Winterhalter STR 110 Energy

Transcription

1 Winterhalter STR 110 Energy The STR 110 is equipped with an optional exhaust air heat recovery system, which saves energy and effectively improves the room atmosphere. It s an investment that can only pay off for the operator, staff and environment. When the dishwasher is running, damp, hot steam is given off in the inlet and outlet areas of conveyor dishwashers valuable energy that is lost in thin air. The STR Energy Series uses this energy to heat up the cold inlet water. Steam is systematically drawn in and fed through an exhaust air heat exchanger. The STR Energy saves around 6 kwh per hour when in use. Based on 6 hours of use per day, it cuts energy costs by up to $2,150 a year. The Energy models are only available with a cold water supply (max. 20 C). Basis of calculation for STR Energy: 6 kwh/hour in use x 0.16/kWh x 6 hours in use/day x 80 % capacity x 365 days in use/year x 10 years = 16,819 Reduced total connected load: With Energy, this value is reduced by 6 kwh. Reduced energy costs: Save up to $ 21,530 in 10 years with the Energy model. An investment that pays: The heat recovery is amortised in less than 2 years. Healthy room climate: The STR Energy Series systematically draws in air through both the inlet and outlet areas. This noticeably reduces the temperature and humidity of the exhaust air and greatly improves the room atmosphere. Total height STR Energy: Weight STR Energy-unit: 1,890 mm 72 kg Schematic diagram of the heat recovery process. Additional information on

2 Winterhalter STR 110 Overview of the STR 110 The STR 110 single tank rack conveyor dishwasher delivers the desired power in peak times and saves energy when it's quiet. With its compact dimensions, the STR 110 single tank rack conveyor dishwasher also fits into the smallest kitchen. Top quality cleaning results are guaranteed by the perfectly coordinated combination of a powerful pump, five upper and three lower wash arms, optimum water distribution and jets positioned for total coverage. With two conveyor speeds (standard and rapid programme), the STR 110 can adapt to variable quantities of dishes and to their degree of soiling. The rapid programme is selected to do the job during busy periods or to wash away light soiling, saving both money and time. Thanks to its rack-activated zones, the STR 110 adapts to changing volumes automatically. The pump is activated and fresh water fed in only if dishes are actually in the respective zone. This STR 110 feature significantly reduces operating costs. Zone activation also significantly reduces noise, steam and heat emissions. Features: Mediamat wash water filtration 180 pivoting hygiene door Deep-drawn hygienic tank Rack-controlled zone activation 2 transport speeds Closed base cover Drain pump Single-button control with colour coding, fault diagnosis and temperature displays Best washing results Easy operation Low operating costs Energy efficiency Short wash-cycle-time Modern and compatible design High service friendliness Options: Detergent dosing device, conductivity controlled Rinse aid dosing device Boiler heater increased by 6 kw Boiler heater increased by 12 kw (only for machines without Energy) Temperature change-over 85 C / 65 C for cleaning glasses Reduction of working height to 850 mm Emergency stop switch Exhaust air heat recovery system Energy* Stainless steel heat exchanger for fully demineralised water (Energy machines only) Steam heating ( bar) Acoustic alarm for empty rinse aid and detergent container Rear infill panel Table bridge (only for machines with an outlet tunnel in combination with 90 /180 corner conveyor) Outlet tunnel with exhaust air pipe (only for machines without drying zone) Infeed tunnel with integrated exhaust air pipe (only for machines with drying zone and not for Energy version) Corner entry (without table) * only cold water supply Additional information on

