSTRUCTIONS IN THIS MANUAL AND RETAIN FOR FUTURE REFERENCE WARNING
See unit nameplate for manufacturer and address. 507350-03 3/2016 Supersedes 9/2015 KG 024, 030, 036, 048, 060, 072, 074, 090 (2, 2-1/2, 3, 4, 5, 6 and 7-1/2 Tons) KG 092, 102, 120, 150 (7-1/2, 8 1/2,
More informationOperation Manual. Instructions for Installation, Operation & Maintenance. PortaPac 5-, 8 and 10-ton Portable Air Conditioners
Operation Manual PortaPac 5-, 8 and 10-ton Portable Air Conditioners A AirPac, Incorporated AirPac Technology Park 888 Shenandoah Shores Road Front Royal, Virginia 22630 U.S.A. Toll Free 888-324-7722 Web:
More informationTCW 2000 Ice liner refrigerator and freezer PIJ
TCW 2000 Ice liner refrigerator and freezer OVER VIEW The unique rotomoulded Chest Freezer and inclined Refrigerator with two separate compartments and compressors worldwide Hold over time @ 32 C Hold
More informationPrecision air handling cabinets Ciatronic MICRO/EXPAIR
/ Reducted footprint Double-wall construction Built-in voltage variator PLC control Variable speed condenser fan ENVIRONMENTALLY HFC R410A PROTECTION DE FRIENDLY L'ENVIRONNEMENT Cooling capacity: 5 to
More informationWarning: 230V / 1ph / 50Hz V / 3ph / 50Hz. Remarks: Make sure that you have enough power. (See page 15 Cable table)
1 2 Warning: - Do not place your hand or any other objects into the air outlet and fan. It could damage the heat pump and cause injuries; - In case of any abnormality with the heat pump, cut off the power
More informationPDF Created with deskpdf PDF Writer - Trial ::
Instruction Manual Index Introduction Uncrating and Checking for Damage Locating Your Unit Installation Fill Tank Process Connections Pre Startup Startup Sequence Trouble Shooting Chart Operating Lights
More informationCS/CD/CP AIR COOLED CONDENSING UNITS (P/N E207120C R2)
CS*/CD*/CP* Series Air Cooled Condensing Units Operating and Installation Manual CS/CD/CP AIR COOLED CONDENSING UNITS (P/N E207120C R2) TABLE OF CONTENTS I. Receipt of Equipment 2 II. Piping...4 III. System
More informationOperating Instructions
Operating Instructions Varioset Standard After-sales service For after-sales service please contact the Veit representative in your country. GmbH & Co. Justus - von - Liebig - Str. 15 D - 86899 Landsberg
More informationE U R O V E N T CERTIFIED PERFORMANCE
Compact Horizontal Air-Air Heat Pump Model RTH-7K to 3K Ref.: Y-R719 7 Technical information E U R O V E N T CERTIFIED PERFORMANCE I S O 9 1 ER-8/1991 Clima Roca York S.L. is participating in the EUROVENT
More informationSWIMMING POOL & SPA HEAT PUMPS OWNERS OPERATIONAL MANUAL
SWIMMING POOL & SPA HEAT PUMPS OWNERS OPERATIONAL MANUAL MODEL AT105 AT115 AT130 with Titanium Heat Exchanger 2213 Andrea Lane Ft. Myers FL 33912 888-297-3826 941-482-0606 www.aquathermheatpumps.com DIGITAL
More informationSTANDARD DEHUMIDIFIERS EH SERIES TECHNICAL MANUAL
STANDARD DEHUMIDIFIERS EH SERIES TECHNICAL MANUAL 2 3 4 INDEX Declaration of conformity page 3 Aim and contents of this manual page 6 How to keep this manual page 6 Graphic symbols page 6 Safety laws page
More informationWINDOW TYPE ROOM AIR CONDITIONER OPERATION AND INSTALLATION MANUAL
MODEL RA-0LDF RA-3LDF WINDOW TYPE ROOM AIR CONDITIONER OPERATION AND INSTALLATION MANUAL AIR DEFLECTORS VERTICAL DEFLECTORS Vertical de ectors at both sides of outlets can be set to either auto-swing or
More informationParts Available from
Montage und Bedienungsanleitung Manuel d entretien Installation, use and maintenance instructions Installatie-, gebruiks- en onderhoudsvoorschriften Oδηγίες εγκατάστασης, χρήσης και συντήρησης D F GB NL
More informationπ H-2268 SANITAIRE UPRIGHT VACUUM SAFETY uline.com
π H-2268 SANITAIRE UPRIGHT VACUUM 1-800-295-5510 uline.com SAFETY PAGE 1 OF 7 NOTE: When using an electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS
More informationInstallation & Service Instructions for Jackson & Church Flexaire Packaged Furnaces SDF-125 thru SDF-400 Gas Firing
Installation & Service Instructions for Jackson & Church Flexaire Packaged Furnaces SDF-125 thru SDF-400 Gas Firing Important: To protect the unit and avoid damage to the heat exchanger, the blower speed
More informationH3/V3 Series Horizontal and Vertical Indoor Air Handling Units. Engineering Catalog
H3/V3 Series Horizontal and Vertical Indoor Air Handling Units Engineering Catalog Table of Contents AAON H3/V3 Series Features and Options Introduction... 6 H3/V3 Base Model Description... 7 Unit Size...
