Tel: 08 0 www.heronhill.co.uk Fax: 08 80 TOSHIBA Heronhill - for all your Toshiba requirements FILE NO. A90-00 SERVICE MANUAL AIR-CONDITIONER SPLIT TYPE, HEAT PUMP COOLING ONLY WAY CASSETTE TYPE RAV-0TUH--PE RAV-TUH--PE/RAV-AH-PE RAV-TUH--PE/RAV-AH-PE RAV-TU--PE/RAV-A-PE RAV-TU--PE/RAV-A-PE Printed in UK NOVEMBER 000
Tel: 08 0 www.heronhill.co.uk Fax: 08 80 Heronhill - for all your Toshiba requirements CONTENTS. SPECIFICATIONS. CONSTRUCTIONS VIEWS. WIRING DIAGRAMS 9. SPECIFICATIONS OF ELECTRICAL PARTS. REFRIGERANT PIPING DIAGRAMS 8. PERFORMANCE CHARACTERISTICS. EXPLODED VIEWS AND PARTS LISTS SUMMARY The units referred to within this Manual conform with the protection requirements of Directives 89//EEC Electromagnetic Compatibility and //EEC Low Voltage. Operating conditions of units are as follows: OUTDOOR TEMPERATURE - to C (COOL) -0 to C (HEAT) ROOM TEMPERATURE 8 to C (COOL) to 9 C (HEAT) ROOM HUMIDITY LESS THAN 80% (COOL) Note : Note : Note : Note : Cooling Capacity is based on the following temperature conditions: Indoor air inlet temperature C DB, 9 C WB. Outdoor air inlet temperature C DB. Heating Capacity is based on the following temperature conditions: Indoor air inlet temperature 0 C DB. Outdoor air inlet temperature C DB, C WB. For details on Control Circuits, refer to Service Manual A90-99. Metric/Imperial pipe conversion: Diameter (). 9...9 9 Nominal Diameter (inch) / /8 / /8 / /8
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS Item Model RAV-0TUH--PE Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Interconnection pipe Condensate drain pipe diameter Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Ceiling Panel Model Appearance Colour Dimensions Net Weight Air Filter Indoor Unit (High/Med/Low) Name of Refrigerant Larger side size Coupler style Smaller side size Coupler style Height Width Depth Height Width Depth kw kw Phase V Hz kw % A A db(a) kg m /hr W kg..8 0-0 0 0.0 9 0. 0. 0// R0C ø. Flare ø. Flare ø. (OD) Grey (galvanized steel & thermal insulation) 90 90 80 Finned tube Transverse flow fan 0 x RBC-UPG(W)-E Silky white (Munsell.9Y8.9/0.8),00 0. Washable Specifications are subject to change without notice
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS Item Model RAV-TUH--PE RAV-TUH--PE Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Refrigerant control Interconnection pipe Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor Protective device Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (0-0m) Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Height Width Depth Height Width Depth Model Output kw kw Phase V Hz kw % A A db(a) db(a) kg g/m m m m m kg m /h W kg m /h W kw.. 0-0 0 COOLING HEATING.0. 88 90 9.9 0. 0 0// 0 R0C.0 Capillary tube & Expansion valve ø. Flare ø. Flare. 0 0 ø. (OD) RAV-TUH--PE Grey (galvanized steel & thermal insulator) 90 90 80 Finned tube Transverse flow fan 00 x RAV-AH-PE Bronze white (Munsell Y./) 0 880 0 Finned tube Propeller fan,00 9 PG0XF-LS...0 0-0 0 COOLING HEATING.. 90 89 0. 0. 0 // 0 R0C. Capillary tube & Expansion valve ø. Flare ø. Flare. 0 0 ø. (OD) RAV-TUH--PE Grey (galvanized steel & thermal insulator) 90 90 80 Finned tube Transverse flow fan 0 x RAV-AH-PE Bronze white (Munsell Y./) 0 880 0 Finned tube Propeller fan,00 9 PG0XF-LS. High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat CEILING PANEL model Appearance colour Dimensions Net weight Air filter Height Width Depth kg RBC-UPG(W)-E Silky white (Munsell.9Y8.9/0.8),00 0. Washable RBC-UPG(W)-E Silky white (Munsell.9Y8.9/0.8),00 0. Washable Specifications are subject to change without notice
