Modular Air Cooled Chiller
|
|
- Dayna Ross
- 6 years ago
- Views:
Transcription
1 Technical Manual MAC Modular Air Cooled Chiller Models: MAC160A/AR MAC210B/BR MAC260B/BR Refrigerant Type: R22 Cooling Capacity: 46/6/78kW Heating Capacity: 57/66/82kW
2 Contents Literature No.: TM-MAC-1201A Supersedes: TM-MAC-1101A Part No.: M Nomenclature...2 Features... Specifications...4 Sound Data...17 Operating Limit...18 Performance Data...18 Dimensional Data...22 Wiring Diagrams...24 Refrigerant Circuit...0 Troubleshooting... Exploded View & Part List...4 NOTE: Installation and maintenance are to be performed only by qualified personnel who are familiar with local codes and regulations, and experienced with this type of equipment. Caution: Sharp edges and coil surfaces are a potential injury hazard. Avoid contact with them. Warning: Moving machinery and electrical power hazard may cause severe personal injury or death. Disconnect and lock off power before servicing equipment. McQuay is a registered trademark of McQuay International. All rights reserved throughout the world McQuay International. Bulletin illustrations cover the general appearance of McQuay International products at the time of publication. We reserve the right to change design and construction specifications at any time without notice. 1
3 Nomenclature M AC 160 A RM 4 - F ABE For Oversea Market Description V/ /50Hz 4: R407 Omitted for R22 Master or slave unit M: master unit C: slave unit in mid E: slave unit at end Omitted for single used R: Heat Pump Omitted for cooling only Series Capacity/HP Air Cooled Chiller/Heat Pump McQuay 2
4 Features MAC units are high thermodynamic engineering products, studied with high accuracy in balancing compressors, condensers and evaporators in order to offer high performance and wide safety margins. The choosing of the materials and the equipment adopted for the products has been made without any compromises, taking care of quality and long life purpose. The products meet ISO 9001 and ISO requirements, and assurance beyond any doubt of the high producing standards followed by McQuay. Modular Design MAC160A/AR,MAC210B/BR,MAC260B/BR are maximum designed as the basic modules, different numbers of modules can be combined to satisfy different load. The number of combination is maxium 6 modules, however it's still very convenient to transport and install these units by separating them into single ones. For more than 6 units combination, please contact McQuay Shenzhen factory. High Flexiblity The MAC units are available in size covering a range from 46 to 468 kw nominal cooling capacity. With availability of many accessories, application of high tech control and safety devices, the units are of high flexibility for their installation in commercial, residential and industrial environment. They couple with different types of fan coil units or AHU. This series is ideal for various kinds of application, different areas by modular combination. Low Installation Cost The units are completely assembled at factory which reduces the cost of installation on site. A rigid steel base distributes the weight of the unit to the support points and allows simple installation by an easy access to the lifting points. Compressor McQuay Modular Air Cooled Chiller is equipped with highly efficient, reliable and silent scroll compressor with internal overload protection. The hermetic type compressor is adopted to further eliminate operating noise and vibration. Air-cooled Condenser The two air cooled condenser coils with V-shaped are made of staggered rows of /8" OD seamless copper tube, mechanically expanded into slit aluminum fins to ensure optimum heat exchange capability. Condenser Fan Motor To achieve the high air charge requirement, the unit is equipped with high airflow propeller fan which is made of acryl styrene resin. The fan is driven directly by weatherproof three-phase motor to ensure reliable continuous operation. Evaporator The heat exchanger is made of stainless steel plates closely arranged and brazed together to ensure high heat exchange efficiency. The whole heat exchanger is insulated with thermal closed cell nitric rubber foam to give optimum thermal insulation. Refrigerant Circuit The refrigerant circuit is factory brazed and evacuated before accurately charged with R22 or R407C to ensure optimum operating requirement. To ensure flawless continuous operation, each refrigerant circuit is equipped with a carefully sized thermostatic expansion valve, or a capillary tube. Additional Safety Protection The modular air-cooled chillers are equipped with intelligently designed safety control to ensure continuous safe operation. High and low pressure switch is provided to prevent the compressor damage resulting from both abnormal high discharge head pressure and low pressure due to insufficient gas. In addition, thermal and current overload protector are supplied with the units as well as phase sequencer protector.
5 Specifications Modular Air Cooled Chiller Cooling Only MODEL (50HZ) MAC160A/AM/AC/AE MAC210B/BM/BC/BE MAC260B/BM/BC/BE Btu/h 157, , ,000 Nominal COOLING CAPACITY kcal/h 9,429 54,170 67,100 W 46,000 6,000 78,000 RATED COOLING INPUT kw COOLING RUNNING CURRENT A POWER SUPPLY V / Ph / 50Hz LENGTH mm(inch) 1,820(72) 2,056(81) 2,056(81) DIMENSION WIDTH mm(inch) 1,091(4) 1,140(45) 1,26(50) HEIGHT mm(inch) 1,84(7) 2,19(86) 2,256(89) NET WEIGHT kg RUNNING WEIGHT kg CASING Electro-galvanized Mild Steel FINISH Epoxy Polyester Power THICKNESS mm 1.5 EVAPORATOR Brazed Plate Heat Exchanger PLATE Stainless Steel WATER VOLUME m WATER FLOW m /h WATER LINE WATER PIPE SIZE inch 5 BRANCH WATER PIPE SIZE inch 1 1/4 1 1/2 JOINT SIZE inch Flange Joint 5 Flange Joint UNIT WATER PRESSURE DROP kpa CONDENSER COIL Aluminum FIN THICKNESS mm 0.11 ROWS FIN PER INCH FACE AREA m 2 (ft 2 ) 2.78(29.60).50 (7.67) 2.0(21.55) CONDENSER FAN /DRIVE Axial Big Vane and Low Noise Blower FAN MOTOR kw BLADE Galvanized Steel BLADE DIAMETER mm(inch) (28 ) (0 ) RATED RUNNING CURRENT A RATED INPUT W AIR VOLUME CFM 15,00 15,0 18,82 COMPRESSOR Scroll Compressor PROTECTION DEVICE H/L pressure switch/thermal and current overload protector REFRIGERANT R22 CHARGING MASS kg CONTROL Capillary Thermostatic Expansion Valve NOTES: 1. RATED COOLING CAPACITY IS BASED ON 12 C ENTERING WATER TEMPERATURE/ 7 C LEAVING WATER TEMPERATURE, 5 C AIR AMBIENT TEMPERATURE. 2. ALL SPECIFICATIONS ARE BASED ON 80V / PH / 50HZ.. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY MANUFACTURER WITHOUT PRIOR NOTICE. 4
6 Modular Air Cooled Chiller Heat Pump MODEL (50Hz) MAC160AR/ARM/ARC/ARE MAC210BR/BRM/BRC/BRE MAC260BR/BRM/BRC/BRE Btu/h 157, , ,000 Nominal COOLING CAPACITY kcal/h 9,429 54,170 67,100 W 46,000 6,000 78,000 Btu/h 194, , ,000 RATED HEATING CAPACITY kcal/h 48,857 56,749 70,600 W 57,000 66,000 82,000 RATED COOLING INPUT kw RATED HEATING INPUT kw COOLING RUNNING CURRENT A HEATING RUNNING CURRENT A POWER SUPPLY V / Ph / 50Hz LENGTH mm(inch) 1,820(72) 2,056(81) 2,056(81) DIMENSION WIDTH mm(inch) 1,091(4) 1,140(45) 1,26(50) HEIGHT Mm(inch) 1,84(7) 2,19(86) 2,256(89) NET WEIGHT kg RunNing Weight kg CASING Electro-galvanized Mild Steel FINISH Epoxy Polyester Power THICKNESS mm 1.5 EVAPORATOR Brazed Plate Heat Exchanger PLATE Stainless Steel WATER VOLUME m WATER FLOW m /h WATER LINE WATER PIPE SIZE inch 5 BRANCH WATER PIPE SIZE inch 1 1/4 1 1/2 JOINT SIZE inch Flange Joint 5 Flange Joint UNIT WATER PRESSURE DROP kpa CONDENSER COIL Aluminum FIN THICKNESS mm 0.11 ROWS FIN PER INCH FACE AREA m 2 (ft 2 ) 2.78(29.60).50 (7.67) 2.0(21.55) CONDENSER FAN /DRIVE Axial Big Vane and Low Noise Blower FAN MOTOR kw BLADE Galvanized Steel BLADE DIAMETER mm(inch) (28 ) (0 ) RATED RUNNING CURRENT A RATED INPUT W AIR VOLUME CFM 15,00 15,0 18,82 COMPRESSOR Scroll Compressor PROTECTION DEVICE H/L pressure switch/thermal and current overload protector REFRIGERANT R22 CHARGING MASS kg CONTROL Capillary Thermostatic Expansion Valve NOTES: 1. RATED COOLING CAPACITY IS BASED ON 12 C ENTERING WATER TEMPERATURE/ 7 C LEAVING WATER TEMPERATURE, 5 C AIR AMBIENT TEMPERATURE. 2. RATED HEATING CAPACITY IS BASED ON 40 C ENTERING WATER TEMPERATURE /45 C LEAVING WATER TEMPERATURE, 7 C AIR AMBIENT TEMPERATURE.. ALL SPECIFICATIONS ARE BASED ON 80V / PH / 50HZ; THE COOLING CAPACITY ARE MEASURED UNDER SIGNLE COOLING MODE. 4. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY MANUFACTURER WITHOUT PRIOR NOTICE. 5
