Recreational Vehicle RRP List. valid from January 2013

Transcription

1 Recreational Vehicle RRP List valid from January 2013

2 General Notes All deliveries made by us shall be governed exclusively by Webasto Thermo & Comfort UK Ltd - Conditions of Sale of Goods and Provision of Services (copy provided at the end of this RRP list). This RRP list supersedes and renders invalid any previous editions and is subject to change without prior notice. In the interests of continued development, specifications may change from time to time without prior notice. E & OE. The RRP listed are exclusive of VAT and are ex-works (exclusive of carriage). 2

3 Contents Heaters & Accessories Air Heaters Air Top 2000 ST Motorhome Dedicated Heater Kits 5 Operating Controls 6 Combustion Air & Exhaust 6 Mounting 6 Fuel System 7 Ducting System 7 Air Top 2000S Spare Parts 8 Air Top 2000 ST Spare Parts 9 Page No Air Top EVO 3900 Motorhome Dedicated Heater Kits 10 Air Top EVO 5500 Motorhome Dedicated Heater Kits 11 Operating Controls 12 Combustion Air & Exhaust 12 Mounting 13 Fuel System 13 Ducting System 14 Air Top 3500 / 5000 Spare Parts 15 Air Top 3500 / 5000 ST Spare Parts 16 Air Top Evo 3900 / 5500 Spare Parts 17 HL90 Vehicle Dedicated Heater Kits 18 Operating Controls 19 Combustion Air & Exhaust 19 Fuel System 19 Mounting 20 Ducting System 20 Common Replacement Parts 21 Integrated Heating Systems Dual Top RHA 100 / 101 / Accessories 22 Spare Parts 23 Water Heaters Thermo Top C 300 Motorcaravan Dedicated Heater Kits 25 Thermo Top C 300 Parking Heaters Dedicated Heater Kits 26 Operating Controls 27 Combustion Air & Exhaust 27 Mounting 27 Fuel System 28 Water System 29 Thermo Top E/C Spare Parts 30 Thermo 90 ST Motorhome Dedicated Heater Kits 31 Operating Controls 32 Combustion Air & Exhaust 32 Fuel System 32 Water System 33 Mounting 33 Thermo 90S Spare Parts 34 Thermo 90 ST Spare Parts 35 Accessories Diesel Cooker 37 Exhaust 38 Fuel System 38 Spare Parts Blower Boxes Florida 5 ; Silencio 2 ; Hercules ED4 41 Madera 4 & Madera 8 42 Madera 4/8 Accessories 43 Mini 12v/240v RV Water Heater 44 Diesel/Electric Water Heater 45 Calorifiers 46 Thermoduct 47 Mechanical Roof Ventilator 48 SMART Controller 49 Part Numbers (in Part number order) Webasto Thermo & Comfort UK Limited Conditions of Sale of Goods and Provision of Services

4 Air Heaters Hot Air - Increased Comfort! The Webasto range of R.V. Air Heater Kits contain specific components suited to the installation and operational requirements for the general R.V. aftermarket. Features include : Remote temperature sensors; Choice of internal floor mounting plates/external mounting options; Exhaust silencer; Wide range of ducting/outlet accessories Air Top 2000 ST Available in 12v (24v on request) Choice of rotary control or digital combi timer Suitable for most panel van conversions or use as an additional independent heater for larger coachbuilt vehicles Petrol version available on request Air Top Evo 3900 / Air Top Evo 5500 MC05RV Range The Air Top Evo Multi Comfort (MC) is a design of control panel for the Air Top Evo 3900 / Air Top Evo 5500 R.V. heaters. Functions: switch on/off; preselection of operational mode; temperature and fan regulation. For the first time, five functions are controllable with only one appliance. Eco-Mode Fast Heating Comfort Heating Altitude Adjustment Ventilation Available in 12v Air Top Evo 3900 is suitable for up to 7.0m coachbuilt vehicles. Can also be used to replace existing gas heater systems and utilise the remaining ducting system (Subject to suitability) External temperature sensor and zero idle current draw Standard kit contains MC05 control panel. Digital timer upgrade kit is available (pricing on request) Zero idle function 4

5 Air Heating Systems Air Top 2000 ST 2.0kW Air Heater Technical Data (tolerance ±10%) Diesel Petrol EG-Type Approval code e1*2001/56*0022*_ e1*2001/56*0022*_ Heating Output Fuel Consumption Control Range Control Range kw l/h Rated Voltage V 12 / Rated Power Consumption Control Range W Heating Air Flow (against 0.5m/bar) Maximum m 3 /h Fuel Type Diesel EN 590 / PME DIN EN / / heating oil EL Petrol EN 228 Operating temperature range ºC -40 to to + 40 Dimensions (LxBxH) Mm 311 x 120 x x 120 x 121 Weight Kg Heater Kits Description Diesel Air Top 2000 ST R.V. Universal kit including rotary control 12v version Base Heater Kit: 41K096A One Outlet Ducting Kit: 41K116C Choice of floor mount plate: Round 41C0193 or Oblong Diesel Air Top 2000 ST R.V. Universal kit including rotary control 12v version Base Heater Kit: 41K096A Choice of floor mount plate: Round 41C0193 or Oblong Choice of Ducting Kit: Two outlet Y Branch Kit : 41K117B or Two Modular outlet kit : 41K118B As above, but with dedicated R.V. External Mounting Box (Part numbers RWA7200, RWA7000, B and 2 x required) in place of floor mount plate. Please note that additional ducting will be required for an externally mounted heater installation. Diesel Air Top 2000 ST R.V. Universal kit including digital timer 12v version Base Heater Kit: 41K096A One Outlet Ducting Kit: 41K116C Timer Upgrade Kit: 41K031A Choice of floor mount plate: Round 41C0193 or Oblong Diesel Air Top 2000 ST R.V. Universal kit including digital timer 12v version Base Heater Kit: 41K096A Choice of floor mount plate: Round 41C0193 or Oblong Timer Upgrade Kit: 41K031A Choice of Ducting Kit: Two outlet Y Branch Kit : 41K117B or Two Modular outlet kit : 41K118B As above, but with dedicated R.V. External Mounting Box (Part numbers RWA7200, RWA7000, B and 2 x required) in place of floor mount plate. Please note that additional ducting will be required for an externally mounted heater installation. RRP Dedicated kits are also available for VW T5 (underseat & underfloor variants) - Price on application 5

6 Air Heating Systems Air Top 2000 Range Air Heaters Operating Controls Item No Description Part No. RRP 1 Rotary Rheostat Control 82819B Rheostat Switch Plate 82422B Temperature Sensor & ECU 5m 12v Temperature Sensor & ECU 5m 24v Remote Temperature Sensor (AT 2000ST) 4 Not Shown Combi Rheostat/Digital Timer Only 12v Combi Timer Upgrade Kit 12v A A B 88206B 41K031A Not Shown Combi Rheostat/Digital Timer Only 24v Combi Timer Upgrade Kit 24v 88205A 41K061A Digital Timer Mounting Kit Digital Timer Housing Not Shown Frost Stat -5 to 15 C A Not Shown Pulse Relay Kit 12v Harness A Not Shown 4 Hour Pulse Relay 12v A Not Shown SMART Surface Mount Controller A Combustion Air & Exhaust Item No Description Part No. RRP 1 Air Intake Silencer Pipe 22mm A Combustion Air Hose 22mm Combustion Air Hose End Cap 24048A Hose Clip 20-27mm A P Clip 25mm Exhaust Silencer 22mm 86450C Exhaust 22mm (S/Steel per m) Exhaust End Cap Exhaust Clamp 22mm 20965A P Clip 25mm Hose Clamp 26-28mm 91383B Exhaust Elbow 22mm 28472C Exhaust Pipe Adaptor 22-24mm 92641A Exhaust Silencer (Leakproof) A Not Shown Silicone Exhaust Grommet 22mm Not Shown Exhaust Lagging 30mm (per m) 41V Not Shown S/Steel Cable Ties (for exhaust lagging) Mounting 3 4 Item No Description Part No. RRP 1 Floor Flattening Tool 82229A POA 2 Base Mount Gasket 82227A Floor Mounting Plate (angled) 41C Plastic Enclosure inc bracket A Not Shown Mounting Box Top Access 86032A Not Shown Floor Mount Plate (flat) Floor Mount Plate (round flange) Floor Mount Plate (oblong flange) C

7 Air Heating Systems Air Top 2000 Range Air Heaters Fuel System 4a Ducting System Item No Description Part No. RRP 1 Plastic Fuel Tank 24 litres C Plastic Fuel Tank 12 litres (no fitting kit incl) B Not Shown Fitting kit for 12l fuel tank A Nylon Fuel Hose 2mm i.d. 5mm od 8m lg Fuel Tank Standpipe 650mm lg 35320A Fuel Tank Standpipe 700mm lg Fuel Tank Standpipe 500mm lg a Fuel Tank Standpipe low profile 495mm lg 41S45017A mm hole 5 Nylon Fuel Hose 2mm id 5mm od per m Fuel Filter Fuel Pipe Connector (Straight) Fuel Hose Clip 10mm Not Shown Fuel Pump Harness 8.5m lg Not Shown Fuel Pipe Connector 90º 34859C 2.44 Not Shown Fuel Cut Off Kit (Switch Type) A Not Shown Fuel Cut Off Kit (tap type) A Not Shown Fuel T Piece Kit 8mm (Refer to Thermo Top C Accessories section for more T Piece options) Item No Description Part No. RRP 1 Ducting PAK (Di.60mm) - per m Not Shown Flexflyte Ducting 60mm (per m) Not Shown 60mm Thermoduct 750mm length 41S70014A Protective Screen 60mm 84937A Air Inlet Grille 60mm 67492A 5.81 Not Shown Outlet/Inlet Grille 60mm (metal) Flap Valve Y Piece (Di. 60mm) A Not Shown Control Switch & Cable for Flap Valve A T Piece 90º (Da 60mm/L 110) Black C Assymetric Y Branch B 7.01 (D1a 60 / D2a 60 / L 145mm) Black 7 Connector Pipe (D1a 60mm) Black C End Cap (D1i 60mm) D Outlet 90º (60mm) - Black Outlet 90º (60mm) - White Outlet 90º (60mm) Grey A A A Outlet 45º (60mm) - Black Outlet 45º (60mm) - White Outlet 45º (60mm) Grey 11 Outlet Closeable (60mm) - Black Outlet Closeable (60mm) - White Outlet Closeable (60mm) Grey A A A A A A Backing Nut (D1a 60mm) Black B T Piece with Connector (D1i/D2a 60mm) B Wall Pipe (60mm) Black C º Elbow (Da 60mm / L 133) 29849A Outlet 60mm Ball Type 360º Not Shown Hose Clamp 50-70mm Ducting Support Bracket A 4.20 Not Shown Backing Nut 60mm (Compact HADS) RWA Not Shown Blanking Cap Black 60mm (Compact RWA HADS) Not Shown Ducting T 60mm (Compact HADS) RWA Not Shown Equal Y Duct Part 60/60/ B

8 Air Heating Systems Air Top 2000 S Air Heater Common Replacement Parts Air Top 2000 Air Top 2000S Item No Description Part No. RRP 1 Inlet/Outlet Screen (Air Top 2000) 29716B Heating Air Outlet (Air Top 2000) 29848F Control Unit Cover (Air Top 2000) 29718B Upper/Lower Plastic Casing (Air Top 2000) 82282A Control Unit 12v Diesel (Air Top 2000) Control Unit 12v Petrol (Air Top 2000) Control Unit 24v Diesel (Air Top 2000) B 87462B 87453B Internal Temperature Sensor (Air Top 2000) 88665A Air Inlet Ring (Air Top 2000) 29717C a Air Inlet Grille (Air Top 2000S) 67492A a Air Inlet Hood (Air Top 2000S) 67490D a Bottom Casing (Air Top 2000S) 67488F a Upper Casing (Air Top 2000S) A a Outlet Hood 60mm (Air Top 2000S) 67491D a Outlet Hood 75mm (Air Top 2000S) 98503B a Supporting Angle (Air Top 2000S) 66967B a Supporting Angle Screw (Air Top 2000S) 70921A Sound Deadening Matting 34473D Drive Assembly 12v Drive Assembly 24v 84841B 70678A Air Guiding Plate 34517B Socket 29845D Flame Detector 82306C Glowpin 12v Glowpin 24v 84906B 82307B Burner Cartridge Diesel Burner Cartridge Petrol 65786A 84883A Burner Tube 82284A Gasket Set 82302A Heat Exchanger 67062B Overheat Protection 82305C Fuel Pump 12v Diesel Fuel Pump 12v Petrol Fuel Pump 24v Diesel 82553B C 47901B Not Shown Wiring Harness (Air Top 2000S Diagnostic) 86514C Not Shown Air Top 2000 / 2000S 12v Service Kit (contains Burner with glowpin & gasket set) Air Top 2000 / 2000S 24v Service Kit (contains Burner with glowpin & gasket set) A A

9 Air Heating Systems Air Top 2000 ST Air Heater Common Replacement Parts Item No Description Part No. RRP 1 Inlet Hood (from serial no ) Inlet Hood A 67490D Outlet Hood 60mm diameter Outlet Hood 75mm diameter 67491D 98503B Control Unit Cover 29718B Upper Plastic Casing A Lower Plastic Casing 67488F Grille 67492A Control Unit 12v Petrol Control Unit 12v Diesel Control Unit 24v Diesel Control Unit 12v Diesel (Camper/Boat Version) A A A A Combustion Air Fan B Drive Assembly 12v (with dosing pump cable from serial no ) Drive Assembly 24v (with dosing pump cable from serial no ) Drive Assembly 12v (with dosing pump cable up to serial no ) Drive Assembly 24v (with dosing pump cable up to serial no ) A A A A Gasket Set A Flame Detector Petrol only B Burner Insert Petrol Burner Insert Diesel 84883A A Glowpin 12v Glowpin 24v A A Burner Tube 82284A Isolator (Pack of 4) A Heat Exchanger Petrol Heat Exchanger Diesel A A Overheat Sensor A Not Shown Fuel Pump 12v Diesel Fuel Pump 12v Petrol Fuel Pump 24v Diesel 82553B C 47901B Not Shown Basic Wiring Harness G Not Shown Air Top 2000 ST 12v Service Kit (contains Burner with glowpin & gasket set) Air Top 2000 ST 24v Service Kit (contains Burner with glowpin & gasket set) A A

10 Air Heating Systems Air Top Evo kW Air Heater Technical Data (tolerance ±10%) Diesel Petrol EG-Type Approval code e1*2001/56*2006/119*0255*_ e1*2001/56*2006/119*0255*_ Heating Output Fuel Consumption Control Range / Plus* Control Range / Plus* kw / 3.9* / 3.9 kg/h / / 0.41 Rated Voltage V 12 / Rated Power Consumption Control Range / Plus* W / / 55 Heating Air Flow (against 0.5m/bar) Maximum m 3 /h 132 / / 139 Fuel Type Diesel EN 590 / PME DIN EN / heating oil EL Petrol EN 228 Operating temperature range ºC -40 to to +40 Dimensions (LxBxH) mm 423 x 148 x x 148 x 162 Weight Kg *Increased heating performance plus possible with control unit MC Multi Comfort (max 60 min with Air Top Evo 3900) Heater Kits Description Diesel Air Top Evo 3900 R.V. Universal kit including standard rotary control 12v version Base Heater Kit: A Control Mount Plate: Choice of floor mount plate: Round 41C0193 or Oblong or Chassis Angled 41C0016 As above, but with dedicated R.V. external mounting box (RWA RWA7400) in place of floor mount plate RRP N.B. Kit does not include any ducting or accessories these are available separately pricing upon application Diesel Air Top Evo 3900 R.V. Universal kit including MC05 control 12v version Base Heater Kit: A Control Mount Plate: Choice of floor mount plate: Round 41C0193 or Oblong or Chassis Angled 41C0016 As above, but with dedicated R.V. external mounting box (RWA RWA7400) in place of floor mount plate N.B. Kit does not include any ducting or accessories these are available separately pricing upon application 10

11 Air Heating Systems Air Top Evo kW Air Heater Technical Data (tolerance ±10%) Diesel Petrol EG-Type Approval code e1*2001/56*2006/119*0256*_ e1*2001/56*2006/119*0256*_ Heating Output Fuel Consumption Control Range / Plus* Control Range / Plus* kw / 5.5** / 5.5** kg/h / / 0.57 Rated Voltage V 12 / Rated Power Consumption Control Range / Plus* W / / 130 Heating Air Flow (against 0.5m/bar) Maximum m 3 /h 200 / / 220 Fuel Type Diesel EN 590 / PME DIN EN / heating oil EL Petrol EN 228 Operating temperature range ºC -40 to to +40 Dimensions (LxBxH) mm 423 x 148 x x 148 x 162 Weight Kg *Increased heating performance plus possible with control unit MC Multi Comfort (max 30 min with Air Top Evo 5500) Heater Kits Description Diesel Air Top Evo 5500 R.V. Universal kit including standard rotary control 12v version Base Heater Kit: A Control Mount Plate: Choice of floor mount plate: Round 41C0193 or Oblong or Chassis Angled 41C0016 As above, but with dedicated R.V. external mounting box (RWA RWA7400) in place of floor mount plate RRP N.B. Kit does not include any ducting or accessories these are available separately pricing upon application Diesel Air Top Evo 5500 R.V. Universal kit including MC05 control 12v version Base Heater Kit: A Control Mount Plate: Choice of floor mount plate: Round 41C0193 or Oblong or Chassis Angled 41C0016 As above, but with dedicated R.V. external mounting box (RWA RWA7400) in place of floor mount plate N.B. Kit does not include any ducting or accessories these are available separately pricing upon application 11

12 Air Heating Systems Air Top Evo Range Air Heaters Operating Controls Item No Description Part No. RRP 1 Rotary Rheostat Control 82819B Not Shown Switch Plate with Vent Switch Adaptor harness for vent switch 92240A A External Temperature Sensor 5m 90821A External Temperature Sensor 20m 92649B Not Shown External Temperature Sensor A m 4 Not Shown 4 Not Shown Combi Rheostat/Digital Timer 12v Combi Timer Upgrade Kit 12v Combi Rheostat/Digital Timer 24v Combi Timer Upgrade Kit 24v 88206B 41K031A 88205A 41K061A Digital Timer Mounting Kit Digital Timer Housing Vent Switch 84586A Not Shown Air Top Evo MC 05 Standard Controller (other versions available) A Not Shown Air Top Evo MC 04 Special A Vehicle Controller Not Shown Frost Stat -5 to 15 C A Not Shown Pulse Relay Kit 12v Harness A Not Shown 4 Hour Pulse Relay A Not Shown SMART Surface Mount Controller A Combustion Air & Exhaust Item No Description Part No. RRP 1 Air Intake Silencer Pipe 90416D Combustion Air Elbow 91563A Combustion Air Hose Assy inc cap 90416D Combustion Air Hose End Cap 29517A Exhaust Silencer 90378C Exhaust Elbow 91564B Exhaust End Cap Exhaust Silencer (leakproof) A Exhaust Clamp 91383B Exhaust 24mm (S/Steel per m) 90394A Not Shown Hose Clip 20-32mm Not Shown P Clip 28mm Not Shown Exhaust Lagging 30mm per m 41V Not Shown S/Steel Cable Ties (for exhaust lagging) (also suitable for Air Top 3500 / 5000 where shown) 12