. SPECIFICATIONS Item Model RAV-TU--PE RAV-TU--PE Cooling capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Refrigerant control Interconnection pipe Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (0-0m) Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Height Width Depth Height Width Depth Model Output kw Phase V Hz kw % A A db(a) db(a) kg g/m m m m m kg m /h W kg m /h W kw. 0-0 0 COOLING.0 88 9.9 0 0// 0 R0C.0 Capillary tube ø. Flare ø. Flare. 0 0 ø. (OD) RAV-TU--PE Grey (galvanized steel & thermal insulator) 90 90 80 Finned tube Transverse flow fan 00 x RAV-A-PE Bronze white (Munsell Y./) 0 880 0 8 Finned tube Propeller fan,00 9 PG0XF-LS.. 0-0 0 COOLING. 90 0. 0 // 0 R0C. Capillary tube ø. Flare ø. Flare. 0 0 ø. (OD) RAV-TU--PE Grey (galvanized steel & thermal insulator) 90 90 80 Finned tube Transverse flow fan 0 x RAV-A-PE Bronze white (Munsell Y./) 0 880 0 8 Finned tube Propeller fan,00 9 PG0XF-LS. Protective device fuse, crankcase heater CEILING PANEL model Appearance colour Dimensions Net weight Air filter Height Width Depth kg RBC-UPG(W)-E Silky white (Munsell.9Y8.9/0.8),00 0. Washable RBC-UPG(W)-E Silky white (Munsell.9Y8.9/0.8),00 0. Washable Specifications are subject to change without notice Tel: 08 0 www.heronhill.co.uk Fax: 08 80
. CONSTRUCTION VIEWS. Indoor Unit RAV-0TUH--PE RAV-TUH--PE RAV-TUH--PE RAV-TU--PE RAV-TU--PE 80 0 0 80 Hanger bolt (-M0) Drain pipe joint (outer ø.) Refrigerant piping joint (Liquid ø.) Refrigerant piping joint (Gas ø.) 90 90 9 Wiring connection A Panel outer dimension 00 00 0 0 0 0 Ceiling opening 00 Hang bolt pitch 90 80 0 90 0 0 0 TOSHIBA View A Panel outer dimension 0 Ceiling opening 0 80 Hang bolt pitch 0 00 (Unit: ) 00 Minimum 00 Minimum 00 Minimum Space required for service and installation Tel: 08 0 www.heronhill.co.uk Fax: 08 80
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. CONSTRUCTION VIEWS. Outdoor Unit RAV-AH-PE RAV-AH-PE RAV-A-PE RAV-A-PE 0 Knock-out hole for drain (-0x0 slots) Hole for drain (xø9 hole) 0 Earth screw (M) 880 Air outlet Electric parts box 0 Terminal cover 0 Handle (Both sides) 0 0 00 0 0 80 0 0 Refrigerant pipe connection (Gas ø.) Refrigerant pipe connection (Liquid ø.) 0 90 Anchor bolt hole (-x8slots) 80 90 88 8 0 Blow out guide mounting hole (-ø embosses) Space required for service (Space for wiring and piping) Outlet 00 00 00 (Space for wiring and piping) 00 00 00 Outlet When installed with the inlet facing the wall When installed with the outlet facing the wall 8
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. WIRING DIAGRAMS. RAV-0TUH--PE RAV-TUH--PE RAV-TUH--PE TA TC DM GRY GRY ORG YEL BLU CN0 CN ORG BLU BLK YEL CN0 (TRANS) CN0 CN (TA) (LAN) REMOCON RY0 RY0 RY0 CN0 (TC) CN0 (FAN) H BLK M ORG L BLU UL YEL 9 9 CN RY0 (output) CN09 () (LOUVER) BLK BLK 0 0 9 9 8 8 F CS Interface PCB RY0 RY0 RY0 TR TR CN0 CN0 F (L) (N) (SERIAL) (PUMP) GRY PUR GRY GRY BLK SM 0 SM 0 RC0 RC0 FM 0 YEL BLU ORG BLK Indoor unit GRN/YEL FM 0 YEL ORG BLU BLK X Y A B C X Y A B C ( Phase model) Earth Screw F L N Central Remote Controller (Optional) Remote Controller (Optional) Outdoor unit Power Supply 0/0V ~0Hz Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. Symbol Name Symbol Name FM0, 0 Fan Motor F Fuse (PCB) RC0,0 Running Capacitor F Fuse (Interface) PCB TR Transformer DM Drain Pump TA Sensor SM0, 0 Stepper Motor TC Sensor CS Float Switch RY0~RY0 Relay 9
