Conforms to Regulation (EC) No. 1907/2006 (REACH), Annex II and Regulation (EC) No. 1272/2008 (CLP)

Transcription

1 Conforms to Regulation (EC) No. 1907/2006 (REACH), Annex II and Regulation (EC) No. 1272/2008 (CLP) SAFETY DATA SHEET Flux Pens Aqualine Identification of the preparation and of the company Product name Flux Pens Aqualine Code Head Office Cookson Electronics Forsyth Road Sheerwater Woking Surrey England GU21 5RZ Tel +44(0) Fax +44(0) Manufacturer Cookson Electronics Koenendelseweg BG 's-hertogenbosch The Netherlands Tel Fax Contact person Material uses Classification shosken@cooksonelectronics.com soldering Hazards identification The product is classified as dangerous according to Directive 1999/45/EC and its amendments. Effects and symptoms Inhalation Ingestion Skin contact Eye contact Toxicity data F; R11 Xi; R36 R67 May be harmful by inhalation after often repeated exposure. May be harmful if swallowed. Slightly hazardous by the following route of exposure of skin contact (irritant). Hazardous by the following route of exposure of eye contact (irritant). Not available. See section 11 for more detailed information on health effects and symptoms. 3 Composition/information on ingredients Substance/preparation Ingredient name Europe Preparation CAS number % EC number Classification F; R11 Xi; R36 R67 dimethylammonium chloride Xn; R21/22 Xi; R36/37/38 See section 16 for the full text of the R-phrases declared above Occupational exposure limits, if available, are listed in section 8. The classifications listed, indecate the potential hazards of the ingredients Date of issue 31/03/ /9

2 4. First-aid measures First-aid measures Inhalation Ingestion Skin contact Eye contact Protection of first-aiders Notes to physician Get medical attention if symptoms appear. In case of inhalation of decomposition products in a fire, symptoms may be delayed. The exposed person may need to be kept under medical surveillance for 48 hours. Wash out mouth with water. If vomiting occurs, the head should be kept low so that vomit does not enter the lungs. Get medical attention if adverse health effects persist or are severe. Wash with soap and water. Get medical attention if irritation develops. Get medical attention if irritation occurs. No action shall be taken involving any personal risk or without suitable training. It may be dangerous to the person providing aid to give mouth-to-mouth resuscitation. In case of inhalation of decomposition products in a fire, symptoms may be delayed. The exposed person may need to be kept under medical surveillance for 48 hours. See section 11 for more detailed information on health effects and symptoms. 5. Fire-fighting measures Extinguishing media Suitable Use dry chemical, CO2, water spray (fog) or foam. Not suitable Do not use water jet. Special exposure hazards Highly flammable liquid. In a fire or if heated, a pressure increase will occur and the container may burst, with the risk of a subsequent explosion. Runoff to sewer may create fire or explosion hazard. Hazardous combustion products Special protective equipment for fire-fighters 6. Accidental release measures Personal precautions Environmental precautions Large spill Small spill 7. Handling Storage Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire. No action shall be taken involving any personal risk or without suitable training. Move containers from fire area if this can be done without risk. Use water spray to keep fire-exposed containers cool. Decomposition products may include the following materials carbon dioxide carbon monoxide nitrogen oxides halogenated compounds Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. Put on appropriate personal protective equipment (see section 8). None identified. Handling and storage Packaging materials Recommended Danish fire class Austria - VbF class Czech Republic - Storage code I Place spilt material in an appropriate container for disposal. Use a water rinse for final clean-up. Dilute with plenty of water. Put on appropriate personal protective equipment (see section 8). Store in accordance with local regulations. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see section 10) and food and drink. Use original container. I-1 A I Very dangerous flammable liquid. Date of issue 31/03/ /9

3 8. Exposure controls/personal protection Exposure limit values Ingredient name Occupational exposure limits Europe ACGIH TLV (United States, 1/2008). STEL 400 ppm 15 minute(s). TWA 200 ppm 8 hour(s). Sweden AFS (Sweden, 6/2007). STEL 600 mg/m³ 15 minute(s). STEL 250 ppm 15 minute(s). TWA 350 mg/m³ 8 hour(s). TWA 150 ppm 8 hour(s). Denmark Norway Arbejdstilsynet (Denmark, 3/2008). Absorbed through skin. Carcinogen. TWA 490 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Arbeidstilsynet (Norway, 11/2007). TWA 245 mg/m³ 8 hour(s). TWA 100 ppm 8 hour(s). France Netherlands No exposure limit value known. Germany INRS (France, 12/2007). Notes indicative exposure limits STEL 980 mg/m³ 15 minute(s). STEL 400 ppm 15 minute(s). TRGS900 AGW (Germany, 7/2008). PEAK 1000 mg/m³ 15 minute(s). PEAK 400 ppm 15 minute(s). TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Finland Työterveyslaitos, Sosiaali- ja terveysministeriö (Finland, 8/2007). STEL 620 mg/m³ 15 minute(s). STEL 250 ppm 15 minute(s). TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). United Kingdom (UK) EH40/2005 WELs (United Kingdom (UK), 8/2007). STEL 1250 mg/m³ 15 minute(s). STEL 500 ppm 15 minute(s). TWA 999 mg/m³ 8 hour(s). TWA 400 ppm 8 hour(s). Austria GKV_MAK (Austria, 9/2007). STEL 2000 mg/m³, 4 times per shift, 15 minute(s). STEL 800 ppm, 4 times per shift, 15 minute(s). TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Switzerland Date of issue 31/03/ /9

