BOILERS GAS FIRED WATER OIL FIRED WATER GAS FIRED STEAM

Transcription

1 OILR G FIRD WTR OIL FIRD WTR G FIRD T PROLCT Force cast iron boilers are offered exclusively by Ferguson. For the stocking branch location nearest you, please call () or go to FRGUON.CO

2 OILR Gas-Fired Cast Iron oilers OILR Dimensions FU Input Rate DO Capacity Net RI Flue Collar (Gallons) pprox. (Pounds) FORC /2" 2" FORC /4" 2" FORC04 " 2" FORC0 1 1/4" 2" FORC0 21 1/2" 2" FORC0 3/4" 30" FORC0 2" 30" FORC /4" 30" FORC /2" 30" NOT 1. tandard piping/control system is located on right side of boiler 2. pecifications and dimensions are subject to change without notice 3. Net RI water ratings shown are based on a piping and pickup allowance of The manufacturer should be consulted before selecting a boiler for installations having unusual piping and pickup requirements, such as intermittent system operation, extensive piping, etc. PROLCT Force boilers are offered exclusively by Ferguson Reliable cast iron heat exchanger using steel nipples to join sections 3, ,000 TUs in 9 sizes uilt-in draft diverter fits in low spaces Industry standard tapping locations, provides drop-in replacement in most installations Can be installed on combustible floors Optional high altitude conversion kit ydrolevel ydrotat 3200 combination high limit/circulator relay control uilt-in LWCO Outdoor reset available (not included) nergy-saving thermal targeting software Grundfos lpha circulator oneywell 10 electronic ignition control & oneywell gas valves utomatic vent damper Roll-out switch, spill switch, relief valve (30 psi) Natural gas build with LP field retrofit kit available s 02, 04 0 part number: part number: s 0 10 part number: Trapezoidal legs with nylon glides permit easy positioning during installation Optional high altitude conversion kit Limited lifetime warranty on heat exchanger, one year manufacturer s warranty on parts 32 1/4" Floor Line 3" 39" Combination Limit /I odule Left ide Front Right ide Vent Damper Gas Valve 1" 1 1/4" upply Relief Valve Temp/Pressure Gauge 1 1/4" Return Drain Valve 1"

3 OILR Gas-Fired Cast Iron team oiler OILR Dimensions (inches) C Flue Collar FU Input Rate DO Capacity Net RI team team (quare Feet) pprox. (Pounds) FORCT /4" 2" 40 /1" FORCT04 1" 2" 40 /1" " FORCT0 19 1/4" 2" 40 /1" " FORCT0 22 1/2" 2" 40 /1" " FORCT0 2 3/4" 30" 40 /1" " FORCT0 29" 30" 40 /1" Natural gas (LP conversion kit available) lectronic ignition uilt-in draft diverter fits in low spaces Cast iron heat exchanger, meets boiler code and pressure vessel code etal section connectors resist chemicals, increase the life of the boiler Fully assembled Fully packaged Insulated jacket Pressure limit PI safety valve oneywell gas valve ydrolevel probe-type LWCO team pressure gauge Flame roll out switch locked vent switch Vent damper Drain valve 10-year limited warranty, 1-year manufacturer s warranty on parts The Net RI team Ratings shown are based on a piping and pickup allowance of The manufacturer should be consulted before selecting a boiler for installations having unusual piping and pickup requirements, such as intermittent system operation, extensive piping systems, etc. Ratings shown are for installations at sea level and elevations up to 2,000 feet.