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. WIRING DIAGRAMS. RAV-TU--PE RAV-TU--PE TA TC DM ORG YEL BLU CN0 ORG BLU BLK YEL CN REMOCON CN0 (TA) CN0 (TRANS) RY0 RY0 CN0 (TC) CN0 (FAN) H BLK M ORG L BLU YEL 9 9 RY0 (output) CN09 () (LOUVER) BLK BLK 0 0 9 9 8 8 F CS Interface PCB RY0 RY RY0 RY TR TR CN0 (PUMP) F (L) (N) CN0 CN (FLOAT) 8 SM 0 SM 0 RC0 RC0 FM 0 YEL BLU ORG BLK Indoor unit GRN/YEL FM 0 YEL ORG BLU BLK A B C A B C Remote Controller (Optional) ( Phase model) Earth screw Outdoor unit F L Power supply 0/0V ~0Hz N Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. Symbol Name Symbol Name FM0, 0 Fan Motor F Fuse (PCB) RC0, 0 Running Capacitor F Fuse (Interface) PCB TR Transformer DM Drain Pump TA Sensor SM0, 0 Stepper Motor TC Sensor CS Float Switch RY0~RY Relay Relay 0
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. WIRING DIAGRAMS. RAV-AH-PE RAV-AH-PE A B C Indoor unit Earth Screw Outdoor unit TR Earth F RY0 F RY0 Wave Control Circuit TD BLK TE TL BLK BLU 9 0 B C A L H C GRY RCo FM 0 BLK 0SF 0SR HD C RCc CM 9C L Power Supply 0/0V~0Hz N CH Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. Symbol Name Symbol Name Symbol Name 0SF Solenoid coil ( way valve) CM Compressor F Fuse (TA) RY0, 0 Relay C Magnetic contactor H High pressure switch 9C Inner overload relay FMo Fan motor CH Crankcase heater 0SR Solenoid coil ( way valve) TL Sensor F Fuse (on PCB) RCc Running capacitor (compressor) TE Sensor TR Transformer RCo Running capacitor (fan motor) HD Bimetal thermostat TD Sensor (Duy)
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. WIRING DIAGRAMS. RAV-A-PE RAV-A-PE Indoor unit Outdoor unit Earth screw A C B RC c CM 9C BLK F C F F BLK ORN BLU BLK ORN BLU BLK ORN BLU FM 0 CH RC o Surge Absorber L N Power Supply 0/0V~0Hz Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. Symbol Name Symbol Name 9C Inner overload relay CM Compressor RCc Running capacitor (compressor) C Magnetic contactor RCo Running capacitor (fan motor) FMo Fan Motor F Fuse (TA) CH Crankcase heater F, Pressure Switch ( Stage)
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS OF ELECTRICAL PARTS. RAV-0TUH--PE No PARTS NAME TYPE SPECIFICATIONS Indoor unit fan motor (x) PAF-0-- Output (rated) W, pole, 0V, Phase, 0Hz Running capacitor for indoor fan motor (x) EVMM0UF AC 0V, 0.µF Transformer (Indoor Unit) ST-08 AC 8-V Stepper motor (x) MPEA DC V, 80mNm Drain pump PJV-0 AC 0V, 0.A Float switch FS-08-00B AC 0V, 0.A Sensor for room temperature Maximum input 8mA C 0 0 0 kω.. 0.0 8.0. 8 Indoor Unit sensor for heat exchanger temperature Maximum input.ma C - 0 kω... RAV-TUH--PE No PARTS NAME TYPE SPECIFICATIONS Indoor unit fan motor (x) PAF-0-- Output (rated) W, pole, 0V, Phase, 0Hz Running capacitor for indoor fan motor (x) EEPH0HQA0 AC 00V,.0µF Transformer (Indoor Unit) ST-08 AC 8-V Stepper motor (x) MPEA DC V, 80mNm Drain pump PJV-0 AC 0V, 0.A Float switch FS-08-00B AC 0V, 0.A Sensor for room temperature Maximum input 8mA C 0 0 0 kω.. 0.0 8.0. 8 Indoor Unit sensor for heat exchanger temperature Maximum input.ma C - 0 kω... RAV-TUH--PE No PARTS NAME TYPE SPECIFICATIONS Indoor unit fan motor (x) PAF-0-- Output (rated) W, pole, 0V, Phase, 0Hz Running capacitor for indoor fan motor (x) EEPH0HQA0 AC 00V,.0µF Transformer (Indoor Unit) ST-08 AC 8-V Stepper motor (x) MPEA DC V, 80mNm Drain pump PJV-0 AC 0V, 0.A Float switch FS-08-00B AC 0V, 0.A Sensor for room temperature Maximum input 8mA C 0 0 0 kω.. 0.0 8.0. 8 Indoor Unit sensor for heat exchanger temperature Maximum input.ma C - 0 kω..
