Daikin McQuay. Applied PTAC Air Conditioner and Heat Pump. PDAA, PDAE, PDAF, PDAN, PDHA, PDHE, PDHF Design 3

Transcription

1 Replacement Parts List No Revision G 02/204 Daikin McQuay Applied PTAC Air Conditioner and Heat Pump PDAA, PDAE, PDAF, PDAN, PDHA, PDHE, PDHF Design 3 To find your Daikin Applied parts distributor, call or visit

2 Contents Parts List Revision History... 3 Nomenclature Serial Number... 4 Unit Model Number... 4 Electrical Legend... 5 Unit Assembly Diagram... 6 Electric Heat... 6 Base Pan, Seals, Drain Valve... 7 Drain Pan... 7 Discharge Plenum Seals Refrigeration Circuit Compressor, Evaporator Coil, Condenser Coil, Capillary Tube, Reversing Valve & Solenoid PDHA, PDHE, PDHF... Compressor, Evaporator Coil, Condenser Coil, Capillary Tube PDAA, PDAE, PDAN, PDAF... 2 Compressors, Compressor, Overload, Terminal, Mounting Components... 3, 4 Dampers Manual Damper- Code 09= MY... 5 Automatic Damper- Code 09= AY, CY, GY... 6 Automatic Damper With Boost Fan- Code 09= AA, CA, GA... 7 Fan Assembly Indoor- Fan, Motor, Bearing, Deflector... 8 Outdoor- Fan, Motor, Housing... 9 Control Box... 20, 2 Cabinets Flat Top Cabinet- PDAF, PDHF (Code = CBYYY) Slope Top Cabinet- PDAA, PDHA (Code = BBYYY) Retrofit Panel/Grilles for EA/RS/MQT/PMEG/PMES/PMRS- Replacement Unit (Code = DBYYY) Field Installed Accessories Critical Parts List... CPL PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 2

3 Parts List Revision History Revision Date Description NEW 07/ New A 9/ Page 2- Ref 2 Change premium controls p/n to B 0/ Formatted Serial Number. Page 2- Changed Thermistor description from outdoor to indoor for p/n Changed Thermistor description from indoor to outdoor for p/n C 2/2 Title Page- Delete the 3 after the unit models. Page CPL Delete the 3 after the unit models. D 4/2 Rebrand the title page and CPL page. Page 2- Ref #500, Change Evaporator Coil to Condenser Coil. Page 8- Footnote number change switch footnotes 5 & 6. Page 23- Ref#0, Change panel p/n to Page 29- Remove Bracket from the Retrofit & installation Kits. E /3 Change all drawings to CS6 format. Page 30-Delete Louver Kit p/n and Louver only p/n Page 23- Ref 0 Change front panel p/n to Delete front panel p/n Change top panel p/n to F 5/3 Deleted all Sheet metal and added note. Changed 0 Digit p/ns to 9 digit numbers. Page 2- Thermistor p/n add descriptions IAS, ICS. Thermistor p/n add descriptions OAS, OCS. CPL- Thermistor p/n add descriptions IAS, ICS. Thermistor p/n add descriptions OAS, OCS. G 2/4 Update to Daikin Applied. Page 8- Delete filters already on page 27. Page 26- Delete mesh filter p/n already on page 27. Page 27- Delete filter p/n not used. Daikin Applied, 3600 Industrial Park Blvd., P.O. Box 55, Minneapolis, MN (763) PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 3