7 General Data - R22 Cooling Only MODEL MAC160A MAC160A 2 MAC160A MAC160A 4 MAC160A 5 MAC160A 6 NOMINAL COOLING CAPACITY Btu/h kw RATED INPUT POWER kw RATED RUNNING CURRENT A POWER SOURCE V/Ph/Hz //50 REFRIGERANT R22 LENGTH mm/inch 1820/72 UNIT DIMENSION WIDTH mm/inch 1091/4 2182/86 27/ / / /258 HEIGHT mm/inch 184/70 LENGTH mm/inch 1850/7 PACKING DIMENSION WIDTH mm/inch 1110/ / / / / /44 6 HEIGHT mm/inch 1850/7 NET WEIGHT kg/lb 620/ / / / / /8202 RUNNING WEIGHT kg/lb 640/ / / / / /8466 MODEL MAC210B MAC210B 2 MAC210B MAC210B 4 MAC210B 5 MAC210B 6 NOMINAL COOLING CAPACITY Btu/h kw RATED INPUT POWER kw RATED RUNNING CURRENT A POWER SOURCE V/Ph/Hz //50 REFRIGERANT UNIT DIMENSION PACKING DIMENSION R22 LENGTH mm/inch 2056/81 WIDTH mm/inch 1140/ /90 420/ / / /270 HEIGHT mm/inch 219/86 LENGTH mm/inch 2060/82 WIDTH mm/inch 1160/ / / / / /46 6 HEIGHT mm/inch 2200/87 NET WEIGHT kg/lb 70/ / / / / /9654 RUNNING WEIGHT kg/lb 750/ / / / / /9918 NOTES: 1. RATED COOLING CAPACITY IS BASED ON 12 C ENTERING WATER TEMPERATURE/ 7 C LEAVING WATER TEMPERATURE, 5 C AIR AMBIENT TEMPERATURE. 2. ALL SPECIFICATIONS ARE BASED ON 80V / PH / 50HZ.. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY MANUFACTURER WITHOUT PRIOR NOTICE. 6
8 MODEL MAC260B MAC260B 2 MAC260B MAC260B 4 MAC260B 5 MAC260B 6 NOMINAL COOLING CAPACITY Btu/h kw RATED INPUT POWER kw RATED RUNNING CURRENT A POWER SOURCE V/Ph/Hz //50 REFRIGERANT R22 LENGTH mm/inch 2056/81 UNIT DIMENSION WIDTH mm/inch 126/ / / / / /00 HEIGHT mm/inch 2256/89 LENGTH mm/inch 2060/81 PACKING DIMENSION WIDTH mm/inch 1265/50 250/ / / / /00 HEIGHT mm/inch 2260/89 NET WEIGHT kg/lb 910/ / / / / /1206 RUNNING WEIGHT kg/lb 90/ / / / / /1200 NOTES: 1. RATED COOLING CAPACITY IS BASED ON 12 C ENTERING WATER TEMPERATURE/ 7 C LEAVING WATER TEMPERATURE, 5 C AIR AMBIENT TEMPERATURE. 2. ALL SPECIFICATIONS ARE BASED ON 80V / PH / 50HZ.. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY MANUFACTURER WITHOUT PRIOR NOTICE. 7
9 General Data - R22 Heat Pump MODEL MAC160AR MAC160AR 2 MAC160AR MAC160AR 4 MAC160AR 5 MAC160AR 6 NOMINAL COOLING CAPACITY Btu/h kw NOMINAL HEATING CAPACITY Btu/h kw RATED INPUT POWER (COOLING) kw RATED INPUT POWER (HEATING) kw RATED RUNNING CURRENT (COOLING) A RATED RUNNING CURRENT (HEATING) A POWER SOURCE V/Ph/Hz //50 REFRIGERANT R22 LENGTH mm/inch 1820/72 UNIT DIMENSION WIDTH mm/inch 1091/4 2182/86 27/ / / /258 HEIGHT mm/inch 184/7 LENGTH mm/inch 1850/7 PACKING DIMENSION WIDTH mm/inch 1110/ / / / / /44 6 HEIGHT mm/inch 184/7 NET WEIGHT kg/lb 640/ / / / / /8466 RUNNING WEIGHT kg/lb 660/ / / / / /870 MODEL MAC210BR MAC210BR 2 MAC210BR MAC210BR 4 MAC210BR 5 MAC210BR 6 NOMINAL COOLING CAPACITY NOMINAL HEATING CAPACITY Btu/h kw Btu/h kw RATED INPUT POWER (COOLING) kw RATED INPUT POWER (HEATING) kw RATED RUNNING CURRENT (COOLING) A RATED RUNNING CURRENT (HEATING) A POWER SOURCE V/Ph/Hz //50 REFRIGERANT UNIT DIMENSION PACKING DIMENSION R22 LENGTH mm/inch 2056/81 WIDTH mm/inch 1140/ /90 420/ / / /270 HEIGHT mm/inch 219/86 LENGTH mm/inch 2060/81 WIDTH mm/inch 1160/ / / / / /46 6 HEIGHT mm/inch 2200/87 NET WEIGHT kg/lb 750/ / / / / /9918 RUNNING WEIGHT kg/lb 770/ /96 210/ / / /10188 NOTES: 1. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 2. NOMINAL COOLING / HEATING CAPACITY IS BASED ON THE CONDITIONS BELOW: a) COOLING: 12 C/7 C entering/leaving water temperature, 5 C DB ambient temperature. b) HEATING: 40 C/45 C entering/leaving water temperature, 7 C DB / 6 C WB ambient temperature.. ALL SPECIFICATION ARE BASED ON POWER RESOURCE 80V/Ph/50Hz 8
10 MODEL MAC260BR MAC260BR 2 MAC260BR MAC260BR 4 MAC260BR 5 MAC260BR 6 NOMINAL COOLING CAPACITY Btu/h kw NOMINAL HEATING CAPACITY Btu/h kw RATED INPUT POWER (COOLING) kw RATED INPUT POWER (HEATING) kw RATED RUNNING CURRENT (COOLING) A RATED RUNNING CURRENT (HEATING) A POWER SOURCE V/Ph/Hz //50 REFRIGERANT R22 LENGTH mm/inch 2056/81 UNIT DIMENSION WIDTH mm/inch 126/ / / / / /00 HEIGHT mm/inch 2256/89 LENGTH mm/inch 2060/81 PACKING DIMENSION WIDTH mm/inch 1265/50 250/ / / / /00 HEIGHT mm/inch 2260/89 NET WEIGHT kg/lb 910/ / / / / /1206 RUNNING WEIGHT kg/lb 90/ / / / / /1200 NOTES: 1. ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 2. NOMINAL COOLING / HEATING CAPACITY IS BASED ON THE CONDITIONS BELOW: a) COOLING: 12 C/7 C entering/leaving water temperature, 5 C DB ambient temperature. b) HEATING: 40 C/45 C entering/leaving water temperature, 7 C DB / 6 C WB ambient temperature.. ALL SPECIFICATION ARE BASED ON POWER RESOURCE 80V/Ph/50Hz 9
11 Components Data- R22 Cooling Only MODEL MAC160A MAC160A 2 MAC160A MAC160A 4 MAC160A 5 MAC160A 6 EVAPORATOR WATER LINE PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.078/ / / / / /16.56 NOMINAL WATER FLOW PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) 7.92/ / / / / / mm/inch 2/1.25 PIPE SIZE mm/inch 7.6/ UNIT WPD kpa(psi) 98/ / / / / /18.00 CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/ 0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 14 TOTAL FACE AREA m 2 (ft 2 ) 2.75/ / / / / /177.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 711.2/28 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.2 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 850 MOTOR POLES 6 AIR VOLUME CMH/CFM 26000/ / / / / /9048 Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 1 RATED INPUT POWER W 7400 MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 72 H/L pressure switch/thermal and current overload protector R22 capillary REFRIGERANT CHARGE kg/lb 12/ / / / / / NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 10
12 MODEL MAC210B MAC210B 2 MAC210B MAC210B 4 MAC210B 5 MAC210B 6 EVAPORATOR WATER LINE CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.102/ / / / / /21.60 NOMINAL WATER FLOW PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) 10.8/ / / / / /285.4 mm/inch 8/1.5 PIPE SIZE mm/inch 125/5 BPHE WPD kpa(psi) 68/9.9 70/ / / / /11. TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 16 TOTAL FACE AREA m 2 (ft 2 ).5/ / / / / /225.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 711.2/28 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.6 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 840 MOTOR POLES 8 AIR VOLUME CMH/CFM 26000/ / / / / /9048 Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 15 RATED INPUT POWER W 8500 MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 84 H/L pressure switch/thermal and current overload protector R22 Thermostatic Expansion valve REFRIGERANT CHARGE kg/lb 17/7.44 4/ / / / / NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 11
13 MODEL MAC260B MAC260B 2 MAC260B MAC260B 4 MAC260B 5 MAC260B 6 EVAPORATOR WATER LINE CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.108/ / / / / /22.86 NOMINAL WATER FLOW PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) 1.9/ / / / / /5.82 mm/inch 8/1.5 PIPE SIZE mm/inch 125/5 UNIT WPD kpa(psi) 65.0/ / / / / /10.7 TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 16 TOTAL FACE AREA m 2 (ft 2 ) 4/4.1 8/ / / / /258.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 760/0 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.6 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 840 MOTOR POLES 8 AIR VOLUME CMH/CFM 2000/ / / / / / Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 21 RATED INPUT POWER W MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 118 H/L pressure switch/thermal and current overload protector R22 Thermostatic Expansion valve REFRIGERANT CHARGE kg/lb 2.5/ / / / / /10.56 NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 12
14 Components Data- R22 Heat pump MODEL MAC160AR MAC160AR 2 MAC160AR MAC160AR 4 MAC160AR 5 MAC160AR 6 EVAPORATOR WATER LINE CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.102/ / / / / /21.6 NOMINAL WATER FLOW (COOLING) NOMINAL WATER FLOW (HEATING) PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) m³/h (US GPM) 10.8/ / / / / / / / / / / / mm/inch 2/1.25 PIPE SIZE mm/inch 7.6/ UNIT WPD kpa(psi) 98/ / / / / /18.00 TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 14 TOTAL FACE AREA m 2 (ft 2 ) 2.75/ / / / / /177.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 711.2/28 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.2 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 850 MOTOR POLES 6 AIR VOLUME CMH/CFM 26000/ / / / / /9048 Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 1 RATED INPUT POWER W 7400 MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 72 H/L pressure switch/thermal and current overload protector R22 Thermostatic Expansion valve and capillary REFRIGERANT CHARGE kg/lb 12/ / / / / / NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 1
