LWU Technical Data Sheet

Transcription

1 C Merchandisers A C G F Technical ata Sheet P/N 03954J NSF Certified February 200 We reserve the right to change or revise specifications and product design in connection with any feature of our products. Such changes do not entitle the buyer to corresponding changes, improvements, additions or replacements for equipment previously sold or shipped. B C Item Part # escription Wiring Item # FAN ASSMBLIS AN THRMOSTATS A. 4W Fan Assembly () Fan Motor, Standard (MO.4400) Front & Rear Fan Blade embossing toward motor (FB.04095) nd Compartment Fan Blade embossing toward motor (FB ) B. Optional Adjustable Refrigeration Thermostat (2) C. efrost Termination Thermostat (3) (lectric efrost only) Front & nd Compartment (CT.44406) Rear (CT.440) Heater Switch (4) (Koolgas efrost only) (CT ) HATRS. Modular lectric efrost Heaters, 20V (5) Parent (H ) nd Compartment (H.4504) Item Part # escription Wiring Item # HATRS (CONTINU) F. s, lectric 20V (6) inch case (H.45046) inch case (H ) nd Compartment (H.45046) F. s, Koolgas 20V () inch case (H ) inch case (H ) nd Compartment (H ) G. Nosing Anti-sweat Heaters () inch case (ischarge) (H.45040) inch case (Return) (H ) inch case (ischarge) (H ) inch case (Return) (H.45046) nd Compartment (ischarge) (H.04062) nd Compartment (Return) (H ) NOT: Revision J corrects heater data on Page HUSSMANN CORPORATION BRIGTON, MO U.S.A. U.S. & CANAA MXICO P/N 03954J

2 ngineering Plan Views Single eck Frozen Food Wide Island with Unitized nd 9 / (25) A Front of Case (L.H.) imensions shown as inches & (mm). B H 3/4 (222) G 3/ (29) lectrical C L 6 3/4 () 9 / (25) 3 /2 (9) Waste Outlet 30 5/ () 6 /4 (59) Refrig. Outlet Base Rail Waste Outlet Access Area (Gray) (R.H.) 22 /4 (565) Water Seal (See Note*) Refrig. Outlet 5 9/6 (4) Refrig. Outlet I nd of Case 69 (53) C F /2 (200) U-90 U-3 General (A) Case Length (without ends or partitions) 9 (226) 3 /4 (346) (ach end and insulated partition adds 2 in. (5 mm) to case line up.) (B) nd of case to end compartment 4 /4 (226) 96 /4 (2445) Maximum O/S dimension of case front to rear (includes bumper) /2 (200) /2 (200) (C) Front of splashguard to O/S edge of base rail /2 (26) /2 (26) Front edge of case to O/S edge of rear base rail 69 (53) 69 (53) () Rear of case to O/S edge of rear base rail 2 /2 (3) 2 /2 (3) Width of base rail 2 /2 (64) 2 /2 (64) Stub-up area (gray) between front base rail and splashguard 5 / (94) 5 / (94) lectrical Service (lectrical Field Wiring connection point) dge of case to center of knockouts 6 3 /4 (2) 6 3 /4 (2) Front O/S edge of case to nearest knockout 9 / (25) 9 / (25) Waste Outlets () nd of case to the center of rear waste outlet 0 / (25) 5 /4 (40) (F) Center of waste outlet to O/S edge of rear base rail 3 3 /4 (95) 3 3 /4 (95) (G) nd of case to center of front waste outlet 3 (965) 3 (965) O/S edge of case to center of waste outlet 3 /4 (222) 3 /4 (222) Water Seal dge of water seal to center of waste outlet (29) (29) O/S diameter of drip pipe lines /2 (3) /2 (3) Note*: Field installed water seal outlet, tees and connectors are shipped with case. Refrigeration Outlet nd of case to center of front and rear refrigeration outlets 5 9 /6 (4) 5 9 /6 (4) (H) nd of case to center of refrigeration outlets at other end 42 5 / (03) 3 / (2245) O/S edges of case to center of refrigeration outlets 3 / (29) 3 / (29) (I) Center of refrigeration outlet to O/S edge of rear base rail /4 (32) /4 (32) 2 of 6 HUSSMANN CORPORATION, Bridgeton, MO U.S.A. Technical ata Sheet