4 Plant Identification Abbreviation AUB = Auburn U= Unit Nomenclature Serial Number AUB U Year of Manufacture 0= 200 = 20 etc. Serial Number (build sequence) Week of Manufacture Unit Model Number PDAA E M A EYAY YY BPUY BBYYY LY YYY YYYY YYYY A A Code 0 & Unit Type & PDHF= PTAC Dual Motor HP w/flat Top 02 PDAA= PTAC Dual Motor AC w/slope Top PDAE= PTAC Dual Motor AC EA/RS Style PDAF= PTAC Dual Motor AC w/flat Top PDAN= PTAC Dual Motor AC NYC Style PDHA= PTAC Dual Motor HP w/slope Top PDHE= PTAC Dual Motor HP EA/RS Style 03 Design Series 3= Design 3 04 Unit Size (000's BTU's) 007= 7000 BTU 02= 2000 BTU 009= 9000 BTU 05= 5000 BTU 07= 7000 BTU (Cooling only) 05 Voltage A= 5/60/ E= 208/230/60/ J= 265/60/ P= 208/230 w/5-60- Stand By 06 Always M 07 Refrigerant A= R40A 08 Heating Options E Y Y Y Always Y Electric Heat Size A= 2.5 KW C= 5.0 KW B= 3.5 KW Y= None Hydronic Heat Type H- Hot Water Top Mount NO J- Hot Water Sub Base- NO S= Steam Top Mount- NC T= Steam Sub Base- NC Y= None Heat Type A= Hydonic w/intermediate Electric E= Electric Heat H= Hydonic Heat Y= None 09 Damper Type YY= None MY= Manual Damper GY= Automatic Damper 230V CY= Automatic Damper 208V AY= Automatic Damper 5V or 265V GA= Automatic Damper 230V w/fa Boost Fan CA= Automatic Damper 208V w/fa Boost Fan AA= Automatic Damper 5 or 265V w/fa Boost Fan 0 Controls YYYY= None PPWY= Premium Programmable Wall Mtd. PPUY= Premium Programmable Unit Mtd. PPRY= Premium Programmable Infrared PNWY= Premium Non-Program. Wall Mtd. PNUY= Premium Non-Program. Unit Mtd. PNRY= Premium Programmable Infrared BPWY= Basic Programmable Wall Mtd. BPUY= Basic Programmable Unit Mtd. BPRY= Basic Programmable Infrared BNWY= Basic Non-Program. Wall Mtd. BNUY= Basic Non-Program. Unit Mtd. BNRY= Basic Non-Program. Infrared Note- 4th digit may be used for: (A= Pack, B= 0 Pack or C = 50 Pack) Application Type BBYYY= Slope Top/Bottom RA BFYYY= Slope Top/Front RA CBYYY= Flat Top/Bottom RA CFYYY= Flat Top/Front RA ABYYY= New York Style/Bottom RA AFYYY= New York Style/Front RA DBYYY= Replacement/Bottom RA DFYYY= Replacement/Front RA (EA/RS/MQT/PMEG/PMES/PMRS) 2 Power Connection SY= Short Cord LY= Long Cord LA= Long Cord Inline LCDI LB= Long Cord Plughead LCDI SA= Short Cord Inline LCDI SB= Short Cord Pluhead LCDI YY= None 3 Upgrade Packages SYY= Seacoast 4 Always YYYY 5 Always YYYY 6 SKU Type A= Stock B, C, Q= Build to Order 7 Warranty PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 4

5 Electrical Legend Sch. Sym. C C2 C3 CM CT DM EHC HFLO IAS ICS IFM LUI MP OAS OCS OFM REV Description Capacitor- Indoor Motor Capacitor- Outdoor Motor Capacitor- Compressor Compressor Motor Control Transformer Damper Motor Electric Heat Contactor Heat Fan Lockout Sensor Indoor Air Sensor Indoor Coil Sensor Indoor Fan Motor Local User Interface Motor Protector Outdoor Air Sensor Outdoor Coil Sensor Outdoor Fan Motor Reversing Valve (PDHP) PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 5

6 Unit Assembly Diagram Indoor Blower Plenum Outdoor Coil (Condenser Coil) Indoor Coil (Evaporator Coil) Compressor & Refrigeration Tubing Cabinet Controls Drain Pan Electric Heat Diagram & Components Base Pan Evaporator Coil 700 Unit Voltage & Electric Heat Option.6kw 2.5kW 3.2kW 3.5 kw 5.0kW Ref Part Part No. Description Number 700 Electric Heater Assy Electric Heater Assy Electric Heater Assy Electric Heater Assy Electric Heater Assy V 208/230V 208/230V 208/230V 265V 5V 208/230V 265V Ref. Part Part No. Description Number Quanity 730 Grommet Bushing- Electrical Bushing- Electrical PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 6

7 Base Pan, Seals, Drain Valve Diagram & Components Top View End View Drain Valve Detail Bottom View (Replacement Application Only) 5 30 Base Pan- Standard Code 3= YYY or AYY Base Pan- Seacoast Code 3= SYY or BYY Seal- LH Code = DBYYY Seal- RH Code = DBYYY Seal- Condenser Seal- Bulkhead Valve- Drain Screw Spacer Flange- Bottom 2 Code = BBYYY Gasket- Bottom Flange 2 Code = BBYYY EA/RS/PMES/PMRS/PMEG/MQT replacement applications only. 2 Standard Unit (non- replacement) application only. Drain Pan Diagram & Components 00 Drain Pan PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 7