15 MODEL MAC210BR MAC210BR 2 MAC210BR MAC210BR 4 MAC210BR 5 MAC210BR 6 EVAPORATOR WATER LINE CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.102/ / / / / /21.6 NOMINAL WATER FLOW (COOLING) NOMINAL WATER FLOW (HEATING) PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) m³/h (US GPM) 10.8/ / / / / / / / / / / / mm/inch 8/1.5 PIPE SIZE mm/inch 125/5 BPHE WPD kpa(psi) 68/9.9 70/ / / / /11. TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 16 TOTAL FACE AREA m 2 (ft 2 ).5/ / / / / /225.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 711.2/28 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.6 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 840 MOTOR POLES 8 AIR VOLUME CMH/CFM 26000/ / / / / /9048 Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 15 RATED INPUT POWER W 8500 MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 84 H/L pressure switch/thermal and current overload protector R22 Thermostatic Expansion valve REFRIGERANT CHARGE kg/lb 17/7.44 4/ / / / / NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 14
16 MODEL MAC260BR MAC260BR 2 MAC260BR MAC260BR 4 MAC260BR 5 MAC260BR 6 EVAPORATOR WATER LINE CONDENSER COIL CASING CONDENSER FAN COMPRESSOR REFRIGERANT PLATE Brazed Plate Heat Exchange Stainless steel WATER VOLUME m (ft ) 0.108/ / / / / /22.86 NOMINAL WATER FLOW (COOLING) NOMINAL WATER FLOW (HEATING) PIPING INSTALLATION PIPE CONNECTION m³/h (US GPM) m³/h (US GPM) 1.9/ / / / / / / / / / / /71.89 mm/inch 8/1.5 PIPE SIZE mm/inch 125/5 UNIT WPD kpa(psi) 65.0/ / / / / /10.7 TUBE FIN TUBE+FIN COPPER INNER GROOVE WALL THICKNESS mm/inch 0.6/0.014 OUTER DIAMETER mm/inch 9.52/0.75 ALUMINUM WHITE FIN THICKNESS mm/inch 0.11/0.004 ROWS FIN PER INCH 16 TOTAL FACE AREA m 2 (ft 2 ) 4/4.1 8/ / / / /258.6 FINISH Electro-galvanized Mild Steel Epoxy Polyester Power THICKNESS mm/inch 1.2/0.047 /DRIVE Axial Big Vane and Low Noise Blower QUANTITY BLADE Galvanized steel BLADE DIAMETER mm/inch 760/0 760/0 760/0 760/0 760/0 760/0 POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 2.6 RATED INPUT POWER W 1150 RATED OUTPUT POWER W 840 MOTOR POLES 8 AIR VOLUME CMH/CFM 2000/ / / / / / Scroll Compressor QUANTITY POWER SUPPLY V/Ph/Hz //50 RATED RUNNING CURRENT A 21 RATED INPUT POWER W MAXIMUM STARTING CURRENT PROTECTION DEVICES CONTROL A 118 H/L pressure switch/thermal and current overload protector R22 Thermostatic Expansion valve REFRIGERANT CHARGE kg/lb 2.5/ / / / / /10.56 NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 15
17 Electrical Data Power source wiring diagram L1 L2 L N BREAKER BREAKER BREAKER R S Master unit T N R S T N R S T N Slave unit 1... Slave unit n R22 Units Electric Parameter MODEL MAC160A MAC160AR MAC210B MAC210BR MAC260B MAC260BR RATED TOTAL POWER INPUT (COOLING) W RATED TOTAL POWER INPUT (HEATING) W RATED RUNNING CURRENT (COOLING) A RATED RUNNING CURRENT (HEATING) A POWER SOURCE V/Ph/Hz //50 POWER SOURCE WIRE MAIN WIRE (R/S/T) NETURAL WIRE EARTH WIRE SECTION AREA mm QTY SECTION AREA mm 2 4 QTY 1 SECTION AREA mm 2 10 QTY 1 Safety Devices PROTECTION MAC160A(R) MAC210B(R) MAC260B(R) HIGH PRESSURE SWITCH (AUTO RESET CARTRIDGE) LOW PRESSURE SWITCH (AUTO RESET CARTRIDGE) OPEN MPa/psi 2.8/406.0/45 2.8/406 CLOSE MPa/psi 2.4/48 2.4/48 2.4/48 OPEN MPa/psi 0.05/ / /7.25 CLOSE MPa/psi 0.15/ / /21.76 COMP. OVERLOAD A N/A N/A FAN MOTOR OVERLOAD A DISCHARGE THERMOSTAT SETTING C / F 125.0±5/257.4±9 PHASE MONITOR YES NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE. 16
18 Sound Data 1/1 Octave Sound Pressure Level(dB, ref 20μPa)(COOL) Model db(a) 6Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz MAC160A(R) MAC210B(R) MAC260B(R) Model 1/1 Octave Sound Pressure Level(dB, ref 20μPa)(HEAT) 6Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz MAC160AR MAC210BR MAC260BR NOTE: According to: ISO744:1994 Acoustics--Determination of sound power levels of noise sources using sound pressure--engineering method in an essentially free field over a reflecting plane db(a) 17
19 Operating Limit Cooling mode Heating mode 48 Ambient T. C Ambient T. C Running range 0 10 Running range Leaving water T. C Leaving water T. C Performance Data Performance Curves and Tables Cooling Capacity Curves Correction Factors C C LWT 5 C LWT 6 C LWT 7 C LWT 8 C LWT 9 C LWT Ambient Temperature ( C) NOTE: LWT=Leaving Water Temperature 18
20 Cooling Mode Power Input Curves Correction Factors C Ambient Temperature ( C) NOTE: When leaving water temperature varies from 4-9 C, the variation of cooling mode power input is less than %. Heating Capacity Curves Correction Factors C C LWT 45 C LWT 50 C LWT 0.7 NOTE: LWT=Leaving Water Temperature Ambient Temperature ( C) 19
21 Heating Mode Power Input Curves Correction Factors C C LWT 45 C LWT 50 C LWT NOTE: LWT=Leaving Water Temperature Ambient Temperature ( C) Correction Factors With Glycol Use GLYCOL% COOLING CAPACITY WATER FLOW PRESSURE DROP
22 Water Pressure Drop Chart Water Pressure Drop Chart MAC160A(R) Pressure Drop (KPa) Water Flow (m /h) Water Pressure Drop Chart MAC210B (R) WPD KPa Water Flow m /h Pressure Drop (KPa) Water Pressure Drop Chart MAC260B(R) Water Flow (m /h) 20 21
23 Dimensional Data Models: MAC160A(R) Intel Outel A A A A A A AxN=L Unit: mm MODEL NUMBER Single unit size(a) units size(l) MAC160A(R) MAC160A(R)* MAC160A(R)* MAC160A(R)* MAC160A(R)* MAC160A(R)* n(n 10) x n Models: MAC210B(R) Intel Outel A A A A A A AxN=L 2056 Unit: mm MODEL NUMBER Single unit size(a) units size(l) MAC210B(R) MAC210B(R)* MAC210B(R)* MAC210B(R)* MAC210B(R)* MAC210B(R)* n(n 10) x n 22
24 Models: MAC260B(R) Intel Outel A A A A A A AxN=L 2056 Unit: mm MODEL NUMBER Single unit size(a) units size(l) MAC260B(R) MAC260B(R)* MAC260B(R)* MAC260B(R)* MAC260B(R)* MAC260B(R)* n(n 10) x n NOTE: Please contact the factory if the number is larger than 6. 2
25 Wiring Diagrams MODEL: MAC160A/AM MODEL: MAC160AC/AE 24
26 MODEL: MAC160AR/ARM MODEL: MAC160ARC/ARE 25
27 MODEL: MAC210B/BM MODEL: MAC210BC/BE 26
28 MODEL: MAC210BR/BRM MODEL: MAC210BRC/BRE 27
29 MODEL: MAC260B/BM MODEL: MAC260BC/BE 28
30 MODEL: MAC260BR/BRM MODEL: MAC260BRC/BRE 29
31 Refrigerant Circuit Model: MAC160A WATER IN 5 WATER OUT REFRIGERANT FLOW 1 COMPRESSOR 2 HEAT EXCHANGER LIQUID RECEIVER 4 CAPILLARY 5 BPHE 6 ACCUMULATOR Model: MAC160AR WATER IN 8 WATER OUT REFRIGERANT FLOW(COOL) REFRIGERANT FLOW(HEAT) 1 COMPRESSOR 2 FOUR WAY VALVE HEAT EXCHANGER 4 TXV 5 CAPILLARY 6 VALVE CHECK 7 LIQUID RECEIVER 8 BPHE 9 ACCUMULATOR 0
32 Model: MAC210B WATER INLET 5 WATER OUTLET REFRIGERANT FLOW 1 COMPRESSOR 2 HEAT EXCHARGER DRY-FILTER 4 TXV 5 BPHE 6 ACCUMULATOR Model: MAC210BR WATER INLET 5 8 WATER OUTLET COOLING REFRIGERANT FLOW HEATING REFRAGERANT FLOW 1 COMPRESSOR 2 FOUR WAY VALVE HEAT EXCHARGER 4 HEATING TXV 5 COOLING TXV 6 CHECK VALVE 7 RECEIVER 8 BPHE 9 ACCUMULATOR 1
33 Model: MAC260B WATER IN 7 6 WATER OUT 1 COMPRESSOR 2 HEAT EXCHANGER FAN MOTOR 5 TXV 6 BPHE 7 ACCUMULATOR 4 FILTER DRIER Model: MAC260BR 12 1 COOL 2 HEAT WATER IN 10 WATER OUT 1 COMPRESSOR 2 FOUR WAY VALVE HEAT EXCHANGER 4 CHECK VALVE 5 LIQUID RECEIVER 6 SIGHT GLASS 7 SOLENOID VALVE 8 FILTER DRIER 9 TXV 10 BPHE 11 ACCUMULATOR 12 FAN MOTOR 2
34 Troubleshooting MAC160A(R)/210B(R) Input terminal Fault description Code Fault resolution TH1 Entering water temperature sensor short/open E1 Shut off all the outer equips. TH2 Leaving water temperature sensor short/open E2 Shut off all the outer equips. TH Out door temperature sensor short/ open E Shut off all the outer equips. TH4 Defrost temperature sensor 1 short/ open E4 Shut off compressor 1. TH5 Defrost temperature sensor 2 short/ open E5 Shut off compressor 2. OVHT/HP2 Comp 2 high-pressure alarm or Electric heater overload. E6 Shut off compressor 2. FLOW Water flow insufficient E7 Shut off all the outer equips. OV-PUMP Water-pump overload. E8 Shut off all the outer equips. OV-FAN Fan overload. E9 Shut off all the outer equips, water-pump operate.. OV-COMP1 Comp 1 overload. EA Shut off comp 1. OV-COMP2 Comp 2 overload. EB Shut off comp 2. HP1 Comp 1 high-pressure alarm. EC Shut off comp 1. LP1 Comp 1 low-pressure alarm. ED Shut off comp 1. FREZ/LP2 Comp 2 low-pressure alarm. EE Shut off compressor 2. Cool output water too low in temperature. EF Shut off comps, water-pump auxiliary heater operates. MAC260B(R) Input terminal Fault description Code Fault resolution TH1 Entering water temperature sensor short/open E1 Shut off all the outer equips. TH2 Leaving water temperature sensor short/open E2 Shut off all the outer equips. TH Out door temperature sensor short/ open E Shut off all the outer equips. TH4 Defrost temperature sensor 1 short/ open E4 Shut off compressor TH5 Defrost temperature sensor 2 short/ open -- Number judge OVHT/HP2 Electric heater overload. E6 Shut off electric heater. FLOW Water flow insufficient E7 Shut off all the outer equips. OV-PUMP Water-pump overload. E8 Shut off all the outer equips. OV-FAN Fan overload. E9 Shut off all the outer equips, water-pump operate OV-COMP1 Comp overload. EA Shut off comp HP1 Comp 1 high-pressure alarm. EC Shut off comp LP1 Comp 1 low-pressure alarm. ED Shut off comp Cool output water too low in temperature. EF Shut off comps, water-pump auxiliary heater operates.