3 Single Level Wide Island isplay, nd and Center Unitized Impact Frozen Food & Ice Cream LC imensions shown in inches & (mm). B C C N FAN COIL COIL FAN O M K G H I J M imensions A B C F G H I J K L /4 3 3/4 /2 69 / /2 4 3/4 32 / (MM) /2 3 N O 30 / (MM) RFRIGRATION ATA Note: This data is based on store temperature and humidity that does not exceed 5 F and 55% R.H. FF IC ischarge Air ( F) 2 22 vaporator ( F) Unit Sizing ( F) Btu/hr/case FF IC Parallel 90 in in Conventional 90 in in FROST ATA FF IC Frequency (hr) efrost Water (lb/case/day) 90 in in (± 5% based on case configuration and product loading). LCTRIC FF IC Temp Term ( F) 4 4 Failsafe (minutes) GAS uration (minutes) 5 OFFTIM Not Recommended Standard efrost Thermostat Close on rise: close 4 F open 33 F CONVNTIONAL CONTROLS Low Pressure Backup Control FF IC CI/CO (Temp F)* 2/ 39 2/ 39 A NSF Certification These merchandisers are manufactured to meet ANSI /National Sanitation Foundation (NSF ) Standard # requirements. Indoor Unit Only, Pressure efrost Termination (Temp F) Not Recommended *Use a Temperature Pressure Chart to determine PSIG conversions. PHYSICAL ATA Merchandiser rip Pipe (in.) /4 Merchandiser Liquid Line (in.) 3 / Merchandiser Suction Line (in.) / stimated Charge (lb)** 90 in in. 5.3 **This is an average for all refrigerant types. Actual refrigerant charge may vary by approximately half a pound. Length Added to Lineup by: ach nd/partition (in.) /2 ach Contoured nd 5 P/N 03954J HUSSMANN CORPORATION BRIGTON, MO U.S.A. 3 of 6

4 Impact Frozen Food & Ice Cream lectrical ata 90 in. 3 in. Number of 4W 3 5 (nergy fficient fan motors are not available for nd or nd-compartment models) Amperes Watts 90 in. 3 in. 90 in. 3 in. vaporator 20V 60Hz Standard V 50Hz Standard NA 230V 60Hz xport V 50Hz xport V 60Hz nergy fficient V 60Hz nergy fficient NA Nosing Anti-sweat Heaters (on fan circuit) 20V 50Hz / 60Hz V 50Hz / 60Hz Cycling Anti-sweat Heaters 20V 50Hz / 60Hz NA 230V 50Hz / 60Hz NA Minimum Circuit Ampacity 20V 60Hz Standard V 50Hz Standard NA 230V 60Hz xport V 50Hz xport V 60Hz nergy fficient V 60Hz nergy fficient NA Maximum Over Current Protection 20V Maximum Over Current Protection 230V 5 5 lectric efrost Heaters 20V 60Hz Standard Front Compartment V 60Hz Standard Rear Compartment V 60Hz Standard nd Compartment V 50Hz xport Front Compartment V 50Hz xport Rear Compartment V 50Hz xport nd Compartment Koolgas s 20V 60Hz Standard V 50Hz xport NA Standard Lighting: None 4 of 6 HUSSMANN CORPORATION, Bridgeton, MO U.S.A. Technical ata Sheet

5 L lectric efrost Standard 20 V Power From efrost Contactors L2 6 Modular lectric efrost Heaters 5 6 Modular lectric efrost Heaters 5 6 Modular lectric efrost Heater 5 20V NUTRAL 20V POWR Fan efrost Termination Thermostat WARNING All components must have mechanical ground, and the merchandiser must be grounded. Circled Numbers = Parts List Item Numbers Grayed components in 3 inch models only. Nosing (anti-sweat) Heater Refrigeration 3 2 Thermostat (Field Installed) Light Blue } To Condensing Unit P/N 03954J HUSSMANN CORPORATION BRIGTON, MO U.S.A. 5 of 6

6 Gas efrost Optional 20V NUTRAL 20V POWR Fan Nosing (anti-sweat) Heater Heater Switch Heater Switch 4 Heater Switch V POWR 20V NUTRAL 20V POWR 20V NUTRAL 20V POWR 20V NUTRAL 2 Refrigeration Thermostat (Field Installed) Light Blue } To Condensing Unit WARNING All components must have mechanical ground, and the merchandiser must be grounded. Circled Numbers = Parts List Item Numbers Grayed components in 2 foot models only. 6 of 6 HUSSMANN CORPORATION, Bridgeton, MO U.S.A. Technical ata Sheet