8 Discharge Plenum Seals Diagram & Components PDAA, PDHA Plenum Mounting Gasket Detail Standard Slope Top Unit (C= BBYYY) 320 Plenum Gasket Detail Plenum Plenum (see detail to right) Evap Coil End View 27 N/S Gasket- Bottom Flange Gasket- Discharge Gasket- Discharge Back Gasket- Discharge Front Gasket- Discharge Side Gasket- Top Flange Gasket- Side Flange Gasket- Bulkhead Top Plenum Mounting Gasket Detail EA/PMES/PMRS/RS/PMEG/MQT Replacement Unit (C= DBYYY) 320 Plenum (see detail to right) Plenum Gasket Detail Plenum Evap Coil Gasket- Discharge Gasket- Discharge Gasket- Discharge Front Gasket- Discharge Side Gasket- Side Flange N/S Discharge Screen A PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 8

9 Discharge Plenum Seals Diagram & Components PDAN Plenum Mounting Gasket Detail New York Style Unit (C= BBYYY) Plenum (see detail to right) Evap Coil Plenum Gasket Detail Plenum 29 N/S Gasket- Bottom Flange Gasket- Discharge Gasket- Discharge Back Gasket- Discharge Front Gasket- Discharge Side Gasket- Top Flange Gasket- Side Flange Gasket- Bulkhead Top PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 9

10 Discharge Plenum Seals Diagram & Components PDAF, PDHF Plenum Mounting Gasket Detail Flat Top Style Unit (C= CBYYY) Plenum (see detail to right) N/S Gasket- Bottom Flange Gasket- Discharge Gasket- Discharge, Front & Back Gasket- Discharge, Right & Left N/S Gasket- Discharge, Top Side Gasket- Top Flange Gasket- Side Flange, Right & Left Gasket- Bulkhead Top PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 0

11 Refrigeration Circuit- PDHA, PDHE, PDHF Compressor, Evaporator Coil, Condenser Coil, Capillary Tube, Reversing Valve & Solenoid Diagram & Components Top View Capillary Tube (see below) End View 00 Condenser Coil Reversing Valve (see below) 0 Compressor 500 Evaporator Coil Capillary Detail 22 Piping Detail Compressor Unit Size No. Number Compressor see next page 22 Capillary Tube Capillary Tube Capillary Tube Capillary Tube Capillary Tube Capillary Tube Capillary Tube Capillary Tube Check Valve Adapter Fitting A 29 Strainer Condenser Coil Outdoor Standard C3= YYY or AYY Seacoast C3= SYY or BYY Reversing Valve Solonoid Coil, Reversing Valve Evaporator Coil Indoor PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page

12 Refrigeration Circuit- PDAA, PDAE, PDAN, PDAF Compressor, Evaporator Coil, Condenser Coil, Capillary Tube Diagram & Components Top View Capillary Tube (see below) End View Condenser Coil 00 0 Compressor Capillary Detail 500 Evaporator Coil Unit Size No. Number Compressor see next page 22 Capillary Tube Capillary Tube Capillary Tube Capillary Tube Capillary Tube Fitting- Adapter Strainer Condenser Coil Outdoor Standard C3= YYY or AYY Seacoast C3= SYY or BYY Condenser Coil Indoor PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 2

13 Refrigeration Circuit- Compressors Compressor, Overload, Terminal, Mounting Components Diagram & Components Compressor Detail Compressor Compressor Unit Sizes 009, 02, 05, 07 Unit Size 007 Bottom View Terminal, Overload Detail PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 3