35 Exploded View & Part List
36 SPARE PART LIST OF MAC160A-FABE NO. Part Number Description Quantity 1 M FAN GUARD 2 2 M FAN BLADE,89MM TFE710C-89 XINCHANG 2 M ASSY,OUTFLOW 1 4 M MOTOR,YT A CHANGHENG 2 5 M FAN SUPPORT 2 6 M ASSY,RIGHT COIL 2 7 M ASSY,LEFT COIL 2 8 ASSY,METAL STRUCTURE 1 9 M PANEL,LEFT SURFACE 2 10 M PRESSURE SWITCH 2.4/2.8MPa 2 11 A ASSY,ACCESS VALVE 1/4 SP M PRESSURE SWITCH 0.05/0.15MPa 2 1 M CONTROL BOX ASSY 1 14 A FILTER DRIER,FK-085S ALCO 2 15 A CAPILLARY 4 16 M PANEL,FRONT SURFACE A 1 17 M PANEL,FRONT SURFACE B 1 18 A COMPRESSOR,ZR125KC-TFD-522 (WITH HEATER) COPELAND 2 19 M ACCUMULATOR, QFQ5.2-A L TONGLI 2 20 ASSY,COPPER TUBE 1 21 M PANEL,FRONT AND BACK SURFACE 22 N/A 2 M SWITCH,DIFFERENCE PRESSORE 5/9 KPa GuangHua 1 24 M HEAT EXCHANGER,BRAZED PLATE V25*40*40 SWEP 1 25 N/A 26 N/A 27 M STRIANER,WATER CU PN25 (1 1/4") ITALY OR 1 28 M WATER PIPE, INLET (PPR) 1 29 M WATER PIPE, OUTLET (PPR) 1 0 M ASSY,BASE PAN 1 TERMINAL BOX OF MAC160A-FABE NO. Part Number Description Quantity 1 M TERMINAL BLOCK, ET501-P-1 150A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-18P 1 M CONTACTOR, LC1-D0910M7C T.E. 2 4 M CONTACTOR, LC1-D6511MTC T.E. 2 5 M FUSE, RT14-10A,BOLT IN 10A 022M M PHASE PROTECTOR,RM4-TG20 T.E. 1 7 M CONTROL MODULE,MCH0B EC (B4.) 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR UA5040-1C ( A) SIEMENS 2 5
37 SPARE PART LIST OF MAC210B-FAAE NO. Part Number Description Quantity 1 M OUTER NOZZLE 810mm 2 2 M FAN BLADE,240MM DBF7A-240 XINCHANG 2 M PANEL,OUTFLOW 2 4 M MOTOR,YT A, CHANGHENG 2 5 M SUPPORT MOTOR 2 6 M ASSY, RIGHT COIL 2 7 M ASSY, LEFT COIL 2 8 ASSY,METAL STRUCTURE 1 9 M PANEL,UNDERSURFACE 4 10 M PRESSURE SWITCH H20PS.0/2.4MPa 2 11 A ASSY,ACCESS VALVE 1/4 SP M LOW PRESSURE SWITCH 0.05/0.15MPa 2 1 M TERMINAL BOX 1 14 A FILTER DRIER,EK-085S ALCO 2 15 M VALVE,TXV TDEBX11 5/8 *7/8 DANFOSS 2 16 M PANEL,UNDERSURFACE (5 ) 1 17 M PANEL,UNDERSURFACE (5 ) 1 18 M COMPRESSOR,ZR144KC-TFD-522 (WITH HEATER) COPELAND 2 19 M ACCUMULATOR,QFQ5.2-A L TONGLI 2 20 ASSY,COPPER TUBE 1 21 M PANEL,UNDERSURFACE 1 22 M VALVE,CONNECT SENSOR 2 2 M SWITCH,DIFFERENCE PRESSURE 5/9KPa 1 24 M BPHE,B QINBAO 1 25 M JOINT,FLEXIBLE RUBBER KST M VALVE,GATE Z15W-16T Rc1-1/2 (DN40) 2 27 M STRAINER,WATER CU PN25 (1 1/2 ) ITALY OR 1 28 M ASSY,WATER PIPE (INLET) 1 29 M ASSY,WATER PIPE (OUTLET) 1 0 M ASSY BASE PAN 1 TERMINAL BOX OF MAC210B-FAAE NO. Part Number Description Quantity 1 M TERMINAL BLOCK,ET2501-4P 100A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-25P 1 M CONTACTOR,TF010-0XN2 50/60Hz 9A SIEMENS 2 4 M CONTACTOR,TF411-0XN2 50/60Hz 2A SIEMENS 2 5 M FUSE LINK RT14-4A WITH BASE DELIXI 1 6 M PHASE PROTECTOR,DBA01A (V.) OYL WAY 1 7 M CONTROL MODULE,MCH0B EC (B4.) 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR, UA5040-1E (2.5-4A) SIEMENS 2 6
38 SPARE PART LIST OF MAC260B-FAAE NO. Part Number Description Quantity 1 M OUTER NOZZLE (900*80*94) 2 2 M FAN BLADE,800mm TFZ800A-170 XINGCHANG 2 M PANEL,OUTFLOW RIGHT; * M PANEL,OUTFLOW LEFT; * M MOTOR,YT A4, CHANGHENG 2 5 M SUPPORT MOTOR 2 6 M COIL ASSY RIGHT 1 7 M COIL ASSY LEFT 1 8 ASSY,METAL STRUCTURE 1 9 M PANEL,FRONT SURFACE 2 10 M PRESSURE SWITCH 2.4/2.8MPa 1 11 A ASSY,ACCESS VALVE 1/4 SP M PRESSURE SWITCH 0.05/0.15MPa 1 1 M TERMINAL BOX 1 14 A FILTER DRIER,EK7/80DF-417S ALCO 1 15 M VALVE,TXV TX6-H17 7/8*1 1/8ODF ALCO 1 16 M PANEL,SIDE SURFACE 1 17 M PANEL,SIDE SURFACE 1 18 M COMPRESSOR,SM185 DANFOSS 2 19 M ACCUMULATOR,1.5L QINAN 1 20 ASSY,COPPER TUBE 1 21 M PANEL,SIDE SURFACE 22 M VALVE,CONNECT SENSOR 2 2 M SWITCH,DIFFERENCE PRESSURE 5/9KPa 1 24 M BPHE,B QINGBAO 1 25 M JOINT,FLEXIBLE RUBBER KST M VALVE,GATE Z15W-16T Rc1-1/2 (DN40) 2 27 M STRAINER,WATER CU PN25 (1 1/2 )ITALY OR 1 28 M ASSY,WATER PIPE (INLET) 1 29 M ASSY,WATER PIPE (OUTLET) 1 0 M ASSY BASE PAN 1 TERMINAL BOX OF MAC260B-FAAE NO. Part Number Description Quantity 1 M TERMINAL BLOCK,ET2501-4P 100A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-0P 1 M CONTACTOR,TF010-0XN2 50/60Hz 9A SIEMENS 2 4 M CONTACTOR,TF511-0XN2 50/60Hz 8A SIEMENS 2 5 M FUSE LINK RT14-4A WITH BASE DELIXI 1 6 M PHASE PROTECTOR,DBA01A (V.) OYL WAY 1 7 M CONTROL MODULE,MCH00BD BD1. EC OYL 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR, UA5040-1E (2.5-4A) SIEMENS 2 10 M OVERLOAD PROTECTOR, UA5540-2R (2-40A) SIEMENS 2 7
39
40 SPARE PART LIST OF MAC160AR-FABE NO. Part Number Description Quantity 1 M FAN GUARD 2 2 M FAN BLADE,89MM TFE710C-89 XINCHANG 2 M ASSY,OUTFLOW 2 4 M MOTOR,YT A CHANGHENG 2 5 M FAN SUPPORT 2 6 M ASSY,RIGHT COIL 2 7 M ASSY,LEFT COIL 2 8 ASSY,METAL STRUCTURE 1 9 M PRESSURE SWITCH 2.4/2.8MPa 2 10 A ASSY,ACCESS VALVE 1/4 SP M PRESSURE SWITCH 0.05/0.15MPa 2 12 M CONTROL BOX ASSY 1 1 M PANEL,LEFT SURFACE 2 14 A CAPILLARY 4 15 M VALVE,TXV BAE6HCA 1/2"*5/8" ALCO 2 16 M SWITCH,DIFFERENCE PRESSURE 5/9 KPa GuangHua 1 17 A FILTER DRIER,BFK-085S ALCO 2 18 M PANEL,FRONT SURFACE A 1 19 M PANEL,FRONT SURFACE B 1 20 A COMPRESSOR,ZR125KC-TFD-522 (WITH HEATER) 2 21 M VALVE,4WV SHF-5A-79 SANHUA 2 22 M ACCUMULATOR, QFQ5.2-A L TONGLI 2 2 M LIQUID RECEIVER,KFR140WLESX 4.0L QINGAN 2 24 ASSY,COPPER TUBE 1 25 M PANEL,FRONT AND BACK SURFACE 26 M YCV8-5 ID16*ID N/A 28 M HEAT EXCHANGER,BRAZED PLATE V25*40*40 SWEP 1 29 N/A 0 N/A 1 M STRIANER,WATER CU PN25 (1 1/4") ITALY OR 1 2 M WATER PIPE, INLET (PPR) 1 M WATER PIPE, OUTLET (PPR) 1 4 M ASSY,BASE PAN 1 TERMINAL BOX OF MAC160AR-FABE NO. Part Number Description Quantity 1 M TERMINAL BLOCK,ET2501-4P 100A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-25P 1 M CONTACTOR,TF010-0XN2 50/60Hz 9A SIEMENS 2 4 M CONTACTOR,TF411-0XN2 50/60Hz 2A SIEMENS 2 5 M FUSE LINK RT14-4A WITH BASE DELIXI 1 6 M PHASE PROTECTOR,DBA01A (V.) OYL WAY 1 7 M CONTROL MODULE,MCH0B AP,2 COMP. (B4.) 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR UA5040-1C ( A) (SIMENS) 2 9
