NYC Department of Education

Transcription

1 Mechanical Inspection Asset: P.S. 1 - MANHATTAN, 8 HENRY STREET, New York, Inspection Id Inspection Type Time In Last Edited ME : Mechanical :39 AM :28 PM Asset Data Are there fuel tanks? Total # of above ground tanks 1 Answer Total capacity of all above ground tanks in gal Total # of below ground tanks 0 Total capacity of all below ground tanks in gal. 0 Total # of water main service entries to the asset 2 MERs/Fan Rooms Locations Are there any spaces with Missing or Defective CO Detectors? Location(s) Are there any Emergency Stop Switches with Missing Hammers? Component Affected Location Are there any Painted/Obstructed Sprinkler Heads? Location(s) Have any Systems/Major Building Components been upgraded? Priority NYC Department of Education Building Assessment Survey Yes Boiler Room Fan Room, 1st Floor MER, Roof Fan Room East, Roof Fan Room West Yes Kitchen Yes Boiler Emergency Stop Switch Basement Workshop area Yes Basement Supply Room outside Gas Meter Room Yes Systems: Years: 2017 Systems: Years: 2014 Electric Pressure Booster System; Water Service; Kitchen - Hood Fire Suppression System CO/Gas Leak Detection Systems: Unit Heater/Cabinet Heater (1 of 9) Years: 2013 Systems: Years: 2011 Climate Control System except Air Compressor; F&T/Steam Drip Traps; Terminal Unit Thermostatic Traps; Unit Heater/Cabinet Heater (8 of 9) Systems: Boiler Safety Valve for Boiler #2 Years: 2010 Systems: Years: 2009 MDF Room - Dedicated A/C Equipment (DX Split System) Systems: Kitchen - Grease Trap; Student - Urinals (70%) Years: 2008 Priority Priority Exist Category Last Year? Description Component Affected Location Description Person(s) Notified Person(s) Title Status PhotoImage No No Defective Boiler Safety Auxiliary Defective CO/Gas Leak Detection Defective Water Column Defective Panel HEATING PLANT Boiler System Steam Boiler GAS SERVICE CO/Gas Leak Detection Boiler Room Diego Pedroza Fireman Sent to DSF Basement Workshop Diego Pedroza Fireman Sent to DSF Inspection Mechanical AIR CONDITIONING PB/A&W Page 1 of 12

2 Mechanical Inspection CENTRAL ACID WASTE NEUTRALIZING TANK CLIMATE CONTROL SYSTEM BMS Pneumatic System Quantity 1 Throughout (except Cafeteria, Multipurpose Room, Gymnasium) Building Area Covered by Operational System % Hybrid System Electric System COMPACTOR CONVEYING DOMESTIC WATER SYSTEM Domestic Cold Water System Gravity System Supply Pump Roof Tank Location/ Quantity 1 NOT IN USE Roof Water Tank Room NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Pressure Booster System Electric Pressure Booster System Quantity 1 Manufacturer Equipment Capacity/Size Quantity 2 Capacity/Size UOM Capacity/Size2 Quantity 10 Capacity/Size2 UOM Source of Capacity/Size Basement 1 - Good Installation Year 2017 Source of Installation Hydraulic/Pneumatic Booster System Water Pressure Booster - Compressor NYC Department of Education Building Assessment Survey Ketcham Pump Company N/A Total # Pumps Total Pumps HP Documented Documented PB/A&W Page 2 of 12

3 NYC Department of Education Building Assessment Survey Mechanical Inspection DOMESTIC WATER SYSTEM Domestic Cold Water System Pressure Booster System Hydraulic/Pneumatic Booster System Water Pressure Booster - Compressor NOT IN USE Location/ Basement Quantity 1 NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Pressure Booster Pump Location/ Quantity 2 NOT IN USE Basement NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Domestic Cold Water Tank Location/ Quantity 1 NOT IN USE Basement NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Water Service Quantity 1 Quantity 1 Basement West 1 - Good Basement South 1 - Good PB/A&W Page 3 of 12

