Eclipse ER Indirect Air Heater
|
|
- Karin McDonald
- 5 years ago
- Views:
Transcription
1 Data 11 1/8/1 Eclipse ER Indirect Air Heater Version 1 Standard Efficiency (1/" Spacing Heat Exchanger) Parameter Air Delivery Temp., F ( C) 1 scfm referenced to 7 F at 1 atmosphere (1.9 psia), Nm /hr referenced to C at 1 atmosphere (.989 bar). Assuming - VAC / Phase / Hz electrical power. Please contact Eclipse for other electrical power options. unit uses two HP (18. kw) motors. All weights are approximate. ER Heater Size (1 through 8) and Burner Size (Small or Large) Small Large Small Large Small Large Small Large Small Large Small Large Small Large Small Large (1),877 Air Flow Rate, scfm (Nm /hr) 1 (7) Air Pressure Drop, "w.c. (mbar) Maximum Heat Transfer, MMBTU/hr (kw) Maximum Burner Firing Demand, MMBTU/hr (kw) Gas Pressure Requirement into Valve Train Fuel Options. (.) (81) Combustion Air Blower Motor Rating, bhp (kw) () 11 (1),79 (7). (11.) 1. (81) 1. () 7 (8),91 (1) 1.9 (.7) 1.8 (8).1 (1) psig ( mbarg) 9,9 (1). (8.). (8). (7) 7 (8), (81). (.). (7).9 (8) 9 9, (119). (8.7).8 (81). (98) 719 (8) 7,98 (118). (.). (97).9 (11) See Design Guide 11, to be used in conjuction with the following curves, to complete design and selection. All information is based on laboratory testing with neutral (." w.c.) exhaust conditions. All inputs based upon gross calorific values and standard conditions: 1 atmosphere, 7 F (1 C). Plumbing of gas will affect accuracy of orifice readings. All information based on general acceptable air and gas piping practices. Custom designs incorporating larger units or multiple units are available for needs greater than above maximums. Eclipse reserves the right to change the construction and/or configuration of our products at any time without being obliged to adjust earlier supplies accordingly. (1) 1, (19).9 (9.7).8 (111). (19) Natural Gas, Propane, Butane (Contact Eclipse for others.) Recirculation Air Fan Motor Rating, bhp (kw) Unit Weight, lbs,1 (kg) (78) 7. 7, ,8 (7) 7. 1 (1) 1,778 () 1 71 (79) 1,1 (198). (.). (119). (1) 1 (1) 1,1 (7) 1,89 (1). (1.7). (1). (178) (1) 77 (8) 1,88 (1899). (.). (1817) 7. (19) (1) (1) 19,1 (889) 7 (),1 (98).8 (1.) 7. (11) 8. 7 (8) 19, ().7 (.7) 8. (91) 1.1 (9) () 9 1,7 (). (1.) 9.8 (87) 11. (1), (119) 7 (8), (11).7 (.7) 11.7 (9) 1.8 () (7) 7, (8). (1.) 1. (9) 1. (7) (),7 (18)
2 High Efficiency (/8" Spacing Heat Exchanger) Parameter Air Delivery Temp., F ( C) 1 scfm referenced to 7 F at 1 atmosphere (1.9 psia), Nm /hr referenced to C at 1 atmosphere (.989 bar). Assuming - VAC / Phase / Hz electrical power. Please contact Eclipse for other electrical power options. unit uses two HP (18. kw) motors. All weights are approximate. See Design Guide 11, to be used in conjuction with the following curves, to complete design and selection. All information is based on laboratory testing with neutral (." w.c.) exhaust conditions. All inputs based upon gross calorific values and standard conditions: 1 atmosphere, 7 F (1 C). Plumbing of gas will affect accuracy of orifice readings. All information based on general acceptable air and gas piping practices. Custom designs incorporating larger units or multiple units are available for needs greater than above maximums. Eclipse reserves the right to change the construction and/or configuration of our products at any time without being obliged to adjust earlier supplies accordingly. The performance curves below assume the following: - Fuel is natural gas - Burners are operated at % excess air - System elevation is at sea level - Process air enters ER Heater at 7 F (1 C), dry ER Heater Size (1 through 8) and Burner Size (Small or Large) Small Large Small Large Small Large Small Large Small Large Small Large Small Large Small Large 89 (),877 Air Flow Rate, scfm (Nm /hr) 1 (7) Air Pressure Drop, "w.c. (mbar) Maximum Heat Transfer, MMBTU/hr (kw) Maximum Burner Firing Demand, MMBTU/hr (kw) Gas Pressure Requirement into Valve Train Fuel Options. (.7) 1. () 1. () Combustion Air Blower Motor Rating, bhp (kw) () 9,79 (7). (11.) 1. (1) 1.7 (98) 778 (1),91 (1). (.). (8). (7) psig ( mbarg) 1 (7),9 (1). (1.).. (7) 777 (1), (81). (.).7 (791).1 (99) 1 (7) 9, (119). (1.7).1 (99). (1) 77 (1) 7,98 (118).9 (7.). (1). (11) 1 () 1, (19).8 (1.). (11).7 (177) Natural Gas, Propane, Butane (Contact Eclipse for others.) Recirculation Air Fan Motor Rating, bhp (kw) Unit Weight, lbs,9 (kg) (8) 7. 7,88 (1) ,7 (7) 7. 1 (1) 1, (1) (11) 1,1 (198). (8.). (1).8 (17) 1 (1) 1,9 (78) 8 1,89 (1). (1.).7 (171). (19) (1) 78 (1) 1,88 (1899).1 (7.7).9 () 8. (1) (1),1 (917) 1 (8),1 (98).7 (1.) 7.9 (1) 8.9 (8) 77 (1) 19, (). (8.7) 9. (7) 1.9 (19) () 1 (7) 1,7 (). (1.7) 1.7 (1) 1. (7), (11) 777 (1), (11). (8.) 1.9 (781) 1. (9) (7) 1 (7), (8). (1.) 1.7 (8) 1.7 (89) (),187 (1) Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1