3 Winterhalter STR 110 Exhaust air pipe Width x depth x height: 1,300x800x1,420 mm Width with drying zone: 2,000 mm Depth with door open: 1,472 mm Height with exhaust air pipe: 1,600 mm Height with drying zone: 1,770 mm Height with Energy: 1,890 mm* Rack dimensions: 500 x 500 mm Clear entry height: 460 ± 5 mm Water connection: G ¾ Waste water connection: ø 50 mm General data Weight Standard (net / gross): Weight Standard Energy (n/g): Weight with drying zone (n/g): Weight Energy + drying zone (n/g): Tank capacity: Circulating pump: Noise emission: 207 / 240 kg 279 / 312 kg* 274 / 316 kg 346 / 388 kg* 65 l 600 l/min < 70 db(a) Max. theoretical capacity Racks / h: 70 / 110 Cycle duration 52 / 33 sec. Rinse water consumption (under ideal conditions) Water connection 260 l / h Flow pressure (pressurized boiler): bar Flow pressure (non pressurized boiler): bar Thermal radiation Flow rate: at least 15 l/min. Sensitive Latent Flow rate Energy: 6 l/min.* STR Water inlet temp.: max. 60 C STR drying zone Water inlet temp. Energy: max. 20 C* STR 110 Energy * STR 110 Energy + drying zone * Weight pressure point per foot Marks of conformity STR 110: 73 kg CB, SVGW, WRAS STR drying zone: 89 kg STR 110 Energy: 91 kg* STR Energy + drying zone: 107 kg* Electrical values Voltage Fuse protection Tank heating Total connected load Boiler heating Pumps + Control unit Heating drying zone 415V3N~,50/60Hz 50 A 10 kw 24.7 kw 12 kw 2.7 kw optional** 415V3N~,50/60Hz 50 A 10 kw 30.7 kw 18 kw 2.7 kw optional** 415V3N~,50/60Hz 63 A 10 kw 36.7 kw 24 kw 2.7 kw optional** * only with Energy version. ** if a drying zone has been selected the total connected load will increase by 6.5 kw. Probably higher fuse protection will be necessary. Additional information on

4 Winterhalter STR 130 Energy The STR 130 is equipped with an optional exhaust air heat recovery system, which saves energy and effectively improves the room atmosphere. It s an investment that can only pay off for the operator, staff and environment. When the dishwasher is running, damp, hot steam is given off in the inlet and outlet areas of conveyor dishwashers valuable energy that is lost in thin air. The STR Energy Series uses this energy to heat up the cold inlet water. Steam is systematically drawn in and fed through an exhaust air heat exchanger. The STR Energy saves around 6 kwh per hour when in use. Based on 6 hours of use per day, it cuts energy costs by up to $2,150 a year. The Energy models are only available with a cold water supply (max. 20 C). Basis of calculation for STR Energy: 6 kwh/hour in use x 0.16/kWh x 6 hours in use/day x 80 % capacity x 365 days in use/year x 10 years = 16,819 Reduced total connected load: With Energy, this value is reduced by 6 kwh. Reduced energy costs: Save up to $ 21,530 in 10 years with the Energy model. An investment that pays: The heat recovery is amortised in less than 2 years. Healthy room climate: The STR Energy Series systematically draws in air through both the inlet and outlet areas. This noticeably reduces the temperature and humidity of the exhaust air and greatly improves the room atmosphere. Total height STR Energy: Weight STR Energy-unit: 1,890 mm 72 kg Schematic diagram of the heat recovery process. Additional information on

5 Winterhalter STR 130 Overview of the STR 130 The STR single tank rack conveyor dishwashing machine is a compact power pack that stands out with highest flexibility. It delivers the desired power at busy times and saves energy whilst idle. It has an additional pre-cleaning zone. In the pre-cleaning zone, coarse dirt particles are removed from the wash items. Top quality cleaning results are also guaranteed by the perfectly coordinated combination of a powerful pump, five upper and three lower wash arms, optimum water distribution and jets positioned for total coverage. With two conveyor speeds (standard and rapid programme), the STR 130 can adapt to variable quantities of dishes and to their degree of soiling. The rapid programme is selected to do the job during busy periods or to wash away light soiling, saving both money and time. Thanks to its rack-activated zones, the STR 130 adapts to changing volumes automatically. The pump is activated and fresh water fed in only if dishes are actually in the respective zone. This STR 130 feature significantly reduces operating costs. Zone activation also significantly reduces noise, steam and heat emission. Features: Mediamat wash water filtration 180 pivoting hygiene door Deep-drawn hygienic tank Rack-controlled zone activation 2 transport speeds Closed base cover Drain pump Single-button operation with colour coding, fault diagnosis and temperature displays Best washing results Easy operation Low operating costs Energy efficiency Short wash-cycle-time Modern and compatible design High service friendliness Options: Outlet tunnel with exhaust air pipe for venting the exhaust in the outlet area Detergent dosing device, conductivity controlled Rinse aid dosing device Boiler heater increased by 6 kw Boiler heater increased by 12 kw (only for machines without Energy) Temperature change-over 85 C / 65 C for cleaning glasses Reduction of working height to 850 mm Emergency stop switch Exhaust air heat recovery system Energy* Stainless steel heat exchanger for fully demineralised water (Energy machines only) Steam heating ( bar) Acoustic alarm for empty rinse aid and detergent container Table bridge (only for machines with an outlet tunnel in combination with 90 /180 corner conveyor) Outlet tunnel with exhaust air pipe (only for machines without drying zone) Pre-cleaning zone with integrated exhaust air pipe (only for machines with drying zone / not for Energy-Version) Corner entry (without table) * only cold water supply Additional information on