41 SPARE PART LIST OF MAC210B-FAAE NO. Part Number Description Quantity 1 M OUTER NOZZLE 810mm 2 2 M FAN BLADE,240MM DBF7A-240 XINCHANG 2 M PANEL,OUTFLOW 2 4 M MOTOR,YT A, CHANGHENG 2 5 M SUPPORT MOTOR 2 6 M ASSY, RIGHE COIL 2 7 M ASSY, LEFT COIL 2 8 ASSY,METAL STRUCTURE 1 9 M PRESSURE SWITCH H20PS.0/2.4MPa 2 10 A ASSY,ACCESS VALVE 1/4 SP M LOW PRESSURE SWITCH 0.05/0.15MPa 2 12 M TERMINAL BOX 1 1 M PANEL,UNDERSURFACE 4 14 M VALVE,TXV TDEBX11 5/8 *7/8 DANFOSS 2 15 M VALVE,TXV BAE6HCA 1/2"*5/8" ALCO 2 16 M SWITCH,DIFFERENCE PRESSURE 5/9KPa 1 17 A FILTER DRIER,BFK-085S ALCO 2 18 M PANEL,UNDERSURFACE (5 ) 1 19 M PANEL,UNDERSURFACE (5 ) 1 20 M COMPRESSOR,ZR144KC-TFD-522 (WITH HEATER) COPELAND 2 21 M VALVE,4WV SHF-5A-79 SANHUA 2 22 M ACCUMULATOR,QFQ5.2-A L TONGLI 2 2 M LIQUID RECEIVER,KFR140WLESX 4.0L QINGAN 2 24 ASSY,COPPER TUBE 1 25 M PANEL,UNDERSURFACE 1 26 M YCV8-5 ID16*ID M VALVE,CONNECT SENSOR 2 28 M BPHE,B QINBAO 1 29 M JOINT,FLEXIBLE RUBBER KST M VALVE,GATE Z15W-16T Rc1-1/2 (DN40) 2 1 M STRAINER,WATER CU PN25 (1 1/2 ) ITALY OR 1 2 M ASSY,WATER PIPE (INLET) 1 M ASSY,WATER PIPE (OUTLET) 1 4 M ASSY BASE PAN 1 TERMINAL BOX OF MAC210B-FAAE NO. Part Number Description Quantity 1 M TERMINAL BLOCK,ET2501-4P 100A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-25P 1 M CONTACTOR, LC1-201M7C T.E. 2 4 M CONTACTOR, LC1-D0910M7C T.E. 2 5 M FUSE LINK RT14-4A WITH BASE DELIXI 1 6 M PHASE PROTECTOR,DBA01A (V.) OYL WAY 1 7 M CONTROL MODULE,MCH0B AP,2 COMP.(B4.) 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR, LRD08KN ( A) T.E. 2 40
42 SPARE PART LIST OF MAC260B-FAAE NO. Part Number Description Quantity 1 M OUTER NOZZLE (900*80*94) 2 2 M FAN BLADE,800mm TFZ800A-170 XINGCHANG 2 M PANEL,OUTFLOW RIGHT; * M PANEL,OUTFLOW LEFT; * M MOTOR,YT A4, CHANGHENG 2 5 M SUPPORT MOTOR 2 6 M COIL ASSY RIGHT 1 7 M COIL ASSY LEFT 1 8 ASSY,METAL STRUCTURE 1 9 M PRESSURE SWITCH 2.4/2.8MPa 1 10 A ASSY,ACCESS VALVE 1/4 SP M PRESSURE SWITCH 0.05/0.15MPa 1 12 M TERMINAL BOX 1 1 M PANEL,FRONT SURFACE 2 14 M VALVE,TXV TX6-H17 7/8*1 1/8ODF ALCO 1 15 M VALVE,TXV TX6-H16 7/8*1 1/8ODF ALCO 1 16 M SWITCH,DIFFERENCE PRESSURE 5/9KPa 1 17 A FILTER DRIER,EK7/80DF-417S ALCO 1 18 M PANEL,SIDE SURFACE 1 19 M PANEL,SIDE SURFACE 1 20 M COMPRESSOR,SM185-4CAM DANFOSS 2 21 M VALVE,4WV VH M ACCUMULATOR,1.5L QINAN 1 2 M LIQUID RECEIVER, 19.0L QINAN 1 24 ASSY,COPPER TUBE 1 25 M PANEL,SIDE SURFACE 26 M VALVE,TAOHVA DXF-7/ M VALVE,CONNECT SENSOR 2 28 M BPHE,B QINGBAO 1 29 M JOINT,FLEXIBLE RUBBER KST M VALVE,GATE Z15W-16T Rc1-1/2 (DN40) 2 1 M STRAINER,WATER CU PN25 (1 1/2 ) ITALY OR 1 2 M ASSY,WATER PIPE (INLET) 1 M ASSY,WATER PIPE (OUTLET) 1 4 M ASSY BASE PAN 1 TERMINAL BOX OF MAC260B-FAAE NO. Part Number Description Quantity 1 M TERMINAL BLOCK,ET2501-4P 100A HUANGZHONG 1 2 M TERMINAL BLOCK, HP-T021-0P 1 M CONTACTOR,TF010-0XN2 50/60Hz 9A SIEMENS 2 4 M CONTACTOR,TF511-0XN2 50/60Hz 8A SIEMENS 2 5 M FUSE LINK RT14-4A WITH BASE DELIXI 1 6 M PHASE PROTECTOR,DBA01A (V.) OYL WAY 1 7 M CONTROL MODULE,MCH0BD BD1. HP OYL 1 8 M CONTROLLER SC02B (MCQUAY,ENGLISH) 1 9 M OVERLOAD PROTECTOR, UA5040-1E (2.5-4A) SIEMENS 2 10 M OVERLOAD PROTECTOR, UA5540-2R (2-40A) SIEMENS 2 41
43 ISO 9001 Certificate No.: BS-OHSAS Certificate No.: 7644 ISO Certificate No.: EMS McQuay International +1 (800) We do our utmost efforts to ensure all details are correct and accurate during the time of publication. However, McQuay reserves the right to discontinue and/or alter the specifications and designs any time without notice and incurring obligations. Specifications may change to suit local conditions and some models are not available for certain countries.
Modular Air Cooled Chiller
Technical anual AC - 2011(60Hz) odular Air Cooled Chiller odels: AC160A-960A AC210A-1260A Refrigerant Type: R22 Cooling Capacity: 56/70kW Engineered for flexibility and performance. T Contents Literature
More informationYour Climate. We're There. TM: MDB B 2140B. Ducted Split Systems. Models: MDB 075B - MDB750B MDB 075B/B - MDB500BR. Air Conditioning REGISTERED
Your Climate. We're There. TM: MDB B 2140B Ducted Split Systems Models: MDB 075B - MDB750B MDB 075B/B - MDB500BR REGISTERED Air Conditioning Contents Nomenclature System... 2 Features... 2 General Specifications...3-5
More informationModular Air Cooled Chiller
Models: 170 A/AR 210 A/AR 340 A/AR 420 A/AR 510 A/AR 630 A/AR 720 A/AR 840 A/AR 1050 A/AR 1260 A/AR Modular Air Cooled Chiller C - A - 2004_1 REGISTERED ISO 9002 S&E Contents 1. Features... 1 2. Nomenclature...2
More informationWall Mounted Split Systems
MWM - 2005 Wall Mounted Split Systems Models: MWM 007F/FR MWM 010F/FR MWM 015F/FR MWM 020F/FR MWM 025F/FR MWM 030F/FR Contents Features... 1 Nomenclature... 2 Specifications... 3 Performance Table... 11
More informationAmendment Sheet. Nomenclature M 5 AC V 100 C R - F X AA. Code : M5ACV Date : Superceded : M5ACV
Amendment Sheet Code : M5ACV-2005-0002 Date : 08-05-2006 Superceded : M5ACV-2005-0001 Nomenclature Production spec variation Type of ref. connection X : Not applicable Electrical A : 220-240V/1Ph/50Hz
More informationAir-Cooled Mini Chiller. Models: AMAC 040 A/AR AMAC 050 A/AR AMAC 058 A/AR AMAC 075 B/BR AMAC 100 B/BR AMAC 125 B/BR. Manual No: TMA-AMAC-1161
Models: AMAC 040 A/AR AMAC 050 A/AR AMAC 058 A/AR AMAC 075 B/BR AMAC 100 B/BR AMAC 125 B/BR Air-Cooled Mini Chiller Manual No: TMA-AMAC-1161 REGISTERED ISO 9002 CONTENTS PAGE 1. NOMENCLATURE SYSTEM...
More informationModels: ACC 75D/DR ACC 100D/DR. ACC - D (Draft) Ceiling Concealed Split Systems
Models: ACC 75D/DR ACC 100D/DR ACC - D2-2007 (Draft) Ceiling Concealed Split Systems CONTENTS 1. NOMENECLATURE... 2 2. FEATURES... 4 3. PRODUCT LINE UP... 5 4. SPECIFICATIONS... 8 5. OPERATING RANGE...
More informationMAC-060HE-01-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.
MAC-060HE-01-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.2 HVAC Guide Specifications Air-Cooled Liquid Chiller with Low Ambient
More informationMAC N-407 Air-Cooled Chiller
MAC036-01-N-407 Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial MicroClimates MAC036 NOMENCLATURE BREAKDOWN MAC036-01 - N - 407 Refrigerant Type Air-Cooled Chiller 036=
More informationMAC-036HE-02-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.
MAC-036HE-02-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.1 HVAC Guide Specifications Air-Cooled Liquid Chiller with Low Ambient
More informationMAC-048HE-01-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.