3 8 Process Air Outlet Temperature vs. Process Air Flow Rate 1/" Exchanger Plate Spacing 7 Process Air Outlet Temperature ( C) 1 Process Air Outlet Temperature F Size Size 1, 1, 1,,,,,,, 1,,,,,, 7, 9 Process Air Outlet Temperature vs. Process Air Flow Rate /8" Exchange Plate Spacing Process Air Outlet Temperature ( C) Process Air Outlet Temperature F 8 7 Size Size 1 1, 1, 1,,,,,,, 1,,,,,, 7, Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1
4 7 Process Air Pressure Drop vs. Process Air Flow Rate 1/" Exchanger Plate Spacing 1 Process Air Pressure Drop (mbar) 1 9 Process Air Pressure Drop "wc Size Size 1, 1, 1,,,,,,, 7 1,,,,,, 7, Process Air Pressure Drop vs. Process Air Flow Rate /8" Exchanger Plate Spacing Process Air Pressure Drop (mbar) Process Air Pressure Drop "w.c. Size Size ,,,,,, 7, Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1
5 .8 Process Air Outlet Temperature Correction Factor vs. Data Point Number Outlet Temp Correction Factor, F t /" Exchanger /8" Exchanger F: T co actual = T co curve + F t (T ci actual - 7) C: T co actual = T co curve + F t (T ci actual - 1) Where: - T co actual = Process Air Outlet Temp - Actual - T co curve = Process Air Outlet Temp - Curve - T ci actual = Process Air Inlet Temp - Actual - F t = Process Air Inlet Temp Correction Factor - Performance Curve Data Points are numbered left-to-right, 1 thru.. 1 Performance Curve Data Point Number 1.1 Process Air P Correction Factor vs. Inlet Temperature 1. P Correction Factor, F dp P actual = F dp P curve Process Air Inlet Temperature, T ci F Process Air Inlet Temperature, T ci ( C) Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1
6 18 Burner Firing Rate vs. Process Air Flow Rate 1/" Exchanger Plate Spacing Gross Firing Rate (kw) 18 1 Gross Firing Rate MMBTU/hr Size Size, 1, 1,,,,,,, 1,,,,,, 7, Burner Firing Rate vs. Process Air Flow Rate /8" Exchanger Plate Spacing Gross Firing Rate (kw) 18 1 Gross Firing Rate MMBTU/hr Size Size, 1, 1,,,,,,, 1,,,,,, 7, Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1
7 Table 1 Burner Options ER Heater 7 8 Small Burner Maximum Demand, MMBTU/hr Maximum Demand, kw Winnox Burner with Package Blower WX WX WX WX WX WX8 N/A N/A Winnox Burner with External Blower N/A N/A N/A N/A N/A N/A WX8 N/A Minnox Burner with External Blower CCS 7 CCS 1 CCS-T 1 CCS-T 17 CCS-T CCS-T CCS-T CCS-T Large Burner Maximum Demand, MMBTU/hr Maximum Demand, kw Winnox Burner with Package Blower WX WX WX WX WX8 N/A N/A N/A Winnox Burner with External Blower N/A N/A N/A N/A N/A WX8 N/A N/A Minnox Burner with External Blower 7 CCS 1 CCS-T 1 CCS-T 17 CCS-T CCS-T CCS-T CCS-T CCS-T Eclipse ER Indirect Air Heater, V1, Data 11, 1/8/1 7
8 Dimensions System Using Winnox Burners (Low Emissions) H W L System Using Minnox Burners (Ultra Low Emissions) H W L Size Length L Inches (m) Width W Inches (m) Height H Inches (m) (.9) 1 (1.) 98 (.9) 198 (.) (1.1) 1 (.9) 9 (.1) (1.) 11 (.87) (.7) (1.) 11 (.9) 9 (.7) 7 (1.8) 119 (.) (.8) 8 (.1) 19 (.) 7 8 (.81) 1 (.) 19 (.) 8 7 (.98) 1 (.) 19 (.) Data 11, 1/8/1
9 Offered By: Power Equipment Company 11 Williamsburg Road Richmond, Virginia 1 Phone (8) -8 Fax (8) -88
Eclipse ER Indirect Air Heater
121 Design Guide 9/3/2010 Eclipse ER Indirect Air Heater Version 1 Copyright Copyright 2010 by Eclipse, Inc. All rights reserved worldwide. This publication is protected by federal regulation and shall
More informationSTARJET BURNER SJ075 SJ980
CAPACITIES STARJET BURNER SJ075 SJ980 Burner Model Air Flow (scfm) Pressure (osig) 36 osig 60 Hz Direct Drive Blowers TBA Blower Motor Model HP Fan Rating (acfm @ 350 F) Max. Capacity (MMBtu/hr) SJ075
More informationDesign Guide 111 9/25/2008. Eclipse Winnox Burners WX Series Version 1
Design Guide 111 9/25/2008 Eclipse Winnox Burners WX Series Version 1 Co p y r i g h t Disclaimer Notice Copyright 2005 by Eclipse, Inc. All rights reserved worldwide. This publication is protected by
More informationECLIPSE AIR HEAT BURNERS Series AH, DAH, TAH & CAH
ECLIPSE AIR HEAT BURNERS Series AH, DAH, TAH & CAH U.S. Reissue Pat. No. 26,244 Canadian Pat. No. 743,782 Spec 140 11/4/03 AH, Front View Data 140-1 AH, Back View Data 140-1 TAH Data 140-3 DAH, Blower
More informationECLIPSE AH-MA BURNERS. Air Make-Up Burners. Designed for trouble-free make-up or process air heating. Ready for the world