4 OILR Chimney Chimney 3 11/1" 1 1/2" NPT YT CONNCTION OILR 3 11/1" 3 11/1" IRION WLL IRION WLL Kit Part FORCOL1 FORCOIL19 FORCOIL1 FU, NRGY TR certified 0. to 1.3 GP in four sizes Chimney vented, optional direct vent kit available (sizes 14, 19) 3-pass cast iron heat exchanger Fully-opening, reversible, cast iron swing door Cast iron section connectors Fully packaged Integrated boiler control system 340 RP flame retention eckett oil burner eckett GeniY primary control Return water mixing tube Grundfos lpha circlulator lectronic ignitor 14KV Clean cut fuel pump Tridcator Relief valve Drain valve Integrated lifting legs (for level installation) Lifetime limited warranty on heat exchanger, 1-year manufacturer s warranty on parts Connector Vent (In.) CKTT FG (OWN) FRONT RVIC CLRNC (FLUWY CLNING) 31 /" * DI. COLLR 3/4" TP/PRUR GUG 19" IN. CKTT FG FL ORVTION (OWN) CLRNC (FULLY OPN) ( NOT 3) CKTT FG (OWN) 31 /" TPPING CONNCTION Return fittings and drain valve shipped loose. 3/4" TP/PRUR FRONT RVIC CLRNC GUG (FLUWY CLNING) FL ORVTION CLN OUT COVR 12" IN RR RVIC CLRNC ( NOT 1) RLIF VLV 12" IN1COLLR 1/2" NPT YT RTURN OKOX RR RVIC CONNCTION CLRNC ( NOT 1) OKOX PRUR RLIF TPPING VLV 21 3/" CLN OKOX OUT COVR PRUR TPPING 1 1/2" NPT YT RTURN DI. CONNCTION COLLR FRONT RVIC CLRNC 13 1/4" (FLUWY CLNING) PNNR R W/ DJUTL LG DI. COLLR CLN OUT COVR DRIN VLV OKOX COLLR 21 3/" 31 /" NOT: 1. TI DINION INCR ND I LD Y OKPIP RRNGNT. 2. DRIN VLV ND RLIF VLV/FITTING IPPD LOO. 3. OILR IPPD WIT TNDRD RIGT ND 19" IN. ING CONFIGURTION, UT CN CONVRTD TO LFT ND ING. PPLY CLRNC CCORDINGLY. CLRNC (FULLY OPN) ( NOT 3) 19" IN. CLRNC NOT: (FULLY OPN) 1. TI DINION INCR ND I LD Y OKPIP RRNGNT. ( NOT 3) 2. DRIN VLV ND RLIF VLV/FITTING IPPD LOO. 3. OILR IPPD WIT TNDRD RIGT ND ING CONFIGURTION, UT CN CONVRTD TO LFT ND ING. PPLY CLRNC CCORDINGLY. NOT: 1. TI DINION INCR Dimensions ND I LD Y OKPIP RRNGNT. 2. DRIN VLV ND RLIF VLV/FITTING IPPD LOO. urner Capacity 3. OILR IPPD WIT TNDRD RIGT ND ING CONFIGURTION, UT CN CONVRTD TO LFT ND ING. PPLY CLRNC CCORDINGLY. urner Capacity DO Net 13 1/4" RI Capacity Ratings13 1/4" FU C GP urner 1 Dimensions Capacity 3 DO FORCOL Net RI urner 23 Dimensions Capacity 11.0 Capacity Net Ratings FU RI DO Net DO C FU GP Ratings RI The Net RI Ratings shown are based pipingc and pickup 1.. GP of 1on a allowance Capacity FU Capacity Ratings FORCOL C GP FORCOIL04 1" " " " 30 " FORCOL FORCOIL1 1" on FORCOIL14 " 1.0 pickup 14allowance 129of 1.. The Net RI Ratings23" shown" are based apiping1.0 and 29 30" 30 " FORCOIL19 29" dditional The Net onon a piping andand pickup allowance of 1.. The NetRI RIRatings Ratingsshown shownare arebased based a piping pickup allowance of 1.. Fully packaged Integrated boiler control system 340 RP flame retention eckett oil burner 1 1/2" NPT YT RTURN Dimensions eckett NX Direct Vent ystem Vent Connector * xxchimney Vent ystem Direct xinch Kit Part Vent Connector 1 1/2" NPT YT (In.) CONNCTION NOT Return fittings and drain valve shipped loose. The manufacturer should consulted Chimney Direct Vent be ystem Return fittings and drain valve shipped loose. x unusual before selecting a boiler for installations having piping and pickup requirements, OILR Inch extensive Kit Part Vent Connector 1 1/2" NPT YT such as intermittent system operation, piping, etc. FORCOL1 (In.) CONNCTION x *Choose appropriate flex oil vent pipe ( ft.), length (all have x inch diameter): (10 ft.), ( ft.), (20 ft.) OILR FORCOL1 12" IN RLIF RR RVIC VLV CLRNC 3/4" valve xloose Return fittings and drain( TP/PRUR NOTshipped 1) GUG OKOX PRUR FL ORVTION igh fficiency Cast Iron Oil-Fired oiler Kit Part Inch FORCOIL04 FORCOIL14 IRION WLL Direct Vent Required ccessories lectronic ignitor 14KV Clean cut fuel pump Tridcator Relief valve dditional OKOX COLLR PNNR R W/ pproximate DJUTL LG rea PNNR R W/ DJUTL (q. Ft.)LG 21 3/" DRIN VLV DRIN VLV pproximate rea pproximate pproximate (q. Ft.) rea (Gallons) (Pounds) reafeet) (quare (q. Ft.)

5 FRGUONVC.CO 201 Ferguson nterprises, Inc