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS OF ELECTRICAL PARTS. RAV-TU--PE No PARTS NAME TYPE SPECIFICATIONS Indoor unit fan motor (x) PAF-0-- Output (rated) W, pole, 0V, Phase, 0Hz Running capacitor for indoor fan motor (x) EEPH0HQA0 AC 00V,.0µF Transformer (Indoor Unit) ST-98 AC 8-V Stepper motor (x) MPEA DC V, 80mNm Drain pump PJV-0 AC 0V, 0.A Float switch FS-08-00B AC 0V, 0.A Sensor for room temperature Maximum input 8mA C 0 0 0 kω.. 0.0 8.0. 8 Indoor Unit sensor for heat exchanger temperature Maximum input.ma C - 0 kω.. 9 Relay LYF-L AC 0V, ab. RAV-TU--PE No PARTS NAME TYPE SPECIFICATIONS Indoor unit fan motor (x) PAF-0-- Output (rated) W, pole, 0V, Phase, 0Hz Running capacitor for indoor fan motor (x) EEPH0HQA0 AC 00V,.0µF Transformer (Indoor Unit) ST-98 AC 8-V Stepper motor (x) MPEA DC V, 80mNm Drain pump PJV-0 AC 0V, 0.A Float switch FS-08-00B AC 0V, 0.A Sensor for room temperature Maximum input 8mA C 0 0 0 kω.. 0.0 8.0. 8 Indoor Unit sensor for heat exchanger temperature Maximum input.ma C - 0 kω.. 9 Relay LYF-L AC 0V, ab
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS OF ELECTRICAL PARTS. RAV-AH-PE No PARTS NAME TYPE SPECIFICATIONS Compressor PG0XF-LS Output (rated).kw, pole, 0/0V, Phase, 0Hz Outdoor unit fan motor SMF-0-9N- Output (rated) 9W, pole, 0V, Phase, 0Hz Running capacitor for outdoor fan motor EEPG0HQA AC 00V, µf Magnetic contactor FMCa-S-0 AC 0-0V, 0Hz High pressure switch ACB-TB0W Tripping pressure 0kgf/cm G Resetting pressure kgf/cm G Solenoid coil for four-way valve CHV-AC0V AC 0-0V Crankcase heater AC 0V, 8W 8 Sensor for defrosting Maximum input.ma C - 0 kω.. 9 Fuse TA 0 Sensor for cooling operation in low ambient temperature Maximum input.ma C - 0 kω.. Solenoid coil for two-way valve NEV AC 0V AC 0-0V, 0Hz Running capacitor for compressor MT-MPW AC 0V, µf Transformer (Outdoor Unit) FT- AC 8-V Bimetal thermostat CS-A Tripping temperature: 0 C Resetting temperature: 90 C
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS OF ELECTRICAL PARTS. RAV-AH-PE No PARTS NAME TYPE SPECIFICATIONS Compressor PG0XF-LS Output (rated).kw, pole, 0/0V, Phase, 0Hz Outdoor unit fan motor SMF-0-9N- Output (rated) 9W, pole, 0V, Phase, 0Hz Running capacitor for outdoor fan motor EEPG0HQA AC 00V, µf Magnetic contactor FMCa-S-0 AC 0-0V, 0Hz High pressure switch ACB-TB0W Tripping pressure 0kgf/cm G Resetting pressure kgf/cm G Solenoid coil for four-way valve CHV-AC0V AC 0-0V Crankcase heater AC 0V, 8W 8 Sensor for defrosting Maximum input.ma C - 0 kω.. 9 Fuse TA 0 Sensor for cooling operation in low ambient temperature Maximum input.ma C - 0 kω.. Solenoid coil for two-way valve NEV AC 0V AC 0-0V, 0Hz Running capacitor for compressor MT-MPW AC 0V, µf Transformer (Outdoor Unit) FT- AC 8-V Bimetal thermostat CS-A Tripping temperature: 0 C Resetting temperature: 90 C