Bulletin 16C 8/ ECLIPSE AH-MA BURNERS Air Make-Up Burners Designed for trouble-free make-up or process air heating. Eclipse AH-MA burners produce a uniform, odorless, and smokeless flame ideal for heating
More informationDesign Guide No /01. RatioMatic Burners. RM Series Version 3.10
Design Guide No.110 12/01 RatioMatic Burners RM Series Version 3.10 COPYRIGHT Copyright I998 by Eclipse Combustion, Inc. All rights reserved worldwide. This publication is protected by federal regulation
More informationEclipse AirHeat Burner
135 Design Guide 6/16/2010 Eclipse AirHeat Burner AH Serie Version 2 Copyright Copyright 1999 by Eclipse, Inc. All rights reserved worldwide. This publication is protected by federal regulation and shall
More informationDesign Guide /12/2008. Eclipse RatioAir Burners RA Series Version 1
Design Guide 115 11/12/2008 Eclipse RatioAir Burners RA Series Version 1 Co p y r i g h t Disclaimer Notice Copyright 2005 by Eclipse, Inc. All rights reserved worldwide. This publication is protected
More informationBosch Buderus SSB255/399/512 Stainless Steel Condensing Boiler
Stainless Steel Condensing Boiler Engineering Submittal Sheet Boiler Components Engineering Specifications There shall be provided and installed Bosch Buderus SSB255 SSB 399 SSB512 in quantities of. Bosch
More informationCOMMERCIAL-GRADE RESIDENTIAL GAS WATER HEATERS
CONDENSING TANKLESS WITH INTEGRATED RECIRCULATION PUMP COMMERCIAL-GRADE RESIDENTIAL Ultra-Low NOx gas tankless water heaters with condensing technology featuring an up to 0.95 Uniform Energy Factor (UEF)
More information940ES Tankless Water Heater
Engineering Submittal Sheet Dimensions and Connections B C D C Combustion air inlet Exhaust outlet Optional combustion air inlet Top view Top view A Hot water outlet Cold water inlet E F Front view Side
More information940ES Tankless Water Heater
Engineering Submittal Sheet Overview and Certifications LOW-LEAD U P C C US Massachusetts Plumbing Board Approved Engineering Specifications Water heater shall be a Model Therm 940 ES. Plant shall consist
More informationResidential Gas Tankless Water Heater
CONDENSING TANKLESS WITH INTEGRATED RECIRCULATION PUMP Ultra-Low NOx gas tankless water heaters with condensing technology featuring up to a 0.95 Uniform Energy Factor (UEF) which lowers operating costs
More informationSAFETY FEATURES: Air-Fuel Ratio (AFR) Sensor Exhaust & Water Temperature Safety Control Overheat Cut-Off Fuse
CONDENSING TANKLESS WITH INTEGRATED RECIRCULATION PUMP COMMERCIAL-GRADE RESIDENTIAL Ultra-Low NOx gas tankless water heaters with condensing technology featuring an up to 0.95 Uniform Energy Factor (UEF)
More informationTankless Condensing High Efficiency Water Heaters with Built-In Pump
Tankless Residential Water Heater Series Tankless Condensing High Efficiency Water Heaters with Built-In Pump Ultra-Low NOx gas tankless water heaters with condensing technology featuring up to an unprecedented
More informationC1210ES Tankless Water Heater
Engineering Submittal Sheet Dimensions and Connections B C D C Combustion air inlet Exhaust outlet Optional combustion air inlet Top view Top view A E Hot water outlet Cold water inlet F H J C I K G Front
More informationC1050ES Tankless Water Heater
Engineering Submittal Sheet Dimensions and Connections B C D C Combustion air inlet Exhaust outlet Optional combustion air inlet Top view Top view A E F Hot water outlet Cold water inlet Inlet water filter
More informationBosch Buderus SSB1000TL/TL2/TL3/TL4 Stainless Steel Condensing Boiler
Bosch Buderus SSB1000TL/TL2/TL3/TL4 Engineering Submittal Sheet Boiler Components C US Engineering Specifications There shall be provided and installed Bosch Buderus Model SSB1000TL in quantities of. Bosch
More informationResidential/Commercial Gas Condensing High Efficiency Tankless Water Heaters
Residential/Commercial Gas Condensing High Efficiency Tankless Water Heaters FEATURES ULTRA-LOW NOx CONDENSING TECHNOLOGY PROVIDES UNPRECEDENTED.95 ENERGY FACTOR DURABLE HEAT EXCHANGER Primary Heat Exchanger
More informationResidential/Commercial Gas Tankless Water Heaters TANKLESS HIGH EFFICIENCY CONDENSING MODELS FEATURES INDOOR MODELS ATI-240H, ATI-340H, ATI-540H
TANKLESS HIGH EFFICIENCY CONDENSING MODELS FEATURES ULTRA-LOW NOx CONDENSING TECHNOLOGY PROVIDES UNPRECEDENTED 0.95 ENERGY FACTOR DURABLE HEAT EXCHANGER Primary Heat Exchanger is constructed of HRS35 Commercial-Grade
More informationBosch Buderus SSB800/1000/1000TL Stainless Steel Condensing Boiler
Bosch Buderus SSB800/1000/1000TL Engineering Submittal Sheet Boiler Components C US Engineering Specifications There shall be provided and installed Bosch Buderus Model SSB800 SA, Model SSB1000 SA, Model