14 Refrigeration Circuit- Compressors Compressor, Overload, Terminal, Mounting Components Components Unit Size Ref Part Part No. Description Number 0 Compressor 6450 BTU Compressor 6450 BTU Compressor 6450 BTU Compressor 8600 BTU Compressor 8700 BTU Compressor 8700 BTU Compressor 200 BTU Compressor 9800 BTU Compressor 200 BTU Compressor 200 BTU Compressor 8200 BTU Grommet Grommet Compressor Pad- Adhe sive Backed Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Overload- Compressor Gasket- Washer Gasket- Washer Cover- Terminal Cover- Terminal Cover- Terminal Gasket- Terminal Cover Gasket- Terminal Cover Spring- Overload Hold Down Nut Nut Adapter Plate- Compressor Screw- Adapter Plate N/S Wire- Overload Jumper Screw/Sleeve Assy Sleeve Washer V 208/230V 265V 5V 208/230V 265V 5V 208/230V 265V 208/230V 265V 208/230V PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 4

15 Damper- Manual Code 09= MY Diagram & Components Back View Front View Door- Damper 30 Panel- Damper Door 305 Rod- Link Bracket- Rod Spring Rod- Hinge Screen Seal- Door Nut Speed Nut Screw Cap- Damper Insulation- Damper Door Please contact Daikin Applied with unit model and serial number for part numbers on Chassis components. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 5

16 Damper- Automatic Code 09= AY, CY, GY Diagram & Components Motor, Coated- Damper 5V Motor Only Motor, Coated- Damper 208V Motor Only Motor, Coated- Damper 240V Motor Only Motor, Coated- Damper 265V Motor Only Bracket- Actuator Sleeve Door- Damper 30 Panel- Damper Door 306 Rod- Link Spring Rod- Hinge Screen Seal- Door Nut- Spring Washer Arm- Lever Insulation- Damper Door Please contact Daikin Applied with unit model and serial number for part numbers on Chassis components. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 6

17 Damper- Automatic With Boost Fan Code 09= AA, CA, GA Diagram & Components Motor, Coated- Damper 5V Motor Only Motor, Coated- Damper 208V Motor Only Motor, Coated- Damper 240V Motor Only Motor, Coated- Damper 265V Motor Only Bracket- Actuator Door- Damper 30 Panel- Damper Door 306 Rod- Link Bracket Spring Rod- Hinge Screen Seal- Door Nut- Spring Washer Arm- Lever Fan- Boost 5V Fan- Boost 208/230V Fan- Boost 265V Insulation- Damper Door Please contact Daikin Applied with unit model and serial number for part numbers on Chassis components. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 7

18 Fan Assembly- Indoor Fan, Motor, Bearing, Deflector Diagram & Components Motor Detail , 009, 02, 05 Motor 625 Ref Part Unit Voltage Qty. No. Description 5V 208/230V 2 265V Motor- Indoor (Evaporator) 5 Unit Sizes 007, 009, 02, Unit Size 07 N/A N/A 625 Mount- Motor only Fan Housing- Front Fan Housing- Back Deflector Baffle- Air Baffle- Air Fan- Tangential Bearing Assy Clip- Filter Retainer Code 5= A or P. 2 Code 5= E. 3 Code 5= J. 4 Each motor has one () ground wire terminal p/n and one () 6-wire/connector harness assy p/n Hi Lo Motor Option (code 3= SAY, AAY, BAY, YAY) are p/n (5V), (208/230V), (265V). PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 8

19 Fan Assembly- Outdoor Fan, Motor, Housing Diagram & Components Motor Mount Detail Condenser Coil (see Refrigeration Section) Ref Part Unit Voltage Qty. No. Description 5V 208/230V 2 265V 3 22 Motor- Outdoor (Condenser) Unit Sizes 007, Unit Sizes 02, Unit Size 07 N/A N/A 24 Mount- Motor Screw Nut Lock Washer Grommet Grommet Spacer Housing, Fan Fan Prop Plate- Louver Screw Washer Screw Code 5= A. 2 Code 5= E or P. 3 Code 5= J. 4 Each motor has one () ground wire terminal p/n and one () 4-wire/connector harness assy p/n PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 9

20 Control Box Diagrams LUI- Unit Mounted in Control Door of Cabinet (see diagram on page after next) or Wall Mounted A 05 Stand by only (Code 5= P) PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 20

