NYC Department of Education

Transcription

1 Asset: P.S BRONX, 968 CAULDWELL AVENUE, New York, Inspection Id Inspection Type Time In Last Edited ME : Mechanical :57 AM :59 PM Asset Data Are there fuel tanks? Total # of above ground tanks 1 Answer Total capacity of all above ground tanks in gal. 10,000 Total # of below ground tanks 0 Total capacity of all below ground tanks in gal. 0 Total # of water main service entries to the asset 3 MERs/Fan Rooms Locations Are there any spaces with Missing or Defective CO Detectors? Are there any Emergency Stop Switches with Missing Hammers? Are there any Painted/Obstructed Sprinkler Heads? Have any Systems/Major Building Components been upgraded? Priority NYC Department of Education Building Assessment Survey Yes MER B12 No No No Yes Systems: Fixtures - Student: Lavatory/Sinks, Toilets, Urinals (50%); Boiler #1 retubed Years: 2018 Systems: Fixtures - Student: Lavatory/Sinks, Toilets, Urinals (35%) Years: 2017 Systems: Steam Condensate Return Pumping System; Kitchen - Grease Traps Years: 2014 Systems: Years: 2012 MDF Room - Dedicated A/C Equipment (DX Split System) Systems: Chilled Water System; Exhaust Fans (12 of 20) Years: 2008 Priority Priority Exist Category Last Year? Description Component Affected Location Description Person(s) Notified Person(s) Title Status PhotoImage No condition recorded Inspection Mechanical AIR CONDITIONING Chilled Water System Absorption Chiller Air Cooled Chiller Air Cooled Condenser Chilled Water Distribution: Piping, Pumps and Auxiliaries Location/Instance Quantity 1 AUXILIARIES: DEFECTIVE MAKE-UP GLYCOL/WATER FEEDER PB/A&W Page 1 of 14

2 Building Assessment Survey AIR CONDITIONING Chilled Water System Chilled Water Distribution: Piping, Pumps and Auxiliaries Photo1 Backflow Preventer Central Station Air Handler Fan Coil Unit 2 - Between Good and Fair Location/Instance Room 105 Quantity 1 DEFECTIVE CONTROLS Photo1 Packaged Air Cooled Chiller Instance Instance Instance Quantity 1 Instance Instance Manufacturer Equipment Capacity/Size Quantity 250 Capacity/Size UOM Source of Capacity/Size Main Roof Trane CH-1 Tons Installation Year 2008 Source of Installation Water Cooled Chiller Condenser Water Distribution: Piping, Pumps and Auxiliaries Cooling Coil in Ductwork Cooling Tower DX Split System Indoor Unit Inspector Estimate Custodial Staff 2 - Between Good and Fair UP TO 5 TONS: DEFECTIVE Location/Instance Room 302 (1 of 3) Quantity 1 REPAIR Photo1 PB/A&W Page 2 of 14

3 AIR CONDITIONING DX Split System Outdoor Unit Dry Cooler Packaged / Rooftop Unit Packaged Terminal A/C Refrigerant Piping Return Fan CENTRAL ACID WASTE NEUTRALIZING TANK CLIMATE CONTROL SYSTEM BMS Pneumatic System Instance Instance Instance Quantity 1 Instance 2 - Between Good and Fair 2 - Between Good and Fair Throughout Building Area Covered by Operational System 61-80% Location/Instance Quantity 15 DEFECTIVE TEMPERATURE CONTROL THERMOSTAT Kitchen Storage Room, Gymnasium, Auditorium, Library and other locations Photo1 Location/Instance Quantity 3 DEFECTIVE TERMINAL UNIT CONTROLLER MER B12 at Auditorium SF, Gymnasium SF, Cafeteria Blower Photo1 Hybrid System Electric System COMPACTOR CONVEYING Dumbwaiter Elevator Escalator Non-auditorium Handicap Lift - Vertical Non-auditorium Handicap Lift - Stair NYC Department of Education Building Assessment Survey PB/A&W Page 3 of 14