13 Air Heating Systems Air Top Evo Range Air Heaters Mounting Item No Description Part No. RRP 1 Floor Mount Plate (angled ) 41C Base Mount Gasket 82227A Plastic Enclosure inc bracket A Not Shown External Enclosure Box Not Shown Floor Mount Plate (flat) Floor Mount Plate (round flange) Floor Mount Plate (oblong flange) C Fuel System 3a Item No Description Part No. RRP 1 Plastic Fuel Tank 24 litres C Plastic Fuel Tank 12 litres B (no fitting kit incl) Not Shown Fitting kit for 12l fuel tank A Fuel Tank Standpipe 650mm lg Fuel Tank Standpipe 700mm lg Fuel Tank Standpipe 500mm lg 35320A a Fuel Tank Standpipe low profile 41S45017A mm lg 8.5mm hole 4 Metal Fuel Tank 12 litres Support Bracket (for ) 2 req Banjo M12 5mm hosetail Gasket Fuel Filter Fuel Hose Clip 10mm Fuel Pipe Connector (Straight) Nylon Fuel Hose 2mm id 5mm od per m 12 Nylon Fuel Hose 2mm i.d. 5mm od m lg 13 Fuel Pump Harness 8.5m lg Fuel Pump Harness 7m lg Not Shown Fuel Pipe Connector 90º 34859C 2.44 Not Shown Fuel Cut Off Kit (Switch Type) A Not Shown Fuel Cut Off Kit (Tap Type) A Not Shown Fuel T Piece Kit 8mm (Refer to Thermo Top C Accessories section for more T Piece options) (also suitable for Air Top 3500 / 5000 where shown) 13

14 Air Heating Systems Air Top Evo Range Air Heaters Ducting System Item No Description Part No. RRP Ducting PAK (Di.80mm) - per m Ducting PAK (Di 90mm) - per m Not Shown Flexflyte Ducting 80mm (per m) Flexflyte Ducting 90mm (per m) Not Shown 80mm Thermoduct 750mm lg 100mm Thermoduct 750mm lg A S70015A S70016A Air Inlet Grille 90mm A Embellisher Grille 80mm Chrome (D1 80mm / D2 112) Black Metal Flap Valve Y Piece (Di. 90mm) A Not Shown Control Switch & Cable for flap valve A Y Piece (Da 90mm) Black D Y Piece (D1a 80mm/D2a 60mm) Black B Elbow (Da 90mm) Black C T Piece 90º (Da 90mm/L 140) C 9.77 Black 9 Assymetric Y Branch B 8.70 (D1a 90 / D2a 60 / L 145mm) Black 10 Connector Pipe (D1a 90mm) C 5.70 Black 11 Reducer Black 90-80mm 90-60mm B C End Cap (D1i 90mm) D Outlet 90º (90mm) - Black Outlet 90º (90mm) White Outlet 90º (90mm) Grey 14 Outlet 45º (90mm) - Black Outlet 45º (90mm) White Outlet 45º (90mm) Grey 15 Outlet Closeable (90mm) - Black Outlet Closeable (90mm) White Outlet Closeable (90mm) - Grey A A A A A A A A A Backing Nut (D1a 90mm) Black B T Piece with Connector B 8.52 (D1i 60mm / D2a 90mm) 18 Wall Pipe (90mm) Black C 5.41 Not Shown Ducting Silencer 90mm Ducting Silencer 80mm A Ducting Support Bracket A 4.20 Not Shown Hose Clip 70-90mm (also suitable for Air Top 3500 / 5000 where shown) For 60mm Ducting Accessories, please refer to the Air Top 2000S Section 14

15 Air Heating Systems Air Top 3500 / 5000 Air Heater Common Replacement Parts Item No Description Part No. RRP 1 Control Unit Cover 88005E Top Casing 1 Locating Peg Top Casing 2 Locating Pegs 88003C 98649B Bottom Casing 1 Locating Peg Bottom Casing 2 Locating Pegs 88002C 98648B Inlet Hood 1 Locating Peg Inlet Hood 2 Locating Pegs 88004C 98650B Outlet Hood 1 Locating Peg Outlet Hood 2 Locating Pegs 88096D 98651B Control Unit Air Top v Diesel (Standard) 89838B Control Unit Air Top v Diesel (Standard) 89839C Control Unit Air Top v Diesel (Standard) 89834B Control Unit Air Top v Diesel (Standard) 89836C Control Unit Air Top v Diesel (RV*) 67787B Control Unit Air Top v Diesel (RV*) 67788B *(Must be used with remote temperature probe) 7 Temperature Sensor 88510C Overheat Protection 88489D Sound Deadening Matting 89307D Drive Assembly Air Top v Diesel (Standard) Drive Assembly Air Top v Diesel (Standard) Drive Assembly Air Top v Diesel (Standard) Drive Assembly Air Top v Diesel (Standard) 91381A 91380A 91379A 91378A Glowpin 12v Glowpin 24v 91370B 91371B ** Burner with Glowpin 12v Burner with Glowpin 24v 67984B 67956B Burner Tube Diesel Version 97566A Gasket Set 91364A Heat Exchanger A ** Burner - Standard Heater 67955A Fuel Pump 12v Diesel Fuel Pump 24v Diesel 82553B 47901B Not Shown Universal Wiring Harness Combi Timer Wiring Harness Not Shown Reflector Foil (Pack of 5 pieces) A 8.57 Not Shown Air Top 3500 / v Service Kit (contains Burner with glowpin & gasket set) Air Top 3500 / v Service Kit (contains Burner with glowpin & gasket set) A A ** DEPENDENT UPON HEATER YEAR OF MANUFACTURE/SERIAL NUMBER PLEASE REFER TO WEBASTO TECHNICAL BULLETIN ED088 15

16 Air Heating Systems Air Top 3500 ST / Air Top 5000 ST Air Heater Common Replacement Parts Item No Description Part No. RRP 1 Top Casing Air Top 3500ST/5000ST 98649B Bottom Casing Air Top 3500ST/5000ST 98648B Air Inlet Hood Air Top 3500ST/5000ST 98650B Air Outlet Hood Air Top 3500ST/5000ST 98651B Electronic Control Unit 12v Air Top 3500ST Diesel (Standard Version) Electronic Control Unit 24v Air Top 3500ST Diesel (Standard Version) Electronic Control Unit 12v Air Top 3500ST Diesel (Boat Version) Electronic Control Unit 24v Air Top 3500ST Diesel (Boat Version) A A A A Electronic Control Unit 12v Air Top 5000ST Diesel (Standard Version) Electronic Control Unit 24v Air Top 5000ST Diesel (Standard Version) Electronic Control Unit 12v Air Top 5000ST Diesel (Boat Version) Electronic Control Unit 24v Air Top 5000ST Diesel (Boat Version) A A A A Overheat Temperature Sensor Air Top 3500ST/5000ST A Sound Deadening Matting 89307D Drive Assembly 12v Air Top 3500ST A Drive Assembly 24v Air Top 3500ST A Drive Assembly 12v Air Top 5000ST A Drive Assembly 24v Air Top 5000ST A Glowpin 12v Air Top 3500ST/5000ST A Glowpin 24v Air Top 3500ST/5000ST A Burner Cartridge Air Top 3500ST/5000ST Diesel Only A Burner Tube Air Top 3500ST/5000ST A Gasket Set Air Top 3500ST/5000ST 91364A Heat Exchanger Air Top 3500ST/5000ST A Fuel Pump 12v Diesel 82553B Fuel Pump 24v Diesel 47901B Not Shown Universal Wiring Harness Combi Timer Wiring Harness Not Shown Reflector Foil (Pack of 5 pieces) A 8.57 Not Shown Air Top 3500 / 5000 ST 12v Service Kit (contains Burner with glowpin & gasket set) Air Top 3500 / 5000 ST 24v Service Kit (contains Burner with glowpin & gasket set) A A

17 Air Heating Systems Air Top Evo 3900 / Air Top Evo 5500 Air Heater Common Replacement Parts Item No Description Part No. RRP 1 Top Casing Air Top Evo 3900/ B Bottom Casing Air Top Evo 3900/ B Air Inlet Hood Air Top Evo 3900/ B Air Outlet Hood Air Top Evo 3900/ B Electronic Control Unit 12v Air Top Evo 3900 Diesel Standard Version Electronic Control Unit 12v Air Top Evo 3900 Petrol Standard Version Electronic Control Unit 24v Air Top Evo 3900 Diesel Standard Version Electronic Control Unit 12v Air Top Evo 5500 Diesel Standard Version Electronic Control Unit 12v Air Top Evo 5500 Petrol Standard Version Electronic Control Unit 24v Air Top Evo 5500 Diesel Standard Version Other specialist version control units are available, dependent upon the model Airtop Evo version please refer to Webasto spare parts list pricing available upon request A A A A A A Overheat Temperature Sensor Air Top Evo 3900/ A Replacement Isolator Set Air Top Evo 3900/ A Drive Assembly 12v/24v Air Top Evo 3900 Drive Assembly 12v/24v Air Top Evo A A Glowpin 12v Air Top Evo 3900/5500 Glowpin 24v Air Top Evo 3900/ A A Burner Cartridge Petrol Air Top Evo 3900/ A Burner Cartridge Diesel Air Top Evo 3900/ A Burner Tube Air Top Evo 3900/ A Gasket Set Air Top Evo 3900/ A Heat Exchanger Air Top Evo 3900/ A Screw Set Air Top Evo 3900/ A 4.42 Not Shown Fuel Pump 12v Diesel Fuel Pump 24v Diesel Fuel Pump 12v Petrol 82553B 47901B 82554A Not Shown Universal Wiring Harness 4.8m Lg D Not Shown Reflector Foil (Pack of 5 pieces) A 8.52 Not Shown Air Top Evo 3900 / v Service Kit (contains Burner with glowpin & gasket set) Air Top Evo 3900 / v Service Kit (contains Burner with glowpin & gasket set) A A

18 Air Heating Systems HL90 9kW Air Heater Technical Data (tolerance ±10%) Diesel EG-Type Approval code Heating Output Full Heat Reduced Heat e1*72/245*95/54*1086 e*2001/56*0017* kw Fuel Consumption Full Heat Reduced Heat l/hr Rated Voltage V Rated Power Consumption Full Heat Reduced Heat W Heating Air Flow Full Heat Reduced Heat m 3 /h Dimensions (LxBxH) mm 650 x 235 x 260 Weight Kg Heater Kits Part No Description RRP 83376B Diesel HL90 12v with control box, fuel pump and connectors (does not include input connections & fuel pump plug) C Diesel HL90 24v with control box, fuel pump and connectors (does not include input connections & fuel pump plug) Universal Vehicle Installation Kit (includes fuel tank standpipe, 1m exhaust but excludes ducting & switch option please refer to Accessories Section)

19 Air Heating Systems HL90 Air Heater Operating Controls Item No Description Part No. RRP 1 3 Position Switch 12v/24v Position Switch 12v 2 Position Switch 24v Room Thermostat Unswitched 25011C Room Thermostat Single Switch 70947A Room Thermostat Twin Switch 70948A Digital Timer/Alarm 12v Digital Timer/Alarm 24v 88204A 88195A Timer Mounting Plate Timer Housing Not Shown Universal Wiring Harness 8m Combustion Air & Exhaust Item No Description Part No. RRP 1 Combustion Air Hose 30mm Hose Clip 20-32mm P Clip 34mm 21499A Combustion Air Hose End Cap 30mm 29519A Exhaust 38mm (S/Steel per m) Exhaust End Cap 24046A Exhaust Silencer 19562E Exhaust Clamp 38mm B Elbow for Upwards Exhaust 38mm Not Shown Exhaust Lagging per m Not Shown S/Steel Cable Ties (for exhaust lagging) Fuel System Item No Description Part No. RRP 1 Plastic Fuel Tank 12 litres B (no fitting kit) Not Shown Fitting kit for 12l fuel tank A Fuel Tank Standpipe 700mm lg Fuel Tank Standpipe 500mm lg a Fuel Tank Standpipe low profile 41S45017A mm lg 8.5mm hole 3 Nylon Fuel Hose 2mm id 5mm od per m Not Shown Nylon Fuel Hose 2mm i.d. 5mm od m lgth 4 Fuel Filter Fuel Pipe Connector (Straight) Fuel Hose Clip 10mm Fuel Tank Extractor Fuel T Piece: 6 x 5 x 6 8 x 5 x 8 12 x 5 x x 5 x 15 (Refer to Thermo Top C Accessories section for more T Piece options) B B A Not Shown Fuel Pump Harness 6m lg Not Shown Fuel Pipe Connector 90º 34859C 2.44 Not Shown Fuel Cut Off Kit (Switch Type) A Not Shown Fuel Cut Off Kit (Tap Type) A

20 Air Heating Systems HL90 Air Heater Mounting Item No Description Part No. RRP Not Shown Mounting Box Ducting System Item No Description Part No. RRP 1 Warm Air Ducting 100mm (per m) Not Shown Thermoduct 100mm 750mm 41S70016A length Not Shown Flexiflyte Ducting 100mm (per m) Warm Air Elbow 90º 100mm Not Shown Y Piece 100/100/ Y Branch 100/100/ T Branch 100/100/ Air Outlet 100mm Hose Clamp mm Not Shown Reducer mm Not Shown Ducting Support Bracket A 4.20 For 80mm Ducting Accessories Please refer to Air Top 3900/5500 Section For 60/55mm Ducting Accessories Please refer to Air Top 2000 Section 20

21 Air Heating Systems HL90 Air Heater Common Replacement Parts Item No Description Part No. RRP 1 Electronic Control Unit 12v Electronic Control Unit 24v 33343A 33331A Glowplug , 4, 5 Flame Detection Photocell inc socket A Overheat Protection 97703A Male Fitting for Pipe Double Conical Ring 37640A Pipe Casing 34489A Fan Rotor 33714A Inflow Ring 86554A Motor 12v Motor 24v 35504A 63111A Displacer Atomiser 33094A Fuel Line 34084B Side Channel Fan 84986A Sealing Ring Gasket Ring A Clutch Half (two required) 82531A Air Intake Housing 34037B Resistor 12v 0.45 Ohm Resistor 24v 1.8 Ohm 34530A 34531A Heat Exchanger 97704A Backwall Sealing Rope 82451A Not Shown Fuel Pump 12v 82553B Not Shown Fuel Pump 24v 47901B

22 Integrated Heating Systems Dual Top RHA Technical Data (tolerance ±10%) RHA 100 / RHA 101 / RHA 102 EG-Type Approval code Heater EMC e e Power Output Diesel Electrical kw kw RHA / RHA Fuel Consumption Control Range kg/h Rated Voltage V 12 Rated Power Consumption Control Range W Heating Air Flow (against 0.5m/bar) m 3 /h 200 Fuel Type Diesel EN 590 Operating temperature range ºC -30 to +50 Dimensions (LxBxH) mm 530 x 352 x 256 Weight Kg 20 / 21 / 21 Boiler capacity l 11 Maximum pressure plumbing water Bar 3.5 Heater Kits These kits are available as an authorised dealer supply & fit service only. Due to the specialist nature of the installation requirements, please contact the RV Sales Team for further details and pricing on Accessories Item No Description Part No. RRP 1 Programmable User Interface D (PUI) RHA 100/101/102 2 Dosing pump wiring C harness extension DP 40 1m 2 Dosing pump wiring C harness extension DP 40 3m 2 Dosing pump wiring C harness extension DP 40 5m 2 Dosing pump wiring C harness extension DP 40 7m 3 Operating Control Wiring Harness A Extension RHA 100 3m 3 Operating Control Wiring Harness B Extension RHA 102 3m 4 Air Intake Cover 60mm A Air Outlet 90mm, 90º black A Air Inlet Bellows Kit C Ducting refer to ducting accessories N/A section in Air Top 2000ST / Air Top Evo 8 10/10mm Pushfit /flexipipe conn B /10mm Pushfit/Pushfit conn B Manual User Interface (MUI) B RHA 100 Not Shown Panel Frame for MUI A Not Shown T91 Holiday remote control kit A

23 Integrated Heating Systems Dual Top RHA 100 /101 / 102 Common Replacement Parts Item No Description Part No. RRP 1 Combustion/Cooling Fan RHA 100 / 101 / C Gasket set thermo unit RHA 100 / 101 / B Overheat protector B Control Unit RHA 100 Control Unit RHA 101 Control Unit RHA C A B Burner RHA 100 / 101 / B Wiring Harness (Internal) RHA 100 / 101 / B Cooling Shell RHA 100 / 101 / B Heat exchanger RHA 100 / 101 / B Thermo unit RHA 100 Thermo unit RHA 101 Thermo unit RHA C A A Drain tube RHA 100 / 101 / B Boiler Drainage Solenoid Valve RHA 100 / 101 / A Valve Air Ventilation/Overpressure B End Cap RHA 100 / 101 / B Heating Air Blower Assy c/w PWM RHA 100 / 101 / B Sensor wiring harness RHA 100 / 101 / B Boiler RHA 100 / 101 / A Gasket Set Basic Heater RHA 100 / 101 / B Service Cap RHA B Service Cap RHA 100 / 101 / 102 Diving pump version A Service Cap RHA 101 / B Water pipes RHA 100 / 101 / 102 (2 pieces) A Air Intake Grille RHA 100 / 101 / B Mains Heating Element Kit RHA 101 (2 pieces) Mains Heating Element Kit RHA 102 (2 pieces) C A Wiring harness tubular heater 230v RHA 101/ B Dosing pump v RHA 100 / 101 / B Exhaust Silencer RHA 100 / 101 / A Rubber Bellow Assembly RHA 100 / 101 / C Hammer Screws (qty 6) B Bag with Screws RHA 101 / A Relay Box RHA 101 / v A Air Intake Cover (D60) RHA 100 / 101 / A External Temperature Sensor RHA 100 / 101 / B Not Shown Dual Top RHA 100/101/102 12v Service Kit (incl burner & gasket set) A Not Shown Seal Boiler (Dual Top) A

24 Water Heaters Comfort, safety and convenience Compact design Robust combustion technology and dependable operation Broad spectrum of applications Thermo Top Range Thermo 90 ST 24

25 Water Heating Systems Thermo Top C 300 Motorcaravan Parking Heater Technical Data (tolerance ±10%) Diesel EG-Type Approval code e1*2001/56*0002*_ Heat Output Partial/Full Load kw 2.5 / 5.2 Fuel Consumption Partial/Full Load kg/h 0.3 / 0.61 Rated Voltage V 12 Rated Power Consumption with circulation pump Partial/Full Load W Fuel Type Diesel / PME-mix, with <50% PME-part Operating temperature range ºC -40 to + 60 Dimensions (LxBxH) mm 214 x 106 x 168 Weight Kg 2.9 Heater Kits Part No Description RRP 41K107D Panel Van/Small Van (Universal Kit) Diesel Thermo Top C kW Universal quick heat independent hot water system complete with header tank, plate heat exchanger, mixer valve, one heater blower, dedicated panel switch, associated pipework, fittings etc Note: Use one blower box for small van (e.g. VW Transporter size). Use an additional Silencio 2 Blower Box for larger sized vehicles (e.g. Fiat Ducato/Renault Master). Refer to blower box section for part numbers and pricing) 25