MAC-048HE-01-L High Efficiency Air-Cooled Chiller Air-Cooled Chillers for Global Residential and Light Commercial Micro Climates Rev 1.1 HVAC Guide Specifications Air-Cooled Liquid Chiller with Low Ambient
More informationMAC-120HE-03 Air-Cooled Chiller
MAC-120HE-03 Air-Cooled Chiller 10 Ton / 120,000 BTUH Air-Cooled Chiller 380/415/460-3-50/60 1 HVAC Guide Specifications Air-Cooled Liquid Chiller Nominal Size: 10 Tons Multiaqua Model Number: MAC-120HE-03
More informationMAC-A R410A Series Air cooled Modular Chiller
Catalogue MAC R410A 2011(60Hz) MAC-A R410A Series Air cooled Modular Chiller Model: Refrigerant: Co ling Capacity: MAC210A5 R410A 72kW Overview Based on the successful McQuay air-cooled modular chiller,
More informationFALCON Rooftop Units ACPSE 50/60Hz Cooling Capacity : 36 to 1388 MBH (11 to 407 kw) Heating Capacity : 40 to 1298 MBH (12 to 380 kw)
FALCON Rooftop Units ACPSE 50/60Hz Cooling : 36 to 1388 MBH (11 to 407 ) Heating : 40 to 1298 MBH (12 to 380 ) R Products that perform...by people who care NOMENCLATURE 6 AC P S E 435 P - HP G Q 6-60 Hz
More informationMACH N-407 Heat Pump Air-Cooled Chiller
MACH060-01-N-407 Heat Pump Air-Cooled Chiller Heat Pump Air-Cooled Chillers for Global Residential and Light Commercial Microclimates MACH NOMENCLATURE BREAKDOWN MACH-060-01 - N - 407 Refrigerant Type
More information30GH Air-Cooled Liquid Chillers 30GH Nominal cooling capacity kw
Air-Cooled Liquid Chillers Nominal cooling capacity 21-94 kw Carrier is participating in the Eurovent Certification Programme. Products are as listed in the Eurovent Directory of Certified Products. The
More informationCeiling Concealed High Volume Chilled Water Fan Coil Unit (50/60Hz)
Technical Manual Ceiling Concealed High Volume Chilled Water Fan Coil Unit (50/60Hz) Models: MCW1400 MCW1600 Air Flow: 2270-3020m3/h MCW1800 Engineered for flexibility and performance. TM MCW-C/F(High
More informationMAC-D R410A Series Air-cooled Modular Chiller/Heat pump
Catalogue MAC-D-2013 (50Hz) MAC-D R410A Series Air-cooled Modular Chiller/Heat pump Model: Refrigerant: Cooling Capacity: Heating Capacity: MAC210D5-MAC1680D5 MAC230D5-MAC1840D5 MAC210DR5-MAC1680DR5 MAC230DR5-MAC1840DR5
More informationModels: A5ACV 30 CR A5ACV 55 CR A5ACV 75 CR A5ACV 100 CR A5ACV 135 CR A5ACV 210 CR A5ACV Air-Cooled Chiller (R410A Inverter Series)
Models: A5ACV 30 CR A5ACV 55 CR A5ACV 75 CR A5ACV 100 CR A5ACV 135 CR A5ACV 10 CR A5ACV - 007 Air-Cooled Chiller (R410A Inverter Series) 1. NOMENCLATURE Production spec variation Type of ref. connection
More informationMODEL: ACWD CEILING CONCEALED Chilled Water Fan Coils Unit
MODEL: ACW200D ACW300D ACW400D ACW500D ACW600D ACW800D ACW900D ACW1000D ACW1200D ACW1400D ACWD-2006 ACWD_2006_Cover.indd 1 CEILING CONCEALED Chilled Water Fan Coils Unit 2006-5-25 17:24:07 Contents Main
More informationAir-Cooled Mini Chiller and Heat Pump
Product, Installation and Operation Manual 309 B/C 03/03 A Date: March 2003 Supersedes: none Air-Cooled Mini Chiller and Heat Pump M4AC 080 150 C Cooling capacity from 22,4 to 40,0 M4AC 080 150 CR Cooling
More informationBRT C/H Series PACKAGED AIR TO AIR UNITS COOLING / HEATING APPLICATIONS OUTDOOR INSTALLATION. Ver. 1.01
b cool manufacturers of air-conditioning equipment ltd BRT C/H Series PACKAGED AIR TO AIR UNITS COOLING / HEATING APPLICATIONS OUTDOOR INSTALLATION Ver. 1.01 Ver. 3.02 01_18 BCool# 1 brt c/h r407c / r410a
More informationHigh Ambient / High Efficiency Series. R - 410a. 50Hz. Ducted Split Air Conditioners (5.0 kw kw)
High Ambient / High Efficiency Series R - 410a 50Hz Ducted Split Air Conditioners (5.0 kw - 17.5 kw) ISO 9001 : 2008 ISO 14001 : 2004 ISO 18001 : 2007 R - 410a 50Hz Introduction: Established in the year
More informationSLS 1202 to With or without total heat recovery. u Air Cooled Screw Chillers. 262 to 916 kw. Engineering Data Manual
u Air Cooled Screw Chillers SLS 1202 to 4004 With or without total heat recovery 262 to 916 kw Engineering Data Manual EDM SLS407-A.4GB Date : December 2008 Supersedes : TM SLS407-A.3GB/11.06 Specifications
More informationCAS. Product Specifications. COMMERCIAL SPLIT SYSTEMS CONDENSING UNITS R 410A, 6 to 12.5 TONS BUILT TO LAST, EASY TO INSTALL AND SERVICE
COMMERCIAL SPLIT SYSTEMS CONDENSING UNITS R 410A, 6 to 12.5 TONS BUILT TO LAST, EASY TO INSTALL AND SERVICE CAS Product Specifications Single stage cooling capacity control on all models with Micro channel
More informationCommercial High-Efficiency Condensing Units
FORM NO. A22-193 REV. 3 Supersedes Form No. A22-193 Rev. 2 Commercial High-Efficiency Condensing Units 15 & 20 TON MODEL [52.8 & 70.3 kw] 10 & 12.5 TON MODEL [35.2 & 44.0 kw] 10 THROUGH 20 NOMINAL TON
More informationCHS. Product Specifications COMMERCIAL SPLIT SYSTEMS HEAT PUMP UNITS R 410A, 6 10 TONS BUILT TO LAST, EASY TO INSTALL AND SERVICE
COMMERCIAL SPLIT SYSTEMS HT PUMP UNITS R 410A, 6 10 TONS BUILT TO LAST, SY TO INSTALL AND SERVICE Single stage cooling capacity control on all models All models utilize round copper tube, aluminum plate
More informationCommercial High-Efficiency Condensing Units
FORM NO. A22-194 REV. 2 Supersedes Form No. A22-194 Rev. 1 Commercial High-Efficiency Condensing Units RAWL High Efficiency 6.5 & 7.5 TON MODEL [22.86 & 26.38 kw] TABLE OF CONTENTS Model Number Designation...2
More informationSPLIT SYSTEM HEAT PUMP 1½ 5 TON HERITAGE 13 MODELS 2A6H A American Standard Heating & Air Conditioning
SPLIT SYSTEM HEAT PUMP 1½ 5 TON HERITAGE 13 MODELS 2A6H3018-060A 2008 American Standard Heating & Air Conditioning PUB. NO. 12-1216-02 June 2008 Features and Benefits Duration compressor Efficiency up
More informationMHW Air Handling Unit (50/60Hz)
Technical Manual MHW Air Handling Unit (50/60Hz) MHW015A MHW025A MHW035A MHW050A MHW020A MHW030A MHW040A Engineered for flexibility and performance. TM MHW - 2011 (50Hz/60Hz) Contents Literature No.: TM-MHW-1101A
More informationTECHNICAL GUIDE. Description SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS YD360, 480 & THRU 50 NOMINAL TONS YTG-B-0811
Description These units are completely assembled, piped and wired at the factory to provide one-piece shipment and rigging. Each unit is pressurized with a holding charge of Refrigerant R-410A for storage
More informationSELF-CONTAINED VERTICAL AIR COOLED PACKAGE AIR-CONDITIONERS
SELF-CONTAINED VERTICAL AIR COOLED PACKAGE AIR-CONDITIONERS Cooling Capacity from 115,000 to 670,000 Btu/hr Btu/hr Smartwise Innovations... Towards Green, Quality & Reliability Solutions SERIES INTRODUCTION
More informationMidea R410A Tropical ClimaCreator Series Rooftop Package 220V 3Ph 60Hz Technical Manual
Midea R410A Tropical ClimaCreator Series Rooftop Package 220V 3Ph 60Hz Technical Manual Midea reserves the right to discontinue, or change specification or designs at any time without notices and without
More informationPAJ3. Product Specifications
13 SEER, R 410A PACKAGE AIR CONDITIONER FOR MANUFACTURED HOUSING, RESIDENTIAL, AND LIGHT COMMERCIAL APPLICATIONS 2 5 TONS Single Phase, 208/230 V, 60 Hz BUILT TO LAST, EASY TO INSTALL AND SERVICE Compact,
More informationSPLIT SYSTEM COOLING 1½ 5 TON ALLEGIANCE 14 MODELS 4A7A C/30-060B American Standard Heating & Air Conditioning
SPLIT SYSTEM COOLING 1½ 5 TON ALLEGIANCE 14 MODELS 4A7A4018-24C/30-060B 2009 American Standard Heating & Air Conditioning PUB.. 12-1173-04 April 2009 Features and Benefits Duration compressor Efficiency
More informationProduct Data. Features/Benefits. 30RQ Air-cooled Modular Chiller R22 & R410A & R407C
Product Data 30RQ Air-cooled Modular Chiller R22 & R410A & R407C Introduction Air-cooled modular chiller is a kind of central airconditioning unit which adopts air as the cooling (or heating) source and
More informationWATER CHILLER UNITS AIR COOLED CONDENSER CENTRIFUGAL FANS HEAT PUMP. EWCBZ COOLING ONLY. EWCZ
WATER CHILLER UNITS AIR COOLED CONDENSER CENTRIFUGAL FANS HEAT PUMP. EWCBZ COOLING ONLY. EWCZ SERIES: EWCBZ - Heat pump MODELS: 70, 80, 00, 0, 60, 00, 40, 00, 50 COOLING CAPACITIES from 5,9 kw to 78,5
More informationZeta Rev LN HP Prochill Bluebox Print Date: 07/17/2017
Zeta Rev LN HP 10.2 Configured unit accessories 1PS - One user-side pump with tank LN - Low noise RG - Condensation control with fan speed regulator CSP - Set point compensation depending on external air
More informationHorizontal Water Source Heat Pumps And Cooling Only Unit
MWH-B-2005 Horizontal Water Source Heat Pumps And Cooling Only Unit Models: MWH MWH MWH MWH MWH 011 B/BR MWH 012 B/BR MWH 015 B/BR MWH 020 B/BR MWH 025 B/BR MWH 030 B/BR 040 B/BR 050 B/BR 060 B/BR 070
More informationAir Cooled Scroll Chiller
Air Cooled Scroll Chiller Midea chillers use H shape heat at air side and single unit s capacity from kw to 0kW. Super chillers are divided to SS,SS-LA, SP-LA and SP-HMLA series according to their water
More informationPACKAGE AIR CONDITIONER
PACKAGE AIR CONDITIONER FORM NO. ATZ-206 TZAA- HIGH EFFICIENCY SERIES NOMINAL SIZE 10 TON [35.2 kw] 10 TON MODEL [35.2 kw] This product is shipped with a nitrogen holding charge that must be vented prior
More informationCMA TECHNICAL MANUAL CONDENSING UNITS FOR OUTDOOR INSTALLATION O L S A F RA N
E S A RE F R E IG RA N T G TECHNICAL MANUAL -FRIEND Y CONDENSING UNITS FOR OUTDOOR INSTALLATION O L CMA C 2 The manufacturer declines all the responsabilities regarding inaccuracies contained in this manual,
More informationKälte Klima. Air cooled liquid chiller Free-Cooling from 45 kw to 365 kw. Scroll Compressors SCAEY-FC DE 98
Air cooled liquid chiller Free-Cooling from 45 kw to 365 kw Scroll Compressors Series: SCAEY-FC Leaflet: DE 98 Issue: 04/11 Supersedes: 12/10 Identification code Index Index... pag. 2 Identification code...»
More informationSplit System Cooling Product Data
Split System Cooling Product Data XR 13 4TTR3018-060 1½ 5 Tons PUB. NO. 22-1842-05 Features and Benefits Climatuff compressor Efficiency up to 14.00 SEER All aluminum Spine Fin coil WeatherGuard fasteners
More informationБольшая библиотека технической документации каталоги, инструкции, сервисные мануалы, схемы.