More informationRG7D 1-Stage Heat Series
TECHNICAL SPECIFICATIONS RG7D 1-Stage Heat Series High Efficiency / Direct Vent Condensing Downflow Gas Furnace Induced Draft - 9%+ AFUE Input 4,000 thru 7,000 Btuh The high efficiency downflow gas furnace
More informationMULTI-LINK UP TO 20 UNITS COMMON VENT UP TO 8 UNITS COMPLIES WITH LEAD FREE STANDARDS SAFETY FEATURES:
TANKLESS CONDENSING HIGH EFFICIENCY COMMERCIAL GAS Ultra-Low NOx gas tankless water heaters with condensing technology featuring up to 0.95 Uniform Energy Factor (UEF) which lowers operating costs and
More informationClean Heat. Clean Air. PRODUCTGUIDE
Clean Heat. Clean Air. PRODUCTGUIDE Clean Heat. Clean Air. At Eclipse, clean heat and clean air are at the center of our investments and our decision-making process. We recognize that providing efficient
More informationResidential/Commercial Gas Condensing Tankless Models
15-Year Residential/1-Year Commercial Heat Exchanger Limited Warranty/5-Year Parts Warranty* FEATURES Ultra-Low NOx Condensing Technology Provides Unprecedented.95 Energy Factor Durable Heat Exchanger
More informationEclipse RatioMatic Burners
Design Guide 110 11/11/2011 Eclipse RatioMatic Burners RM Series Version 5 Copyright Copyright 2010 by Eclipse, Inc. All rights reserved worldwide. This publication is protected by federal regulation and
More informationV-Line. Nozzle-mix line burner
V-Line Nozzle-mix line burner Duct Burners - V-Line 4-22.5-1 Nozzle-mixing line burner for use with low pressure natural gas, propane and butane. Suitable for operation in variable process air-flows. Stainless
More informationGB Condensing Gas Boiler
Engineering Submittal Sheet Boiler Overview C US Engineering Specifications There shall be provided and installed a quantity of Buderus GB162/100 wall-hung condensing hot water boiler(s), suitable for
More informationEclipse AirHeat Burners
Design Guide No. 135, 7/99 L00060 Eclipse AirHeat Burners AH Series Version 2.00 (Patent Pending) Eclipse Combustion COPYRIGHT Copyright I999 by Eclipse Combustion, Inc. All rights reserved worldwide.
More informationCondensing Hydronic Boilers 2,000,000-6,000,000 BTU/HR
Condensing Hydronic Boilers 2,000,000-6,000,000 BTU/HR The heat transfer innovators. FEATURES High Mass and Water Volume Ultra High Efficiencies Linkageless Modulation Rugged, Robust, Reliable Duplex Alloy
More informationG315/6 Cast Iron Boiler
Engineering Submittal Sheet Boiler Overview LISTED Engineering Specifications There shall be provided and installed G315-6 Buderus sectional cast iron hot water boiler(s), suitable for forced draft firing
More informationDesign Guide No. 330, 10/02 Immersion Burners
Design Guide No. 330, 10/02 Immersion Burners ImmersoJet Series version 2.20 COPYRIGHT Copyright I997 by Eclipse Combustion, Inc. All rights reserved worldwide. This publication is protected by federal
More informationFor More Information Click Here or Call General Supply M7RL Series TECHNICAL SPECIFICATIONS. FEATURES and BENEFITS
TECHNICAL SPECIFICATIONS M7RL Series High Efficiency / Direct Vent Condensing Downflow Gas Furnace Induced Draft - 95%+ AFUE Input 45,000 thru 7,000 Btuh The high efficiency downflow gas furnace is especially
More informationMD-170 Installation/Operator's Manual
MD-170 Installation/Operator's Manual DATE OF PURCHASE DISTRIBUTORS NAME MODEL NO. MD-170 Serial Number(s) Table of Contents 3 4 5 Maximum Capacity (Dry Weight) 170 lbs. 77.1 kg Basket Diameter 51-1/2"
More informationDELTA-TE III. Nozzle-mix line burner
4-21.7-1 DELTA-TE III Nozzle-mix line burner Combines excellent flexibility with extreme low emissions for direct firing Especially designed for firing in low oxygen, high humidity and/or inert process
More informationG315/5 Cast Iron Boiler
Engineering Submittal Sheet Boiler Overview LISTED Engineering Specifications There shall be provided and installed G315-5 Buderus sectional cast iron hot water boiler(s), suitable for forced draft firing
More informationG515/7 Cast Iron Boiler
Engineering Submittal Sheet Boiler Overview Engineering Specifications There shall be provided and installed G515-7 Buderus sectional cast iron hot water boiler(s), suitable for forced draft firing with
More informationBosch Greentherm T9800 SE 199 Gas Tankless Water Heater
Engineering Submittal Sheet Product Overview & Certifications Engineering Specifications The system shall consist of gas tankless water heater model Greentherm T9800 SE 199 as manufactured by Bosch Thermotechnology.