21 Control Box Components Unit Size Ref Part Part No. Description Number 2 Control Board- Digital Basic Controls C0= B**Y Premium Controls C0= P**Y Bracket- Compressor Capacitor Strain Relief Standoff- Control Board Bushing Screw Grommet Local User Interface LUI Programmable C0 digit 2= P Non-Programmable C0 digit 2= N Transformer 30VA Transformer 30VA Transformer 30VA Capacitor- Indoor Motor 440V V V Capacitor- Compressor C3 370V V V V V V V V V Capacitor- Outdoor Motor C2 440V V V V Contactor- Electric Heat EHC Terminal Block TB/TB A Terminal Block TB3/TB N/S Kit Power Connection, Stand By, APTAC Screw Screw- Terminal Block /blk /blk /blk /blk /blk /blk /blk /blk /blk /blk /blk /blk 96 Screw N/S Cable, Communications- LUI N/S Thermistor- IAS, ICS K N/S Thermistor- OAS, OCS 0K N/S Thermistor- HFLO 0K N/S Wire Harness, Hydronic Valve N/S Cord Set 2 This Terminal Block is used only on units with Stand By Power (Code 5= P). 2 The Cord Set required for the unit is contingent on unit voltage, unit size and the size of the electric heater (if unit has heat). Contact Daikin Applied with the unit GO and/or serial number to insure that the correct replacement is selected. 5V 208/230V 265V 5V 208/230V 265V 5V 208/230V 265V 208/230V 265/V 208/230V PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 2

22 Cabinet- Flat Top PDHP, PDAC, PDAF, PDHF (Code = CBYYY) Diagram & Components Local User Interface see previous page 0 Panel- Front, Bottom Return Air Panel- Front, Front Return Air 40 Support, Brace Support, Filter- Left Hand Grille Gasket- Filter Bracket Screw Screw Wrap Panel Control Door Assembly Please contact Daikin Applied with unit model and serial number for part numbers on Cabinet components. 2 Not used on Front Return Air option, Ref # 90 and 20. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 22

23 Cabinet- Slope Top PDHP, PDAC, PDAA, PDHA (Code = BBYYY) Diagram & Components LUI Mounting Detail NOTE: For PDAN (NYC) Cabinet Kits- see FIA, 6 pages after next Local User Interface see previous page 0 Panel- Front 30 Panel- Top 50 Panel, End- Left Hand 70 Panel, End- Right Hand 90 Support, Filter- Left Hand Support, Filter- Right Hand Frame- Door Blockoff Unit Mounted LUI Code 0= BPUY,BNUY,PPUY,PPNY Wall Mounted LUI Code 0= BPWY,BNWY,PPWY,PPWY 45 Panel- Water Deflector Door- Control Grille Cap- End Gasket- Filter Bracket Screw Screw Fastener Please contact Daikin Applied with unit model and serial number for part numbers on Cabinet components. Retrofit Panel/Grilles for EA/RS/MQT/PMEG/PMES/PMRS Replacement Unit (Code = DBYYY) Description Part Number Qty. Control Door Kit No Lock EA Units Control Door Kit With Lock EA Units Front Panel/Grilles Kit for putting PDAC/PDHP in existing sleeve for EA/RS/MQT/PMEG/PMES/PMRS PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 23

24 Field Installed Accessories 3" High Subbase- Electric Heat Units Complete Assemblies Description Unit Unit Part Size Voltage Number Std. Subbase All All w/ds & 5A Receptacle All 208/ w/ds & 20A Receptacle All 208/ w/ds & 25A Receptacle All 208/ w/ds & 30A Receptacle All 208/ w/ds & 5A Receptacle All w/ds & 20A Receptacle All w/ds & 25A Receptacle All Qty. No. Number N/S Subbase Frame N/S Junction Box- 3" N/S Subbase- Front Piece N/S Electrical Barrier N/S Panel N/S Electrical Inspection Panel N/S Electrical Component Panel N/S Rear Base N/S Receptacle Plate Subbase Components Disconnect Switch, Receptacle and Fuse Components Description Part Unit Number Voltage Fuse Holder- 5A Fuse /230/265 Fuse Holder- 20A Fuse /230/265 Fuse Holder- 25A, 30A Fuse /230/265 Fuse- 5A (2) /230/265 Fuse- 20A (2) /230/265 Fuse- 25A (2) /265 Fuse- 30A (2) Receptacle- 5A /230 Receptacle- 20A Receptacle- 20A /230 Receptacle- 30A /230 Disconnect Switch /230 Disconnect Switch 4EAL PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 24