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. SPECIFICATIONS OF ELECTRICAL PARTS.8 RAV-A-PE No PARTS NAME TYPE SPECIFICATIONS Compressor PG0XF-LS Output (rated).kw, pole, 0/0V, Phase, 0Hz Outdoor unit fan motor SMF-0-9N- Output (rated) 9W, pole, 0V, Phase, 0Hz Running capacitor for outdoor fan motor EEPG0HQA AC 00V, µf Magnetic contactor FMCa-S-0 AC 0-0V, 0Hz Pressure switch (-Stage) STB-X0 Tripping pressure 9kgf/cm G, kgf/cm G Resetting pressure kgf/cm G,kgf/cm G Crankcase heater AC 0V, 8W Fuse TA 8 Running capacitor for compressor MT-MPW AC 0V, µf.9 RAV-A-PE No PARTS NAME TYPE SPECIFICATIONS Compressor PG0XF-LS Output (rated).kw, pole, 0/0V, Phase, 0Hz Outdoor unit fan motor SMF-0-9N- Output (rated) 9W, pole, 0V, Phase, 0Hz Running capacitor for outdoor fan motor EEPG0HQA AC 00V, µf Magnetic contactor FMCa-S-0 AC 0-0V, 0Hz Pressure switch (-Stage) STB-X0 Tripping pressure kgf/cm G, kgf/cm G Resetting pressure kgf/cm G,kgf/cm G Crankcase heater AC 0V, 8W Fuse TA 8 Running capacitor for compressor MT-MPW AC 0V, µf
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. REFRIGERANT PIPING DIAGRAMS. Indoor Unit RAV-0TUH--PE Cooling Heating Indoor unit Heat exchanger Distributor strainer capillary tube Strainer Refrigerant pipe (Liquid) ø. (/") TC Sensor Refrigerant pipe (Gas) ø. (/") 8
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. Indoor Unit Outdoor Unit RAV-TUH--PE RAV-AH-PE. REFRIGERANT PIPING DIAGRAMS Cooling Heating Indoor unit Distributor strainer capillary tube Heat exchanger Strainer TC Sensor Refrigerant pipe (Liquid) ø. (/") Refrigerant pipe (Gas) ø. (/") Packed valve Strainer Liquid receiver Packed valve P Line pressure Cooling Heating P High pressure Low pressure P Low pressure High pressure Capillary tube ø.x00lxp Dryer Capillary tube ø.0x00lxp Expansion valve Check valve -way valve TL sensor Distributor Heat exchanger TE sensor Check joint P Strainer Capillary tube ø0.8x000lxp Four-way valve Accumulator Compressor High pressure switch Outdoor unit INDOOR UNIT Model Capillary Model OUTDOOR UNIT Main Bypass Cooling Bypass Capillary Capillary Capillary RAV-TUH--PE IDø.x00LxP RAV-AH-PE IDø.x00LxP IDø0.8x000LxP IDøx00LxP 9
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. Indoor Unit Outdoor Unit RAV-TUH--PE RAV-AH-PE. REFRIGERANT PIPING DIAGRAMS Cooling Heating Distributor strainer capillary tube Indoor unit Heat exchanger Strainer TC Sensor Refrigerant pipe (Liquid) ø. (/") Refrigerant pipe (Gas) ø. (/") Packed valve Strainer Liquid receiver Packed valve P Line pressure Cooling Heating P High pressure Low pressure P Low pressure High pressure Capillary tube ø.x00lxp Dryer Capillary tube ø.0x00lxp Expansion valve Check valve -way valve TL sensor Distributor Heat exchanger TE sensor Check joint P Strainer Capillary tube ø0.8x000lxp Four-way valve Accumulator Compressor High pressure switch Outdoor unit INDOOR UNIT Model Capillary Model OUTDOOR UNIT Main Bypass Cooling Bypass Capillary Capillary Capillary RAV-TUH--PE IDø.x00LxP RAV-AH-PE IDø.x00LxP IDø0.8x000LxP IDøx00LxP 0
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. Indoor Unit Outdoor Unit RAV-TU--PE RAV-A-PE. REFRIGERANT PIPING DIAGRAMS Indoor unit Distributor strainer & capillary tube Heat exchanger Strainer TC Sensor Refrigerant pipe (Smaller side) ø. (/") Refrigerant pipe (Larger side) ø. (/") Packed valve Packed valve Liquid tank Capillary tube Dryer Heat exchanger Distributor Strainer Compressor Pressure switch Accumulator Outdoor unit INDOOR UNIT OUTDOOR UNIT Model Capillary Model Main Capillary RAV-TU--PE IDø.x00LxP RAV-A-PE IDø.x00LxP Bypass Capillary
