NYC Department of Education

Transcription

1 Asset: P.S MANHATTAN, 442 EAST HOUSTON STREET, New York, Inspection Id Inspection Type Time In Last Edited ME : Mechanical :52 AM :06 PM Asset Data Are there fuel tanks? Total # of above ground tanks 1 Answer Total capacity of all above ground tanks in gal Total # of below ground tanks 0 Total capacity of all below ground tanks in gal. 0 Total # of water main service entries to the asset 2 MERs/Fan Rooms Locations MER 110 Are there any spaces with Missing or Defective CO Detectors? Are there any Emergency Stop Switches with Missing Hammers? Component Affected Location Are there any Painted/Obstructed Sprinkler Heads? Have any Systems/Major Building Components been upgraded? Priority Yes No Yes Boiler Emergency Stop Switch Outside Boiler Room No Yes Systems: Years: 2016 Systems: Years: 2014 Systems: Years: 2012 Systems: Years: 2010 Systems: Years: 2008 Systems: Years: 2007 Gas Fired Domestic Water Heater, Electric Domestic Water Heater MDF Room - Dedicated A/C Equipment (DX Split System) Elevator; DX Split System for Elevator Machine Room; Boiler Safety Valves (2 of 4); Fixtures - Student: Lavatory/Sinks (approximately 50%), Toilets (approximately 50%), Urinals (approximately 50%); Fixtures - Staff: Lavatory/Sinks (approximately 90%), Toilets (approximately 90%); Supply Fan and Electric Heating Coil in Ductwork inside Room 312 Science Lab Domestic Hot Water Remote Storage Tank Boiler Make-up Water Backflow Preventer; Water Service; CO/Gas Leak Detection Priority Priority Exist Category Last Year? Description Component Affected Location Description Person(s) Notified Person(s) Title Status PhotoImage Yes Defective Sprinkler/Stand pipe System Painted Sprinkler Head SPRINKLERS, STANDPIPE, FIRE SYSTEM Sprinkler Head Room 104 Christian Mardones Handyman Sent to DSF Inspection Mechanical AIR CONDITIONING Chilled Water System Condenser Water Distribution: Piping, Pumps and Auxiliaries Cooling Coil in Ductwork PB/A&W Page 1 of 15

2 AIR CONDITIONING Cooling Tower DX Split System Indoor Unit Outdoor Unit Dry Cooler Packaged / Rooftop Unit Technology Room L-2 Roof Quantity 2 Source of Heating Gas Manufacturer Trane Equipment RTU-1, RTU-2 Capacity/Size Quantity 5 Capacity/Size UOM Tons Source of Capacity/Size Inspector Estimate Installation Year 2006 Inspector Estimate UP TO 20 TONS: DEFECTIVE GAS FURNACE Location/ Technology Room L-2 Roof Quantity 2 REPAIR Photo1 Packaged Terminal A/C Refrigerant Piping Return Fan CENTRAL ACID WASTE NEUTRALIZING TANK CLIMATE CONTROL SYSTEM BMS Pneumatic System Quantity 1 Throughout Building Area Covered by Operational System % Location/ Quantity 1 DEFECTIVE AIR COMPRESSOR Boiler Room (1 of 2 compressors on tank seized) PB/A&W Page 2 of 15

3 CLIMATE CONTROL SYSTEM Pneumatic System Photo1 DEFECTIVE TEMPERATURE CONTROL THERMOSTAT Location/ 1st Floor, Rooms 211, 212, 311 and other locations Quantity 15 Photo1 Hybrid System Electric System COMPACTOR CONVEYING Dumbwaiter Elevator Are all the existing elevators operable? Yes Escalator Non-auditorium Handicap Lift - Vertical Non-auditorium Handicap Lift - Stair Ash Hoist Sidewalk Elevator DOMESTIC WATER SYSTEM Domestic Cold Water System Gravity System Supply Pump Roof Tank NOT IN USE Location/ Penthouses 1 and 2 Quantity 2 NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Pressure Booster System Electric Pressure Booster System PB/A&W Page 3 of 15

4 DOMESTIC WATER SYSTEM Domestic Cold Water System Pressure Booster System Electric Pressure Booster System Water Pump Room Between Fair and Poor Quantity 1 Manufacturer Federal Pump Equipment N/A Capacity/Size Quantity 3 Capacity/Size UOM Total # Pumps Capacity/Size2 Quantity 20 Capacity/Size2 UOM Total Pumps HP Source of Capacity/Size Installation Year 1997 Inspector Estimate DEFECTIVE PUMP Quantity 2 Photo1 Quantity 1 RUSTY/LEAKY VALVES AND PIPE FITTINGS Photo1 Hydraulic/Pneumatic Booster System Water Service Quantity 1 Quantity 1 Domestic Hot Water System Domestic Hot Water Remote Storage Tank Crawlspace - Northwest Corner Crawlspace - Southwest Corner DEFECTIVE/LEAKS PB/A&W Page 4 of 15