26 Water Heating Systems Thermo Top C kW Parking Heater Technical Data (tolerance ±10%) Diesel EG-Type Approval code e1*2001/56*0002*_ Heat Output Partial/Full Load kw 2.5 / 5.2 Fuel Consumption Partial/Full Load kg/h 0.3 / 0.61 Rated Voltage V 12 Rated Power Consumption with circulation pump Partial/Full Load W Fuel Type Diesel / PME-mix, with <50% PME-part Operating temperature range ºC -40 to + 60 Dimensions (LxBxH) mm 214 x 106 x 168 Weight Kg 2.9 Heater Kits Description Part Number (s) RRP Fiat Ducato 2.3/2.8 (Model Year ) C Fiat Ducato PS (Model Year 2006) A B Fiat Ducato PS (Model Year 2006) A D Fiat Ducato PS (Model Year 2006) A B Ford Transit 2.0 /2.4 (Model Year ) B Ford Transit 2.2 for front wheel drive (Model Year 2006) A B Ford Transit 2.4 for rear wheel drive (Model Year 2006) A B Iveco Daily 3.0 (Model Year 2006) A B Iveco Daily 3.0 (Model Year 2010) Euro A B A Mercedes-Benz Sprinter 2.2/3.0 (Model Year 2006) A A Renault Master 2.5/3.0 (Model Year ) C Renault Master 2.5/3.0 (Model Year 2006) A A Please note: The contents of the above kits are based on LHD vehicles and can generally be adapted for RHD installation, however, other minor parts may be required to fulfil the installation. Standard parking heater systems are also available, please refer to the Vehicle Product Price List for pricing 26

27 Water Heating Systems Thermo Top Range Water Heaters Operating Controls Item No Description Part No. RRP 1 T91 Handset Upgrade Kit A T91 Handset Only A HTM T100 Upgrade Kit A HTM T100 Handset Only A Not Shown Receiver T91/HTM A Digital Timer (60 mins) Oval Type D Not Shown Digital Timer (60 mins) Square 35967B Not Shown Automatic blower control kit A Not Shown 3 Gang Panel Switch 41M Not Shown Plug kit for 3 gang Panel Switch 41N Not Shown Frost Stat -5 to +15 C A Not Shown 4 hour Pulse Relay 12v A Not shown Pulse Relay Kit Harness 12v A Combustion Air & Exhaust Item No Description Part No. RRP 1 Combustion Air Pipe 25mm 23298A C/Air Pipe End Cap 25mm 29516B Hose Clip 20-27mm A Flexible Exhaust 22mm (per m) Exhaust Silencer 22mm 86450C P Clip 25mm Protection End Cap Exhaust Clamp 24-27mm A 7.08 Not Shown Exhaust Lagging 41V Not Shown Cable Ties (S/Steel for Lagging) Not Shown Exhaust Adaptor 22-24mm 92641A Mounting Item No Description Part No. RRP 1 Universal Mounting Bracket TTE/C 87394B Universal Mounting Bracket 28382A

28 Water Heating Systems Thermo Top Range Water Heaters Fuel System Item No Description Part No. RRP 1 a) Fuel Tank Standpipe 500mm lg b) Fuel Sender 8mm c) Fuel Sender 90º 300mm lg d) Fuel Sender 6mm e) Fuel Extractor Low Profile f) Fuel Tank Standpipe low profile 495mm lg 8.5mm hole B A C 41S45017A Nylon Fuel Hose 2mm id 5mm od Nylon Fuel Hose 2mm i.d. 5mm od 8m length Fuel Filter Fuel Pipe Connector (Straight) f 6 Fuel Hose Clip 10mm Fuel T Piece(s) 6 x 5 x 6 (J Shape) 8 x 5 x 8 (J Shape) 10 x 5 x 10 (J Shape) 12 x 5 x 12 (J Shape) 6 x 5 x 6 (T shape Metal) 8 x 5 x 8 (T shape Metal) 10 x 5 x 10 (T shape Metal) 12 x 5 x 12 (T shape Metal) 15 x 6 x 15 (T shape Metal) 6 x 5 x 6 (T shape Plastic) 8 x 5 x 8 (T shape Plastic) 10 x 5 x 10 (T shape Plastic) 12 x 5 x 12 (T shape Plastic) B B B A B B B B A 66944A B 66946A 98052A Tank Extractor 5mm Tank Extractor VAG Group B Tank Extractor (15mm Fuel Hose) Tank Extractor (18mm Fuel Hose) Tank Extractor (20mm Fuel Hose) 86277A 86379A 67435A Not Shown Fuel Pipe Connector 90º 34859C

29 Water Heating Systems Thermo Top Range Water Heaters Water System Item No Description Part No. RRP 1 Formed Hose 90º Di18/Da Formed Hose 180º Di 18/Da 25 Di 20/Da A Formed Hose Di18/Da Formed Hose Di18/Da mm lg Di18/Da mm lg Di20/Da mm lg A Formed Hose Di18/Da25 576mm lg Di18/Da mm lg 6 Formed Hose 1020mm lg Di15/Da22 Di18/Da27 Di22/Da A A Formed Hose D1i15/D1a22; D2i18/D2a Straight Coolant Hose Di15/Da mm lg Di18/Da mm lg Not shown Coolant Hose (sold as a 15m roll) 15mm-5/8 i.d. 16mm-5/8 i.d. 19mm-3/4 i.d S30013A G Item No Description Part No. RRP 1 Connecting Tube: D1a15/D2a18 D1a18/D2a20 D1a18/D2a22 D1a20/D2a20 D1a20/D2a A 66908B 66932A 66934C 19867B T Piece: D1a15/D2a15 D1a18/D2a15 D1a18/D2a18 D1a20/D2a15 D1a20/D2a A Connection Pipe 18mm T Piece Da15 65mm lg Da18 100mm lg 5 In line Bleed Valve Da15 Da18 6 T Piece with Bleed Valve Da15 Da18 7 One Way Valve without Junction Da15 104mm lg Da18 100mm lg Da18 90mm lg Da20 100mm lg A 12706A A Not Shown 19-19mm brass hose connector 41H Not Shown Dual T Piece 41K Not Shown Hose Adaptor B 5.54 Not Shown 5 litre plastic expansion tank kit 41K5210A Other Valves and T Pieces are available upon request 29

30 Water Heating Systems Thermo Top Range Water Heaters Common Replacement Parts Item No Description Part No. RRP 1 Diesel Combustion Air Motor 12v TTE/C B Diesel Burner Cartridge c/w Glowpin 12v Standard 92995D Diesel Burner Head/Heat Exchanger/Control Unit TTC (Std) Diesel Burner Head/Heat Exchanger/Control Unit TTE Diesel Burner Head/Heat Exchanger/Control Unit TTC 300 MODEL (RV & Marine Version) 92998G D C Water Pump U v TTE/C B Water Pump Housing 193º - TTE/C 93011C Water Pump Housing Axial TTE/C 93012C 8.36 Not Shown Fuel Pump 12v 82553B Not Shown Gasket Set A FOR PETROL HEATER COMPONENTS, PLEASE REFER TO RELEVANT TECHNICAL SPARE PARTS HANDBOOK 30

31 Water Heating Systems Thermo 90 ST 9.1kW Water Heater Technical Data (tolerance ±10%) Diesel Petrol EG-Type Approval code e1*2001/56*2004*78*0019 e1*2001/56*2004*78*0019 Heat Performance Fuel Consumption Control range/boost mode Control range/boost mode kw / kg/h / Rated Voltage V 12 / Rated Power Consumption Control range/boost mode W / Fuel Type Diesel EN590 (B5) / Arctic Diesel / heating oil (EL) Petrol EN 228 ROZ 91 / 95 / 98 Operating temperature range ºC -40 to to + 80 Dimensions (LxBxH) mm 355 x 133 x x 133 x 232 Weight Kg Heater Kits Due to the diverse nature of installation requirements, please contact the Webasto Sales Team for pricing and application to suit your exact needs. 31

32 Water Heating Systems Thermo 90 ST / Thermo 90 S Water Heater Operating Controls Item No Description Part No. RRP 1 2 Position Switch 12v 2 Position Switch 24v Room Thermostat Unswitched 25011C Room Thermostat Electrical 34875A Room Thermostat Sensor 82356A Timer Mounting Plate Timer Housing Digital Timer/Alarm 12v Digital Timer/Alarm 24v 88204A 88195A Combustion Air & Exhaust Fuel Supply 3a 3a Item No Description Part No. RRP 1 Intake Silencer Pipe Combustion Air Hose 30mm Hose Clip 20-32mm P Clip 34mm 21499A 3.29 Not Shown Combustion Air Hose End Cap 30mm 29519A Exhaust Silencer 19562E Exhaust 38mm (S/Steel per m) Exhaust End Cap 24046A Exhaust Clamp 38mm B P Clip 42mm Mounting Strip Not Shown Exhaust Lagging Not Shown S/Steel Cable Ties (for exhaust lagging) Item No Description Part No. RRP 1 Plastic Fuel Tank 24 litres C Plastic Fuel Tank 12 litres (no fittings) B Not Shown Fitting kit for 12l fuel tank A Fuel Tank Standpipe 650mm lg Fuel Tank Standpipe 700mm lg Fuel Tank Standpipe 500mm lg 35320A a Fuel Tank Standpipe low profile 41S45017A mm lg 8.5mm hole 4 Fuel Tank Extractor 98605C Fuel Tank Extractor Fuel T Piece: 6 x 5 x 6 8 x 5 x 8 12 x 5 x x 5 x 15 (for plastic versions please refer to Thermo Top C fuel accessories section) B B A A Fuel Filter Nylon Fuel Hose 2mm id 5mm od per m Not Shown Nylon Fuel Hose 2mm i.d. 5mm od 8m length 9 Fuel Pipe Connector (Straight) Fuel Hose Clip 10mm Not Shown Fuel Pump Harness 90216B Not Shown Fuel Pipe Connector 90º 34859C 2.44 Not Shown Fuel Cut Off Kit (Switch Type) A Not Shown Fuel Cut Off Kit (Tap Type) A

33 Water Heating Systems Thermo 90 ST / Thermo 90 S Water Heater Water System Item No Description Part No. RRP 1 Thermostat Valve 20mm 19872A Hose 20mm/ 2.2m lg 33894A Hose Clamp 20-27mm A Connecting Tube 18 x B Connecting Tube 20 x C T Pieces: 15mm 20 x 15mm 20mm A Check Valve 20mm 19873A Elbow 22524B Not Shown 19-19mm brass hose connector 41H Not Shown Dual T Piece 41K Not Shown Hose Adaptor B 5.54 Not Shown 5 litre plastic expansion tank kit 41K5210A Item No Description Part No. RRP 1 Formed Hose 180º Di20 Da A Formed Hose 180º Ends Di20 Da lg 33894A Formed Hose Di15 Da lg Di22 Da lg 21488A Formed Hose D1i 15/D1a22; D2i 18/D2a Straight Hose Di 15/Da mm lg Not shown Coolant Hose (sold as a 15m roll) 15mm-5/8 i.d. 16mm-5/8 i.d. 19mm-3/4 i.d. 41S30013A G Mounting Item No Description Part No. RRP 1 Universal Mounting Plate 20583A Control Box Mounting Holder 88746D

34 Water Heating Systems Thermo 90 S Water Heater Common Replacement Parts Item No Description Part No. RRP 1 Combustion Air Fan 12v Combustion Air Fan 24v 90214A 90215B Hose Clamp Gasket Ring 34888A Gasket Ring 83515B Flame Detector 82407B Glowpin 12v Glowpin 24v 82408B 82410B Temperature Sensor 41244G Gasket Ring Overheat Protection 37955C Water Pump 12v Water Pump 24v 86568A 86569A Gasket Ring 22405B Water Pump Mounting Bracket 86252A Protection Cap 38641C Burner Cartridge (Standard Heater) Diesel A Gasket Ring 83230A Burner Tube 82415B Heat Exchanger (U4846 pump) 86244C Fuel Pump 12v Fuel Pump 24v 19 Control Unit 12v Control Unit 24v 82553B 47901B A 89093E Not Shown Harness Heater to Control Box 90223B Not Shown Harness Control Box to Switch 90228B Not Shown Thermo 90 / S 12v Service Kit (contains Burner with glowpin, flame detector & gasket set) Thermo 90 / S 24v Service Kit (contains Burner with glowpin, flame detector & gasket set) A A

35 Water Heating Systems Thermo 90 ST Water Heater Common Replacement Parts Item No Description Part No. RRP 1 Combustion Air Fan 12v Combustion Air Fan 24v A A Hose Clamp Gasket Ring 34888A Gasket Ring 83515B Flame Detector B Glowpin 12v Glowpin 24v B B Temperature Sensor A Gasket Ring A Overheat Protection A Taptite Self Tapping Screw Set A Water Pump U v Water Pump U v A A Mounting Parts Set U4846 Pump A Burner Cartridge Diesel A Gasket Ring 83230A Mounting Parts Set for Burner Head A Inlet Guide Plate 32151B Burner Tube 82415B Tightening Clamp 21295A Heat Exchanger (U4846 pump) 86244C Control Unit SG v Control Unit SG v A A Not Shown Not Shown Fuel Pump 12v Fuel Pump 24v Thermo 90 ST 12v Service Kit (contains Burner with glowpin, flame detector & gasket set) Thermo 90 ST 24v Service Kit (contains Burner with glowpin, flame detector & gasket set) 82553B 47901B A A

36 Accessories Complete solutions for R.V. Diesel Cooker Blower Boxes 36

37 Accessories Diesel Cooker X100 Technical Data (tolerance ±10%) EG-Type Approval code GS / Fi /CE : / Heating Output Control Range kw Fuel Consumption Control Range kg/h Rated Voltage V 12 Rated Power Consumption Control Range W 0.3 (with start 8) Heating up time min 3 Fuel Type Diesel EN 590 Maximum temperature cooking field ºC 550 Dimensions (Ceran cooking field) LxWxH mm 466x316x50 Dimensions (Ventilation box) LxWxH mm 565x366x172 Weight Kg 9.5 Unit Part No Description RRP WA90000B Diesel Cooker X100 including universal installation kit

38 Accessories Diesel Cooker X100 Exhaust Item No Description Part No. RRP 1 Exhaust 28mm diameter 3m length A Exhaust 28mm diameter 20m roll A Exhaust 28mm diameter 1.9m length A Hose Clamp 30-35mm B Cooling air hose APK 60mm diameter Hose Clamp DIN mm A Hose Clamp 62mm Fuel Supply Item No Description Part No. RRP 1 Fuel hose (per m) Fuel filter Fuel hose connector Fuel T piece 8 x 5 x 8 (plastic) B Hose clamp 10mm A Hose clamp 12mm Fuel connector cooker fuel pump WA

39 Accessories Diesel Cooker X100 Common Replacement Parts Item No Description Part No. RRP 1 Fuel Pump FC1 WA Combustion Blower WA Mounting flange for power connector WA Terminal block male for power connector WA Control unit XPS WA Hot plate indication LED WA Overheat thermostat complete incl wire set WA Table mounting bracket (Qty 2) WA CERAN Glass plate WA Gasket for CERAN Glass plate WA Silicone glue for CERAN Glass plate WA Fuel pipe WA Gasket for glowplug WA Glowplug WA Fixing bracket for glowplug WA Thermo element T4 + gasket WA Gasket for thermo element T4 WA Fixing bracket for thermo element T4 WA Reflector plate 1 WA Burner Cylinder Assembly WA Radiation element WA Burner Cylinder WA Burner matting 85mm diameter with spring WA Burner outer cylinder WA Burner collar assembly WA Burner chamber bottom section WA601928KOK

40 Accessories Diesel Cooker X100 Common Replacement Parts Item No Description Part No. RRP 1 Ventilation box WA Front plate assembly WA Ventilation fan WA Seal 25mm diameter WA Seal 38mm diameter WA Operating Panel WA Fuse A Operating panel wiring harness 2m long WA Wiring harness for high altitude switch WA Power cable with connectors 4m long WA Wiring harness for glowplug WA B Grounding wiring harness WA

41 Accessories Blower Boxes Florida / Silencio / Hercules range Technical Data (tolerance ±10%) Florida 5 Silencio 2 Hercules ED4 Heating Output kw Dimensions (L x B x H) mm 269x218x x125x x241x130 Weight Kg Rated Input W Airflow m 3 /h Units Part No Description RRP A Florida 5 with control 12v A Florida 5 with control 24v A Florida 5 without control 12v A Florida 5 without control 24v T0034 Silencio 2 12v S80003A Silencio 2 24v A Hercules ED4 12v (supplied with 4 x 55mm spigots) S80011A Hercules ED4 24v (supplied with 4 x 55mm spigots) Accessories Part No Description RRP 41K119A Universal Coolant Hose Kit (inc 7.5m length of 16mm coolant hose, various joiners, t pieces, clips) A Automatic Blower Control Kit

42 Accessories Blower Boxes Madera range Technical Data (tolerance ±10%) Madera 4 Madera 8 Heating Output kw Dimensions (L x B x H) mm 275x203x x250x115 Weight Kg Rated Input W Airflow m 3 /h Fan Speed 3 3 Units Part No Description RRP Madera 4 12v (supplied with 2 x 90/90 Louvred Grilles as standard) Madera 4 24v (supplied with 2 x 90/90 Louvred Grilles as standard) Madera 8 12v (supplied with 4 x 90/90 Louvred Grilles as standard) Madera 8 24v (supplied with 4 x 90/90 Louvred Grilles as standard)

43 Accessories Blower Boxes Madera range accessories Madera 4 Madera 8 Madera Accessories Part No Description Qty Reqd Madera 4 Qty Reqd Madera Grille (90x90) Outlet 55mm straight Outlet 45mm Outlet 45mm Air Outlet Closeable Electronic speed control 12v/24v RRP Electronic speed control with on/off switch 12v/24v K120A 3 Speed rotary blower switch K119A Universal Coolant Hose Kit (inc 7.5m length of 16mm coolant hose, various joiners, t pieces, clips)

44 Accessories Mini 12v / 240v R.V. Water Heater Technical Data (tolerance ±10%) Rated voltage V 12/240 Electric element power consumption 12v 240v W Pressure relieve valve rating Bar 4 Water storage period Average time Hours 6-8 Dimensions of heater LxBxH mm 320x230x x250x250 = total length/foot width Weight of heater Kg 6 Capacity litres 6 Water connection fittings ½ BSP Unit Part No Description RRP 41S80013A Mini R.V. Water Heater

45 Accessories Diesel / Electric Water Heater System Technical Data (tolerance ±10%) Rated voltage V 240 Electric element power consumption 240v W 2000 Pressure relieve valve rating Bar 4 Water storage period Constant Maintained by device Dimensions of heater HxD mm 318 x 275 Dry Weight of heater Kg 11.6 Capacity litres Typically 6-8 Hot Water 6 C Up to C Water connection fittings ½ BSP Unit Concept The concept of the mini water heater is to produce hot water via mains electric or a diesel fired coolant heater. The heated water is then stored within the insulated tank ready for use as required. The water heater does not need to be connected to the engine, therefore there are no conversion issues to be addressed with the vehicle manufacturer. The system is heated to approximately 80 C. At the set temperature, the thermostat turns off the mains electric or diesel heater. The system design allows extremely quick hot water production and recovery. Heating The system can be connected to a Webasto Thermo Top diesel heater and incorporated into a wet heating system Heat is produced by active or dynamic heating modules When connected into a heating circuit, the mains system can also be used for heating Pricing available upon request 45

46 Accessories Calorifiers Technical Data (tolerance ±10%) Horizontal Vertical Capacity Litre Dimensions inc. fittings LxWxH (mm) 575x240x x260x395 Weight Kg Units Part No Description RRP 41S40048A Horizontal 10 litre calorifier A Vertical 10 litre calorifier Accessories Part No Description RRP A ½ BSP x 16mm A ½ BSP x 19mm