More informationComponent. Maintenance. Manual Z SERIES. Evaporator Assembly
Component Maintenance Manual with Illustrated Parts List for Z21-701-SERIES Evaporator Assembly 1 of 16 Record of Revision REVISION ISSUE POSTED NO: DATE DATE INSERTED BY: 2 of 16 List of Effective Pages
More informationVertiCool Aurora Engineering Guide
Engineering Guide Effective August 2016 Air-Cooled, Water-Cooled and Water Source Heat Pump Contents Product Features... 3 Options... 4 Physical Data...5-6 Air-Cooled Performance Data (a) (b) (c)...7-8
More informationOperation Manual. AvantAC Classic Bus Air Conditioning Units. Carrier Transicold China
Operation Manual AvantAC Classic Bus Air Conditioning Units 1235 1821 86-21-59166868 86-21-59165013 Headquarter: No.1235 Ye Cheng Rd. Jiading District, Shanghai, 1821, China Tel: 86-21-59166868 Fax: 86-21-59165013
More informationNominal Capacity 024 = 7 kw (2 tons) 036 = 10.5 kw (3 tons) 048 = 14 kw (4 tons) 060 = 17.5 kw (5 tons)
ENGINEERING DATA HEAT PUMP OUTDOOR UNITS HP40 50HZ Capacity 6.2 to 16.3 (21 200 to 55 500 Btuh) Heating Capacity 6.4 to 16.1 (21 800 to 55 500 Btuh) Bulletin No. 490088 October 2004 Supersedes August 1999
More information50Hz AC, HP and Air Handler Units Up to 70 kw. Commercial Split Systems. Reliable, cost-effective and servicefriendly split systems inside and out
50Hz AC, HP and Air Handler Units Up to 70 kw T-Class Commercial Split Systems TSA/TPA and TAA Models Reliable, cost-effective and servicefriendly split systems inside and out Lennox units deliver comfort
More informationSECTION WATER-SOURCE UNITARY HEAT PUMPS
SECTION 23 81 46 WATER-SOURCE UNITARY HEAT PUMPS PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of Contract, including General and Supplementary Conditions and Division 1 Specification
More informationEH0554 Indoor Climate Control
EH0554 Indoor Climate Control 3.2kW heating or cooling capacity Air conditioning Dehumidification Cooling Efficient heating via air-source heat-pump Suitable for high- or low-wall installation No external
More informationINSTALLATION, COMMISSIONING AND OPERATING MANUAL
INSTALLATION, COMMISSIONING AND OPERATING MANUAL 1 YTBV-D-CE42_0109 CONTENT Available models and capacities Supplier information Warranty Safety Emergency stops/ shutdowns About this manual Models Physical
More informationNiles Steel Tank Hot Water Generator Installation and Operation Manual
Niles Steel Tank Hot Water Generator Installation and Operation Manual Contents: Contents 1 Hazard definitions 1 1. General Information.... 2 Availability... 3 Optional Control Packages... 5 2. Installation....