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. Indoor Unit Outdoor Unit RAV-TU--PE RAV-A-PE. REFRIGERANT PIPING DIAGRAMS Indoor unit Distributor strainer & capillary tube Heat exchanger Strainer TC Sensor Refrigerant pipe (Smaller side) ø. (/") Refrigerant pipe (Larger side) ø. (/") Packed valve Packed valve Liquid tank Capillary tube Dryer Heat exchanger Distributor Strainer Compressor Pressure switch Accumulator Outdoor unit INDOOR UNIT OUTDOOR UNIT Model Capillary Model Main Capillary RAV-TU--PE IDø.x00LxP RAV-A-PE IDø.x00LxP Bypass Capillary
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. PERFORMANCE CHARACTERISTICS. Cooling capacity Capacity Ratio (%) (kw) Ambient Temp. (Dry Bulb) ( C) RAV-AH-PE.88.0...0.8.9.. RAV-AH-PE.0.8.0.8.0..9.8.0 Room Temp. (Wet Bulb) ( C). Heating capacity Ambient Temp. (Wet Bulb) ( C) Capacity Ratio (%) RAV-AH-PE.0.8...0.99.8....9... (kw) RAV-AH-PE.00..0..00..0..00..0..00. Room Temp. (Dry Bulb) ( C)
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. PERFORMANCE CHARACTERISTICS. Cooling capacity RAV-AH-PE RAV-AH-PE Cooling Capacity Ratio Heating Capacity Ratio Outdoor Unit Height H (m) Outdoor Unit Height H (m) H L INDOOR UNIT Piping Length L (m) Piping Length L (m). Cooling capacity RAV-A-PE RAV-A-PE Cooling Capacity Ratio Outdoor Unit Height H (m) H L INDOOR UNIT Piping Length L (m)
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. PERFORMANCE CHARACTERISTICS. Piping Length/Additional Refrigerant Volume! The amount of refrigerant put into the outdoor unit at the factory is sufficient to fill up to 0m of refrigerant pipework.!!! If the length of the refrigerant pipework is 0m or less, addition of refrigerant at the installation site is unnecessary. If the length of the pipework exceeds 0m, extra refrigerant must be added. Refer to the table below for details of the extra amounts. Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction of the compressor. The prescribed amount of the replenishment of the refrigerant is shown in the table below: Additional amount of refrigerant to add at installation site (kg)±0g Recharge amount if unit is reclaimed (kg)±0g MODEL (RAV-) Less than 0m Less than m Less than 0m Less than m Less than 0m Less than m Less than 0m Less than m Less than 0m Less than m Less than 0m Less than m Less than 0m Less than m Less than 0m AH-PE AH-PE A-PE A-PE Filled at Factory! 0.8 0. 0.9.0.. 0.8 0. 0.9..8. 0.8 0. 0.9.0.. 0.8 0. 0.9..8. ADD ONLY R0C REFRIGERANT TO THESE UNITS
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. EXPLODED VIEWS AND PARTS LISTS. Indoor Unit RAV-0TUH--PE RAV-TUH--PE RAV-TUH--PE RAV-TU--PE RAV-TU--PE 9 8 0 / 8 9 8 0 Ref No. Part No. Description Model A00 Blower Base Assembly All 0088 Fan-C-F All A00 Float Switch All A0008 Pump Assembly All 00 Bearing All 009 Drain Connection All A0009 Drain Hose All 8 A000 Terminal ABC XY All 9 A000 Terminal,, All 0 A9008 Interface PC Board All MF Capacitor RAV-0TUH--PE 00 MF Capacitor RAV-/TU/TUH--PE A900 PC Board (AI) RAV-0//TUH--PE A900 ASM Cont PC IN RAV-/TU--PE A800 Transformer (AI) RAV-0//TUH--PE A800 