4 NYC Department of Education Building Assessment Survey Mechanical Inspection DOMESTIC WATER SYSTEM Domestic Cold Water System Water Service Domestic Hot Water System Domestic Hot Water Remote Storage Tank Domestic Water Heat Exchanger Electric Domestic Water Heater Gas Fired Domestic Water Heater Boiler Room Quantity 1 Manufacturer PVI Equipment N/A Capacity/Size Quantity 800 Capacity/Size UOM MBH Input Capacity/Size2 Quantity 225 Capacity/Size2 UOM Gallons Source of Capacity/Size Documented Installation Year 1995 Source of Installation Inspector Estimate BEYOND USEFUL LIFE Location/ Boiler Room Quantity 1 Urgency of Action PRIORITY 1 Photo1 Oil Fired Domestic Water Heater Domestic Water Distribution Piping DRAIN/WASTE/VENT AND STORM SYSTEM Interior Storm Piping Sewage/Waste/Vent Piping Sewage Ejector Pump Sump Pump DUAL TEMPERATURE SYSTEM (CHILLED AND HOT WATER) FIXTURES PB/A&W Page 4 of 12

5 Mechanical Inspection FIXTURES Staff And Other Janitor Sink Lavatory/Sink Toilet Urinal Student Location/ Quantity 1 DEFECTIVE AUXILIARY (FAUCET, SHUT OFF VALVE,ETC.) 5th Floor Toilet Room MAINTENANCE Photo1 Drinking Fountain CRACKED/PHYSICAL DAMAGE Location/ Corridor adjacent to Room 402 Quantity 1 Photo1 Lavatory/Sink Location/ Quantity 5 DEFECTIVE AUXILIARY (FAUCET, SHUT OFF VALVE,ETC.) Cafeteria, 2nd Floor Boy's Toilet Room, 3rd Floor Student Toilet Room, 4th Floor Boy's Toilet Room MAINTENANCE Photo1 Locker Room Shower Sink And Fountain Combo Unit NYC Department of Education Building Assessment Survey PB/A&W Page 5 of 12

6 NYC Department of Education Building Assessment Survey Mechanical Inspection FIXTURES Student Toilet Urinal CRACKED/PHYSICAL DAMAGE Location/ 2nd Floor Boy's Toilet Room Quantity 2 Photo1 GAS FIRED FURNACE GAS SERVICE Gas Distribution Piping Gas Meter Room Exhaust Fan Gas Meter Room Vent Gas Pressure Booster Gas Meter Room Quantity 1 Manufacturer Eclipse Equipment N/A Capacity/Size Quantity 12,000 Capacity/Size UOM SCFH Source of Capacity/Size Inspector Estimate Installation Year 1995 Source of Installation Inspector Estimate CO/Gas Leak Detection Boiler Room and Gas Meter Room 1 - Good Quantity 1 Installation Year 2014 Source of Installation Inspector Estimate DEFECTIVE CONTROL PANEL Location/ Basement Workshop PB/A&W Page 6 of 12

7 NYC Department of Education Building Assessment Survey Mechanical Inspection GAS SERVICE CO/Gas Leak Detection Quantity 1 REPAIR Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 HEATING Heating Coil In Ductwork 5 - Poor DEFECTIVE/DETERIORATED Location/ 1st Floor MER Quantity 1 Photo1 Hydronic Heating Radiator/Convector/Fin Tube Steam Heating F&T/Steam Drip Trap MER Steam and Condensate Piping Steam Condensate Return Piping Steam Condensate Return Pumping System Steam Piping DEFECTIVE/LEAKS Location/ Basement near Sump Pumps and Boiler Room Quantity 20 L.F. Photo1 PB/A&W Page 7 of 12