47 Accessories Thermoduct Webasto Thermoduct is constructed using market leading Thermal Insulation Material. The material is stitched into 750mm long tubes and is designed to slide directly over warm air ducting, providing exceptional thermal insulating properties. Temperature Resistant up to 40ºC Hydrophobic actually repels water, thus preventing mould & mildew Hypoallergenic Easy to handle Can double the effective heat output from air heaters by minimising ducting heat loss Allows long ducting runs to provide effective heat output Reduces heater running times, improving fuel and electrical power consumption Reduces external duct temperature from circ. 100º to 30ºC Part No Description RRP 41S70014A 60mm Thermoduct 750mm length S70015A 80mm Thermoduct 750mm length S70016A 100mm Thermoduct 750mm length

48 Accessories Mechanical Roof Ventilator Mechanical roof ventilator, assembled with 2 ball bearings. Supplied with black polycarbonate air diffuser. Part No Description RRP Autogire Mechanical Roof Ventilator ABS in white

49 Accessories SMART Surface Mount Controller Product Features: Simple surface mount installation Simple and ergonomic ON/OFF rotary switch Ventilation mode with adjustable speed Heating mode with temperature set point display LED and symbol indication of heating and ventilation Ambient temperature display (as default display) Integrated temperature sensor 12 or 24v operation (one variant) Diagnostic readout Timed shut down option Timed back light (time can be set in engineer mode) Hours counter (can be reset in engineer mode) Adjustable C to F display for international markets E11 Type Approved Part No Description RRP A KIT - SMART Surface Mount Controller for Air heaters

50 Full Product Listing (Part Number Order) All products are subject to availability. In particular, Webasto Thermo & Comfort UK Limited are unable to guarantee the ongoing availability of replacement parts for older heaters, in particular:- HL18/HL24/HL32/HL20/HL30/HL65/HL95/HL125 Air Top 18/24/32 models Please note that whilst every effort has been made to include the most common parts available, this listing is not exhaustive. Please contact our Sales Office if you require any further assistance. 50

51 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Connector Plug Clip - DBW Sensoric Y Piece 80mm Variable Flap Valve 80mm Combustion Air Fan - HL30/ Water Pump U v Variable Flap Valve 55mm Wall Pipe Connector 55mm Wall Pipe Connector 80mm Outlet/Inlet Hood 55mm 90º Hood - HL65/ Air Outlet 55mm 90º Louvre Warning Label Hose Clip Motor Mount Ignition Unit 12v Ignition Unit Switch Two Position Rotary On/Off 12v Switch Two Position Rotary On/Off 24v Electronic Ignition Unit DBW470 24v Heat Exchanger HL30 - Downward Exhaust Washer - HL30/ Washer - HL30/38/ Heat Exchanger - DBW2020/350 Sensoric 1, Fuel Drain Tube - HL Nozzle Holder Plate - DBW Switch - Three Position Rotary On/Off/Vent 12v Switch - Three Position Rotary On/Off/Vent 24v Micro Switch - HL Ident Label - HL Screw - Thermo Combustion Air Intake Elbow 22mm - AT Hexagon Head Screw M5 x 50 - AT Fuel Hose 70mm lg Connector Plug for Rotary Switch Control Unit 12v - B/DBW Control Unit 24v - B/DBW Formed Hose Di18/Da mm lg Heat Exchanger Downward Exhaust - DBW2010 Sensoric Burner Head - DBW2010 2, In line bleed valve 18mm o.d Spur Wheel Kit - HL Gasket Flange - HL Air Intake - HL U Clamp

52 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Motor 12v - DBW Control Stat & Gasket - DBW2010 Sensoric Fan - HL Spacer - HL Flame Ring - HL Fuel Tank Fitting Bowden Cable 850mm lg Air Outlet 55mm 45º Louvre Fuel Supply Pipe Air Outlet 80mm 90º Louvre Air Outlet 80mm 45º Louvre Jointing Paste Curil T AT 100g Control Cable 1.5m lg Cable Support U Bracket Overheat Fuse 138º - B/DBW Turnbuckle One Way Valve No Junction Nozzle Holder Pre Heat Kit 24v - DBW Three Position Switch Plate Adhesive Fan/Off/Heat Wiring Harness & Cap Switch Two Position inc connector & plate 12v Switch Two Position inc connector & plate 24v M8 Allen Screw A Temperature Sensor Screw M4 x Underseal Compound Aerosol Fuel Supply Line - DBW2010 Sensoric Fuel Supply Banjo Pipe - DBW One Way Valve Double T 20mm End Cover Assembly - B/DBW Burner Head Assembly - B/DBW T Piece 18mm 100mm lg T Piece with Bleed Valve Burner Matting (Diesel) - DBW Exhaust Clamp 80mm Wiring Harness - DBW Wiring Harness - B/DBW Connector Clamp Gasket (Heat Exchanger) - HL/AT Check Valve Switch Plate Two Position Off/Heat Wiring Harness Flame Detector Photocell - DBW Sensoric Overheat Protection

53 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Overheat Thermostat - DBW Sensoric Outlet/Inlet Hood 80mm 90º - AT Gasket Ring - HL Flame Detector - HL/AT Clamp - DBW Burner Matting Petrol - HL Burner Matting Diesel - HL/AT Burner Matting Diesel - HL/AT Adaptor - DBW Marine Mounting Bracket - AT18/ T Piece 15mm 65mm lg Heat Exchanger - DBW Hose Clamp Autogire Mechanical Roof Ventilator ABS in white Carrier Plate Profiled Seal - B/DBW Anti-Rad Disc - HL Resistor Digital Timer 12v - B/DBW Connection Pipe 18mm A Cover Disc - HL Fuel Tank 10 Litre Hollow Screw - M12 x Hose Clip 38mm Fuel Tank 25 Litre Fuel Tank 60 Litre Fuel Tank 35 litre Fuel Tank 35 litre metal Water Pump 24v U Exhaust P Clip Water Hose 20mm 2.2m 180º Ends A One Way Valve without Junction 18mm A One Way Valve Double T 18mm A One Way Valve without Junction 15mm A Check Valve B One Way Valve Single T 18mm Louvre Plate 310mm x 240mm Warm Air Elbow 90º 80mm Warm Air Elbow 90º 100mm T Piece 100 x 100 x Relay 24v A Switch HL30/HL A Fuel Standpipe A Wiring Harness Heater Control

54 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Wiring Harness A Cable A Harness Retrofit T90ST ECU to T90 Heater B External Temperature Sensor 12v AT2000S D Digital Timer (Oval Shape) A Water Pump Aquavent 5000S 24v U A Securing Strap HL A Junior Timer Terminal A U4854 Water Pump 24v A U4854 Water Pump 24v A Protection Cover HL B Combustion Air Fan AT2000ST A Drive Assembly 12v AT2000ST (with dosing pump cable from serial no ) B Drive Assembly 12v AT2000ST (with long dosing pump cable from serial no ) A Drive Assembly 24v AT2000ST (with dosing pump cable from serial no ) A Burner Insert Only AT2000ST A Heat Exchanger Diesel AT2000ST A Stud Bolt Set Air Top EVO 3900/ A Hose Clamp 20-27mm A Isolator AT2000ST/AT EVO 3900/ A Screw Set A Fuel Nozzle 7 Bar - DBW2010/ A Gasket Set AT2000ST A Drive Assembly 12v AT2000ST (with dosing pump cable) A Drive Assembly 24v AT2000ST (with dosing pump cable) B Ignition Electrode DBW Air Outlet 100mm A Self Tapping Screw A Taptite Screw Bracket to Heater B T Piece 6 x 5 x B T Piece 8 x 5 x B T Piece - 10 x 5 x B T Piece 12 x 5 x B Fuel T Piece 6 x 5 x 6 "J" Shape B Fuel T Piece 8 x 5 x 8 "J" shape B Fuel T Piece 10 x 5 x 10 "J" Shape A Fuel T Piece 12 x 5 x 12 "J" shape A Anti Vibration Mount M A Mounting Stud - AT A Fuel T Piece 15 x 5 x A Screen Inlet/Outlet AT EVO 3900/AT A Mounting Bracket Clamp 40-50mm - AT

55 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Hexagon Nut - HL A Screw M3 x D Programmable User Interface (PUI) RHA 100/101/ A Self Tapping Screw B Manual User Interface (MUI) RHA A Filister Head Screw A Olive Nut M A Hose Clip 8mm A Anti Vibration Mount A Hose Clamp 60-80mm A Ducting Support Bracket A Hose Clip 10 mm A Motor - AT2000ST - Daimler Chrysler A Central End Cover T Exhaust Seal - HL/AT A Air Outlet 55mm A Combustion Air Inlet Extension Pipe A Hose Clamp 16-24mm B Y Branch 60/60/ Intake Extension - HL A Exhaust Clamp 24-27mm Set of Parts C Dosing pump wiring harness extension DP 40 1m C Dosing pump wiring harness extension DP 40 3m C Dosing pump wiring harness extension DP 40 7m A Drive Assembly - AT EVO A Burner c/w Glowpin 12v Petrol Air Top EVO 3900/ B Wiring Harness - AT EVO 3900/5500 Marine - Length 9500mm A Burner c/w Glowpin 12v Diesel Air Top EVO 3900/ A Burner c/w Glowpin 24v Diesel Air Top EVO 3900/ A Burner Cartridge Petrol - Air Top EVO 3900/ A Burner Cartridge Diesel - Air Top EVO 3900/ A Electronic Control Unit 12v - Air Top EVO 5500 Diesel Standard Version A Electronic Control Unit 12v - Air Top EVO 5500 Petrol Standard Version A Electronic Control Unit 24v - Air Top EVO 5500 Diesel Standard Version A Electronic Control Unit 12v - Air Top EVO 3900 Diesel Standard Version A Electronic Control Unit 12v - Air Top EVO 3900 Petrol Standard Version A Electronic Control Unit 24v - Air Top EVO 3900 Diesel Standard Version A Overheat Temperature Sensor Air Top EVO 3900/ A Control Panel Marine 12v/24v Rubber Mounting A Air Top Evo MC05 Special Vehicle Controller B Control Panel RV 12v/24v A Control Panel MC 05 12v/24v

56 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Warm Air Silencer 80mm A Combustion Air Intake Silencer - HL/AT A Gasket Ring - HL65/95/ A Adaptor Harness for Vent Switch A Glowpin 12v - Air Top EVO 3900/ A Glowpin 24v - Air Top EVO 3900/ A Heat Exchanger - Air Top EVO 3900/ A Connecting Tube B hose adaptor B Coolant Hose Joiner 18 x 18mm A Air Top Evo 5500 Slave Heater Automatic 24v 1, A Air Top Evo 5500 Slave Heater Automatic 12v 1, A Air Top Evo 3900 Slave Heater Automatic 12v 1, A Air Top Evo 3900 Slave Heater Automatic 24v 1, A U v B Fuel Pump 24v DW A Motor 24v - DBW A T91 Handset Upgrade Kit A T91 Handset only A HTM T100 Upgrade Kit A HTM T100 Handset Only A Receiver T91/HTM T A U v A U v A U v A U v A Circulation Pump U A U v A Bag with Screws RHA 101 / A Thermo unit RHA 101 1, A Thermo unit RHA 102 1, A Control Unit RHA B Control Unit RHA A Exhaust Silencer RHA 100 / 101 / A Relay Box RHA 101 / v A Water pipes RHA 100 / 101 / 102 (2 pieces) A Air Intake Cover 60mm A Service Cap RHA 100 / 101 / 102 Diving pump version A Panel Frame for MUI A Split Pin - Thermo Combustion Air Intake Extension - HL A Thermostat Nozzle Pre-heat - DBW A Flame Detector HL Fuel Cap for Plastic Fuel Tank

57 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Exhaust Pipe Extension - HL Intake Pipe Extension 80mm - DBW Support Bracket Fuel Tank 12 Litre (2 required) Support Bracket Fuel Tank 25 Litre (2 required) Support Bracket - HL Bolt Securing Strap for 12 Litre Fuel Tank (two required) Securing Strap - HL Cross Arm Turnbuckle Fuel Hose - HL Low Pressure Ball Valve - DBW One Way Valve Mounting Bracket Support Bracket for Solenoid Valve - HL30/ T Piece 38mm Control T Piece 15mm T Piece - 18 x 15 x T Piece 20 x 15 x Gasket - HL P Clip 12mm Hose Clip 70-90mm Hose Clip mm Hose Clip 60-80mm Hose Clip 40-55mm Hose Clip 40-50mm Fuel Filter Assembly - DBW In-line Fuel Filter 6-8mm Fuel Filter Assembly (glass) Fuel Balancer Valve - HL18/2011/2012/32B Flexible Exhaust (Stainless Steel) 50mm - per m Flexible Exhaust (Stainless Steel) 30mm - per m Fuel Tank Cap for steel fuel tanks Plate Nut M6 Nut - HL Brass Nut 8mm - HL30/ Cap Nut - HL Hexagon Nut - M Hexagon Screw - M6 x Self Tapping Screw M4 x 6 - HL65/DBW Self Tapping Screw A Screw M4 x Screw - Phillips Head Screw M5 x

58 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Self Tapping Screw - M6 x Allen Bolt M5 x Hexagon Socket Head Screw M6 x D Electronic Ignition D Ignition Electrodes - DW A Overheat Thermostat - Resettable A Control Thermostat - DBW Sensoric A Nozzle Pre-heating Element - DW C Support Plate C Control unit 24v DBW C Temperature Control Thermostat - DW B Temperature Sensor D Overheat Reset - DW A Overheat Thermostat (re-settable) - DW C Overheat Fuse A Wiring Harness (Heater to Control Box) - DW B Temperature Control Thermostat - DW Screw Screw Screw - HL Self Tapping Screw - HL65/ Self Tapping Screw - HL A Eye Bolt M8 x A Screwed Fitting DW Banjo M12 8mm Pipe Banjo Bolt M Olive Nut 12mm Olive (Solder Type) 8mm Gasket Ring - HL65/ Gasket Ring - HL65/ Gasket Ring - DBW300/ Gasket Ring Gasket Ring - HL Gasket Ring Sealing String - HL30/38/ Sealing String - HL65/ Sealing String - HL30/38/ Spring Washer - HL Washer Locking Washer Circlip - DBW2010/ Circlip Spring Washer - HL6511/12/DBW Spring Washer M

59 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Spring Washer Washer - HL Washer - LO Washer A Flat Washer M Spacer - HL30/ Spacer - HL30/ Spacer - HL30/ Spacer - HL30/ Spacer A Wiring Harness (Heater to Control Box) - HL B Anti Vibration Mount - M Piston Assembly A Flexible Hose A Gasket Ring Pumpshaft & Worm - HL65/95/ Fuel Pump - HL Washer - HL30/ A Heat protection hose Eccentric Shaft - HL A Thermobox Cover (Hinged) A Non Return Valve 20mm (Plastic) C Control Unit 12v - HL18/24/ C Control Unit 24v - HL18/24/ D Control Unit 12v - DW D Control Unit 24v - DW B Harness - DBW2010 Sensoric B Timer 24v A Switch Green Light Wiring Harness with Cap Glowplug 24v - HL18/24/32/DBW Knob - Start Switch Knob - Start Switch A Locking Washer Bulb Bulb Bulb A Overheat Fuse A Kit Accessories T300 Switch & Connectors Plug Socket - HL30/65/ Coupling Magnet Capacitor A Screw - HL Brush Screw Cap - HL

60 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Motor Brush 12 x 8 x Motor Brush HL Diode Glowplug - HL30/65/95/125/ Relay 24v B Exhaust with Plate - Thermo Top Resistor 12-4v Supplementary Fuel Pump 24v Grommet - HL65/ Protection Cap - HL30/65/95/ Protection Cap - HL Tab Male Terminal Suppressor Electrode Plug Receptacle Female Terminal Receptacle Female Terminal High Tension Ignition Cable - DBW A Washer - DBW A Washer One Way Connector Housing - Female Connector Housing (two way) 6.3 Receptacle Female Two Way Connector Housing - Flat 6.3 Receptacle FM Four Way Connector Housing Tab Male Eight Way Connector Housing Receptacle FM Six Way Connector Housing Receptacle FM One Way Connector Housing Tab Male A Two Way Connector Housing Tab Male Four Way Connector Housing Tab Male Six Way Connector Housing Tab Male Louvre Plate 250 x250 mm A Hose Clamp Time Switch Madera Electronic Speed Control 12v/24v Madera Electronic Speed Control with on off switch 12v/24v Banjo A M6 Nutsert Aluminium A Fuel Pipe id od lg E Exhaust Silencer 38mm A Fuel Pump Connector A Burner Head - DBW300 1, A Heat Exchanger Seal B Strap - HL B Support B Exhaust Seal - Thermo Top

61 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 19733A Combustion Air Hose 18mm A Combustion Air Silencer 30mm i.d B Connector - Thermo Top A Thermostat Valve 20mm A Check Valve B Insulator - DW A Exhaust with Silencer - DBW A Control Unit 24v A Flame Detector Photocell - DW A Heat Exchanger DW E Parts Kit for Fuel Pump - DW B Burner Head - DW300 2, A Hood - HL B Core Grip - Thermo B Self Tapping Screw M5 x C Water Pump Mounting Bracket - DW80/T A Mounting Bracket - DW80/T D Flame Detector Grommet - DW B Combustion Air Fan - DW A Clutch - DW B Cap - DW Exhaust Pipe Extension - HL A Console F Heat Exchanger - DW C Support - DW B Hose Protection B Grid B Adjustable Ring A Burner Matting Petrol - BBW A Gasket & Washer Set - BBW C Exhaust Silencer A Exhaust Clamp 22mm B Pump Clamp Bolt - DW A Resistor on Bracket 12v A Resistor on Bracket 24v - HL/AT A T Piece 20 x 20 x A Distributor Box - HL A Hood - HL A Guard Bar - HL A Cover Plate D U4814 Water Pump 24v B Exhaust Intake 22mm B Pressure Compensator B Exhaust Balancer 38mm

62 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 21214A Drive Assembly 12v - HL/AT A Drive Assembly 24v - HL/AT A Heat Exchanger - HL/AT Plug - Male 5 Pin - HL30/65/ C Mounting Bracket - Thermo Top C Cradle Clamp Plate - Thermo Top A Dense Ring A Gasket Ring Joint C Combustion Air Fan 12v - DW C Combustion Air Fan 24v - DW C Glowpin 24v - DW D Flame Detector - DW B Fitted Burner Petrol - BW A Burner Head Clamp - DW C Burner Head - DW A Gasket Set - DW B Drive Assembly 24v - DW/Thermo B Drive Assembly 24v - DW/Thermo B Drive Assembly 24v - DW/Thermo A Hose Clamp 32-50mm A Combustion Air Hose 30mm KPK - per m A Water Pump 12v - U A Water Pump 24v - U A Formed Hose Di22 Da lg A P Clip 34mm Flame Detector Photocell - DBW A Screw A Heat Protective Sleeving 28mm i.d A Grommet Relay Housing Screw - HL20/30/ Gasket Ring - DBW Hose Box Spanner A Exhaust & End Cap 700mm lg A Timer Gasket Fuel Filter Connections A Combustion Air Filter - AT A Overheat Stat & Micro Switch - HL/AT Plate A Hose A Fuel Line Exhaust Pipe Extension 81mm - DBW B Seal - Water Pump U