More informationM3RL Series TECHNICAL SPECIFICATIONS. FEATURES and BENEFITS. High Efficiency / Direct Vent Condensing Downflow Gas Furnace
TECHNICAL SPECIFICATIONS M3RL Series High Efficiency / Direct Vent Condensing Downflow Gas Furnace Induced Draft - 90+ AFUE Input 60,000 & 80,000 Btuh The high efficiency downflow gas furnace is especially
More information"HC" AIRFLO. In-duct firing line burner
"HC" AIRFLO In-duct firing line burner -.- High heat release up to.5 MW per unit of burner length (05 mm) Clean combustion with low CO and NO x emission levels Minimal process air pressure drops locally
More informationG615/11 Cast Iron Boiler
Engineering Submittal Sheet Boiler Overview LISTED Engineering Specifications There shall be provided and installed G615-11 Buderus sectional cast iron hot water boiler(s), suitable for forced draft firing
More informationPROFIRE -E SERIES BURNERS
PROFIRE -E SERIES BURNERS 8.4-42.0 MMBTU/HR High-efficiency burner technology for the most stringent emissions requirements Integration Starts with the Burner Suitable for firetube, firebox and watertube
More informationSTS-JZ (premierschwank) POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS
SUBMITTAL DATA (premierschwank) POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS PROJECT: ENGINEER: CONTRACTOR: DISTRIBUTOR: SCHWANK MODEL #: FUEL: APPROVED BY: DATE: APPROVAL #: 1 Submittal NOTICE:
More informationAir-Fuel Ratio (AFR) Sensor Exhaust & Water Temperature Safety Control Overheat Cut-Off Fuse
TANKLESS HIGH EFFICIENCY CONDENSING WATER HEATERS COMMERCIAL-GRADE RESIDENTIAL / COMMERCIAL Ultra-Low NOx gas tankless water heaters with condensing technology featuring up to.95 Uniform Energy Factor
More informationAPX. Nozzle-mix line burner
APX Nozzle-mix line burner Duct burners - APX Burner 4-21.9-1 Nozzle-mixing line burner for use with low pressure natural gas, propane and butane Eliminates leakage with its single-piece, aluminium extrusion
More informationTankless Condensing High Efficiency Water Heaters
Tankless Residential Water Heater Series Tankless Condensing High Efficiency Water Heaters Ultra-Low NOx gas tankless water heaters with condensing technology featuring up to an unprecedented.95 Uniform
More informationProduct Data BW9 WATER BOILER SERIES B
GAS --- FIRED CONDENSING WATER BOILER SERIES B Product Data Fig. 1 - Model 50-100 Series B Fig. 2 - Model 125-200 Series B C US Use of the AHRI Certified TM Mark indicates a manufacturer s participation
More informationSB615/310 Stainless Steel Condensing Boiler
Stainless Steel Condensing Boiler Engineering Submittal Sheet Boiler Components R Engineering Specifications The boiler(s) shall have a full three pass fire tube design to allow complete combustion of
More informationGB Condensing Gas Boiler
Engineering Submittal Sheet Boiler Overview C US Engineering Specifications There shall be provided and installed a quantity of Buderus GB12/90 condensing hot water boiler(s), suitable for induced draft
More informationDate: Project #: Engineer: Prepared By: Bid Date:
Brute NEOTHERM Date: Project #: Hydronic Boiler Hydronic Boiler Indoor Sizes 285-850 Submittal Data Engineer: Project Name: Prepared By: Location: Bid Date: Contractor: Standard Equipment Electronic PID
More informationTECHNICAL GUIDE MODELS: P*DH GAS-FIRED CONDENSING / HIGH EFFICIENCY DOWNFLOW / HORIZONTAL FURNACES 91 AFUE DESCRIPTION WARRANTY FEATURES
036-1354-001 Rev. D (110) Heating TECHNICAL GUIDE MODELS: P*DH GAS-FIRED CONDENSING / HIGH EFFICIENCY DOWNFLOW / HORIZONTAL FURNACES 91 AFUE NATURAL GAS 37-111 MBH OUTPUT Air Conditioning EFFICIENCY RATING
More informationHeating Systems. Brooders, Space Heaters and QuadRadiant Heaters
Heating Systems Brooders, Space Heaters and QuadRadiant Heaters Let s grow together. QUADRATHERM QuadRadiant Heater Patent Pending With Chore-Time s QUADRATHERM Heater, the Most Innovative Concept in Heating
More informationG6RC Series TECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS G6RC Series High Efficiency / Direct Vent or Non Direct Vent Condensing Upflow/ Horizontal Gas Furnace Induced Draft - 92+ AFUE Input 40,000-120,000 Btuh The high effi ciency upfl
More informationGB Condensing Gas Boiler
Engineering Submittal Sheet Boiler Overview C US Engineering Specifications There shall be provided and installed a quantity of Buderus GB142/45 wall-hung condensing hot water boiler(s), suitable for induced
More informationPresentation Outline. Commercial 1 Track. Unit #4: Commercial Water Heating
Track: Commercial Natural Gas I Unit #4: Commercial Water Heating An overview of Water Heating Technologies Mr. Eric Burgis, Energy Solutions Center Copyright 2016 Energy Energy Solutions Solutions Center
More informationProduct Data. ama. BW1, BW2 & BW3 Gas-Fired Water Boilers Series B
BW1, BW2 & BW3 Gas-Fired Water Boilers Series B Product Data MODEL BW1, BW2 Series B MODEL BW3 Series B MODELS BW1, BW2, and BW3 Models BW1 and BW2 Gas-Fired Hot Water Boilers provide fast heat quietly
More informationTECHNICAL GUIDE MODELS: P*UR GAS-FIRED CONDENSING / HIGH EFFICIENCY UPFLOW FURNACES 92 AFUE DESCRIPTION WARRANTY FEATURES Rev.