More informationRefrigeration. User Instructions & Service History
Refrigeration User Instructions & Service History Eberspächer (UK) Ltd. Headlands Business Park Salisbury Road, Ringwood Hampshire, BH24 3PB Tel: +44 (0) 1425 480151 Fax: +44 (0) 1425 480152 Website: www.eberspacher.com
More informationBRT C/H Series PACKAGED AIR TO AIR UNITS COOLING / HEATING APPLICATIONS OUTDOOR INSTALLATION. Ver. 1.01
b cool manufacturers of air-conditioning equipment ltd BRT C/H Series PACKAGED AIR TO AIR UNITS COOLING / HEATING APPLICATIONS OUTDOOR INSTALLATION Ver. 1.01 Ver. 3.02 01_18 BCool# 1 brt c/h r407c / r410a
More informationCZT CZT. High efficiency air to water heat pumps with E.V.I. compressors E.V.I. HP OTHER VERSIONS ACCESSORIES
High efficiency air to water heat pumps with E.V.I. compressors infolinia: +48 691 262 691-15 C +63 C +43 C E.V.I. HP The series of high efficiency heat pumps has been specifically designed for use with
More informationUNDERCOUNTER LABORATORY REFRIGERATORS and FREEZERS Installation, Operation and Maintenance Instructions
UNDERCOUNTER LABORATORY REFRIGERATORS and FREEZERS Installation, Operation and Maintenance Instructions INSPECTION When the equipment is received, all items should be carefully checked against the bill
More informationOwner s Manual. Middle Static Pressure Duct Type MEU-18MPH2 MEU-24MPH2 MEU-36MPL2 MEU-48MPL2 MIDDLE STATIC PRESSURE DUCT TYPE AIR CONDITIONER
MIDDLE STATIC PRESSURE DUCT TYPE AIR CONDITIONER Owner s Manual Middle Static Pressure Duct Type MEU-18MPH2 MEU-24MPH2 MEU-36MPL2 MEU-48MPL2 IMPORTANT NOTE: Read this manual carefully before installing
More informationDEALER SERVICE BULLETIN
DEALER SERVICE BULLETIN Number: DSB 13-0025 Issued: 10/25/2013 Title: Schrader Valve Core Removal on Humidi-Mizer SRT Units PRODUCT CATEGORY: SRT with Humidi-Mizer System MODELS AFFECTED: Carrier: 48/50
More informationSECTION ROTARY-SCREW WATER CHILLERS
PART 1 GENERAL 1.01 SECTION INCLUDES A. Factory-assembled packaged chiller. B. Charge of refrigerant and oil. C. Controls and control connections. D. Chilled water connections. E. Electrical power connections.
More informationPart 3 Troubleshooting
Part Troubleshooting What is in this part? This part contains the following chapters: Chapter See page Troubleshooting 2 Error Codes: Hydro-box 7 Error Codes: Outdoor Units Error Codes: System Malfunctions
More information53 KNL / 53 QNL OWNER S MANUAL
53 KNL / 53 QNL /OFF OWNER S MANUAL Split system air conditioner Contents Page Precautions... Unit description... 4 Remote controller description... 6 Remote controller preparation... 8 Unit operation...
More informationDSV Model Air Cooled Self Contained Indoor Packaged Units 3-5 Tons Preliminary Application Data
DSV Model Air Cooled Self Contained Indoor Packaged Units 3-5 Tons Preliminary Application Data July 28, 2008 Page 1 1 of 3 PROJECT: TAG: Gross Cooling Capacity [Btuh]: 37,800* Design CFM: 1,200 Seasonal
More informationOPERATION AND SERVICE for
T-313 Manual OPERATION AND SERVICE for 68RM50-100/101 MICROMAX T-313 REV. 07/2012 2012 Mobile Climate Control SAFETY SUMMARY GENERAL SAFETY NOTICES The following general safety notices supplement the specific
More informationHORIZONTAL MULTISTAGE CENTRIFUGAL PUMP
HORIZONTAL MULTISTAGE CENTRIFUGAL PUMP WWPPCHLFT260 Instructions WWPPCHLFT260_Horizontal Multistage Centrifugal Pump_IB.indd 1 READ THIS MANUAL CAREFULL BEFORE INSTALL, START THE PUMP 1. Suction 2. Plug
More informationFLAME115 INFRARED HEATER SERVICE MANUAL INDEX FIRE 115 WARNING
FLAME115 INFRARED HEATER SERVICE MANUAL INDEX 1. CONTROLS AND COMPONENTS 2. FLAME CONTROL CYCLES 3. MAINTENANCE SCHEDULE 4. TROUBLESHOOTING GUIDE 5. REPAIR PROCEDURES 1. FAN MOTOR ASSEMBLY 2. FUEL FILTER
More informationEBAC MODEL WM150 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL WM150 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL WM150 OWNERS MANUAL Page 1 of 9 INTRODUCTION Designed for a wide range of applications, the WM150 is a rugged, industrial unit, which utilizes an
More informationCMA CONDENSING UNITS FOR OUTDOOR INSTALLATION INSTALLATION AND OPERATION MANUAL
CMA CONDENSING UNITS FOR OUTDOOR INSTALLATION ECO-FRIENDLY REFRIGERANT GAS INSTALLATION AND OPERATION MANUAL Dear Customer, Thank you for having purchased a FERROLI product. It is the result of many years
More informationMIN. CCT. QTY RLA LRA HP FLA AMPACITY /1/ /3/
1 of 3 Cooling Capacity [Btuh] 24,800 * Condensing Unit SEER: 13.0 ** Condensing Unit CFM: 1,600 Condenser Fan No./Type: 1/CENTRIFUGAL Diameter x Width [in]: 10x10 Drive: Adjustable Belt Motor HP: 0.5
More informationThe breaker trips at once when it is set to ON. The breaker trips in few minutes when it is set to ON.