25 Field Installed Accessories, Continued 4" High Subbase- Electric Heat Units Complete Assemblies Description Unit Heater Unit Part Size Code 05 Voltage Number Std. Subbase All All All w/ds & 5A Receptacle All 2 208/ w/ds & 20A Receptacle All 3 208/ w/ds & 25A Receptacle All w/ds & 30A Receptacle All w/ds & 5A Receptacle All w/ds & 20A Receptacle All w/ds & 25A Receptacle All Subbase Components Qty. No. Number N/S Subbase Frame N/S Junction Box- 4" N/S Subbase- Front Piece N/S Electrical Barrier N/S Panel N/S Electrical Inspection Panel N/S Electrical Component Panel N/S Rear Base N/S Receptacle Plate Disconnect Switch, Receptacle and Fuse Components Description Part Unit Number Voltage Fuse Holder- 5A Fuse /230/265 Fuse Holder- 20A Fuse /230/265 Fuse Holder- 25A, 30A Fuse /230/265 Fuse- 5A (2) /230/265 Fuse- 20A (2) /230/265 Fuse- 25A (2) /265 Fuse- 30A (2) Receptacle- 5A /230 Receptacle- 20A Receptacle- 20A /230 Receptacle- 30A /230 Disconnect Switch /230 Disconnect Switch 4EAL PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 25

26 Field Installed Accessories, Continued 8" High Subbase- Hydronic Heat Units 6 7 Front View 4 Top View Ref. Description no w/disconnect w/disconnect Qty. No. disconnect 208/230V 265V Complete Assembly End Gasket Coil- Hydronic Front Gasket Rear Gasket Clamp Gasket N/S Inserts for type N units N/S Fuse Holder N/A N/S Fuse N/A N/S Disconnect Switch N/A EAL4022 N/S Cord Grip N/A N/S Receptacle N/A N/A= Not Applicable. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 26

27 Field Installed Accessories, Continued Hydronic Valve Kits Description Kit Valve Body Actuator Plug P/N 24V 2- ckt. N.O. Hot Water/ 2-Way/ ½" Sweat/ pack N.O. Hot Water/ 2-Way/ ½" Sweat/ 0 pack N.O. Hot Water/ 3-Way/ ½" Sweat/ pack N.O. Hot Water/ 3-Way/ ½" Sweat/ 0 pack N.C. Steam/ 2-Way/ ½" Sweat/ pack N.C. Steam/ 2-Way/ ½" Sweat/ 0 pack Hydronic Coil Kits- PDAN N/S Coil Kit- Top Mounted, Hydronic, NYC Hot Water- LH Supply/ LH Return Coil Only Hot Water- RH Supply/ RH Return Coil Only Hot Water- Opposite End Connection Coil Only Steam- LH Supply/ LH Return Coil Only Steam- RH Supply/ RH Return Coil Only Steam- LH Supply/ RH Return Coil Only Steam- RH Supply/ LH Return Coil Only Receptacles and Plug Covers Ref. Description Unit Pack Kit 0 Pack Kit Receptacle No. Voltage PN PN Only N/S 5A Receptacle 208/230V A Receptacle 208/230V A Receptacle 208/230V A Receptacle 265V Plug/Cord Cover 265V N/A N/A Filters Ref. Description Pack 5 Pack Part No. Kit Kit Number Qty. N/S Filter- Permanent N/S Filter- Permanent C=BBYYY N/A N/A N/S Filter- Mesh Hydronic Subbase N/A N/A PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 27

28 Field Installed Accessories, Continued Wall Sleeves- Slope Top and Flat Top- PD*A, PD*F N/S Wall Sleeve- CWS 6 x Weather Panel Only N/S Wall Sleeve- BWS 6 x Weather Panel Only Base Pan Only Wall Sleeves- New York Style- PDAN N/S Wall Sleeve- New York Style 6 x 42 4¾" Deep N/S Wall Sleeve- New York Style 6 x 42 5¾" Deep N/S Wall Sleeve- New York Style 6 x 42 6¾" Deep N/S Wall Sleeve- New York Style 6 x 42 7¾" Deep N/S Wall Sleeve- New York Style 6 x 42 8¾" Deep N/S Wall Sleeve- New York Style 6 x 42 3¾" Deep N/S Wall Sleeve- NY Style 6 x 42 Insulated 3¾" Deep NOTE: The part numbers listed above are for single pack wall sleeves. The sleeves are also available in multi-packs: 4¾ D, 5¾D, 6¾D are available in 2 packs (last two digits of p/n are 2); 7¾D & 8¾D are available in 9 packs (last two digits of p/n are 09); the 3¾D comes in a 5 pack, p/n ). Combination Room Cabinet & Wall Sleeve- PDAC, PDHP, PDAE, PDHE Ref. Part Part Qty. No. Description Number Complete Kit Grille Assy Gasket- Grille Door- Controls Front Panel Assembly contact Daikin Applied PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 28