036-1349-001 Rev. A (30) Heating TECHNICAL GUIDE MODELS: P*UR GAS-FIRED CONDENSING / HIGH EFFICIENCY UPFLOW FURNACES 9 AFUE NATURAL GAS 37-130 MBH OUTPUT Air Conditioning EFFICIENCY RATING CERTIFIED R
More informationSuggested Specifications Prestige Excellence 110
Suggested Specifications Prestige Excellence 110 General Requirements A. Furnish and install (qty) completely assembled, modulating, sealed combustion, high efficiency, combination gas-fired boiler(s)
More information1500 SERIES SMALL CAPACITY ULTRA 2 LOW NO X TM BURNER
CAPABILITIES Similar design for hot or cold air Good turndown with flame characteristics and direction maintained Multiple gaseous fuel capabilities including commercial and many by-product fuels FEATURES
More informationEclipse ImmersoJet Burner
Design Guide 330 11/15/2016 Eclipse ImmersoJet Burner IJ Series Version 3 Copyright Copyright 2005 by Eclipse, Inc. All rights reserved worldwide. This publication is protected by federal regulation and
More informationCommercial Gas Water Heaters
CYCLONE Mxi MODULATING MODULATING BURNER ADVANCES THE CYCLONE TO HIGHER LEVELS OF EFFICIENCY The full line of A. O. Smith Cyclone Mxi condensing water heaters has been designed to provide years of dependable
More informationVCLEARFIRE. High-Efficiency, Commercial Steam Boiler Horsepower
VCLEARFIRE High-Efficiency, Commercial Steam Boiler 9.5-60 Horsepower High-Efficiency, Low-Emissions Steam Boiler in a Compact Footprint The Cleaver-Brooks compact, gas-fired ClearFire -V vertical boiler
More informationEclipse 90 UV Scanner Model A Version 1
85 Instruction Manual 10/14/010 Eclipse 90 UV Model 5600-90A Version 1 C US Introduction This sensor features a high sensitivity ultraviolet (UV) tube for monitoring gas or oil flames that cycle on and
More informationINDITHERM. Low temperature gas burners
INDITHERM Low temperature gas burners 1-2.3-1 High turndown for maximum operation flexibility. Maximum capacities up to 1800 kw. Designed for firing in indirect fired processes. Excellent combustion throughout
More informationTECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS Model PGC2T (C and L) Series SmartStart M1200 Product Line Two Stage, Variable Speed, High Efficiency Upflow/Horizontal and Downflow Gas Furnaces 95.1 AFUE Input 60,000-120,000
More informationSan Joaquin Valley Unified Air Pollution Control District. Best Performance Standard (BPS) x.x.xx
San Joaquin Valley Unified Air Pollution Control District Best Performance Standard (BPS) x.x.xx Class Category Dryers and Dehydrators Pistachio Dryer Best Performance Standard Natural Gas-Fired Column
More informationProduct Data. 95% AFUE Single Stage Furnace Upflow / Downflow / Horizontal. ama ! WARNING
DIRECT OR NON -DIRECT VENT 4-WAY MULTIPOISE CONDENSING GAS FURNACE 95% AFUE Single Stage Furnace Upflow / Downflow / Horizontal FLEXIBILITY S Dual certified venting (1 or 2 pipes) Direct Vent furnace S
More informationMECHANICAL VENTING VERSATILITY
MODULATING ULTRA FORCE HIGH EFFICIENCY POWER VENT The full line of State Modulating Ultra Force High Efficiency Power Vent condensing water heaters has been designed to provide years of dependable service
More informationCommercial Gas Water Heaters
CYCLONE Mxi MODULATING MODULATING BURNER ADVANCES THE CYCLONE TO HIGHER LEVELS OF EFFICIENCY The full line of A. O. Smith Cyclone Mxi condensing water heaters has been designed to provide years of dependable
More informationKG6RC Series TECHNICAL SPECIFICATIONS FEATURES AND BENEFITS
TECHNICAL SPECIFICATIONS KG6RC Series High Efficiency / Direct Vent or Non Direct Vent Condensing Upflow/ Horizontal Gas Furnace Induced Draft - 92+ AFUE Input 40,000-120,000 Btuh The high effi ciency
More informationFG7T (C and L Series)
TECHNICAL SPECIFICATIONS FG7T (C and L Series) WARRANTY Smartlite Two Stage, Variable Speed, Condensing Upflow/Horizontal and Downflow Gas Furnaces Induced Draft - 95.1 AFUE Input 60,000-120,000 Btuh The
More informationINFRARED RADIANT HEATER RSCA SERIES CERAMIC HEATERS NATURAL GAS PROPANE GAS DATE: PROJECT: ARCHITECT/ENGINEER: CONTRACTOR: SUBMITTED BY:
INFRARED RADIANT HEATER RSCA SERIES CERAMIC HEATERS NATURAL GAS (CHECK ONE) PROPANE GAS PROJECT: ARCHITECT/ENGINEER: NAME: ADDRESS: NAME: ADDRESS: DATE: CONTRACTOR: SUBMITTED BY: NAME: ADDRESS: EQUIPMENT
More informationTCD-TCH. Self-contained rooftop unit. VOYAGER I and II range TCD: Downflow discharge and intake TCH: Horizontal discharge and intake
TCD-TCH 5-20 TR 50 Hz, 2.5-25 TR 60 Hz Single circuit unit : sizes 06 and 07, Dual circuit unit : sizes 00 to 200, D-Scroll compressor for sizes 25 to 250, Internal protection of winding for fans and compressor(s),
More informationLanemark Midco HMA2A Series Air Heating Burner and DB Duct Burner System Application Manual
Lanemark Midco HMA2A Series Air Heating Burner and DB Duct Burner System Application Manual HMA2A Burners DB Duct Burner Systems Contents Section 1 Section 2 Section 3 Section 4 Introduction Design Calculations
More informationCONDENSING HIGH EFFICIENCY BOILERS
Built by 3I Innovative Industrial Inc. ABS Series CONDENSING HIGH EFFICIENCY BOILERS ABS 1500-2000-2500-3000-4000MBH Cast aluminum heat exchanger 10 to 1 turndown ratio Honeywell Sola boiler control system
More informationSan Joaquin Valley Unified Air Pollution Control District. Best Performance Standard (BPS) x.x.xx
San Joaquin Valley Unified Air Pollution Control District Best Performance Standard (BPS) x.x.xx Class Category Dryers and Dehydrators Pistachio Dryer Best Performance Standard Natural Gas-Fired Column
More informationAdvanced Heating and Hot Water Systems
Advanced Heating and Hot Water Systems High Efficiency Fire Tube Heating Boiler One of a kind design from the inside, out! A Closer Look Exhaust Vent Connection Intake Vent Connection Pressure Relief Valve
More informationVNE GAS FURNACE 2- STAGE VARIABLE SPEED UPFLOW/HORIZONTAL
VNE GAS FURNACE 2- STAGE VARIABLE SPEED UPFLOW/HORIZONTAL 25--21--65 Representative photo only, some models may vary in appearance. MANUFACTURED FOR NATURAL GAS CONVERTIBLE TO (LP) PROPANE GAS NOTE: These
More informationCLIMATE CONTROL PRODUCT GUIDE
CLIMATE CONTROL PRODUCT GUIDE 0985822 Climate Control Product Guide 3/08-25M CURE THAW PREVENT FROST AIR HEAT DRY TABLE OF CONTENTS 2 3 GROUND HEATERS HEATING AND DRYING Ground Heaters is a brand of climate
More informationEclipse Self-Check UV Scanner
856 Instruction Manual 10/18/2010 Eclipse Self-Check UV Model 5602-91 Version 1 Introduction The self-check UV is used for continuous gas or oil flames. A mechanical shutter in the scanner closes briefly
More informationHCLEARFIRE. High-efficiency, modular steam boiler HP
HCLEARFIRE High-efficiency, modular steam boiler 10-60 HP High-Efficiency, Low-Emission Steam Boiler in a Compact Footprint The ClearFire -H compact, gas-fired horizontal boiler is designed specifically
More informationDRY-PAK INDUSTRIAL AIR DRYER Installation and Instruction Manual
DRRRRDRY-PAK Instruction and Installation Manual IB-160 Rev. B P/N 36595 Registered by UL to ISO 9001 DRY-PAK INDUSTRIAL AIR DRYER Installation and Instruction Manual INSTALLATION: Models DS0-00-000 through
More informationMEGASTAR TM BURNER MS-25 MS-150
INSTRUCTIONS MEGASTAR TM BURNER MS-25 MS-150 WARNING These instructions are intended for use only by experienced, qualified combustion startup personnel. Adjustment of this equipment by unqualified personnel
More informationENERGY OPTIMIZATION IN THE MAA GAS PROCESSING FACILITIES
ENERGY OPTIMIZATION IN THE MAA GAS PROCESSING FACILITIES ABDULLAH AJMI, K.S.SABAPATHI, MUSAALAM AL MOWAIZRI, SHAIMA AL AMEEN PROCESS ENGINEERING MINA AL-AHMADI REFINERY, KNPC Kuwait Oil & Gas Summit and
More informationIndiana WX Oil Furnace Inspection Guide
Indiana WX Oil Furnace Inspection Guide Client: Job # : Address: Phone: Client Interview: Oil Dealer: Date of last service: Comments/Billing information: Standard Inspection / Clean and Tune Follow-up:
More informationTECHNICAL SPECIFICATIONS
TM TECHNICAL SPECIFICATIONS Model PGF1TE 2 Stage Series Upflow/Horizontal M1010 Product Line High Efficiency / 95.1 AFUE Direct Vent or Non Direct Vent Condensing Furnace 10 YEAR WARRANTY WORRY-FREE PERFORMANCE