4 8. Exposure controls/personal protection Belgium SUVA (Switzerland, 1/2007). Notes not temporary STEL 1000 mg/m³ 15 minute(s). STEL 400 ppm 15 minute(s). TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Lijst Grenswaarden / Valeurs Limites (Belgium, 6/2007). STEL 1248 mg/m³ 15 minute(s). STEL 500 ppm 15 minute(s). TWA 997 mg/m³ 8 hour(s). TWA 400 ppm 8 hour(s). Spain INSHT (Spain, 1/2008). STEL 1250 mg/m³ 15 minute(s). STEL 500 ppm 15 minute(s). TWA 998 mg/m³ 8 hour(s). TWA 400 ppm 8 hour(s). Turkey NIOSH REL (United States, 6/2008). STEL 1225 mg/m³ 15 minute(s). STEL 500 ppm 15 minute(s). TWA 980 mg/m³ 10 hour(s). TWA 400 ppm 10 hour(s). Czech Republic Ireland Italy 178/2001 (Czech Republic, 12/2007). Absorbed through skin. STEL 1000 mg/m³ 15 minute(s). STEL 407 ppm 15 minute(s). TWA 500 mg/m³ 8 hour(s). TWA ppm 8 hour(s). NAOSH (Ireland, 8/2007). Absorbed through skin. OELV-15min 400 ppm 15 minute(s). OELV-8hr 200 ppm 8 hour(s). ACGIH TLV (United States, 1/2008). STEL 400 ppm 15 minute(s). TWA 200 ppm 8 hour(s). Estonia Sotsiaalminister (Estonia, 10/2007). STEL 600 mg/m³ 15 minute(s). STEL 250 ppm 15 minute(s). TWA 350 mg/m³ 8 hour(s). TWA 150 ppm 8 hour(s). Lithuania Del Lietuvos Higienos Normos (Lithuania, 10/2007). STEL 600 mg/m³ 15 minute(s). STEL 250 ppm 15 minute(s). TWA 350 mg/m³ 8 hour(s). TWA 150 ppm 8 hour(s). Slovakia Nariadenie Vlády Slovenskej republiky (Slovakia, 6/2007). CEIL 1000 mg/m³ TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Hungary Date of issue 31/03/ /9

5 8. Exposure controls/personal protection Poland Recommended monitoring procedures Respiratory protection Hand protection Eye protection Skin protection None identified. Recommended None assigned. Recommended disposable vinyl Recommended safety glasses with side-shields EN 166 1F Recommended overall EüM-SzCsM (Hungary, 12/2007). Absorbed through skin. Skin sensitiser. PEAK 2000 mg/m³ 15 minute(s). TWA 500 mg/m³ 8 hour(s). Ministra Pracy i Polityki Społecznej (Poland, 9/2007). STEL 1200 mg/m³ 15 minute(s). TWA 900 mg/m³ 8 hour(s). Slovenia Uradni list Republike Slovenije (Slovenia, 6/2007). TWA 500 mg/m³ 8 hour(s). TWA 200 ppm 8 hour(s). Latvia Exposure controls Occupational exposure controls Environmental exposure controls LV Nat. Standardisation and Meterological Centre (Latvia, 5/2007). STEL 600 mg/m³ 15 minute(s). TWA 350 mg/m³ 8 hour(s). Greece PD 90/1999 (Greece, 8/2007). STEL 1225 mg/m³ 15 minute(s). STEL 500 ppm 15 minute(s). TWA 980 mg/m³ 8 hour(s). TWA 400 ppm 8 hour(s). Portugal Instituto Português da Qualidade (Portugal, 3/2007). STEL 400 ppm 15 minute(s). TWA 200 ppm 8 hour(s). Hygiene measures Use only with adequate ventilation. Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking and using the lavatory and at the end of the working period. Appropriate techniques should be used to remove potentially contaminated clothing. Wash contaminated clothing before reusing. Ensure that eyewash stations and safety showers are close to the workstation location. Emissions from ventilation or work process equipment should be checked to ensure they comply with the requirements of environmental protection legislation. In some cases, fume scrubbers, filters or engineering modifications to the process equipment will be necessary to reduce emissions to acceptable levels. 9. Physical and chemical properties General information Appearance Physical state Liquid. Colour Yellowish. Odour Alcohol-like. Important health, safety and environmental information Boiling point 82 C (179.6 F) Date of issue 31/03/ /9