6 Winterhalter STR 130 Exhaust air pipe Width x depth: Height: Width with drying zone: Depth with door open: Height with exhaust air pipe: Height with drying zone: Height with Energy: Rack dimensions: 1,600 x 800 mm 1,420 mm 2,300 mm 1,472 mm 1,600 mm 1,770 mm 1,890 mm* 500 x 500 mm Clear entry height: 460 ± 5 mm Water connection: G ¾ Waste water connection: ø 50 mm General data Weight Standard (net / gross): 243 / 273 kg Weight Standard Energy (n/g): 315 / 345 kg* Weight with drying zone (n/g): 290 / 340 kg Weight Energy + drying zone (n/g): 362 / 412 kg* Tank capacity: 65 l Circulating pump: 600 l/min Noise emission: < 70 db(a) Cycle duration 40 / 28 sec. 40 / 28 sec. Max. theoretical capacity Racks / h: 90 / 130 Rinse water consumption (under ideal conditions) Water connection 260 l / h Flow pressure (pressurized boiler): bar Flow pressure (non pressurized boiler): bar Flow rate: at least 15 l/min. Thermal radiation Flow rate Energy: 6 l/min.* Sensitive Latent Water inlet temp.: max. 60 C STR Water inlet temp. Energy: max. 20 C* STR drying zone STR 130 Energy * STR 130 Energy + drying zone * Weight pressure point per foot Marks of conformity STR 130: 82 kg CB, SVGW, WRAS STR drying zone: 100 kg STR 130 Energy: 95 kg* STR 130 Energy + drying zone: 111 kg* Electrical values Voltage Fuse protection Tank heating Total connected load Boiler heating Pumps + Control unit Heating drying zone 415V3N~,50/60Hz 50 A 12 kw 27 kw 12 kw 3 kw optional** 415V3N~,50/60Hz 50 A 12 kw 33 kw 18 kw 3 kw optional** 415V3N~,50/60Hz 63 A 12 kw 39 kw 24 kw 3 kw optional** * only with Energy version. ** if a drying zone has been selected the total connected load will increase by 6.5 kw. Probably higher fuse protection will be necessary. Additional information on

7 Winterhalter STR 110 The STR 110 single tank rack conveyor dishwasher delivers the desired power in peak times and saves energy when it's quiet. With its compact dimensions, the STR 110 single tank rack conveyor dishwasher also fits into the smallest kitchen. Top quality cleaning results are guaranteed by the perfectly coordinated combination of a powerful pump, five upper and three lower wash arms, optimum water distribution and jets positioned for total coverage. With two conveyor speeds (standard and rapid programme), the STR 110 can adapt to variable quantities of dishes and to their degree of soiling. The rapid programme is selected to do the job during busy periods or to wash away light soiling, saving both money and time. Thanks to its rack-activated zones, the STR 110 adapts to changing volumes automatically. The pump is activated and fresh water fed in only if dishes are actually in the respective zone. This STR 110 feature significantly reduces operating costs. Zone activation also significantly reduces noise, steam and heat emissions. Features: Mediamat wash water filtration 180 pivoting hygiene door Deep-drawn hygienic tank Rack-controlled zone activation 2 transport speeds Closed base cover Drain pump Single-button control with colour coding, fault diagnosis and temperature displays Best washing results Easy operation Low operating costs Energy efficiency Short wash-cycle-time Modern and compatible design High service friendliness Options: Detergent dosing device, conductivity controlled Rinse aid dosing device Boiler heater increased by 6 kw Boiler heater increased by 12 kw (only for machines without Energy) Non pressurised boiler Temperature change-over 85 C / 65 C for cleaning glasses Reduction of working height to 850 mm Emergency stop switch (Corner) drying zone Exhaust air heat recovery system Energy* Stainless steel heat exchanger for fully demineralised water (Energy machines only) Steam heating ( bar) Acoustic alarm for empty rinse aid and detergent container Rear infill panel Table bridge (only for machines with an outlet tunnel in combination with 90 /180 corner conveyor) Outlet tunnel with exhaust air pipe (only for machines without (corner) drying zone, not for Energy) Infeed tunnel with integrated exhaust air pipe (only for machines with (corner) drying zone and not for Energy version) Corner entry 90 inlet corner conveyor 90 / 180 outlet corner conveyor * only cold water supply, max. 20 C Additional information on