63 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Description RRP 2013 Number (Exc VAT) 22428A Screw B Elbow Protection Cap - HL30/65/ B Blower Casing - DBW Button Head Screw - HL30/ Support Bracket - Fuel Tank A Resistor Kit B Combustion Air Pipe Silencer 30mm B Control Unit 12v B Control Unit 24v B Terminal Support A Combustion Air Pipe - Thermo Top Z/C A Set of Parts - Thermo Top T Support Strap - HL30/ C Glowpin 12v - Thermo Top (Push on Connectors) C Flame Detector - Thermo Top A Protection End Cap 38mm A Exhaust End Cap A End Cap 34mm B Control Unit 24v - AT18/24/ Angle Bracket (Universal) Mounting Strip (Universal) P Clip 34mm B Housing - HL D Control Unit 24v - Thermo Olive 6mm Hosetail Olive 8mm Hosetail Formed Hose Di15 Da lg Relay 24v - DBW Pump Seal Kit - U A Eight Way Plug - AT C Room Thermostat - Unswitched Supplementary Fuel Pump 12v B Eight Way Black Connector Fuse Holder Intake Silencer - Thermo Chrome Embellisher - 80mm Chrome Embellisher - 100mm Reducer 80-60mm Reducer Pipe (Galvanised) mm Y Branch 80/60/ Branch Pipe 80x80x80 370lg Y Piece (Galvanised) 100 x 100 x 80mm

64 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Supplementary Fuel Pump 24v Fuel Pipe Rain Cap 100mm Combustion Air Hose 30mm - per m Combustion Air Hose 40mm - per m Warm Air Ducting 50mm - per m Warm Air Ducting 70mm (Aluminium) per m Warm Air Ducting 80mm (Aluminium) per m Warm Air Ducting (Aluminium) 100mm - per m B Time Delay Relay Seconds Connector Housing with Mnt Tab for 5 Pin Relay A Four Way Housing - AT Securing Strap for Fuel Tank Litre (Two Required) B Fuel Tank Fitting A Combustion Air Pipe 560mm - Thermo Top Gasket Ring Thermostat Control - DBW Locking Washer Changeover Relay 12v A Housing C Burner Assembly Diesel - Thermo Top A Terminal Timer A Control Unit 12v - AT18/24/ B Burner Assembly Petrol - Thermo Top Air Outlet 360º Ball Type - 80mm A Burner Tube - AT A Wiring Harness A Plug Housing B Wiring Harness A Combustion Chamber DBW2010/ Protection Cap Gasket Ring - HL A Air Inlet - HL H/T Suppressor A Burner Tube - AT Hexagon Screw M6 x Self Tapping Screw - HL Screw M5 x A Glowpin 24v - AT18/24/ Self Tapping Screw - M4 x Flame Detector Thermostat - HL30/65/ Rubber Grommet - DBW A U v Exhaust Clamp - HL

65 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Connector Clip - DBW Screw A Housing Exhaust Blower 24v - G Combustion Air Fan Rotor - DBW Eight Way Distributor Connector Supplementary Fuel Pump 12v Hexagon Socket Head Screw - M4 x Banjo 6mm Hosetail Warning Light - Orange Anti Vibration Mount M Electrode Clamp - DBW Locking Screw - DBW A Top Case Half - AT A Seal A Fuel Supply - HL/AT 24/ A Bottom Casing - AT24/ A Top Casing - AT24/ A Air Outlet Hood (Black) - AT24/ B Fuel Pump 12v - HL Flexible Exhaust (Stainless Steel) 60mm per m A Centre Cover - Thermo Top A Fuse Holder - AT A Fuse Holder Terminal For Blade Fuses A Terminal Fuse Holder A Mounting Bracket - Thermo Top A Heater Harness 2.4m - DW A Bulb 24v B Elbow C Aluminium Exhaust Elbow Overheat Fuse - LO Control Thermostat 85 Deg. - DBW Intermediate Casing - DBW Motor Support - DBW A Fuse with Connector Clamp 6.5mm Rubber Grommet - DBW Control Thermostat Angle Bracket - DBW A Fitting Banjo M12 5mm Hosetail Banjo M10 5mm Hosetail Supplementary Fuel Pump 24v - HL Self Tapping Screw 6.3 x

66 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 29099A Timer - Thermotop A Washer - Thermo D Magnetic Coil Pull Switch - LO2305/20/ C Water Pump 12V - ThermoTop A Central Cover with Screws - Thermo Top B Connector Kit - Thermo Top A Fuel Assembly Petrol - Thermo Top A Formed Hose Di18/Da mm lg B Combustion Air Hose Cap A Embellisher Cap 36mm - AT24S/32S A Combustion Air Pipe Cap - 30mm A Exhaust Protection Cap 70mm A Heater Base Gasket A Gasket Ring - HL C Fuse Harness - Thermo Disc Nozzle Holder - DBW B Inlet & Outlet Screen - AT C Air Inlet Ring - AT B Control Cover - AT B Rubber Grommet - AT D Socket - AT F Heating Air Outlet - AT A Elbow 60mm - AT A Reducer Pipe 60-55mm - AT Bracket A Glowpin 12v - AT18/24/ Rubber Grommet LH - DBW A Water Hose 180 deg. Di20/Da Rubber Grommet RH - DBW C Wiring Harness - Tele Thermo Top S 12v Motor Support - DBW A Spring - HL A Drive Assembly 24v - HL A Air Intake Socket - Thermo Top A Plug Connector - AT A Flat Spring Contact AT G Receiver T60 - Tele Thermo Top Motor 24v A Gasket Set Water Pump U Nut - DBW Fuel Filter Gauze - DBW Washer Pass Washer - HL30/

67 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 31162B Fuel Hose Joiner 8 x 8mm A Water Pump U B Intake Pipe - AT Hexagon Nut M5 - HL A Cap - Thermo Top B Burner Head - Thermo Top B Control Unit/Heat Exchanger - Thermo Top B Control Unit/Heat Exchanger - Thermo Top T A Intermediate Reservoir - Thermo Top A Silencer Insulation - Thermo Top B Fuel Pipe Connector Reducer 4-5mm Clamp 12.5mm Exhaust Pipe End - 22mm A Rubber Bush A Clamp B Wiring Harness (Room Stat) P Clip 8mm A Fuse X A Florida 5 12v A Florida 5 24v A Florida 5 without control 12v A Florida 5 without control 24v A Exhaust 28mm diameter - 1.9m length A Exhaust Tube 28mm to suit X100 Diesel Hob A Exhaust 28mm diameter- 20m roll length Fuel Hose 14mm i.d Intake Pipe Extension 81mm 09mm lg A Seal A Terminal B Inlet Guide Plate - Thermo 90ST Solenoid Valve 12v - DBW Solenoid Valve 24v - DBW B Telestart Aerial A Exhaust Protection Screen Self Tapping Screw A Resistor A Burner Tube (Petrol) - AT Electrode Plug - DBW Flange Exhaust - HL Six Way Connector Housing 6.3 Receptacle FM Spacer Bolt - HL Sealing Ring - HL Fresh Air Fan - HL Hose Clip 10mm

68 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Metal Fuel Pipe - HL Atomiser - HL A Temperature Sensor - DW A Atomiser Spacer - HL A Carrier Plate 24v - DW Control Unit 12v Control Unit Gasket Ring - DBW2020/ A Control Unit 24v - HL Grommet Rubber Grommet - HL A Control Unit 12v - HL A Half Shield - HL Spring Clip - HL Flange - HL Flame Detector Thermostat - HL A Fan Rotor - HL Flexible Exhaust (Stainless Steel) 22mm - per m M6 x 15.5 Nutsert Aluminium Stand Mounting - HL Strap Mounting - HL Resistance - HL A Water Hose 20mm 2 x 180º Bends 2.2m lg A Automatic Blower Control Kit A Junior Timer Terminal Overheat Fuse - HL65/ B Air Intake Housing - HL B Motor 24v - HL C Heater Harness 2.6m - Thermo C Heater Harness 4m - Thermo C Wiring Harness - HL B Fuel Line - HL B Fuel Pump Harness - Thermo A Two Way Connector Relay 24v Changeover with Diode High Pressure Nozzle - DBW B Adaptor Combustion Chamber - DBW Eight Way Connector Housing 6.3 Tab Male A Self Tapping Screw M5 x A Self Tapping Screw M5 x Combustion Air Fan Back Wall - HL

69 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Motor 24v Open Casing - DBW D Insulation Matting - AT A Case - HL Displacer - HL B Air Conduction Plate - AT A Cable Clamp - HL Fuel Return Line - DBW A Resistor 0.45 Ohm 12v A Resistor 1.8 Ohm 24v Control Thermostat - LO Flame Detector Spark Ignition Unit 12v - LO A Distribution Box - HL A Hood - HL Washer Gasket - HL Gasket - HL Top Case Half - HL Bottom Case Half - HL Gearbox Casing - HL Locking Plate - HL Locking Washer - HL Sliding Valve - HL Gasket - HL A Half Shield Lower - HL Air Intake Ring - HL Carrier Shaft - HL Adjusting Lever - HL Socket - HL Fresh Air Fan - HL Fuel Pump 24v - HL100 2, Pull Pole - HL C Fuel Hose Elbow 90º Fuel Pipe - HL Fuel Line Fuel Return Line - HL A Electronic Thermostat 12v/24v A Gasket Ring Joint A Half Washer - HL U Clamp - HL Wiring Harness - HL A Cover Gasket - HL Spring Clip Fuel Hose

70 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Exhaust End Cap Combustion Air Intake Socket 80mm - DBW Clutch Half 6mm - DBW B Motor Mounting - DBW A Link Pin for Thermostat Control B Fuel Supply Line (Braided) - DBW Fuel Return Line (Braided) - DBW Split Pin Burner Head/Heat Exchanger - DBW Securing Hinge Pin - DBW A Screw Pump A Burner Assembly - AT24/ Terminal Block - 6 Way Fuel Standpipe Single 8mm x 500mm lg A Fuel Standpipe Fuel Standpipe Single 8mm x 500mm lg Flexible Exhaust (Stainless Steel) 38mm - per m Gasket Ring - HL A Motor 12v - HL T Piece 18mm Nozzle Pressure Regulating Valve - DBW Combustion Air Hose 30mm - per m A Water Pump U v A Glow Plug Protective Resistor 1.15 OHM B Digital Timer Three Event 60 Minutes - Thermo Top Gasket Set - HL Cable Harness - DBW2010/ Casing Cover - HL Support Bracket - DBW Clamp - Thermo Hose Clip 14mm Screen - HL Screw Insert - HL Reducer 70-80mm Ring Seal Protective Screen 80mm Gasket - HL Straight Coolant Hose 2000mm lg Di18/Da Plug with Cable - HL Grommet - HL65/ Circuit Breaker 20A - HL Starting Switch - HL A Delay Timer Relay 24v Exhaust U Bend 38mm i.d Fuel Hose (Braided Rubber) 5mm i.d. 10mm o.d

71 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Straight Spur Gear - DBW Flexible Exhaust (Stainless Steel) 40mm - per m Flexible Exhaust (Stainless Steel) 80mm - per m Flexible Exhaust (Stainless Steel) - 100mm Wiring Harness - HL A Support Bracket - B/DBW Impellor & Shaft - DBW Gasket Flange - HL Connecting Flange Air Intake Housing - HL Circuit Breaker - HL Rubber Lined P Clip 18mm Combustion Chamber A Reducer 90-80mm Bulb 12v Bulb 24v A Self Tapping Screw - AT A Heating Air Fan - AT24S/32S Connector Housing FM A Inlet Cover - AT24S/32S A Outlet Cover - AT24S/32S A Double Conical Ring - HL A Stand - AT24S/32S A Housing - AT24S/32S A Heat Exchanger - AT24S/32S B Gasket - AT24S/32S A Gasket - AT24S/32S A Combustion Air Intake Elbow 30mm Self Tapping Screw Disc Nozzle Holder - DBW Parts Kit for Mounting Shaft - DBW Drive Shaft Bearing Kit - DBW B Bottom Casing - AT24S/32S A Top Casing - AT24S/32S Gasket Ring - HL C Overheat Protection - Thermo Fuel Hose 5mm i.d Hose Clip 9mm Hose Clamp 12mm Extractor for Fresh Air Fan Flame Detector - HL Fuel Pump and Motor Assembly 24v - HL20 1, Combustion Air Fan - HL Motor 12v - HL65 1,

72 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Overheat Protection Thermostat 107º - DBW Heat Exchanger - HL6511 1, Fuel Nozzle 10 Bar - DBW Fuel Pump Assembly 24v - HL Thermostat Flame Detector Thermostat - HL65/ C HL90 24v heater 2, A Intake Pipe - HL A Water Pump U Bracket U B Connector Housing - Thermo Heat Exchanger (Downwards) - HL9511 1, Heat Exchanger (Upwards) - HL9512 1, C Protection Cap - Thermo C Combustion Air Fan Cover - Thermo Parts for Solenoid Valve - DBW Exhaust - Damper Ring Plate Nut - HL/AT 24/ A Outer Wrap - HL A Guard Bar - HL Heat Exchanger HL Green Light Holder Yellow Light Holder Electronic Ignition Unit 12v - DBW Electronic Ignition Unit 24v - DBW Solenoid Valve Outlet 70mm Flexible Exhaust & Cap (Stainless Steel) 22mm - 0.9m High Pressure Nozzle - DBW Switch Plate Two Position Full/Half Tank Extracting Device with Return Combustion Chamber - DBW Overheat Fuse 171º Exhaust Skin Fitting 35mm Heat Exchanger - DBW Drive Shaft 8mm - DBW Clutch Half 8mm - DBW /HL Wiring Harness - HL65/ Drive Shaft 8mm - DBW Warm Air Ducting (PAK) 60mm - per m Warm Air Ducting (PAK) 70mm - per m Warm Air Ducting (PAK) 80mm - per m Warm Air Ducting (PAK) 100mm - per m Air Outlet 360º Ball Type 60mm Gasket - HL

73 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Fuel Pump Assembly 24v - HL95 1, Glowplug 24v - HL Parts Kit - U A Burner Fuse Parts Kit for Mounting Shaft Formed Hose 180º Di18/Da Formed Hose Di15/Da Overheat Fuse 122º - DBW2010/ Socket - DBW A Air Outlet - HL P Clip 25mm Emblem Water Hose 15mm i.d. x 2.75m Overheat Fuse 138º (Yellow) - DBW Overheat Thermostat 117º (Green) A Clamping Wedge A Vertical 10 litre calorifier A Airtop EVO 3900 Marine Air Heater Kit 12v 1, A Airtop EVO 3900 Marine Air Heater Kit 24v 1, A Airtop EVO 5500 Marine Air Heater Kit 12v 1, A Airtop EVO 5500 Marine Air Heater Kit 24v 1, Tamperproof Thermostat Break on Rise 12/24v Tamperproof Thermostat Make on Rise 12/24v Wiring Loom with Cap - HL Fuel Pump Harness 6m lg F Thermo Top E Narrowboat Kit 12v with digital timer and filter 1, A Marine Dedicated 7 Day Timer Kit 12v - Thermo Top E/C A Marine Dedicated 7 Day Timer Kit 12v - Air Top Evo 3900/ A Marine Dedicated 7 Day Timer Kit 12v - Air Top A Marine Dedicated 7 Day Timer Kit 12v - Thermo 90ST Switch & Power Harness 7.75m - HL18/ Diode Set - HL Heater Harness 0.6m - AT Heater Harness - AT Marine Switch/Power Harness - AT18/24/ Switch & Power Harness 8m - AT Heater to Control Box Harness 1.6m - AT A Marine Fuel Filter and stop tap kit Fuel Pump Harness 8.5m - AT Fuel Pump Loom Connector Kit - AT Universal Switch Harness - Thermo Fuel Pump Harness 8.5m lg Combination Timer Harness - AT Combination Timer Harness - AT3500/

74 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Universal Wiring Harness - AT3500/ A Airtop 2000ST Universal Installation & Ducting Kit A Climate Controller 12v A Harness set climate control module A Thermo 90S 12v Marine Kit with Switch 1, A Sensor kit climate - Air Top Evo 3900 / A Sensor kit climate - Air Top 2000 ST B Air Top 2000 ST Marine Universal Kit 12v 1, B Air Top 2000 ST Marine Universal Kit 24v 1, A Thermo 90S 24v Marine Kit with Switch 1, A Frost Stat A Pulse Relay Kit 12v Harness A Air Top 2000 ST Diesel Vehicle Universal Kit 12v A Air Top 2000 ST Diesel Vehicle Universal Kit 24v A Air Top Evo 3900 Vehicle Universal Kit 12v 1, A Air Top Evo 3900 Vehicle Universal Kit 24v 1, A Air Top Evo 5500 Diesel Vehicle Universal Kit 12v 1, A Air Top Evo 5500 Diesel Vehicle Universal Kit 24v 1, A Hercules ED4 12v A Air Top Evo 3900 Petrol Vehicle Universal Kit 12v 1, A Air Top Evo 5500 Petrol Vehicle Universal Kit 12v 1, A Air Top 2000 / 2000 S 12v Service Kit A Air Top 2000 / 2000 S 24v Service Kit A Fuel Cut Off Kit (Tap Type) A Air Top 2000 ST 12v Service Kit A Air Top 2000ST 24v Service Kit A Air Top 3500 / v Service Kit A Air Top 3500 / v Service Kit A Air Top 3500 / 5000 ST 12v Service Kit A Air Top 3500 / 5000 ST 24v Service Kit A Air Top Evo 3900 / v Service Kit A Air Top Evo 3900 / v Service Kit A Dual Top RHA 100/101/102 12v Service Kit A Thermo 90 / S 12v Service Kit A Thermo 90 / S 24v Service Kit A Thermo 90 ST 12v Service Kit A Thermo 90 ST 24v Service Kit A 4 hour pulse relay 12v A SMART Controller A Fuel Cut Off Kit (Switch Type) Timer Installation Module (for use with ) Switch Installation Module (for use with ) Brush Set U Heat Exchanger (Curved Water Inlet Pipe) - DBW

75 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Universal Vehicle Installation Kit AT3500/ Mounting Box AT3500/ Fuel T Piece Kit 8mm Universal Installation Kit HL Thermo 300 Diesel 24v preboxed with water pump 2, Fuel Pump Harness 7m lg EF3 12v with white cover EF3 24v with white cover Embellisher Grille 80mm (black metal) Wiring Harness - Heater to Control Unit - DBW Nozzle Holder - DBW Sealing Ring Twin Floor Mount Outlet 80mm G Temperature Sensor - Thermo A Control Thermostat (green/red Cable) 75º - DBW2010 Non-Sen Fuel Tap with lever ¼ ¼ BSP T Handle Ball Valve Silicone Grommet Outlet Bracket 55/60mm Marine Mounting Bracket - Thermo Top C/Thermo Connector Pipe 90mm Exhaust End Cap Wallpipe 90mm (Metal) Mounting Box - HL Outlet/Inlet Grille (Metal) 60mm Universal Floor Mount Bracket - Airtop 2000/3500/ Marine Mounting Bracket Floor Mount Plate Oblong Flange Y Piece 100/100/ Y Branch 90/90/80 (Metal) 45º Heat Exchanger Downwards Exhaust Flexflyte Ducting 80mm - per m Flexflyte Ducting 100mm - per m Flexflyte Ducting 55mm - per m Flexflyte Ducting 60mm - per m Flexflyte Ducting 90mm - per m Reducer 38-35mm Elbow 38/35mm 90º Elbow 35mm 90º Reducer 38-19mm Elbow 38/19mm 90º Water Hose 38mm 1000lg Elbow 38mm 90º 130mm leg Fuel Pipe Nylon 6mm i.d. 8mm o.d. - per m