4 CONVEYING Non-auditorium Handicap Lift - Stair Ash Hoist Are all the existing ash hoists operable? Sidewalk Elevator DOMESTIC WATER SYSTEM Domestic Cold Water System Gravity System Pressure Booster System Water Service Instance Instance Instance Quantity 1 Instance Location/Instance Quantity 1 Yes - Crawlspace WATER MAIN: MISSING BACKFLOW PREVENTION DEVICE - Crawlspace INSTALL Photo1 Instance Instance Instance Quantity 2 Instance Location/Instance Quantity 2 Sprinkler/Water Meter Room B1 WATER MAIN: MISSING BACKFLOW PREVENTION DEVICE Sprinkler/Water Meter Room B1 INSTALL Photo1 Domestic Hot Water System Domestic Hot Water Remote Storage Tank Domestic Water Heat Exchanger Electric Domestic Water Heater Gas Fired Domestic Water Heater Instance Instance Instance Quantity 1 Instance NYC Department of Education Building Assessment Survey PB/A&W Page 4 of 14

5 Building Assessment Survey DOMESTIC WATER SYSTEM Domestic Hot Water System Gas Fired Domestic Water Heater Instance Manufacturer RayPak Equipment N/A Capacity/Size Quantity 158 Capacity/Size UOM MBH Output Capacity/Size2 Quantity 0 Capacity/Size2 UOM Gallons Source of Capacity/Size Documented Installation Year 1975 Source of Installation Inspector Estimate DEFECTIVE CONTROLS Location/Instance Quantity 1 Photo1 Location/Instance Quantity 1 BEYOND USEFUL LIFE Urgency of Action PRIORITY 1 Photo1 Oil Fired Domestic Water Heater Domestic Water Distribution Piping Location/Instance Quantity 1 DEFECTIVE DOMESTIC HOT WATER CIRCULATING PUMP Photo1 Location/Instance Quantity 1 DEFECTIVE ISOLATION VALVE near Gas Fired Domestic Water Heater PB/A&W Page 5 of 14

6 DOMESTIC WATER SYSTEM Domestic Water Distribution Piping Photo1 NYC Department of Education Building Assessment Survey DRAIN/WASTE/VENT AND STORM SYSTEM Interior Storm Piping Sewage/Waste/Vent Piping Location/Instance Quantity 40 SEWAGE/WASTE PIPING: DEFECTIVE/LEAKS near Incinerator and Boilers L.F. Photo1 Sewage Ejector Pump Sump Pump DUAL TEMPERATURE SYSTEM (CHILLED AND HOT WATER) FIXTURES Staff And Other Janitor Sink Lavatory/Sink Toilet Urinal Student Drinking Fountain Lavatory/Sink Locker Room Shower - Boys Instance Instance Quantity 1 PB/A&W Page 6 of 14

7 Building Assessment Survey FIXTURES Student Locker Room Shower Instance Alternative use Yes - Girls Instance Instance Quantity 1 Instance Alternative use Yes Sink And Fountain Combo Unit Toilet Urinal GAS FIRED FURNACE GAS SERVICE Gas Distribution Piping Gas Meter Room Exhaust Fan Gas Meter Room Vent Gas Pressure Booster CO/Gas Leak Detection HEATING Heating Coil In Ductwork Hydronic Heating Radiator/Convector/Fin Tube AUXILIARY (VALVE,VENT): DEFECTIVE Location/Instance Stairs 2-1st Floor, landing between 1st and 2nd Floor Quantity 2 Photo1 RADIATOR/CONVECTOR: DEFECTIVE PB/A&W Page 7 of 14

8 Building Assessment Survey HEATING Radiator/Convector/Fin Tube Location/Instance Principal's office Quantity 1 Photo1 Steam Heating F&T/Steam Drip Trap DEFECTIVE/DETERIORATED Location/Instance, MER B12 Quantity 5 Photo1 MER Steam and Condensate Piping Steam Condensate Return Piping DAMAGED/MISSING INSULATION Location/Instance near Air Compressor area Quantity 10 L.F. Photo1 DEFECTIVE/LEAKS Location/Instance near Air Compressor area Quantity 10 L.F. Photo1 Steam Condensate Return Pumping System Steam Piping PB/A&W Page 8 of 14