Большая библиотека технической документации http://splitoff.ru/tehn-doc.html каталоги, инструкции, сервисные мануалы, схемы. AIR BLUE AIR BLUE air conditioning Homes Easy to install and use, quiet, attractive,
More informationUP to 14.5 SEER, PACKAGE AIR CONDITIONER UNIT, 2 to 5 TONS 208/230 Volt, 1 phase, 60 Hz REFRIGERATION CIRCUIT
SOUND REFRIGERANT ENVIRONMENTALLY PAJ4 Product Specifications UP to 14.5 SEER, PACKAGE AIR CONDITIONER UNIT, 2 to 5 TONS 208/230 Volt, 1 phase, 60 Hz REFRIGERATION CIRCUIT Environmentally sound R-410A
More informationUP TO 17.5 SEER / 13.5 EER / 9.5 HSPF HEAT PUMP ENVIRONMENTALLY BALANCED R- 410A REFRIGERANT 2 THRU 5 TONS SPLIT SYSTEM
EFFICIENT UP TO 17.5 SEER / 13.5 EER / 9.5 HSPF HEAT PUMP ENVIRONMENTALLY BALANCED R- 410A REFRIGERANT 2 THRU 5 TONS SPLIT SYSTEM 208/230 Volt 1- phase REFRIGERATION CIRCUIT S 2- stage scroll compressors
More informationKälte Klima. Air cooled water chillers air cooled reversible heat pumps from 45 kw to 320 KW. Compressors Scroll SCAEY DE 88 04/11 12/10
Air cooled water chillers air cooled reversible heat pumps from 45 kw to 320 KW Compressors Scroll Serie: Series: Emissione: Issue: SCAEY Catalogo: Leaflet: Sostituisce: Supersedes: DE 88 04/11 12/10 Index
More informationKälte Klima. Air cooled liquid chiller Free-Cooling from 45 kw to 385 kw. Scroll Compressors SCAEY-FC DE 98
Air cooled liquid chiller Free-Cooling from 45 kw to 385 kw Scroll Compressors Series: SCAEY-FC Leaflet: DE 98 Issue: 01/16 Supersedes: 12/13 Identification code Index Index... pag. 2 Identification code...»
More informationJOB NAME: LOCATION: PURCHASER: ENGINEER: SUBMITTED TO: FOR: REFERENCE [ ] APPROVAL [ ] CONSTRUCTION [ ] SUBMITTED BY: DATE:
T2HA, T3HA, and T4HA with CAHB Systems Limited Range Multi-Zone Heat Pumps Rev. 1.1 [07/07] JOB NAME: LOCATION: PURCHASER: ENGINEER: SUBMITTED TO: FOR: ERENCE [ ] APPROVAL [ ] CONSTRUCTION [ ] SUBMITTED
More informationConcealed Ducted Split Series R-407C MBH
Concealed Ducted Split Series R-407C 4-60 MBH Ducted Split with Hermetic Compressor Tropical 50 Hz For more technical information please visit Table of Contents INTRODUCTION NOMENCLATURE UNIT RATING SUMMARY
More informationtons MTZ Rooftop Units Plug and Play comfort solutions for residential and commercial application
6.2-30 tons MTZ Rooftop Units Plug and Play comfort solutions for residential and commercial application High-performance, energy-saving, cost-effective rooftop air conditioning solutions for your business
More informationCMA CONDENSING UNITS FOR OUTDOOR INSTALLATION INSTALLATION AND OPERATION MANUAL
CMA CONDENSING UNITS FOR OUTDOOR INSTALLATION ECO-FRIENDLY REFRIGERANT GAS INSTALLATION AND OPERATION MANUAL Dear Customer, Thank you for having purchased a FERROLI product. It is the result of many years
More informationENGINEERING GUIDE. Water-Cooled Self-Contained Units C-Series, Vertical
ENGINEERING GUIDE Water-Cooled Self-Contained Units C-Series, Vertical TABLE OF CONTENTS Introduction...2 Product Overview...3 Nomenclature...4 General Data...5 Cooling Performance Data....6 Evaporator
More informationProduct Data. Features/Benefits. 38AH Commercial Air-Cooled Condensing Units 50/60 Hz. 20 to 130 Nominal Tons (63 to 390 Nominal kw)
Product Data 38AH024-134 Commercial Air-Cooled Condensing Units 50/60 Hz 20 to 130 Nominal Tons (63 to 390 Nominal kw) a38-4143ef 38AH044-134 These dependable split systems match Carrier s 40RM or 39 Series
More informationMODULAR WATER-COOLED CHILLER
Catalogue -B-2011 MODULAR WATER-COOLED CHILLER MODEL: 020BM/020BS 030BM/030BS COOLING CAPACITY: 66/103KW HEATING CAPACITY: 79/118KW For More Than a Century, McQuay has been Devoted to Different Buildings
More informationMHCCW Chilled Water Ceiling Concealed With 5kW Electric Heat 2-Pipe Heat / Cool Fan Coil 30,000 BTUH
MHCCW-10-05 Chilled Water Ceiling Concealed With 5kW Electric Heat 2-Pipe Heat / Cool Fan Coil 30,000 BTUH Rev. 1.21 HVAC Guide Specifications Chilled Water Fan Coil with Electric Heat 2-Pipe Nominal Size:
More informationEKS/HE. MultiScroll Air-cooled liquid chillers High efficiency. Solution B - Base I - Integrata
EKS/HE Refrigerant R410A GWP=2.088 Scroll Compressor Shell & Tube exchanger Axial fan Brazed plate heat exchanger MultiScroll Air-cooled liquid chillers High efficiency Solution B - Base I - Integrata
More informationPYXIS U PYXIS U. rcgroupairconditioning
Industrial : Packaged air cooled liquid chillers for outdoor installation equipped with scroll compressors and microchannel condensing coils Cooling capacity: 44 284 rcgroupairconditioning MIN FETURES
More informationTECAM S.A. harmony. 5PZA Direct Expansion. Air Conditioning Equipment Manufacturer. R-410A PRECISION UNIT 2 Ton 6 Ton / 60 Hz. Tecnología Ambiental
TECAM S.A. Tecnología Ambiental R-410A PRECISION UNIT 2 Ton 6 Ton / 60 Hz harmony 5PZA Direct Expansion Registration No.: SC 4696-1 Registration No.: CO-SC 4696-1 Air Conditioning Equipment Manufacturer
More informationCATALOGUES SUMMARY - WCHBZ Pages WCHZ Pages 19-42
SELF CONTAINED HORIZONTAL UNITS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER ) HEAT PUMP. WCHBZ COOLING ONLY. WCHZ SERIES: WCHBZ - Heat Pump MODELS: 201, 251, 271, 351, 401, 501 COOLING
More informationSINGLE SCREW AIR COOLED CHILLER-HEAT RECOVERY
MHS-F HR-2011 SINGLE SCREW AIR COOLED CHILLER-HEAT RECOVERY MODEL: MCS050.1-380.2FSP MHS050.1-380.2FSP MHS050.1-235.2FSR COOLING CAPACITY: 164KW-1370KW HEATING CAPACITY: 172KW-1439KW PARTIAL HEAT RECOVERY:
More informationSplit System Cooling Product & Performance Data
Split System Cooling Product & Performance Data Three Phase 2TTA3048-060A3 4 5 Tons PUB. NO. 22-1770-03 Features and Benefits All aluminum Spine Fin coil Durable base, fast complete drain, weather proof
More informationMHCCW Chilled Water Ceiling Concealed Without Electric Heat 2-Pipe Heat / Cool Fan Coil 18,000 BTUH
MHCCW-06-00 Chilled Water Ceiling Concealed Without Electric Heat 2-Pipe Heat / Cool Fan Coil 18,000 BTUH Rev. 1.21 HVAC Guide Specifications Chilled or Hot Water Fan Coil 2-Pipe Nominal Size: 18,000 BTUH
More informationR22 air-cooled modular chiller 50Hz unit. Content
Content 1.Nomenclature... 2 2.Product Schedule... 2. External Appearance... 4.Features... 4 5.Specification... 6 6.Dimension... 10 7.Refrigeration System Sketch Drawing... 14 8.Wiring Diagrams... 16 9.Electric
More informationMULTIPLO PF Multifunction chillers for indoor installation. Cooling Capacity: kw Heating Capacity: kw
Multifunction chillers for indoor installation. Cooling Capacity: 22 222 Heating Capacity: 25 236 Scroll compressors EC Plug Fans Plate type heat exchangers EER up to 3,12 COP up to 3,84 ESEER up to 4,01
More informationLow Flow Unit Coolers
BN-LFTB October 2016 Replaces BN-LFTB APR 2015 Low Flow Unit Coolers Technical Guide s LO Air Defrost LOD Electric Defrost LOG Hot Gas Defrost Table of Contents Nomenclature...2 Features & Benefits...3
More informationTECHNICAL GUIDE DESCRIPTION SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS. HA300, HB360, HB480 & HB thru 50 NOMINAL TONS (50 Hz)
DESCRIPTION These units are completely assembled, piped and wired at the factory to provide one-piece shipment and rigging. Each unit is pressurized with a holding charge of refrigerant-22 for storage
More informationSELF CONTAINED HORIZONTAL AIR CONDITIONERS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER)
SELF CONTAINED HORIZONTAL AIR CONDITIONERS WATER COOLED CONDENSER (COAXIAL REFRIGERANT-WATER HEAT EXCHANGER) SERIES: WCHZ MODELS: 201, 251, 271, 351, 401, 501, 701, 721, 751 COOLING CAPACITIES OF: 6,4
More informationSubmittal Data PERFORMANCE DATA CERTIFIED DIMENSION PRINTS CERTIFIED ROOF CURB DIMENSION PRINTS SERVICE OPTION DIMENSION PRINTS
016---028 Single---Package Cooling Units with Factory---Installed Optional Electric Heat Submittal Data PERFORMANCE DATA CERTIFIED DIMENSION PRINTS CERTIFIED ROOF CURB DIMENSION PRINTS SERVICE OPTION DIMENSION
More informationSplit System Heat Pump Product & Performance Data
SS-PRC007-EN Split System Heat Pump Product & Performance Data XL14i 2TWX4018-060 1½ 5 Tons PUB. NO. 22-1750-05 Features and Benefits Climatuff compressor Efficiency up to 15.25 SEER and 9.6 HSPF All aluminum
More informationEpsilon Echos kw. General information Air-Water unit with scroll compressors driven by DC inverter. Unique selling points
Epsilon Echos+ 5 38 kw General information Air-Water unit with scroll compressors driven by DC inverter Configuration /LN: Low noise unit /HP: Reversible heat pump /LE /HP: Reversible condensing unit Unique
More informationTECHNICAL DATA & SERVICE MANUAL