6 9. Flash point Physical and chemical properties Explosion limits Relative density Closed cup 12 C (53.6 F) Lower 2% Upper 12% VOC content 70 % (w/w) [ISO % ] Other information Auto-ignition temperature 10. Stability Stability and reactivity Conditions to avoid Materials to avoid Hazardous decomposition products C (750.2 F) The product is stable. Toxicological information Avoid all possible sources of ignition (spark or flame). Do not pressurise, cut, weld, braze, solder, drill, grind or expose containers to heat or sources of ignition. Highly reactive or incompatible with the following materials oxidizing materials Under normal conditions of storage and use, hazardous decomposition products should not be produced. Potential acute health effects Inhalation Ingestion Skin contact Eye contact Acute toxicity Vapours may cause drowsiness and dizziness. Exposure to decomposition products may cause a health hazard. Serious effects may be delayed following exposure. No known significant effects or critical hazards. May cause skin irritation. Irritating to eyes. Over-exposure signs/symptoms Target organs Contains material which may cause damage to the following organs upper respiratory tract, skin, central nervous system (CNS), eye, lens or cornea. Product name List name Name on list Classification Notes Netherlands Netherlands Carcinogenic Chemicals isopropylalcohol Carc. Carcinogenic process process with strong acid used for the production of isoproylalcohol 12. Ecological information Aquatic ecotoxicity Product/ingredient name Test Result Species Exposure Date of issue 31/03/ /9

7 12. Ecological information ug/l to ug/l to ug/l to ug/l ug/l to ug/l Marine water > ug/l Fish - Fathead 96 hours minnow - Pimephales promelas - Juvenile (Fledgling, Hatchling, Weanling) - 4 to 8 weeks to 3.1 cm Fish - Fathead 96 hours minnow - Pimephales promelas - 29 days - 20 mm g Fish - Fathead 96 hours minnow - Pimephales promelas - 31 days mm g Fish - Fathead 96 hours minnow - Pimephales promelas - 31 days mm g Fish - 96 hours Harlequinfish, red rasbora - Rasbora heteromorpha - 1 to 3 cm Crustaceans - 48 hours Common shrimp, sand shrimp - Crangon crangon Fish - Western 96 hours mosquitofish - Gambusia affinis - 20 to 30 mm Biodegradability Other adverse effects AOX 13. Disposal considerations Methods of disposal Hazardous waste No known significant effects or critical hazards. The product contains organically bound halogens and can contribute to the AOX value in waste water. The generation of waste should be avoided or minimised wherever possible. Dispose of surplus and non-recyclable products via a licensed waste disposal contractor * other solvents and solvent mixtures Yes. Date of issue 31/03/ /9

8 14. International transport regulations Regulatory information Transport information ADR/RID Class UN number Proper shipping name Classes PG* Label 1993 FLAMMABLE LIQUIDS, N.O.S. () 3 II Additional information Hazard identification number 33 CEFIC Tremcard 30GF1-II IMDG Class 1993 FLAMMABLE LIQUIDS, N.O.S. () 3 II Emergency schedules (EmS) F-E, S-E IATA Class 1993 FLAMMABLE 3 LIQUIDS, N.O.S. () PG* Packing group 15. Regulatory information EU regulations Hazard symbol or symbols II Passenger and Cargo AircraftQuantity limitation 5 L Cargo Aircraft Only Quantity limitation 60 L Classification and labeling have been determined according to EU Directives 67/548/EEC and 1999/45/EC (including amendments) and take into account the intended product use. Risk phrases Safety phrases Product use Highly flammable, Irritant R11- Highly flammable. R36- Irritating to eyes. R67- Vapours may cause drowsiness and dizziness. S37- Wear suitable gloves. Industrial applications. France Professional disease or diseases Germany Hazardous incident ordinance Hazard class for water Technical instruction on air quality control Italy Emission control directive 84 Applicable. Category 7b Highly flammable liquid. 3 Appendix No. 4 TA-Luft Number % Not classified. Date of issue 31/03/ /9

9 16. History Other information Full text of R-phrases referred to in sections 2 and 3 - Europe Full text of classifications referred to in sections 2 and 3 - Europe Date of printing 31/03/2011. Date of issue 31/03/2011. Date of previous issue 04/12/2009. Version Prepared by Notice to reader R11- Highly flammable. R21/22- Harmful in contact with skin and if swallowed. R36- Irritating to eyes. R36/37/38- Irritating to eyes, respiratory system and skin. R67- Vapours may cause drowsiness and dizziness. F - Highly flammable Xn - Harmful Xi - Irritant 3 Not available. Indicates information that has changed from previously issued version. References The Health and Safety At Work Act 1974, section 6. Control of Substances Hazardous to Health (CoSHH) Regulations 2002 and its amendments. Preparation contains soley TSCA and REACh 1907/2006 listed substances. This safety data sheet has been prepared in accordance with the requirements of the Chemicals (Hazard Information and Packaging for Supply) Regulations 2002 which implement EC Directives 1999/45/EC and 2001/58/EC and their amendments. To the best of our knowledge, the information contained herein is accurate. However, neither the above-named supplier, nor any of its subsidiaries, assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that exist. Date of issue 31/03/ /9