More informationNAVIEN AMERICA INC FITCH AVENUE IRVINE, CALIFORNIA, USA
Navien America Inc. Specification Details for the Navien models: CR-210 CR-210A For Indoor Installation Only For Potable Water Heating and Space Heating NAVIEN AMERICA INC. 17855 FITCH AVENUE IRVINE, CALIFORNIA,
More informationFSA, FOA, SEP & HED Series Unit Heaters and Duct Furnaces
SG-UUH-03 November 2014 Specification Guide FSA, FOA, & HED Series Unit Heaters and Duct Furnaces Product improvement is a continuous process at Advanced Distributor Products. Therefore, product specifications
More informationLAARS MIGHTY THERM 2. High Efficiency Boilers and Volume Water Heaters
LAARS MIGHTY THERM High Efficiency Boilers and Volume Water Heaters The Ideal Replacement Boiler % Thermal Efficiency Straight Forward, Easy to Use Controls - 000 MBH s Industry Leading Low NOx, ppm Indoor/Outdoor
More informationCounterflo CF BASIC COUNTERFLO HEATER RCF CURB MOUNTED ROOFTOP HEATER CFDF COUNTERFLO DUCT FURNACE INDIRECT-FIRED INDUSTRIAL HEATERS
Bulletin CF-1 May 2005 Supersedes CF-1 Dated February 1998 Counterflo INDIRECT-FIRED INDUSTRIAL HEATERS Self-contained, Automatic, Indirect-fired, Warm-air Heater C.S.A. APPROVED UNITS AVAILABLE Natural
More informationResidential & Commercial
Residential & Commercial Effective May 2017 Product Catalog Complete Line www.americanstandardwaterheaters.com Setting The New Standard Tankless Condensing Water Heaters Available in 180,000 & 199,000
More informationU n i t H e at e r s
Unit Heaters LF Models Enduring performance Allied commercial unit heaters are built to last, season after season Designed and built for durability and peak performance, Allied Commercial unit heaters
More information7 sizes: 55,000, 80,000, 110,000, 155,000, 199,000, 285,000 & 399,000 Btuh. One of a kind design from the inside, out!
Advanced Heating and Hot Water Systems High Efficiency Fire Tube Heating Boiler 7 sizes: 55,000, 80,000, 110,000, 155,000, 199,000, 285,000 & 399,000 Btuh up to 97% Efficient 5:1 Turndown Ratio One of
More information10 : 1 Turndown Ratio
+ Residential Gas Hybrid The Best Features of Both a Tank & Tankless Combined into 1 Superior Unit Endless Hot Tank Tankless = 10 : 1 Turndown Ratio SCAQMD Rule 1146.2 Residential Gas Hybrid High Efficiency:
More informationLAARS PENNANT. Economical efficiency for greater savings
LAARS PENNANT Economical efficiency for greater savings PENNANT Easy to install, easy to maintain and easy to use. For more than 50 years, the LAARS brand has stood for quality, reliability, and innovation
More informationRuud Achiever Series Multi position Gas Furnaces
Gas Furnaces Ruud Achiever Series Multi position Gas Furnaces R92P- Series 92% A.F.U.E. Input Rates from 40 to 115 kbtu [11.72 to 33.71 kw] A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance
More informationXLT Oven & AVI Hood. Technical/Rough-In Specifications for Gas & Electric Ovens & Hoods
D 9002A AGKGSWGHE 10/16/2017 CAUTION LT Oven & AVI Hood Technical/Rough-In Specifications for Gas & Electric Ovens & Hoods This appliance is for professional use by qualified personnel. This appliance
More informationLGH/LCH WARNING. CAUTION Danger of sharp metallic edges. Can cause injury. Take care when servicing unit to avoid accidental contact with sharp edges.
Service Literature The LGH/LCH high and standard efficiency 5, 0, 5 and 50 ton (, 0.7, 58. and 75.9 kw) units, are configure to order units (CTO) with a wide selection of factory installed options. The
More informationSUBMITTAL DATA S100 & S100U POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS. Page 1 PROJECT: ENGINEER: CONTRACTOR:
SUBMITTAL DATA & U POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS PROJECT: ENGINEER: CONTRACTOR: DISTRIBUTOR: SCHWANK MODEL #: FUEL: APPROVED BY: DATE: APPROVAL #: www.schwankgroup.com Page
More informationUV Scanner. Model Specification. Introduction. 854 Instruction Manual
854 Instruction Manual 10/11/010 UV Model 5600-91 C US Introduction This sensor features a high temperature and high sensitivity ultraviolet (UV) tube for monitoring gas or oil flames in applications that
More information