TECHNICAL DATA & SERVICE MANUAL OUTDOOR UNIT: GRF188R5TAA GRF228R5TAA GRF228R7TAA SPLIT SYSTEM AIR CONDITIONER Model No. Product Code No. GRF188R5TAA 38.7107.083 GRF228R5TAA 38.7107.084 GRF228R7TAA 38.7107.085
More informationGLIDER EVO FREE GLIDER EVO FREE GLYCOL FREECOOLING. rcgroupairconditioning
: Packaged air cooled liquid chillers with free-cooling system for outdoor installation, equipped with screw compressors and axial fans Cooling Capacity: 314 1343 Free-Cooling Capacity: 308 938 GLYCOL
More informationSubmittal. Split System Cooling 4A7A6024J-SUB-1B-EN. January A7A6024J1000B TAG:
Submittal Split System Cooling 4A7A6024J1000B Note: Graphics in this document are for representation only. Actual model may differ in appearance. SAFETY WARNING TAG: Only qualified personnel should install
More informationTECHNICAL GUIDE SPLIT-SYSTEM AIR-COOLED EVAPORATOR BLOWER 25, 30, 40 & 50 TON LA300, LB360, 480 & 600 (50 Hz) PROVEN PERFORMANCE GENERAL FEATURING
TECHNICAL GUIDE SPLIT-SYSTEM AIR-COOLED EVAPORATOR BLOWER 25, 30, 40 & 50 TON LA300, LB360, 480 & 600 (50 Hz) PROVEN PERFORMANCE GENERAL The LA/LB line is a flexible performer. LA300, LB360 & 480 can be
More informationLDK LDK. Air to water chillers and heat pumps VERSIONS ACCESSORIES
Air to water chillers and heat pumps The water chillers range is an efficient and low-noise product designed for medium to big applications. The water chillers are suitable for water outlet temperatures
More information30RB Air-Cooled Liquid Chillers. Nominal cooling capacity 8-14 kw. Features. Quiet operation
Air-Cooled Liquid Chillers www.eurovent-certification.com www.certiflash.com Quality Management Systems 0RB 008-05 Nominal cooling capacity 8- The new generation of Aquasnap liquid chillers was designed
More informationGPE Kc UNITS FOR 4-PIPE SYSTEMS WITH SCROLL COMPRESSORS. COOLING CAPACITY FROM 77 TO 426 kw - 2 COOLING CIRCUITS. GPE 802 Kc + CF + GP + MV + P1
UNITS FOR 4-PIPE SYSTEMS WITH SCROLL COMPRESSORS COOLING CAPACITY FROM 77 TO 426 kw - 2 COOLING CIRCUITS GPE 802 Kc + CF + GP + MV + P1 130 Above picture is only indicative and is not binding. AIR R-410A
More informationSplit System Heat Pump Product Data
Split System Heat Pump Product Data XR 13 4TWR3018-060 1½ 5 Tons PUB. NO. 22-1795-06 Features and Benefits Climatuff compressor All aluminum Spine Fin coil Quick-Sess cabinet, service access and refrigerant
More informationSplit System Cooling Product Data
Split System Cooling Product Data Three Phase 4TTA3 3 5 Tons PUB. NO. 22-1791-16-EN Features and Benefits All aluminum Spine Fin coil WeatherGuard fasteners Quick-Sess cabinet, service access and refrigerant
More information1. Product Lineup. 2. External Appearance. 3. Nomenclature M R C 36 H W N1 - R. Power supply R: 380~415V 3Ph~ 50Hz. Refrigerant type N1: R410A
Contents 1. Product Lineup... 1 2. External Appearance... 1 3. Nomenclature... 1 4. Features... 2 5. List of Functions... 3 6. Specifications... 6 7. Dimensional Drawings... 8 8. Wiring Diagrams... 9 9.
More informationDUCTED SPLIT AIR CONDITIONERS 50Hz GCUN/GDS SERIES R 407C
DUCTED SPLIT AIR CONDITIONERS 50Hz GCUN/GDS SERIES R 407C CONTENTS General features Page 3 Components features Pages 3 to 5 Compressors Condensers Condenser fans Evaporators Evaporator fan and drive Casing-Structure
More informationT-SERIES SPLIT SYSTEM UNITS R-410A - 60 HZ. EER up to to 20 Tons Cooling Capacity - 71,000 to 236,000 Btuh AIR CONDITIONERS TS
PRODUCT SPECIFICATIONS CONDITIONERS TS T-SERIES SPLIT SYSTEM UNITS R-410A - 60 HZ Bulletin No. TSA-072-240 (11/2016) 072-090 Models 180-240 Models 120-150 Models EER up to 11.7 6 to 20 Tons Cooling Capacity
More informationProduct Data PH13(N,P)R FEATURES AND BENEFITS. SPLIT SYSTEM HEAT PUMP For Use With R Refrigerant 1---1/2 TO 5 TONS ( )
(N,P)R SPLIT SYSTEM HEAT PUMP For Use With R --- 22 Refrigerant 1---1/2 TO 5 TONS (018 --- 060) Product Data *Units factory---shipped with no refrigerant. Dry nitrogen charge only. FEATURES AND BENEFITS
More informationTECHNICAL GUIDE DESCRIPTION SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS MODELS: HF-07 FEATURES B-0703
TECHNICAL GUIDE SPLIT-SYSTEM AIR-COOLED CONDENSING UNITS MODELS: HF-07 DESCRIPTION These Sunline 2000 units are completely assembled, piped and wired at the factory to provide one-piece shipment and rigging.
More informationMHNCCW (4-Pipe) Chilled/Hot Water Ceiling Concealed 208/230V 4-Pipe Heating & Cooling Fan Coil 12,000 BTUH
MHNCCW-04-01 (4-Pipe) Chilled/Hot Water Ceiling Concealed 208/230V 4-Pipe Heating & Cooling Fan Coil 12,000 BTUH Rev. 1.2 HVAC Guide Specifications Chilled and Hot Water Fan Coil 4-Pipe Nominal Size: 12,000
More informationUnit Dimension. Unit Nomenclature DEHUMIDIFIER NOMENCLATURE UNIT VOLTAGE: 2: 240/1/60 5: /3/60 9: 480/3/60 8: 600/3/60
Unit Dimension Unit Nomenclature DEHUMIDIFIER NOMENCLATURE R K D A - 0050 - C Z - M 4-8 UNIT VOLTAGE: 2: 240/1/60 5: 208-240/3/60 9: 480/3/60 8: 600/3/60 REFRIGEREANT R-404a MEDIUM TEMPERATURE SCROLL COMPRESSOR
More informationAll side discharge units are having high pressure switch (LP switch- Optional) and time delay relay. Compressors are scroll type, Copeland make.
All outdoor units are designed to perform satisfactorily at 52 C, with the option of either top discharge condensing units, with Copeland reciprocating scroll compressors. All top discharge condensing
More informationClimaMaster Series. Rooftop Package Unit 50Hz 1311-R1211. D e a l e r i n f o r m a t i o n
1311-R1211 GD Midea Refrigeration Equipment Co., Ltd. Is certified under the ISO 9001 International standard for quality assurance. NO.01 100 019209 D e a l e r i n f o r m a t i o n GD Midea Refrigeration
More informationSplit System Cooling Product Data
Split System Cooling Product Data Three Phase 4TTA3 2½ 5 Tons PUB. NO. 22-1791-14-EN Features and Benefits All aluminum Spine Fin coil WeatherGuard fasteners Quick-Sess cabinet, service access and refrigerant
More informationTITAN SERIES Complete Central Chiller & Pump Tank Package 20 to 70 Tons 20 F to 70 F
Temperature Control Units Water & Oil - F Portable Chillers Air & Water-Cooled - 7 F Central Chillers Air & Water-Cooled Packages & Modules - 7 F Pump Tank Stations Chilled or Tower Water - gallons Cooling
More informationCFFWA4P-08-1-U Chilled/Hot Water Universal Mount Fan Coil (4-Pipe) 4-Pipe Heat / Cool Fan Coil 24,000 BTUH
CFFWA4P-08-1-U Chilled/Hot Water Universal Mount Fan Coil (4-Pipe) 4-Pipe Heat / Cool Fan Coil 24,000 BTUH Rev. 1.3 HVAC Guide Specifications Chilled and Hot Water Universal Mount Fan Coil 4-Pipe Nominal
More information15 SEER SINGLE- PACKAGED HEAT PUMP SYSTEM WITH PURON
7D- -A EVOLUTIONr 15 SEER SINGLE-PACKAGED HEAT PUMP SYSTEM WITH PURONr (R-410A) REFRIGERANT SINGLE PHASE 2-5 NOMINAL TONS (SIZES 24-) Fig. 1 - Unit 7D - -A Product Data A09032 Single-Packaged Products
More informationTechnical Data OPA 101, 150, 180. Ducted Three Phase Packaged Air Conditioner kw 18.5 kw. Extra Long Life Epoxy Coated Outdoor Coil
Ducted Three Phase Packaged Air Conditioner Technical Data, 0, 180 Extra Long Life Epoxy Coated Outdoor Coil Nominal Cooling Capacity 10.0 kw 18.5 kw JUNE 5 , 0, 180 DUCTED PACKAGED ROOF TOP AIR CONDITIONERS
More informationModular Air Cooled Scroll Chillers
Modular Air Cooled Scroll Chillers 65 80 130 Find out more at www.greeonline.com 160 249 High Efficiency Shell and Tube Heat Exchanger The Gree D Series Chillers utilise high efficiency shell and tube
More informationAIR COOLED MINI CHILLER
Catalogue MAC-D-2009(60Hz) AIR COOLED MINI CHILLER MODEL: MAC060D4 MAC090D4 MAC120D4 COOLING CAPACITY: 16.2~33KW For More Than a Century, McQuay has been Devoted to Different Buildings 1010101010101010101010101010101010101010101010101010101010101010101010010101010101010101010101010101010101001010101010101010101010101010101010101010101010101010101010101010101010101010101010101
More information50TM TFF COMBINATION HEATING/COOLING UNITS
50T-1SB 50TM007-012 50TFF004-014 COMBINATION HEATING/COOLING UNITS PERFORMANCE DATA CERTIFIED DIMENSION PRINTS CERTIFIED ROOF CURB DIMENSION PRINTS Copyright 2002 Carrier Corporation Syracuse, New York
More informationSubmittal. Split System Cooling 5.0 Ton 4A7A3060D1000P TAG:
Submittal Split System Cooling 5.0 Ton 4A7A3060D1000P SAFETYWARNING TAG: Only qualified personnel should install and service the equipment. The installation, starting up, and servicing of heating, ventilating,
More informationAIR-CONDITIONER SERVICE MANUAL
FILE NO. A90-9608 SERVICE MANUAL AIR-CONDITIONER S SPLIT BUILT-IN DUCT TYPE RAV-362B-PE/ RAV-462B-PE/ SPLIT CEILING TYPE RAV-362C-PE/ RAV-462C-PE/ SPLIT CASSETTE TYPE RAV-362U-PE/ RAV-462U-PE/ PRINTED
More information