9 Building Assessment Survey HEATING Steam Heating Steam Piping DAMAGED/MISSING INSULATION Location/Instance near Air Compressor area Quantity 10 L.F. Photo1 Terminal Unit Thermostatic Trap Steam supplied by External Sources Unit Heater/Cabinet Heater HEATING PLANT Replacement Quantity 8,074 Replacement Uom Burner Type Heating Plant Oil Number Boiler Auxiliaries Boiler Auxiliary Piping Boiler Emergency Stop Switch Boiler Feedwater System Boiler Feedwater Treatment(Automatic) Boiler Flue Exhaust Boiler Make-up Water Backflow Preventer Steam And Condensate Piping MBH Net Oil 2 DAMAGED/MISSING INSULATION PB/A&W Page 9 of 14

10 Building Assessment Survey HEATING PLANT Boiler Auxiliaries Steam And Condensate Piping Location/Instance Quantity 20 L.F. Photo1 Boiler Safety Valve Boiler System Coal-fired Boiler Hot Water Boiler Modular Boiler Steam Boiler Instance Instance 2 - Between Good and Fair Instance Quantity 4,037 Instance Instance Manufacturer MBH Net Equipment Capacity/Size Quantity 5,360 Capacity/Size UOM Source of Capacity/Size Installation Year 1958 Source of Installation Quantity 1 National U.S. Radiator Corp. Lbs/Hr steam Documented Documented DAMAGED/MISSING INSULATION Photo1 Location/Instance Quantity 1 BEYOND USEFUL LIFE PB/A&W Page 10 of 14

11 Building Assessment Survey HEATING PLANT Boiler System Steam Boiler Urgency of Action PRIORITY 1 Photo1 Instance Instance Instance Quantity 4,037 Instance MBH Net Instance Manufacturer National U.S. Radiator Corp. Equipment Capacity/Size Quantity 5,360 Capacity/Size UOM Lbs/Hr steam Source of Capacity/Size Documented Installation Year 1958 Source of Installation Documented DAMAGED CASING Quantity 1 REPAIR Photo1 BEYOND USEFUL LIFE Location/Instance Quantity 1 Urgency of Action PRIORITY 1 Photo1 Fuel System Boiler Fresh Air Louver/Damper Burner/Burner Control Panel Fuel Oil Storage/Supply System PB/A&W Page 11 of 14

12 Building Assessment Survey HEATING PLANT Fuel System Fuel Oil Storage/Supply System FUEL OIL LEVEL GAUGE: DEFECTIVE Location/Instance Quantity 1 Photo1 Gas Trains And Vent At The Boiler Enclosed IDF Room Instance on Room 215 Dedicated A/C Equipment Instance on Room Between Fair and Poor DOES NOT EXIST Location/Instance Room 215 Quantity 1 INSTALL Photo1 KITCHEN CO Detector Gas System Grease Trap DEFECTIVE/CLOGGED Location/Instance Kitchen (1 of 2) Quantity 1 Photo1 PB/A&W Page 12 of 14

13 KITCHEN Grease Trap NYC Department of Education Building Assessment Survey Hood Hood Exhaust Ductwork Hood Exhaust Fan Hood Fire Suppression System Hot Water Temperature Booster Kitchen Sink MDF Room Instance on Room B9 Dedicated A/C Equipment Instance on Room B9 SCIENCE DEMO ROOM SCIENCE LAB SCIENCE PREP ROOM SPRINKLERS, STANDPIPE, FIRE SYSTEM Dry Sprinkler Alarm Valve Assembly Wet Sprinkler Alarm Valve Assembly Fire Booster Pump Assembly Roof Tank Siamese Connection Sprinkler Head Sprinkler Piping Standpipe System 2 - Between Good and Fair PB/A&W Page 13 of 14

14 Building Assessment Survey SPRINKLERS, STANDPIPE, FIRE SYSTEM Water Gong SWIMMING POOL VENTILATION Exhaust Fan Approximate Total # of Fans Between Good and Fair DEFECTIVE Location/Instance Main Roof / EF-10 Quantity 1 Photo1 Heating And Ventilating Unit Metal Ductwork DAMAGED FLEXIBLE CONNECTION Location/Instance MER B12 at Auditorium SF Quantity 1 Photo1 Supply Fan Approximate Total # of Fans 1-5 Unit Ventilator PB/A&W Page 14 of 14