5 DOMESTIC WATER SYSTEM Domestic Hot Water System Domestic Hot Water Remote Storage Tank Location/ Boiler Room Quantity 1 REPAIR Photo1 Domestic Water Heat Exchanger Electric Domestic Water Heater Gas Fired Domestic Water Heater Boiler Room Quantity 1 Manufacturer RayPak Equipment N/A Capacity/Size Quantity 264 Capacity/Size UOM MBH Input Capacity/Size2 Quantity 0 Capacity/Size2 UOM Gallons Source of Capacity/Size Installation Year 2016 Inspector Estimate Oil Fired Domestic Water Heater Domestic Water Distribution Piping DRAIN/WASTE/VENT AND STORM SYSTEM Interior Storm Piping DEFECTIVE/LEAKS Location/ Crawlspace Quantity 20 L.F. Photo1 Sewage/Waste/Vent Piping PB/A&W Page 5 of 15

6 DRAIN/WASTE/VENT AND STORM SYSTEM Sewage Ejector Pump Sump Pump DUAL TEMPERATURE SYSTEM (CHILLED AND HOT WATER) FIXTURES Staff And Other Janitor Sink Lavatory/Sink Toilet Urinal Student Location/ Quantity 1 DEFECTIVE AUXILIARY (FAUCET, SHUT OFF VALVE,ETC.) Toilet Room in Room 501A Photo1 Drinking Fountain Lavatory/Sink DEFECTIVE AUXILIARY (FAUCET, SHUT OFF VALVE,ETC.) Location/ Girl's Toilet Room 425, Boy's Toilet Room 525 Quantity 2 Photo1 Locker Room Shower on Inside Room 121 Quantity 1 Alternative use PB/A&W Page 6 of 15 Yes

7 FIXTURES Student Locker Room Shower Sink And Fountain Combo Unit Toilet DEFECTIVE FLUSHOMETER VALVE Location/ Toilet Room in 424 Quantity 1 Photo1 Urinal GAS FIRED FURNACE GAS SERVICE Gas Distribution Piping Gas Meter Room Exhaust Fan Gas Meter Room Vent Gas Pressure Booster Quantity 1 Manufacturer Equipment Gas Meter Room Eclipse Capacity/Size Quantity 18,000 Capacity/Size UOM Source of Capacity/Size N/A SCFH Installation Year 1994 Quantity 1 Manufacturer Gas Meter Room PB/A&W Page 7 of 15 Ametek

8 GAS SERVICE Gas Pressure Booster Equipment Capacity/Size Quantity 1,080 Capacity/Size UOM Source of Capacity/Size N/A SCFH Installation Year 2006 CO/Gas Leak Detection HEATING Quantity 1 Inspector Estimate Boiler Room, Gas Meter Room Installation Year 2007 Heating Coil In Ductwork Hydronic Heating Radiator/Convector/Fin Tube Inspector Estimate AUXILIARY (VALVE,VENT): DEFECTIVE Location/ Staircase A 2nd Floor Landing, Corridors adjacent to Rooms 318C, 319, 422 and Boy's Toilet Room 525 Quantity 6 Photo1 Steam Heating F&T/Steam Drip Trap MER Steam and Condensate Piping Steam Condensate Return Piping Location/ Quantity 10 DAMAGED/MISSING INSULATION Corridor adjacent to Room 322B L.F. Photo1 PB/A&W Page 8 of 15

9 HEATING Steam Heating Steam Condensate Return Piping Steam Condensate Return Pumping System Location/ Quantity 1 DEFECTIVE PUMP Boiler Room Photo1 Steam Piping Location/ Quantity 10 DAMAGED/MISSING INSULATION Corridor adjacent to Room 322B L.F. Photo1 Location/ Quantity 10 DEFECTIVE/LEAKS Gymnasium L.F. Photo1 Terminal Unit Thermostatic Trap Steam supplied by External Sources Unit Heater/Cabinet Heater HEATING PLANT Replacement Quantity 10,322 Replacement Uom on Basement Burner Type Heating Plant Oil Number Boiler Auxiliaries MBH Net Dual Fuel (Gas/Oil) 2 PB/A&W Page 9 of 15