Trip of breaker or The breaker trips at once when it is set to O. Measure insulation resistance to ground to see if there is any leakage. Air conditioner can not start up blow of fuse The air conditioner
More informationINSTALLATION AND OPERATING MANUAL
INSTALLATION AND OPERATING MANUAL COMPACTAIR KVCK KVHA / KVHK TABLE OF CONTENTS POINTS TO KEEP IN MIND PAGE 2 DATA PAGE FOR UNIT COMMISSIONING PAGE 3 1.- GENERAL CHARACTERISTICS PAGE 1.1.- PHYSICAL DATA
More informationForced draught gas burner
Installation, use and maintenance instructions Forced draught gas burner Code Model Type 3751982 GAS 3 519T80 291 (3) - 02/2010 DECLARATION Declaration of conformity in accordance with ISO / IEC 17050-1
More informationDUCTED AIR CONDITIONER. Owner s Manual. KD Series KD24. Kaden Owner s Manual 1
DUCTED AIR CONDITIONER Owner s Manual KD Series KD24 Kaden Owner s Manual 1 Table of Contents 1. Safety Precautions 4 2. Indoor Unit Parts and Major Functions 6 3. Care and Maintenance 8 4. Troubleshooting
More informationDTW Works Master Specification Version 2006 Issued 2006/08/01 Section15621 Packaged Reciprocating Water Chillers Page 1 of 5
Issued 2006/08/01 Section15621 Packaged Reciprocating Water Chillers Page 1 of 5 PART 1 GENERAL 1.1 RELATED SECTIONS.1 Section 01330 Submittal Procedures..2 Section 01355 Waste Management and Disposal..3
More informationAdvance Release September 2009
Vertical Air Cooled DSV Series R 410A Model DSV096 DSV120 DSV144 DSV180 Nominal Cooling (Tons) 8 10 12 15 Refrigerant R 410A R 410A R 410A R 410A Cooling Performance Gross Cooling Capacity(Btu/h) 95,000*
More information1. Information before installation General terms of delivery, storage and transport
EN Read this manual carefully before installing, maintaining or repairing this device! The symbol indicates important information that must be taken into account in order to avoid risk of personal injury
More informationE-COMBI EVO E-SYSTEM EVO
E-COMBI EVO E-SYSTEM EVO User s manual CONDENSING WALL-HUNG GAS BOILER G.C.N.:47-116-68 (24 kw) G.C.N.:47-116-69 (30 kw) G.C.N.:47-116-70 (38 kw) G.C.N.:41-116-39 (24 kw) G.C.N.:41-116-40 (30 kw) Country
More informationFELIX STORCH, INC. SUMMIT APPLIANCE DIVISION INSTRUCTION MANUAL FOR MODELS: FS60-FROST
FELIX STORCH, INC. SUMMIT APPLIANCE DIVISION INSTRUCTION MANUAL FOR MODELS: FS60-FROST Thank you for putting your trust in our company and for purchasing this appliance. We hope it will successfully serve
More informationG-10s. Instruction Manual. G-Series Cooler UPRIGHT COOLER. Part No.11IPA
G-Series Cooler UPRIGHT COOLER Part No.11IPA-062800 Instruction Manual FOR YOUR FUTURE REFERENCE Thank you for using our product. This manual will guide you in getting the best use of your cooler. Remember
More informationOperation manual. Rooftop Packaged Unit
Operation manual Rooftop Packaged Unit odels: UATYQ20ABAY1 UATYQ25ABAY1 UATYQ30ABAY1 UATYQ45ABAY1 UATYQ50ABAY1 UATYQ55ABAY1 UATYQ65ABAY1 UATYQ75ABAY1 UATYQ90ABAY1 UATYQ110ABAY1 UATYQ115ABAY1 UATYQ20AFC2Y1
More information