76 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Exhaust Lagging Ducting Silencer 90mm Fuel Tank Standpipe 700mm lg Fuel Tank Standpipe - Twin Outlet Fuel Sender 8mm Nylon Fuel Hose 2mm i.d. 5mm o.d. - 8m lg Combustion Air Hose 22mm - per m Marine Fuel Hose 5mm ISO per m Exhaust Clamp 71mm Hose Clip 20-32mm Cable Ties (Stainless Steel) P Clip 28mm Mounting Bracket - Water Pump U4851/U Exhaust U Clamp 71mm Outlet Closeable - 55mm Outlet Closeable - 75mm Outlet/Inlet Grille 62mm (plastic) Floor Mount Outlet 90mm Outlet Fishtail (aluminium) 90mm Hosetail 5mm Heater Blank Ident Label B0012 Hose Clip mm C0016 Mounting Bracket - AT2000/3500/ C0193 Floor Mount Plate Round Flange H mm brass hose connector K Dual T Piece K031A Universal Combi Timer Upgrade Kit 12v K061A Universal Combi Timer Upgrade Kit 24v K107D Thermo Top C 300 Universal Motorhome Kit 1, K119A Blower Box universal coolant hose installation kit K120A 3 Speed Rotary Blower Switch Kit K5037C Thermo Top C Narrowboat Kit with Digital Timer 12v 1, K5083C Thermo Top C Marine kit with digital timer 12v 1, K5210A 5 litre plastic expansion tank kit L0061 Harness Time Delay (AT3500/5000) M Gang Panel Switch N0171 Plug kit for 3 Gang Panel Switch S05037A Hose clips stainless steel 8-12mm S40048A Horizontal 10 litre calorifier S45017A Fuel Tank Standpipe Low Profile 495mm lg (8.5mm hole) S70014A Thermoduct 60mm - 750mm length S70015A Thermoduct 80mm - 750mm length S70016A Thermoduct 100mm - 750mm length S80003A Silencio 24v

77 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 41S80011A Hercules ED4 24v S80013A Mini RV Boiler S85022A Marine Fuel Pump Insulation Jacket SK464 Airtop 2000ST Petrol One Outlet Universal Kit 12v T0034 Silencio 12v V0001 Exhaust Lagging 30mm Nozzle Pre-Heating Element 24v Tightening Clamp - DBW Warm Air Ducting (Aluminium) 55mm - per m Heater Inlet Grille 55mm Flap Valve 55mm Switch Plate Formed Hose 90º Di18/Da Formed Hose Di18/Da C Water Pump 24v with Viton Seal - U D Water Pump 12v - U Gasket Ring - DBW Screw - DBW2010/ A Thermostat - DBW Foam Gasket - HL/AT Protective Cap - DBW2010/ Formed Hose 1020mm lg Rubber Elbow Gasket - HL Holding Strap Air Inlet Hood - AT Rubber Grommet - HL Warm Air Ducting (PAK) 55mm - per m Combustion Air Silencer - DBW A High Pressure Nozzle Gasket Ring Gasket Ring A Burner Tube - Thermo E Burner Tube - HL/AT Top Case Half - HL Combustion Air Intake Elbow - HL/AT Plate Nut HL Grub Screw Fuel Supply Line - DBW Exhaust Skin Fitting 22mm Exhaust Fitting - DBW Gasket Set - DBW Protection Cap Flexible Exhaust & End Cap 22mm 1.2m lg

78 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Wiring Harness - DBW470 24v Solenoid Housing Circlip - DBW Gasket Ring Mounting Cradle - Heat Exchanger - DBW2020/ Fan Control Thermostat 40ºC - DBW Water Pump 12v U Water Pump 24v U Water Pump 12v U With Mount Bracket Water Pump 24v U With Mount Bracket Pipe Fitting - HL Exhaust Pipe Extension 70mm x 98mm lg - DBW Exhaust Pipe Extension 70mm x 91mm lg - DBW Connector Plug - HL Connector Clamp Bottom Case Half - HL Fuel Hose 8mm i.d. 70mm lg Fuel Return Line - DBW Fuel Supply Line - DBW2020/ Hose Support - Thermo Hose Clip 10mm Fuel Return Line - DBW Fuel Hose 4.5mm i.d Combustion Chamber 70mm - DBW Gasket - HL Gasket Ring - B/DBW Reducer 55mm-70mm Connector Clamp Elbow 90º 70mm Flame Detector - HL/AT 24/ Overheat Protection - HL Fuel Hose (per m) Exhaust Elbow 90º 70mm Drive Assembly 12v - HL/AT Drive Assembly 24v - HL/AT Fuel Pipe Connection - HL18D Fuel Pipe Connection - HL18B A Gasket Set - HL/AT Solenoid Valve 24v Combustion Air Hose 22mm Resistor 24-12v Hose Clamp 50-70mm Air Outlet Hood 55mm - HL/AT Gasket Ring - HL/AT 24/

79 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 46871G Burner Tube - HL Motor Housing - HL24/ Fresh Air Fan HL/AT 24/ F Motor Cap - HL/AT 24/ Gasket HL/AT 24/ Drive Assembly 24v - HL/AT32 Diesel Gasket Harness Cap - HL/AT 24/ Spring Washer Gasket Ring - HL/AT 24/ Gasket Ring - HL/AT 24/ Diaphragm Grommet - HL Bulb 24v Heat Exchanger Assy 70mm - DBW Clamp Heater Body Clip - HL/AT High Pressure Fuel Nozzle - DBW High Pressure Fuel Nozzle - DBW High Pressure Fuel Nozzle - DBW Self Tapping Screw - HL Water Hose 18mm x 2.2m with 180º ends Gasket Set - B/DBW A Equaliser Tube Mounting Plate - Digital Timer Locking Washer 3mm - HL Exhaust Pipe 22mm - HL/AT Anti Vibration Mount M6 with self tapping screw Timer Cover Temperature Sensor - B/DBW Combustion Air Fan 24v - B/DBW Air Inlet Hood (Blue) - HL Air Outlet Hood (Red) - HL Mounting Plate Digital Timer Combustion Air Fan 12v - B/DBW Combustion Air Fan 24v - B/DBW Membrane Damper - Fuel Pump Sealing Set - HL/AT Digital Timer 12v Flame Detector - B/DBW B Dosing Pump 24v Exhaust Silencer 30mm Exhaust Pipe & End Cap 30mm 1.2m lg Glowplug 12v - HL18/24/32/DBW Flexible Exhaust (Stainless Steel) 70mm - per m Gasket Ring - HL/AT 24/ Mounting Stand - HL/AT 24/

80 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Top Case Half (Black) - HL24/ Bottom Case Half (Black) - HL24/ Exhaust Gasket HL/AT Combustion Air Gasket - HL/AT 24/ Support - DBW Sensoric Wiring Harness Resistor Part Load - HL Resistance Part Load 12v - HL/AT Water Pump 12v U B/DBW Cable Clamp Foam Gasket Mounting Stand - HL/AT 24/ Fuel Hose (Nylon) 5mm o.d. - per m Fuel Hose Connector 5mm i.d. 50mm lg Sound Deadening Mat - HL/AT 24/ Diaphragm Grommet - HL/AT 24/ Resistance Part Load 24v - B/DBW In Line Fuel Filter 5mm Protection Cap Stat Cover - DBW T Piece with Bleed Valve 15/15/ T Piece 18 x 15 x Combination Screw - DBW Fuel Supply - HL32 Petrol Gasket Set - HL/AT 24/ Grommet Washer - HL One Way Valve Double T 20mm Screw (Heater Mounting) M6 - HL/AT Pipe - HL High Pressure Nozzle - DBW Timer Demist Nozzle 55mm Adaptor - HL Fuel T Piece 15/5/ Wall Pipe 55mm Air Outlet Outer Bezel 55mm Outlet Louvre 55mm Wall Pipe 80mm Air Outlet Outer Bezel 80mm Air Outlet Insert Straight 80mm Air Outlet Insert 45º 80mm Exhaust Outlet Socket 30mm Reducer 80mm Connector Pipe 55mm x 55mm lg Connector Pipe 80mm x 75mm lg

81 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Reducer 80-55mm Y Branch 80 x 55 x Y Branch 55 x 55 x Y Branch 80 x 80 x Y Branch 80 x 55 x Air Outlet HL/AT Terminal Protection Cap Connector Motor 24v - HL100 1, Overheat Fuse 138º - DBW2010 Sensoric Exhaust Fitting Heat Protection Foil - HL/AT 24/ Spring P Clip 33mm Mounting Stand - HL/AT A Motor 24v - HL C Water Thermostat 40º Bypass 20mm Tail A Control Unit 12v - DBW A Timer 24v - B/DBW A Temperature Sensor - B/DBW F Electronic Control Unit SG1572D- Thermo C U4814 Water Pump 24v A Receptacle Terminal - AMP Faston A External Temperature Sensor A Batteries - T70/T80 Remote Handset B Small Parts Kit - Airtop A Fuel Hose 4.5 x 10.5 x 50mm A Combustion Air Elbow - AT E Control Unit SG1572D - DW/Thermo F Control Unit SG DW E Control Unit SG DW230/300/ F Control Unit SG1572D - DW A Pressure Pipe - DBW2010 Non Sensoric A Burner Head 24v - Thermo 230 1, E Burner Head 24v - Thermo 300 1, A Burner Head 24v - Thermo 350 1, A Hollow Screw (Banjo Bolt) - DBW A Gasket - DBW Sensoric A Fuel Pump - DBW A Fitted Burner - AT A Combustion Air Silencer - 20mm A Clamp Electrode DBW A Fuel Pump - DBW

82 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 66546A Fuel Pump A Water Pump Cover Kit - Thermo 90S A Joint Paste A Wiring Harness A Rubber Mounting T A Control Unit AT3500 Diesel 24v SG A Drive Assembly 12v AT3500 D Volume Plus A Drive Assembly 24v AT3500 D Volume Plus A Exhaust Pipe Adaptor - 24mm-30mm B Connection Tube 18 x A Connection Tube 18 x C Connection Tube 20 x A Fuel Extractor 6 x 5 x A T Piece 10 x 5 x B Supporting Angle - AT2000S A Mounting bracket Thermo B Heat Exchanger - AT A Screw set - Airtop A T70 Remote Control A Hose Clamp 32-50mm A Fuel Extractor 20mm F Lower Casing - AT2000S D Air Inlet Hood - AT2000S D Outlet Hood - 60mm - AT2000S A Air Inlet Grille - AT2000S A Combustion Air Pipe - Thermo Top E B Control Unit 12v AT3500 RV (must be used with remote temperature probe) 67788B Control Unit 12v AT5000 RV (must be used with remote temperature probe) 67863C Harness T A Burner Tube - AT3500/ > Version A Antenna Kit - T70 Remote Control A Fitted Burner - AT3500/ B Exchange Burner with Glowpin 24v - AT3500/ B Exchange Burner with Glowpin 12v - AT3500/ B T80 Receiver only A Drive Assembly 24v - AT A Supporting Angle Screw - AT2000S A Room Thermostat Single Switch 12v/24v A Room Thermostat Twin Switch 12v/24v Madera 4 12v Madera 4 24v Madera 8 12v Madera 8 24v

83 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) Madera Grille 90 x Madera Outlet 55mm straight Madera Outlet Closeable Madera Outlet 45mm 90deg Madera Outlet 45mm 45deg A U4814 Pump Repair Kit - Without Cover B Fuel Pump 7 bar - DBW2010 Sensoric A Magnetic Clutch Brushless Motor A 1/2" BSP x 16mm hosetail A 1/2" BSP x 19mm hosetail A Cargo Heater Cassette Thermo 90 ST 12v 3, A Cargo Heater Cassette Thermo 90 ST 24v 3, A Cargo Heater Cassette DBW v 3, A Cargo Heater Cassette DBW v 3, Hose Clamp 62mm X B Combustion Air Fan 12v - Thermo Top S A Hose Clamp 37mm A Rubber Pipe D Housing - Thermo A Heater Base Gasket 5mm - AT A Fuel Pump - Thermo B Fuel Supply Line - Thermo B Fuel Return Line - Thermo B Basic Wiring Harness 24v - AT A Upper/Lower Casing - AT A Burner Tube - AT A Proportioning Pump Complete A Damper - AT A Sealing Set - AT C Overheat Protection - AT C Flame Detector - AT B Glowpin 24v - AT A Fixing Kit - AT A Remote Temperature Sensor for Room Thermostat A Adaptor 60/75mm A Water Pump Magnetic Drive 12v - DW A Water Pump Magnetic Drive 24v - DW A Combustion Air Fan 12v - Thermo A Combustion Air Fan 24v - Thermo B Flame Detector - Thermo B Glowpin 12v - Thermo B Glowpin 24v - Thermo B Burner Tube - Thermo A Gasket Set - Thermo

84 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 82418A Water Pump 12v - Thermo A Switch Knob - Rotary Controller B Switch Plate Rheostat A Sealing Rope A Exhaust Gasket - HL90/ A Gasket - HL C Stand U DW A Screw - AT 24S/32S A Clutch Half B Dosing Pump 12v A Fuel Pump 12v petrol F Harness - Thermo A Digital Timer 7 Day Three Event 12v A Digital Timer 7 Day Three Event 24v A Eight Way Timer Plug Kit B Rotary Rheostat Control B Harness - DW300 Control Unit C Adaptor Wiring Harness C Overheat Protection AT24S/32S A Gasket Ring B HL90 12v heater 2, B Gasket Ring C Transistor Relay - 12v A Standpipe - Thermo Top A Combustion Air Restrictor - AT32S A T60 Telestart Battery A T60 Transmitter 60 Minutes C Wiring Harness (Waterproof Connections) - Thermo Top B Wiring Harness 12v AT A Vent Switch A Summer/Winter Switch A Burner Cartridge - Thermo 90 Petrol B Drive Assembly 12v - AT A Burner - Airtop 2000 Petrol B Glowpin 12v - AT B Water Pump 12v - Thermo Top (Waterproof Connectors) A Protective Screen 60mm A Exhaust Gas Deflector - Thermo 230/300/ A Side Channel Fan - HL A Fuel Pump Plug Kit A Glowpin A Glowpin 12v - Thermo Top S A Flame Detector - Thermo Top (Waterproof Connectors) B Thermo 230 Diesel 24v with switch 1,

85 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 85313B Thermo 300 Diesel 24v with switch 1, C Thermo 350 Diesel 24v with switch 1, C Digital Timer 12/24v Airtop B Fuel Hose Connector 3.5mm x 9.5mm x 50mm A Air Outlet (Short) 90º - AT A Mounting Box - Top Access - AT B Electronic Room Thermostat C Heat Exchanger - Thermo A Water Pump Bracket - DW80/Thermo A Tank Extractor (15mm Fuel Hose) A Tank Extractor 18mm fuel hose A Control Unit/Heat Exchanger 12v - Thermo Top C Exhaust Silencer 22mm - Stainless Steel A Hose Ring A Water Hose Connection B Water Pump Clamp E U4814 Water Pump 24v C Basic Wiring Harness - AT2000 (Diagnostic Version) B Water Pump - Thermo Top Z/C A Inflow Ring - HL A Inflow Ring - HL A Water Pump 12v - Thermo A Water Pump 24v - Thermo A Housing A T Branch 60mm B Fuel Connector A Heat Exchanger - Thermo B Heating Element - Thermo A Combustion Air Pipe & End Cap 30mm i.d. 5m lg B Screw to Secure Water Pump - Thermo Top C B Wiring Harness - HL18/24/ A Fuel Return Line A Fuel Supply Line A Non return valve 20/20/22/ A Electronic Control Unit SG v - HL A Control Unit A Grille 60mm A Air Outlet 60mm Flush B Universal Mount Bracket - Thermo Top E/C B Control Unit 24v - AT2000 Diesel B Control Unit 12v - AT2000 Diesel B Control Unit 12v Petrol AT C Fitted Burner - DW A Fuel Return Line T230/300/

86 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 87787A Fuel Pipe - Thermo C Lower Casing - AT3500/5000 (1 Locating Peg) C Upper Casing - AT3500/5000 (1 Locating Peg) C Air Inlet Hood - AT3500/5000 (1 Locating Peg) E Control Cover - AT3500/ C Burner Tube - AT3500/ D Fuel Tap E End Cover - Thermo 90S D Air Outlet Hood - AT3500/5000 (1 Locating Peg) A Bulb 12v - KombiTimer A Timer Alarm 24v A Timer Alarm 12v A Combination Timer/Rheostat 24v B Combination Timer/Rheostat 12v B Overheat Protection - Thermo A Wiring Harness - Timer Link A Washer - DW/Thermo A Washer - Thermo 230/300/ D Overheat Protection - AT3500/ C Temperature Sensor - AT3500/ A Temperature Sensor D Control Unit Mount Plate - Thermo 90S A Washer - DBW2010 Non Sensoric A Washer A Water Valve A Reducer 90-80mm E Control Unit 24v - Thermo 90S Diesel B Adaptor 90-80mm B Universal Wiring Harness - Thermo Top Z B Thermo Top Z Supplementary Heater Kit Diesel 12v D Upgrade Kit for Thermo Top Z C Gasket - AT3500/ B Reflector Foil AT3500 Combustion Air Fan D Insulating Matting - AT3500/ A Air Temperature Sensor A Air Temperature Sensor Bracket A Rubber Seal for Air Sensor Bracket C Rubber Grommet - Harness - AT C Control Unit 24v - DBW Sensoric C Control Unit 24v - DBW2010 Sensoric E Basic Wiring Harness - AT3500/ B Air Intake Silencer - Thermo Top S B Control Unit 24v - AT5000 Diesel C Control Unit 12v - AT5000 Diesel

87 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 89838B Control Unit 24v - AT3500 Diesel C Control Unit 12v - AT3500 Diesel A Connector Pipe 60mm A Gasket Set - Thermo Top C D Universal Wiring Harness - Thermo Top C C Plastic Fuel Tank 24 litres B Fuel Extractor - 8x5x B Combustion Air Motor - Thermo Top Z 12v C Control Unit 12v Petrol TTE D Control Unit 12v - Thermo Top E Diesel B Fuel Pump Mounting B Tank Extractor - VAG Group only A Upper Casing - AT2000S B Exhaust Clamp A Thermostat Switch A Fuel Supply Line DW230/300/ B Water Pump U v 130Deg. TTZ/C C Thermo Top C Petrol Basic Vehicle Universal Kit 12v without operating control C Thermo Top C Diesel Basic Vehicle Universal Kit 12v without operating control C Thermo Top E Petrol Basic Vehicle Universal Kit 12v without operating control C Thermo Top E Diesel Basic Vehicle Universal Kit 12v without operating control C Fuel Standpipe - Thermo Top G Wiring Harness Universal AT2000ST A Drive Assembly 12v AT3500ST A Drive Assembly 24v AT3500ST A Drive Assembly 12v AT5000ST A Drive Assembly 24v AT5000ST A Glowpin 12v AT3500ST/AT5000ST A Glowpin 24v AT3500ST/AT5000ST A Heat Exchanger AT3500ST/AT5000ST A Burner AT3500ST/AT5000ST A Overheat Temperature Sensor AT3500ST/AT5000ST A Screw Set - AT EVO 3900/ A Blanking Seal D Universal Wiring Harness - AT EVO A Brushless Motor 24v Airtop B Sensor External Temp AT2000ST A Temperature Sensor c/w control unit 12v - AT A Temperature Sensor c/w control unit 24v - AT A Temperature Sensor 5m lg AT2000S A Overheat Sensor AT2000ST A Glowpin 12v AT2000ST