10 HEATING PLANT Boiler Auxiliaries on Basement Boiler Auxiliary Piping on Basement Boiler Emergency Stop Switch on Basement MISSING HAMMER Location/ Outside Boiler Room Quantity 1 Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 Boiler Feedwater System on Basement FEEDWATER TANK: DAMAGED/MISSING INSULATION Location/ Boiler Room Quantity 200 S.F. Photo1 Boiler Feedwater Treatment(Automatic) on Basement Boiler Flue Exhaust on Basement Boiler Make-up Water Backflow Preventer on Basement Boiler Room Steam And Condensate Piping on Basement Boiler Safety Valve on Basement Boiler System PB/A&W Page 10 of 15

11 HEATING PLANT Boiler System on Basement Coal-fired Boiler on Basement Hot Water Boiler on Basement Modular Boiler on Basement Steam Boiler on Basement Boiler Room Quantity 5,161 MBH Net Manufacturer A. L. Eastmond & Sons Inc. Equipment Capacity/Size Quantity 5,161 Capacity/Size UOM MBH Net Source of Capacity/Size Installation Year 1994 Boiler Room Quantity 5,161 MBH Net Manufacturer A. L. Eastmond & Sons Inc. Equipment Capacity/Size Quantity 5,161 Capacity/Size UOM MBH Net Source of Capacity/Size Installation Year 1994 Fuel System on Basement Boiler Fresh Air Louver/Damper on Basement DEFECTIVE ACTUATOR Location/ Boiler Room Quantity 1 Photo1 PB/A&W Page 11 of 15

12 HEATING PLANT Fuel System Burner/Burner Control Panel on Basement Fuel Oil Storage/Supply System on Basement Gas Trains And Vent At The Boiler on Basement Enclosed IDF Room on Rooms L-3, 318D Dedicated A/C Equipment on Rooms L-3, 318D 4 - Between Fair and Poor DOES NOT EXIST Location/ Rooms L-3, 318D Quantity 2 INSTALL Photo1 KITCHEN CO Detector Gas System Grease Trap Hood on 1st Floor on 1st Floor on 1st Floor on 1st Floor on 1st Floor Hood Exhaust Ductwork on 1st Floor Hood Exhaust Fan on 1st Floor Hood Fire Suppression System on 1st Floor Hot Water Temperature Booster Kitchen Sink on 1st Floor on 1st Floor Not Required Not Required PB/A&W Page 12 of 15

13 KITCHEN Kitchen Sink MDF Room on Room 318C on Room 422B Dedicated A/C Equipment on Room 422B on Room 318C 4 - Between Fair and Poor DOES NOT EXIST Location/ Room 318C Quantity 1 INSTALL Photo1 SCIENCE DEMO ROOM on Rooms 510, 513 Alternative use Acid Waste Neutralizing Tank on Rooms 510, 513 CO Detector on Rooms 510, 513 Emergency Shower on Rooms 510, 513 Eye Wash on Rooms 510, 513 Hood Exhaust Ductwork on Rooms 510, 513 Hood Exhaust Fan on Rooms 510, 513 Fixed Laboratory Hood on Rooms 510, 513 Laboratory Sink on Rooms 510, 513 Make-up Air Unit on Rooms 510, 513 SCIENCE LAB on Room 401 Alternative use Acid Waste Neutralizing Tank Yes Not Required Not Required No PB/A&W Page 13 of 15

14 SCIENCE LAB Acid Waste Neutralizing Tank on Room 401 CO Detector on Room 401 Emergency Shower on Room 401 Eye Wash on Room 401 Hood Exhaust Ductwork on Room 401 Hood Exhaust Fan on Room 401 Fixed Laboratory Hood on Room 401 Laboratory Sink on Room 401 Make-up Air Unit on Room 401 SCIENCE PREP ROOM SPRINKLERS, STANDPIPE, FIRE SYSTEM Dry Sprinkler Alarm Valve Assembly Wet Sprinkler Alarm Valve Assembly Fire Booster Pump Assembly Roof Tank Siamese Connection Sprinkler Head DEFECTIVE/DETERIORATED Location/ Room 104 Quantity 3 Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 Sprinkler Piping Standpipe System PB/A&W Page 14 of 15

15 SPRINKLERS, STANDPIPE, FIRE SYSTEM Water Gong SWIMMING POOL VENTILATION Exhaust Fan Approximate Total # of Fans 1-25 Heating And Ventilating Unit Metal Ductwork Supply Fan Approximate Total # of Fans 1-5 DEFECTIVE MOTOR Location/ Room 312 Quantity 1 Photo1 NOT IN USE Location/ MER 110 Quantity 1 NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 Unit Ventilator PB/A&W Page 15 of 15