29 Field Installed Accessories, Continued Retrofit Kits- ES, RS, MQT Units Existing Sleeve Shown Blockoff N/S Retrofit Kit- MQT, ES, RS Blockoff, Front Panel, Seals Seal- cabinet underside along grill tray Seal- between grille and control door N/S Retrofit Kit- Control Door, No Lock N/S Retrofit Kit- Control Door, With Lock Seal- Control Door used in both kits Lock Only kit N/S Retrofit Kit- EA, MRS, MES Grilles, Front Panel, Seals Seal- cabinet underside along grill tray Seal- between grille and control door Grille Assy Retrofit Kits- EA, MES, MRS Units Retrofit & Installation Kits- PDAN New York Units No. Number N/S Panel, Louvered Front- Front Return N/S Kit, Mounting Plate- Digital Control Retrofit PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 29

30 Field Installed Accessories, Continued N/S Louver Kit- Extruded Architectural, NYC PDAN Louver Only N/S Louver Kit- Flush Stamped, NYC PDAN Louver Only N/S Louver Frame- NYC PDAN Frame Only Outdoor Louvers Room Cabinet/Front Panel- PDAN Units Description Kick Manual Infrared Wall Plate Changeover Remote Stat Room Cabinet/Front Panel 0¾" Deep 4" Room Cabinet/Front Panel 0¾" Deep 6" Room Cabinet/Front Panel 0¾" Deep 8" Room Cabinet/Front Panel 0¾" Deep 0" Room Cabinet/Front Panel ¾" Deep 4" Room Cabinet/Front Panel 2¾" Deep 4" Room Cabinet/Front Panel 3¾" Deep 4" Room Cabinet/Front Panel 4¾" Deep 4" Room Cabinet/Front Panel 5¾" Deep 4" Room Cabinet/Front Panel 6¾" Deep 4" Room Cabinet/Front Panel 7¾" Deep 4" Room Cabinet/Front Panel 8¾" Deep 4" Part Description Number Kit, Assy, Cabinet Conversion PDAN to PDAF Replacement Front Panels for Infrared Receiver Part Description Number Kit, Front Panel only, for IR Receiver, Antique Ivory PDAN Unit Kit, Front Panel only, for IR Receiver, Antique Ivory PDAF Unit Kit, Assy, Front Panel, w/ir Receiver & Remote, Antique Ivory PDAE Unit Replacement Infrared Receiver & Hand-held Remote Control Part Description Number Kit, Conversion, IR Receiver & Hand-held Remote PDAN/PDAF Sensor Only Hand-held Remote Control Only PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 30

31 Field Installed Accessories, Continued Indoor/Outdoor Drain Kit Complete Kit N/S Drain Kit Assy N/S Gasket N/S Gasket Chassis Levelers No. Part No. No. - Pack 5- Pack N/S Chassis Leveler for Plastic G.E. Wall Sleeve for Trane/ Amana Wall Sleeve Climatemaster Extension-.25" Adapter No. Number N/S Extension Kit- Climatemaster Locking Access Cover No. Number N/S Locking Access Cover Kit Lock & Key Only Remote Wall- Mounted Thermostats & Controls Ref. Part No. Description Number N/S Non- Programmable Heat/Cool Manual Changeover Thermostat N/S 7- Day Programmable Manual Changeover Thermostat N/S 7- Day Programmable Auto Changeover Thermostat N/S Optional Remote Sensor for Thermostat N/S Wall Plate , or N/S Kit, T9000 Thermostat-only, Wireless, Programmable N/S Kit, T9000 Thermostat-only, Wireless, Non- Programmable N/S T9000 Wireless RCN & Overlay, A/C only N/S T9000 Wireless RCN & Overlay, HP N/S T9000 Wire Harness, RCN to Unit PC Board * N/S Kit, Remote Thermostat, Field Wiring, Primary/Secondary functioning N/S Kit,Conversion, Unit-mount to Remote, 6 x 42, Slope-top N/S Kit,Conversion, Unit-mount to Remote, 6 x 44, Flat-top N/S Kit,Conversion, Unit-mount to Remote, 6 x 42, Flat-top, NYC w/top Hydro Heat * To retrofit an APTAC with a T9000 Wireless T-stat you need: T9000 Wireless T-stat (qty=), T9000 Wire Harness (qty=) & RCN (qty=). PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 3