88 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Glowpin 24v AT2000ST A Heat Exchanger Petrol AT2000ST B Flame Detector AT2000ST B Glowpin 24v Thermo 90ST A Airtop plastic enclosure with bracket A T80 Antenna (>July 2003) A Burner Tube AT3500ST/AT5000ST A Control Unit 24v AT5000ST (SG1580) A Control Unit 24v AT3500ST (SG1580) A Control Unit 12v AT5000ST (SG1580) A Control Unit 12v AT3500ST (SG1580) A T80 Set (< ) Red A T80 Handset only (>July 2003 Black Buttons) A Thermo 90 ST Vehicle Universal Kit without operating control 12v 1, A Thermo 90 ST Vehicle Universal Kit without operating control 24v 1, C Diesel Burner Head/Heat Exchanger/Control Unit TTC300 (Camper & Marine) A Fuel Pipe T Piece Kit A Control Switch & Cable for Flap Valve A Connector Harness 1531 Digital Timer B Backing Nut 60mm Black B Backing Nut 90mm Black C Wall pipe 60mm Black C Wall Pipe 90mm Black C Pipe Connector 60/ C Pipe Connector 90/ C Elbow 90mm D Y Piece 90/90/ B Y Piece 80/60/ B Assymetric Y 90/60/ B Assymetric Y 60/60/ C T Piece 90/90/ C T Piece 60/60/ B T Piece Connector 90/60/ B T Piece Connector 60/60/ B Reducer 90/ D End Cap 90mm D End Cap 60mm A Flap Valve Y Piece 90mm A Flap Valve Y Piece 60mm A Elbow 38mm 90Deg A Electronic Control Unit 12v Air Top 3500ST Diesel (Boat Version) A Electronic Control Unit 24v Air Top 3500ST Diesel (Boat Version) A Electronic Control Unit 12v Air Top 5000ST Diesel (Boat Version)

89 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Electronic Control Unit 24v Air Top 5000ST Diesel (Boat Version) A Fixing Parts for TTC B Glowpin 12v T90ST A Overheat Protection T90ST B Flame Detector T90ST A Water Pump 24v T90ST A Water Pump U v A Temperature Sensor Thermo 90ST A Fan Assembly 24v T90ST A Combustion Air Fan 12v Thermo 90ST A Burner Diesel - T90ST C Reducer 90/ A Control Unit - Thermo 90 ST 12v A Control Unit - Thermo 90 ST 24v A Control Unit SG v (Marine Chiller Heater Version) A Control Unit SG v (Marine Chiller Heater Version) A Taptite Self Tapping Screw Set Thermo 90ST A Gasket Set - Thermo 90ST A Mounting Parts Set for Burner Head - Thermo 90ST A Mounting Parts Set - U4846 Pump B Exhaust Clamp 30-35mm B Support A 90mm Outlet 45º - Black A 90mm Outlet 45º - White A 90mm Outlet 45Deg - Grey HADS A 90mm Outlet 90º - Black A 90mm Outlet 90º - White A 90mm Outlet 90Deg - Grey HADS A 90mm Outlet Closeable Black A 90mm Outlet Closeable White A 90mm Outlet Closeable - Grey HADS A 60mm Outlet 45º - Black A 60mm Outlet 45º - White A 60mm Outlet 45Deg - Grey HADS A 60mm Outlet 90º - Black A 60mm Outlet 90º - White A 60mm Outlet 90Deg - Grey HADS A 60mm Outlet Closeable Black A 60mm Outlet Closeable White A 60mm Outlet Closeable - Grey HADS A Water Pump Thermo Top Z C Fuel Pump 12v petrol A DBW2016 Heater with 2 position switch & Switch plate 24v 1, A DBW2016 Heater with 2 position switch & Switch plate 12v 1,

90 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) A Control Unit 12v Diesel AT2000ST A Control Unit 24v Diesel AT2000ST A Control Unit 12v Petrol AT2000ST A Control Unit 12v Diesel AT2000ST (Camper/Marine Version) B Antenna T90 Telestart A Thermo Top P Petrol Basic Vehicle Universal Kit 12v without operating 1, control A Thermo Top P Diesel Basic Vehicle Universal Kit 12v without operating 1, control A Exhaust Silencer A Temperature Sensor (External) 2.5m AT EVO 3900/ A Anti Vibration Mount M A Relay with mounting bracket 12v 20/30A A Katadyn 100ml bottle A Katadyn Tank Care Set MT Box C Dosing pump wiring harness extension DP 40 5m A U4847 Water Pump econ axial A U4847 Water Pump econ A T91 Holiday remote control kit A Exhaust Skin Fitting 24mm (through hull kit straight) A Exhaust Skin Fitting 24mm (through hull kit 90 deg.) A Drive Assembly - AT EVO C Air Inlet Bellows Kit A End Cover - DW A Protection Hood DBW A Protection Cap DBW300 24v A Protection Cap DBW350 24v B Air Top Evo 3900 Master Heater Automatic 12v 1, C Air Top Evo 3900 Master Heater Automatic 24v 1, C Air Top Evo 5500 Master Heater Automatic 12v 1, B Air Top Evo 5500 Master Heater Automatic 24v 1, B Service Cap RHA B Sensor wiring harness RHA 100 / 101 / B End Cap RHA 100 / 101 / B Heating Air Blower Assy c/w PWM RHA 100 / 101 / B Valve Air Ventilation/Overpressure B Gasket Set Basic Heater RHA 100 / 101 / C Combustion/Cooling Fan RHA 100 / 101 / C Control Unit RHA B Wiring Harness (Internal) RHA 100 / 101 / B Burner RHA 100 / 101 / B Overheat protector B Heat exchanger RHA 100 / 101 / B Gasket set thermo unit RHA 100 / 101 / B External Temperature Sensor RHA 100 / 101 /

91 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) B Dosing pump v RHA 100 / 101 / B Drain tube RHA 100 / 101 / B Air Intake Grille RHA 100 / 101 / B Hammer Screws (qty 6) B Cooling Shell RHA 100 / 101 / A Electronic Control Unit 24v - Air Top Evo 3900 Diesel A Electronic Control Unit 12v - Air Top Evo 3900 Diesel A Inlet Hood AT2000ST A Upper Plastic Casing - Air Top 2000 ST C Mains Heating Element Kit RHA 101 (2 pieces) B Wiring harness tubular heater 230v RHA 101/ B Service Cap RHA 101 / C Thermo unit RHA 100 1, B 10/10mm Pushfit /flexipipe conn B 15/10mm Pushfit/Pushfit conn B Operating Control Wiring Harness Extension RHA 102 3m A Boiler RHA 100 / 101 / A Boiler Drainage Solenoid Valve RHA 100 / 101 / A Mains Heating Element Kit RHA 102 (2 pieces) A Blower 12v - Thermo 90S B Blower 24v - Thermo 90S B Fuel Pump Harness Thermo 90S A Operating Control Wiring Harness Extension RHA 100 3m A Reflector Foil AT3500/5000 pack B Wiring Harness - T90S Harness to C Box B Wiring Harness - T90S C Box to Switch A Control Unit 12v - DBW A Control Unit 24v DBW 2010 (non sensoric) A DBW2010 Diesel 12v with Switch 2, A DBW2010 Diesel 24v with Switch 2, B Wiring Harness - Relay A Motor 12v - DBW A Motor 24v - DBW B Plastic Fuel Tank 12 Litre A Seal Boiler (Dual Top) A Control Unit 12v - Thermo 90S Diesel A Fitting kit - 12l plastic fuel tank C Exhaust Silencer - AT3500/ A Flexible Exhaust (Stainless Steel) 24mm - per m A Warm Air Ducting (PAK) 90mm - per m A Exhaust End Cap 27mm D Combustion Air Silencer A P Clip 42mm Stainless Steel A Wiring Harness - Thermo

92 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 90808A Bulb 24v 1.4W A External Temperature Sensor 5m - AT3500/ A Y Branch 90 x 90 x B Y Branch 90 x 80 x 80 (Equal Y) A Gasket Set - AT3500/ B Glowpin 12v - AT3500/ B Glowpin 24v - AT3500/ A Drive Assembly 12v - AT5000 Diesel A Drive Assembly 24v - AT5000 Diesel A Drive Assembly 12v - AT3500 Diesel A Drive Assembly 24v - AT3500 Diesel B Exhaust Clamp 28mm B Thermo Top E/C Fixings Kit A Combustion Air Hose 25mm A Combustion Air Elbow 25mm B Exhaust Elbow 24mm B Hose Clamp mm C Air Outlet 90mm A Small Parts Kit - Airtop C Extension Cable - Water Pump A Control Unit 12v - HL A Control Unit 24v - HL A Electronic Thermostat A Micro Switch - HL/AT 24/ A Harness - Thermo Top A Fuel Supply - TTD A Combustion Air Fan - Thermo Top T/S A Control Unit 12v - Thermo Top Diesel C Control Unit 12v - Airtop 5000 Diesel "Boost" A Exhaust Condensate Drain Tube 24mm C Marine Stand - AT3500/ A Rheostat Mount & Vent Switch - AT3500/ A Exhaust Jointer - AT3500/ D Burner Petrol - Thermo Top C A Fuel Shut Off - T A Drain Tube A Exhaust Pipe Adaptor - 22mm-24mm B External Temperature Sensor - 20m A Outlet 70mm A Reducer 55mm-60mm D Burner Diesel - Thermo Top C F Control Unit 12v - Thermo Top C Petrol G Control Unit/Heat Exchanger - Thermo Top C C Water Pump Housing 193º

93 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) 93012C Water Pump Housing Axial C Harness - Thermo A External Temperature Sensor A Relay Kit - Thermo Top A Temperature Sensor A Fuel Filter Element - DBW A Burner Tube Diesel AT3500/ A Top Cover - U4814 Water Pump A Overheat Switch - HL A Heat Exchanger HL90 1, A Heat Exchanger - HL100 2, A T Piece - 12 x 5 x A Combustion Air Silencer with clip - Thermo Top B Burner (Diesel) - Thermo B Combustion Air Fan c/w screws & gasket C Control Unit Thermo A Water Pump - U B Outlet Hood - 75mm - AT2000S B Overheat Protection - HL/AT 24/ C Fuel Tank Extractor - Mercedes Benz B Bottom Casing - AT3500/5000 (2 locating pegs) B Top Casing - AT3500/5000 (2 locating pegs) B Inlet Hood - AT3500/5000 (2 Locating Pegs) B Outlet Hood - AT3500/5000 (2 Locating Pegs) A Water thermostat 20/20/ BE A Parking Cooler Cool Top Vario 10 E 1, RWA8300 Backing Nut 60mm (Compact HADS) 9.65 RWA8400 Blanking Cap Black 60mm (Compact HADS) 4.82 RWA8500 Ducting T 60mm (Compact HADS) SPH A Control Thermostat 75º - DBW SPH A Circulation Pump U SPH82823D Overheat Limit - 120º WA Overheat thermostat complete incl wiring harness X WA17689 Fuel Connector - X100 Cooker fuel pump 7.14 WA Radiation element X WA Burner outer cylinder X WA Gasket for thermo element T4 X WA Fixing bracket for glowplug X WA Gasket for glowplug X WA Grounding wiring harness X WA Fuel Pipe X WA36098 Burner matting 85mm diameter with spring X WA36207 Ventilation fan X WA36400 Thermo element T4 + gasket X

94 WEBASTO THERMO & COMFORT UK LTD RRP LIST JANUARY 2013 EDITION PRODUCTS BY PART NUMBER (Prices exclude VAT & Carriage) Webasto Part Number Description RRP 2013 (Exc VAT) WA Seal 25mm diameter X WA Seal 38mm diameter X WA40125 Operating Panel X WA40130 Control unit XPS X WA40140 Hot plate indication LED X WA601928KOK Burner chamber bottom section X WA Fuel Pump FC 1 X WA Burner Cylinder Assembly X WA Burner Cylinder X WA Fixing bracket for thermo element T4 X WA Burner collar Assembly X WA Table mounting bracket X100 (qty 2) WA Ceran Glass Plate X WA Gasket for Ceran Glass plate X WA Ventilation box X WA Front plate assembly X WA Reflector plate 1 X WA Combustion Blower X WA Glowplug X WA B Wiring harness for glowplug X WA Wiring harness for high altitude switch X WA Operating Panel wiring harness 2m X WA Power Cable with connectors 4m long X WA Terminal block for power connector X WA Mounting flange for power connector X WA Silicone glue for Ceran Glass plate X WA90000B Diesel Cooker X

95 Webasto Thermo & Comfort UK Ltd - Conditions of Sale of Goods and Provision of Services 1 Definitions and Interpretation 1.1 In these Conditions the following words have the following meanings: "the Company" means Webasto Thermo & Comfort UK Ltd (Registered No: ) whose registered office is at Webasto House, White Rose Way, Doncaster Carr, South Yorkshire, DN4 5JH; "Contract means any contract between the Company and the Customer for the sale of Goods and/or provision of Services, incorporating these Conditions; "the Customer means the person(s), firm or company who purchases the Goods and/or Services from the Company; Goods means any goods agreed in the Contract to be supplied to the Customer by the Company (including any part or parts of them); Services means any Services agreed in the contract to be supplied to the Customer by the Company; "Working Day" means any day except Saturday, Sunday or a bank holiday, public or statutory holiday in England. 1.2 In these Conditions references to any statute or statutory provision shall, unless the context otherwise requires, be construed as a reference to that statute or statutory provision as from time to time amended, consolidated, modified, extended, re-enacted, suspended or replaced 1.3 In these Conditions references to a gender include every gender, reference to persons include an individual, company, corporation, firm or partnership and reference to the singular include the plural and vice versa as the context admits or requires. 1.4 Headings are for ease of reference only and shall not affect the construction of these Conditions 2 2. Application of Terms 2.1 Subject to any variation under Condition 2.2 the Contract will be subject to these Conditions to the exclusion of all other terms and Conditions (including any terms or Conditions which the Customer purports to apply under any purchase order, confirmation of order, specification or other document whatsoever). 2.2 Any variation to these Conditions and any representations about the Goods or Services shall have no effect unless expressly agreed in writing and signed by a director of the Company. 2.3 Each order for Goods or Services by the Customer from the Company shall be deemed to be an offer by the Customer to purchase Goods or Services subject to these Conditions. 2.4 No order placed by the Customer shall be deemed to be accepted by the Company until a written acknowledgement of order is issued by the Company or (if earlier) the Company commences manufacture or despatch of the Goods to the Customer. Any order shall be accepted entirely at the discretion of the Company. 2.5 The Customer must ensure that the terms of its order and any applicable specification are complete and accurate. 2.6 Any quotation or estimate is given subject to these Conditions. Without prejudice to the Company's right not to accept an order, quotations will be valid for 30 days from date of issue. 2.7 The Customer can only cancel an order (or any part of an order) which the Company has already accepted, with the Company's prior agreement in writing and provided that the Customer indemnifies the Company in full in terms established by the Company. The Company is not bound to agree to any such cancellation and may complete such order even if the Customer claims to cancel the order. 3 Description of the Goods and Services 3.1 The description of the Goods or Services shall be set out in the Company's acknowledgement of order, or in its absence the Company's quotation. 3.2 All drawings, descriptive matter, specifications and advertising issued by the Company and any descriptions or illustrations contained in the Company's catalogues or brochures are issued or published for the sole purpose of giving an approximate idea of the Goods or Services described in them and they will not form part of the Contract. 4 Delivery and Acceptance of Goods 4.1 Unless otherwise agreed in writing by the Company delivery of the Goods shall take place at the Customer's place of business. 4.2 The Customer will take delivery of the Goods within 7 days of the Company giving it notice that the Goods are ready for delivery. 4.3 Any dates specified by the Company for delivery of the Goods are intended to be an estimate and time for delivery shall not be made of the essence by notice. If no dates are so specified, delivery will be within a reasonable time. 4.4 Subject to the other provisions of these Conditions the Company will not be liable for any loss (including loss of profit), costs, damages, charges or expenses caused directly or indirectly by any delay in the delivery of the Goods (even if caused by the Company's negligence), nor will any delay entitle the Customer to terminate or rescind the Contract unless such delay exceeds 90 days. 4.5 If for any reason the Customer does not accept delivery of any of the Goods when they are ready for delivery, or the Company is unable to deliver the Goods on time because the Customer has not provided appropriate instructions, documents, licences or authorisations then the Goods will be deemed to have been delivered, risk passing to the Customer (including for loss or damage caused by the Company's negligence) and the Company may: (a) store the Goods until actual delivery whereupon the Customer will be liable for all related costs and expenses (including without limitation storage and insurance); or (b) sell the Goods at the best price readily obtainable and (after deduction all reasonable storage and selling expenses) account to the Customer for any excess over the price under the Contract or charge the Customer for any shortfall below the price under the Contract 4.6 The Customer will provide at its expense at the place of delivery adequate and appropriate equipment and manual labour for loading the Goods. 4.7 If the Company delivers to the Customer a quantity of Goods of up to 10% more or less than the quantity accepted by the Company the Customer shall not be entitled to object to or reject the Goods or any of them by reason of the surplus or shortfall and shall pay for such goods at the pro rata Contract rate 4.8 The Company shall be entitled at its discretion to make delivery of the Goods by instalments and to invoice the Customer for each Instalment despatched. Where the Goods are to be delivered in instalments, each delivery shall constitute a separate contract and failure by the Company to deliver any one or more of the instalments in accordance with these Conditions or any claim by the Customer in respect of anyone or more instalments shall not entitle the Customer to treat the Contract as a whole as repudiated or to refuse to accept subsequent instalments. 4.9 The quantity of any consignment of Goods as recorded by the Company upon despatch from the Company's place of business shall be conclusive evidence of the quantity received by the Customer on delivery unless the Customer can provide conclusive evidence proving the contrary The Company shall not be liable for any non-delivery of Goods (even if caused by the Company's negligence) unless written notice is given to the Company within 7 days and oral notice by telephone to the Company within 48 hours of the date when the Goods would in the ordinary course of events have been delivered Any liability of the Company for non delivery of the Goods shall be limited to replacing the Goods within a reasonable time or issuing a credit not at the pro rata Contract rate against any invoice raised for such Goods Subject to Condition 4.13 the Customer will be deemed to have accepted the Goods as being in accordance with the Contract unless, within 14 days of the date of delivery of the Goods, the Customer notifies the Company in writing of any defect or other failure of the Goods to conform with the Contract which would be apparent upon reasonable inspection and testing of the Goods within 14 days (or within a reasonable time where the defect or failure would not be so apparent), failing which the Customer shall not be entitled to reject the Goods and the Company shall have no liability for such defect or failure, and the Customer shall be bound to pay the price as If the Goods had been delivered in accordance with the Contract Where the Company agrees to deliver the Goods at premises other than the Customer's the Company shall have no liability for damage caused by the carrier or caused in transport or loading or unloading unless the Company is notified of that damage within 2 Working Days of delivery 4.14 Goods, once delivered may not be returned, unless agreed in advance in writing by the Company, and subject to the following conditions: a) Goods are returned in a new and unused condition; b) Any packaging remains unbroken and in reasonable condition; c) Returns are made within 3 weeks of delivery of those Goods; all transport and other costs paid by the Customer; d) Payment by the Customer to the Company of a restocking charge of 20% of the nett invoice value of the relevant Goods; e) Returned goods shall be accompanied by a written record of invoice number, date and note of reasons for return Blanket Orders The following provisions will apply where the Company supplies the goods under a blanket order received from the Customer:- a) If the order is a scheduled order where the maximum quantity of goods required and the approximate dates (including the terminal date) on which the requirements will be called off are specified, the whole order will be treated as a single contract upon the contract terms. b) If the ordered is a non-scheduled order where the maximum quantity of goods required or where the appropriate call off dates are not specified, each call off will be deemed to conclude a separate contract upon the Contract Terms. Without limiting the generality of any of the other Contract Terms the Company will not be under any liability to the Customer if at the time of any call off by the Customer the Company is unable for whatever reason to supply goods in accordance with the Customers requirements Design etc. a) Where the goods are manufactured in accordance with information or drawings supplied by the Customer or to his design or specification or where standard goods of the Company are altered in accordance with the Customers instructions:- i) No guarantee or warranty is given by the Company as to the practicability, efficiency, safety or otherwise of the Goods (this being without prejudice to any other of the Contract Terms) ii) The Customer will indemnify and keep the Company indemnified against all liability incurred by the Company as a result of such Goods infringing any patent, registered design, copyright, or other like protection of the provision of any statute, statutory instrument or regulation for the time being in force b) No variation by the Company in the specification or design of any Goods shall constitute a breach of contract or impose upon the Company any liability whatsoever c) The Company shall be under no liability whatsoever to the Customer in respect of any loss, damage or claim incurred by or made against the Customer should any goods supplied by the Company infringe any patent, registered design, copyright or other like protection or the provision of any statute, statutory instrument or regulation for the time being in force d) Unless otherwise agreed in writing all patterns, drawings, tools, electronic data, etc., produced by or on behalf of the Company shall remain the property of the Company 5 Risk and Legal Title 6 Services 7 Price 8 Payment 5.1 The Goods shall be at the risk of the Customer from the time of delivery. 5.2 Full legal beneficial and equitable title to and property in the Goods shall remain vested in the Company (even though they have been delivered and risk has passed to the Customer) until: (a) payment in full, in cash or cleared funds, for all the Goods has been received by the Company; and (b) all other money payable by the Customer to the Company on any other account or under the Contract or any other contract has been received by the Company. 5.3 Until title to and property in the Goods passes to the Customer: (a) the Customer shall hold the Goods on a fiduciary basis as the Company's bailee; (b) the Customer shall store the Goods at its premises in a proper manner in conditions which adequately protect, preserve the Goods and insure them without any charge to the Company and not tamper with any identification upon the Goods or their packaging and shall ensure that they are stored adequately from any other goods whether or not supplied by the Company and are clearly identified as belonging to the Company and the Company shall be entitled to examine any such Goods in storage at any time during normal business hours upon giving the Customer reasonable notice of its intention to do so; (c) the Company may at any time on demand and without prior notice require the Customer to deliver the Goods up to the Company and the Company may repossess and resell the Goods if any of the events specified in Condition 14 occurs or if any sum due to the Company from the Customer under the Contract or on any other account or under any other contract is not paid when due; (d) for the purposes of this Condition 5 the Company, its employees and agents will be entitled to free and unrestricted access to any premises owned, occupied or controlled by the Customer and/or any other location where any of the Goods are situated at any time without prior notice; (e) the Company shall be entitled to maintain an action against the Customer for the price of the Goods notwithstanding that title to and property in the Goods has not passed to the Customer; and (f) the Company hereby authorises the Customer to use and/or sell the Goods in the normal course of the Customer's business and to pass good title in the Goods to its customers if they are purchasers in good faith without notice of the Company's rights. This right shall automatically cease on the occurrence of any event set out in Condition 14 and/or if any sum owed to the Company by the Customer is not paid when due. If the Customer sells the Goods prior to paying the full price thereof the Customer shall hold the proceeds of sale on trust for the Company and shall immediately pay the proceeds of the sale into a separate bank account. The Company shall be entitled to call upon the Customer to assign all claims that the Customer may have against purchasers of the Goods from the Customer 5.3 The Company's rights and remedies set out in this Condition 5 are in addition to and shall not in any way prejudice, limit or restrict any of the Company's other rights or remedies under the Contract or in law or equity. 6.1 If the Contract includes the Company undertaking Services, then such Services shall be on the basis of the exclusions set out in Condition 6, 9 and 10 and the warranties set out in Conditions 6.2 and The Company warrants that it will carry out the Services under the Contract with reasonable care and skill. This warranty will be the only warranty given in respect of such Services. 6.3 Where the Company is to per1orm the Services at the Customer's premises, the Customer shall procure safe access to the premises and the provision of adequate power, lighting, heating and other such facilities or supplies for the Company's employees or agents in accordance with the demands of any applicable legislation and as the Company shall reasonably require. 6.4 The Services will be deemed completed and the relevant element of the price accordingly due and payable forthwith when the Company issues a written notice to the Customer confirming such completion or if the Company is available to perform the Services but is prevented from doing so by reason of: (a) the lack of relevant assistance from the Customer (such as lack of availability of test components or parts from the Customer); and/or (b) the condition of the installation site and/or the facilities or the services available therein at the time of agreed provision of the Services. 7.1 Unless otherwise agreed by the Company in writing the price for the Goods or Services shall be the price set out in the Company's price list published on the date of delivery or deemed delivery of the Goods, or completion of performance of the Services 7.2 Unless agreed otherwise the price for the Goods shall be exclusive of any value added tax or other similar taxes or levies and all costs or charges in relation to loading, unloading, carriage and insurance all of which amounts the Customer will pay in addition when it is due to pay for the Goods. 8.1 Payment of the price for the Goods and/or Services is due 30 days after the earlier of the delivery of Goods or provision of Services, or date of invoice. 8.2 Time for payment shall be of the essence. 8.3 No payment shall be deemed to have been received until the Company has received cleared funds. 8.4 All payments payable to the Company under the Contract shall become due immediately upon termination of this Contract despite any other provision. 8.5 The Customer shall make all payments due under the Contract without any deduction whether by way of set-off, counterclaim, discount, abatement or otherwise unless the Customer has a valid court order requiring an amount equal to such deduction to be paid by the Company to the Customer. 8.6 If payments received from the Customer are not stated to refer to a particular invoice, the Company may appropriate such payment to any outstanding invoice addressed to the Customer from the Company. 8.7 The Company may withdraw any credit facility granted by it to the Customer at its sole discretion at any time. 8.8 If any sum due from the Customer to the Company under the Contract or any other contract is not paid on or before the due date for payment then all sums then owing by the Customer to the Company shall become due and payable immediately and, without prejudice to any other right or remedy available to the Company, the Company shall be entitled to: (a) cancel or suspend its performance of the Contract or any order including suspending deliveries of the Goods and suspending delivery of any other goods to the Customer and suspending provision of the Services until arrangements as to payment or credit have been established which are satisfactory to the Company; (b) appropriate any payment made by the Customer to such of the Goods or such of the Services (or any goods or services supplied under any other contract between the Customer and the Company) or as the Company may think fit; (c) require the Customer to pay for Goods prior to their despatch or collection from the Company's premises; (d) suspend performance of Services remaining to be carried out; and (e) charge the Customer: (f) interest calculated on a daily basis on all overdue amounts (both before and after judgment) until actual payment at the rate of eight per cent (8%) per annum above the base lending rate of Barclays Bank Plc prevailing from time to time until payment is made in full; (g) the cost of obtaining judgement or payment to include all reasonable professional costs (including legal fees) and other costs of issuing proceedings or otherwise pursuing a debt recovery procedure.