8 Winterhalter STR 110 Exhaust air pipe Width x depth: 1,300 x 800 mm Depth with corner drying zone: mm Height: 1,420 mm Width with drying zone: 2,000 mm Width with corner drying zone: 2,095 mm Depth with door open: 1,472 mm Height with exhaust air pipe: 1,600 mm Height with (corner) drying zone: 1,805 mm Height with Energy: 1,890 mm* Rack dimensions: 500 x 500 mm Clear entry height: 460 ± 5 mm Water connection: G ¾ Waste water connection: ø 50 mm Energy Corner drying zone General data Weight Standard (net / gross): Weight Standard Energy (n/g): Weight with drying zone (n/g): Weight Energy + drying zone (n/g): Tank capacity: Circulating pump: Noise emission: 207 / 240 kg 279 / 312 kg* 274 / 316 kg 346 / 388 kg* 65 l 600 l/min < 70 db(a) Max. theoretical capacity Racks / h: 70 / 110 Rinse water consumption (under ideal conditions) Water connection 260 l / h Flow pressure (pressurized boiler): bar Flow pressure (non pressurized boiler): bar Thermal radiation Flow rate: at least 15 l/min. Sensitive Latent Flow rate Energy: 6 l/min.* STR Water inlet temp.: max. 60 C STR (corner) drying zone Water inlet temp. Energy: max. 20 C* STR 110 Energy * STR 110 Energy + (corner) * drying zone Weight pressure point per foot Marks of conformity STR 110: 73 kg CB, SVGW, WRAS STR drying zone: 89 kg STR 110 Energy: 91 kg* STR Energy + drying zone: 107 kg* Electrical values Voltage Fuse protection Tank heating Total connected load Boiler heating Pumps + Control unit Additional information on Heating (corner) drying zone 200V3~,50/60Hz 80 A 10 kw 24.7 kw 12 kw 2.7 kw optional** 200V3~,50/60Hz 100 A 10 kw 30.7 kw 18 kw 2.7 kw optional** 200V3~,50/60Hz 125 A 10 kw 36.7 kw 24 kw 2.7 kw not possible 230V3~,50/60Hz 80 A 10 kw 24.7 kw 12 kw 2.7 kw optional** 230V3~,50/60Hz 100 A 10 kw 30.7 kw 18 kw 2.7 kw optional** 230V3~,50/60Hz 100 A 10 kw 36.7 kw 24 kw 2.7 kw optional** 400V3N~,50/60Hz 50 A 10 kw 24.7 kw 12 kw 2.7 kw optional** 400V3N~,50/60Hz 50 A 10 kw 30.7 kw 18 kw 2.7 kw optional** 400V3N~,50/60Hz 63 A 10 kw 36.7 kw 24 kw 2.7 kw optional** 415V3N~,50/60Hz 50 A 10 kw 24.7 kw 12 kw 2.7 kw optional** 415V3N~,50/60Hz 50 A 10 kw 30.7 kw 18 kw 2.7 kw optional** 415V3N~,50/60Hz 63 A 10 kw 36.7 kw 24 kw 2.7 kw optional** * only with Energy version. ** if a (corner) drying zone has been selected the total connected load will increase by 6.5 kw. Probably higher fuse protection will be necessary.