Transformer RAV-/TU--PE Ref No. Part No. Description Model Relay LYF-L RAV-/TU--PE A0 Fan Motor (PAF-0--) All A000 Sensor Holder All A008 Motor Band L All 8 A009 Motor Band R All 9 A00 Refrigeration Assembly RAV-0TUH--PE 9 A0 RefrigerationAssembly RAV-TU/TUH--PE 9 A0 Refrigeration Assembly RAV-TU/TUH--PE 0 A00 Drain Pan All A800 Drain Guide Assembly All A880 Owner Manual All 08 Sensor Room Temperature RAV-/TU--PE A0008 Sensor Room Temperature RAV-0//TUH--PE A000 Sensor Heat Exchanger All A00 TC Adapter RAV-0//TUH--PE
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. EXPLODED VIEWS AND PARTS LISTS. Outdoor Unit RAV-AH-PE RAV-AH-PE 0 9 8 0 8 9 9 9 8 8 0 0 Ref No. Part No. Description Model 0 Propeller Fan All A00 Fan Motor All A0 Condensor All 09 Base Spring, B All 9 Base Spring, A All 998 Spring Buffer All A90 PC Board All 8 A900 High Pressure Switch All 9 009 Terminal Block, P All 0 A000 Terminal Block, P All A000 Terminal Block, P All Magnetic Contactor All A900 Fan Guard All 98 Hanger All A00 Solenoid Coil All 0 Cover, Electrical Parts All 0 Sensor Holder All 8 A00 Cord Clamp All 9 80 Accumulator All 0 A00 Dryer All MF Capacitor Compressor All 080 MF Capacitor Fan All Ref No. Part No. Description Model A0 Comp PG0XF-LS RAV-AH-PE A0 Comp PG0XF-LS RAV-AH-PE 0 Packed Valve (.) All A0 Packed Valve (.) All A0 Check Joint All A0 Expansion Valve All 8 A0 Coil, -Way Valve All 9 8 Check Valve All 0 A800 Transformer Power All 0 -Way Valve All A000 Sensor Heat Exchanger (TL) All A900 Sensor Heat Exchanger (TC) All 90 Spring All Heater, Crankcase All 0 Thermostat, Bi-metal All 8 A000 Fuse TA All 9 8 -Way Valve All 0 A0 Capi Form All A90 ASM Roof Plate All A909 ASM Side Cabinet All A90 ASM Air-Out Cabinet All A90 Fin-Guard (back) All
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. EXPLODED VIEWS AND PARTS LISTS. Outdoor Unit RAV-A-PE RAV-A-PE 8 9 8 0 0 8 9 0 9 Ref No. Part No. Description Model 0 Propellor Fan All A0 Fan Motor All A0 Condensor All 09 Base Spring, B All 9 Base Spring, A All 998 Spring Buffer All 98 Surge Absorber All 8 A900 Pressure Switch ( stage) All 9 A000 Terminal Block, P All 0 A000 Terminal Block, P All Magnetic Contactor All A900 Fan Guard All 98 Hanger All 0 Cover, Electrical Parts All A00 Cord Clamp All 80 Accumulator All Ref No. Part No. Description Model A00 Dryer All 8 MF Capacitor Compressor All 9 080 MF Capacitor Fan All 0 A0 Comp PG0XF-LS RAV-A-PE 0 A0 Comp PG0XF-LS RAV-A-PE 0 Packed Valve (.) All A0 Packed Valve (.) All 90 Spring All Heater, Crankcase All A000 Fuse TA All A0 Capi Form All 8 A90 ASM Roof Plate All 9 A909 ASM Side Cabinet All 0 A90 ASM Air-Out Cabinet All A90 Fin-Guard (back) All 8
Tel: 08 0 www.heronhill.co.uk Fax: 08 80. EXPLODED VIEWS AND PARTS LISTS. Ceiling Panel RBC-UPG(W)-E 0 8 0 9 Ref No Part No. Description 0809 Filter 0008 Plate Connect (Long) 0090 ASM-Grille-Out 000 Bushing 0009 Plate Connect (Short) Ref No Part No. Description 0090 Grille-L-R 00 Support Plate 8 00999 ASM-Grille-Out 9 ASM-Motor 0 00 Support Plate 9
Tel: 08 0 www.heronhill.co.uk Fax: 08 80 NOTES 0
Tel: 08 0 www.heronhill.co.uk Fax: 08 80 TOSHIBA AIR CONDITIONING www.toshiba-aircon.co.uk MADE IN UK A90-00