96 9 Quality 9.1 If the Customer establishes to the Company s reasonable satisfaction that there is a defect in the materials or workmanship of the Goods manufactured or there is some other failure by the Company in relation to the conformity of the Goods with the Contract or the Services have not been performed with reasonable care and skill then the Company shall at its option and within a reasonable time at its sole discretion either: (a) repair or make good such defect or failure in such Goods or re-perform such Services free of charge to the Customer (including all costs of transportation of any Goods or materials to and from the Customer for that purpose); (b) replace such Goods with Goods which are in all respects in accordance with the Contract; or (c) issue a credit note to the Customer in respect of the whole or part of the purchase price of such Goods or Services as appropriate having taken back such Goods or materials relating to such Services subject in every case to the remaining provisions of this Condition 9 provided that the liability of the Company under this Condition 9 shall in no event exceed the purchase price of such Goods or Services and performance of anyone of the above options shall constitute an entire discharge of the Company's liability under this warranty. 9.2 Condition 9.1 shall not apply unless the Customer: (a) notifies the Company in writing of the alleged defect within 7 days of the time when the Customer discovers or ought to have discovered the defect and in any event within 12 months of the delivery of the Goods or 3 months of performance of Services to the Customer or such other periods as agreed by the Company in writing; and (b) affords the Company a reasonable opportunity to inspect the relevant Goods or the location at which the Services were performed and, if so requested by the Company and where it is reasonable to do so, promptly returns to the Company or such other person nominated by the Company a sample of the Goods or materials relating to the Services within 14 days, carriage paid by the Customer, for inspection, examination and testing and/or otherwise permit the Company to have access to the Goods or such materials at the Customer's premises or other location where they may be or the Services were performed for such purposes. 9.3 If the Company elects to replace the Goods or re-perform the Services the Company shall deliver the replacement Goods to or re-perform the Services for the Customer at the Company s own expense at the address to which the defective Goods were delivered and the title to the defective Goods which are being replaced shall (if it has vested in the Customer) re-vest in the Company and the Customer shall make any arrangements as may be necessary to deliver up to the Company the defective Goods which are being replaced or materials relating to the previously performed Services to the Company. 9.4 The Company shall be under no liability under the warranty at Condition 9.1 above: (a) in respect of any defect arising from fair wear and tear, wilful damage, negligence, abnormal working conditions, failure to follow the Company s instructions (whether oral or in writing), failure to follow the Company s recommended maintenance programme, misuse or alteration or repair of the Goods without the Company's approval; (b) if the total price for the Goods or Services has not been paid by the due date for payment; (c) for any parts, materials or equipment not manufactured by the Company, in respect of which the Customer shall only be entitled to the benefit of any such warranty or guarantee as is given by the manufacturer to the Company to the extent to which it is assignable; (d) in respect of any components or type of wear specifically excluded by the Company by notice in writing; or (e) if the Goods were not correctly installed in accordance with the Company's instructions, or were not installed by an installer approved by the Company. 9.5 The terms of Condition 9 are subject to any amendment or superseding warranty made by notice in writing from the Company to the Customer. 10 Limitation of Liability 10.1 Subject to Condition 9, the following provisions set out the entire liability of the Company (including any liability for the acts or omissions of its employees, agents and sub-contractors) to the Customer in respect of: (a) any breach of these Conditions or the Contract; and (b) any representation, statement or tortuous act or omission including negligence arising under or in connection with the Contract All warranties, conditions and other terms implied by statute or common law (save for the conditions implied by, in relation to Goods, section 12 of the Sale of Goods Act 1979 and, in relation to Services, Section 2 of the Supply of Goods and Services Act 1982) are, to the fullest extent permitted by law, excluded from the Contract Nothing in these Conditions excludes or limits the liability of the Company for death or personal injury caused by the Company's negligence, or fraudulent misrepresentation (save that in respect of any fraudulent misrepresentation, the Customer's remedy shall be limited to damages). THE CUSTOMER'S ATTENTION IS IN PARTICULAR DRAWN TO THE PROVISIONS OF CONDITION Safety 10.4 Subject to Conditions 10.2 and 103: (a) the Company's total liability in contract, tort (including negligence or breach of statutory duty), misrepresentation or otherwise, arising in connection with the performance or contemplated performance of this Contract shall be limited to 120% of the price of the Goods/Services in respect of which the Customer suffered or incurred such loss or damage; and (b) the Company shall not be liable to the Customer for any loss of profit or other economic loss (direct or indirect), indirect or consequential loss or damage, costs, expenses or other claims for consequential compensation whatsoever (howsoever caused) or loss or damage (contractual, tortious, breach of statutory duty or otherwise) which arise out of or in connection with the Contract, or for any liability incurred by the Customer to any other person for any economic loss, claim for damages or awards howsoever arising from the Goods, Services or otherwise The price of the Goods/Services has been calculated on the basis that the Company will exclude or limit its liability as set out in the Contract and the Customer by placing an order agrees and warrants that the Customer shall insure against or bear itself any loss for which the Company has excluded or limited its liability in the Contract and the Company shall have no further liability to the Customer The Customer shall comply at all times with the written instructions and all written guidelines issued from time to time attached to the Goods concerning their storage, application, installation, repair, maintenance and use and the Customer shall refer its employees and its customers to such instructions and guidelines. The Customer shall ensure that the Goods are only installed by those persons approved by the Company The Customer should satisfy itself that the persons responsible for the storage, application, installation, use, repair or maintenance of any Goods supplied by the Company have all the information required on health and safety and the Company shall not be liable to the Customer in any civil proceedings brought by the Customer against the Company in respect of a breach of the user Instructions or any health and safety regulations, orders or directions made pursuant to the Health & Safety at Work Act Etc. Act 1974 or any other directive regulation order or other instrument relating to health and safety where such exclusion of liability is permitted by law If the Company notifies the Customer in writing of any defect in the Goods previously delivered to the Company or Services previously performed at any time or any error or omission in the instructions for the use and/or assembly or installation of the Goods (whether or not any such defect, error or omission represents a breach of the warranty in Condition 6 or 9 or any other provision of the Contract) which exposes or may expose consumers to any risk of death, injury or damage to property, the Customer shall co-operate fully and promptly with any steps taken by the Company under Condition 11.4 below The Company may at its discretion recall any Goods already sold by the Company to its customers (where for a refund or credit or for replacement of the Goods which shall in each case be undertaken by the Company) and/or Issue any written or other notification to its customers about the manner of use or operation of any Goods already sold by the Customer to its customers and/or offer to reperform Services previously quoted The Customer, acknowledging the importance of this Condition 11, agrees that in addition to any other remedy available to the Company to irrevocably and unconditionally indemnify the Company and its employees, servants or agents on full and on demand and keep them indemnified from and against all claims, demands, actions, proceedings and all damages, losses, costs and expenses (including without limitation legal and other professional adviser's fees and all economic loss whether direct or indirect (including without limitation loss of profit, future revenue, reputation or goodwill and anticipated savings) which are made or brought against or incurred or suffered by any of them directly or indirectly and whether wholly or in part result from the Customer's breach of Conditions 11.2, 11.2 and 11.3 whether or not such losses or consequences of such breach were foreseeable at the time of creation of the Contract. This indemnity shall cover all consequential and indirect losses suffered by the Company and its employees, servants or agents and they shall have no duty to mitigate any such loss. 12 Subcontracting, Assignment and Third Party Rights 12.1 The Customer shall not be entitled to assign, charge, subcontract or transfer the Contract or any part of it without the prior written consent of the Company The Company may assign, charge, subcontract or transfer the Contract or any part of it to any person A person who is not a party to the Contract (including without limitation any employee, officer, agent, representative or sub contractor of either party) shall not have any right to enforce any term of the Contract which expressly or by implication confers a benefit on that person without the express prior agreement in writing of the Company and the Customer. 13 Force Majeure The Company reserves the right to defer the date of delivery or to cancel the Contract or reduce the volume of the Goods or Services ordered by the Customer (without liability to the Customer) if it is prevented from or delayed in the carrying on of Its business and its obligations under the Contract due to circumstances beyond the reasonable control of the Company including, without limitation, acts of God, governmental actions, war or national emergency, riot, civil commotion, fire, explosion, flood, epidemic, lock-outs, strikes or other labour disputes (whether or not relating to either party's workforce), or restraints or delays affecting carriers or inability or delay in obtaining supplies of adequate or suitable materials ('Force Majeure') provided that, if the event of Force Majeure continues for a continuous period in excess of 3 months, the Customer shall be entitled to give notice in writing to the Company to terminate the Contract. 14 Breach of Contract or Insolvency 15 Notices 16 General 14.1 If any of the following events occurs: (a) the Customer commits a material breach of any of its obligations under the Contract which is incapable of remedy or fails to remedy a breach, where it Is capable of remedy, or persists in any breach of any of its obligations under the Contract after having been requested in writing by the Company to remedy or desist from such breach within a period of 14 days; (b) any distress execution or diligence is levied upon any of the Customers goods or property and is not paid out within 7 days or it being levied; (c) the Customer (being a partnership) or the Customer s partner offers to make any arrangements with or for the benefit of the creditors of the Customer or the Customer s partner generally or there is presented in relation to the Customer or the Customer's partner a petition of bankruptcy; (d) the Customer (being a limited company) is deemed to be unable to pay its debts within the meaning of Section 123 of the Insolvency Act 1986 or the Customer calls a meeting for the purpose of passing a resolution to wind up its company, or such a resolution is passed or the Customer presents or has presented a petition to wind up or present or have presented a petition to appoint an administrator or have an administrative receiver or receiver appointed to the whole or any part of the Customer's business, undertaking, property or assets; (e) the Customer ceases, or threatens to cease, to carry on business; or (f) the Company reasonably believes that any of the events specified in Condition 14.1 (a) to (e) above is about to occur in relation to the Customer; then the Company may, as it thinks fit, (without prejudice to any other rights or remedies it may have against the Customer) immediately suspend further performance of the Contract or cancel any outstanding provision of the Services or delivery of the Goods or stop any Goods in transit or by notice in writing to the Customer terminate the Contract without liability to the Company Notwithstanding any such termination or suspension in accordance with Conditions 13 or 14.1 above the Customer shall pay the Company at the contract rate for all Goods delivered or Services provided up to and including the date of suspension or termination and termination of any Contract for whatever reason shall not affect the rights or remedies of either party in respect of any antecedent breach or in respect of any such owing or to become owing to the other All communications between the parties about this Contract must be in writing and delivered by hand or sent by pre-paid first class post or sent by facsimile transmission: (a) (in case of communications to the Company) to its registered office or such other address as shall be notified to the Customer by the Company in accordance with this Condition 15; or (b) (in the case of the communications to the Customer) to the registered office of the addressee (if it is a company) or (in any other case) to any address of the Customer set out in any document which forms part of this Contract or such other address as shall be notified to the Company by the Customer in writing Communications shall be deemed to have been received: (a) if sent by pre-paid first class post, 2 Working Days after posting (exclusive of the day of posting); (b) if delivered by hand, on the day of delivery or if that is not a Working Day, the first Working Day after delivery; (c) if sent by facsimile transmission, at 10:00am local time on the first Working Day following despatch, subject to being able to show that the notice was sent to the correct telephone number Communications addressed to the Company shall be marked for the attention of the Commercial Manager 16.1 Any intellectual property rights (including, without limitation, patents, registered and unregistered designs, trade marks and service marks (registered or not) and copyright) created by the Company in the course of the performance of the Contract or otherwise in the manufacture of the Goods or the provision of the Services shall remain the Company's property. Nothing in the Contract shall be deemed to have given the Customer a licence or any other right to use any of the intellectual property rights of the Company Nothing in the Contract shall create, or be deemed to create a partnership or joint venture or relationship of employer and employee or principal and agent between the parties The rights and remedies of either party in respect of the Contract shall not be diminished, waived or extinguished by the granting of any indulgence, forbearance or extension of time granted by such party to the other nor by any failure of, or delay by the said party in ascertaining or exercising any such rights or remedies. The waiver by either party of any breach of the Contract shall not prevent the subsequent enforcement of that provision and shall not be deemed to be a waiver of any subsequent breach of that or any other provision If at any time anyone or more of the Conditions of the Contract (or any sub-condition or paragraph or any part of one or more of these Conditions) is held to be or becomes void or otherwise unenforceable for any reason under any applicable law, the same shall be deemed omitted from the Contract and the validity and/or enforceability of the remaining provisions of the Contract shall not in any way be affected or impaired as a result of that omission The Contract sets out the entire agreement and understanding between the Customer and the Company in connection with the sale of the Goods and shall supersede and replace all documentation previously issued by the Company purporting to set out its terms and conditions of sale of the Goods The Contract shall be governed by and be construed in all respects in accordance with English law and the Customer and the Company both hereby irrevocably agree to submit to the exclusive jurisdiction of the English Courts.

97 Webasto Thermo & Comfort UK Limited Webasto House, White Rose Way Doncaster Carr South Yorkshire DN4 5JH Tel: (0) info-uk@webasto.com