32 Field Installed Accessories, Continued Applied PTAC ExtendAire Components & Kits PDAE/PDHE/PDAF/PDHF End Cap 2. Angle Adapter 3. 3' Extension Section 4. Side Plenum 7 5. Baseboard Discharge Section 6. Shelf Discharge Section 7. Primary Discharge Section 8. Trim Piece Description Qty per Kit Part/Kit Number Primary Discharge Section BaseBoard Outlet Assembly Primary Discharge Section Side Plenum 3' Extension Section Baseboard Discharge Section (Right-Hand) (Left-Hand) Trim Piece End Cap 3 Shelf Discharge Assembly Primary Discharge Section 3' Extension Section Shelf Discharge Section Trim Piece 2 End Cap 2 Side Wall Outlet Assembly 2 Primary Discharge Section 3' Extension Section Trim Piece 2 End Cap 2 3' Extension Section Pack 3' Extension Section Trim Piece 2 Angle Adapter Pack Angle Adapter Trim Piece 5 Control door and end cap are included in Primary Discharge Section. 2 Discharge grille in adjoining room to be supplied by others. Side wall discharge, angle adapters and additional 3' extention sections must be ordered in packages. PTAC; PDAA,PDAE,PDAF,PDAN,PDHA,PDHE,PDHF Design 3 Rev. G 02/4 RPL / Page 32

33 Critical Daikin Applied OEM Parts Are What Your HVAC Unit Needs! Daikin PTAC Air Conditioner & Heat Pump McQuay PTAC Air Conditioner & Heat Pump PDAA, PDAE, PDAF, PDAN, PDHA, PDHE, PDHF , Design 3 CRITICAL COMPONENTS MODEL UNIT SIZE VOLTAGE PART NUMBER CONTROLS Control Board Basic ALL ALL ALL Control Board Premium ALL ALL ALL Local Interface (LUI) Non- Programmable ALL ALL ALL Local Interface (LUI) Programmable ALL ALL ALL Solenoid, Reversing Valve ALL ALL ALL COMPRESSOR 6450 BTU ALL 007 5/60/ BTU ALL /230/60/ BTU ALL /60/ BTU ALL 009 5/60/ BTU ALL /230/60/ BTU ALL /60/ BTU ALL /230/60/ BTU ALL /60/ BTU ALL /230/60/ BTU ALL /60/ BTU ALL /230/60/ EVAPORATOR MOTOR Motor, Indoor 75 RPM ALL 007,009,02,05 208/230/60/ Motor, Indoor 75 RPM ALL 007,009,02,05 5/60/ Motor, Indoor 75 RPM ALL 007,009,02,05 265/60/ Motor, Indoor 580 RPM ALL /230/60/ CONDENSER MOTOR Motor, Outdoor 580 RPM ALL 02,05 208/230/60/ Motor, Outdoor 580 RPM ALL 02,05 5/60/ Motor, Outdoor 580 RPM ALL 02,05 265/60/ Motor, Outdoor 20 RPM ALL 007, /230/60/ Motor, Outdoor 20 RPM ALL 007,009 5/60/ Motor, Outdoor 20 RPM ALL 007, /60/ Motor, Outdoor 640 RPM ALL /230/60/ WHEEL Fan Housing- Condenser ALL ALL N/A Fan Prop- Condenser ALL ALL N/A Wheel, Indoor Tangential ALL ALL N/A BEARING Bearing Assembly Indoor fan ALL ALL N/A SENSORS Thermistor- OAS, OCS 0K ALL ALL N/A Thermistor- IAS, ICS K ALL ALL N/A Thermistor- HFLO ALL ALL N/A Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs. To Locate A Distributor, Go To or Call PARTS Rev. G 02/204 CPL Page of