8 Mechanical Inspection HEATING Steam Heating Terminal Unit Thermostatic Trap Steam supplied by External Sources Unit Heater/Cabinet Heater HEATING PLANT 1 - Good Replacement Quantity 5,854 Replacement Uom Burner Type Heating Plant Oil Number Boiler Auxiliaries Boiler Auxiliary Piping Boiler Emergency Stop Switch Location/ Quantity 1 MBH Net Dual Fuel (Gas/Oil) 2 MISSING HAMMER Basement Workshop MAINTENANCE Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 NYC Department of Education Building Assessment Survey Boiler Feedwater System FEEDWATER TANK: DAMAGED/MISSING INSULATION Location/ Boiler Room Quantity 10 S.F. Photo1 Boiler Feedwater Treatment(Automatic) Boiler Flue Exhaust PB/A&W Page 8 of 12

9 NYC Department of Education Building Assessment Survey Mechanical Inspection HEATING PLANT Boiler Auxiliaries Boiler Flue Exhaust Boiler Make-up Water Backflow Preventer Boiler Room Steam And Condensate Piping Boiler Safety Valve Boiler System Coal-fired Boiler Hot Water Boiler Modular Boiler Steam Boiler Boiler Room Quantity 2,927 MBH Net Manufacturer Kewanee Boiler Corporation Equipment Capacity/Size Quantity 3,770 Capacity/Size UOM MBH Gross Source of Capacity/Size Documented Installation Year 1995 Source of Installation Inspector Estimate Boiler Room Quantity 2,927 MBH Net Manufacturer Kewanee Boiler Corporation Equipment Capacity/Size Quantity 3,770 Capacity/Size UOM MBH Gross Source of Capacity/Size Documented Installation Year 1995 Source of Installation Inspector Estimate PB/A&W Page 9 of 12

10 Mechanical Inspection HEATING PLANT Boiler System Steam Boiler Fuel System Quantity 1 DEFECTIVE SAFETY AUXILIARY: LOW-WATER CUT-OFF, WATER COLUMN ASSEMBLY MAINTENANCE Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 Boiler Fresh Air Louver/Damper Burner/Burner Control Panel Fuel Oil Storage/Supply System Gas Trains And Vent At The Boiler Enclosed IDF Room KITCHEN CO Detector Location/ Quantity Between Fair and Poor DEFECTIVE/MISSING Kitchen MAINTENANCE Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 NYC Department of Education Building Assessment Survey Gas System Grease Trap PB/A&W Page 10 of 12

11 Mechanical Inspection KITCHEN Grease Trap Hood Hood Exhaust Ductwork Hood Exhaust Fan Hood Fire Suppression System Hot Water Temperature Booster Kitchen Sink MDF Room on Room 409 Dedicated A/C Equipment on Room 409 SCIENCE DEMO ROOM SCIENCE LAB SCIENCE PREP ROOM SPRINKLERS, STANDPIPE, FIRE SYSTEM Dry Sprinkler Alarm Valve Assembly Wet Sprinkler Alarm Valve Assembly Fire Booster Pump Assembly Roof Tank Siamese Connection Sprinkler Head Location/ Quantity Good DEFECTIVE/DETERIORATED Basement Supply Room outside Gas Meter Room Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 NYC Department of Education Building Assessment Survey PB/A&W Page 11 of 12

12 NYC Department of Education Building Assessment Survey Mechanical Inspection SPRINKLERS, STANDPIPE, FIRE SYSTEM Sprinkler Head Sprinkler Piping Standpipe System Water Gong SWIMMING POOL VENTILATION Exhaust Fan Approximate Total # of Fans 1-25 Heating And Ventilating Unit Metal Ductwork DEFECTIVE DUCTWORK Location/ Basement Fan Room, 1st Floor MER, Roof Fan Rooms East and West Quantity 200 L.F. MAINTENANCE Photo1 DAMAGED FLEXIBLE CONNECTION Location/ Basement Fan Room, Roof East Fan Room Quantity 3 Photo1 Supply Fan Approximate Total # of Fans 1-5 Unit Ventilator PB/A&W Page 12 of 12