GRILLE, REGISTER AND DIFFUSER SCHEDULE

Size: px

Start display at page:

Download "GRILLE, REGISTER AND DIFFUSER SCHEDULE"

Maryann Joseph
5 years ago
Views:

2 ROOFTOP UNIT SCHEDULE (NATURAL GAS HEAT) MARK MANUFACTURER MODEL SUPPLY FAN COOLING COIL HEAT EXCHANGER MIN. MIN. MCA MOCP V/PH WEIGHT NOTES FAN CFM MIN ESP REFR. TH SH EAT LAT MIN. OUTPUT MIN. EFF. NOM. INPUT MIN. NO. LAT O/A SEER LBS TYPE HP (IN) TYPE (MBH) (MBH) DB WB DB WB (MBH) (%) (MBH) STAGES DB (F) CFM RTU-1 CARRIER 48KCDA05 FC 1, R-410A /3 700 A-K RTU-2 CARRIER 48KCDA05 FC 1, R-410A /3 700 A-K NOTES: A. PROVIDE 100% DRY-BULB ECONOMIZER WITH BAROMETRIC RELIEF. B. PROVIDE LOW AMBIENT CONTROL TO 25 F. C. EQUIPMENT SIZED FOR 105 F AMBIENT TEMPERATURE. D. PROVIDE 2", 30% EFFICIENT PLEATED THROWAWAY AIR FILTERS. E. PROVIDE MANUFACTURER'S STANDARD INSULATED ROOF CURB WITH MINIMUM HEIGHT OF 14". F. PROVIDE WITH 7-DAY PROGRAMMABLE THERMOSTAT WITH STAGED HEATING AND COOLING CAPABILITY AS REQUIRED FOR OPERATION OF STAGED HEATING, ECONOMIZER AND COOLING CONTROLS. G. DIVISION 16 CONTRACTOR SHALL PROVIDE SMOKE DETECTORS IN RETURN AIR DUCTS. H. DISCONNECT SWITCH FURNISHED BY DIVISION 16 CONTRACTOR. J, PROVIDE HEATER TO MEET OR EXCEED SCHEDULED MINIMUM MBH OUTPUT. NOMINAL INPUT IS BASED ON LISTED MANUFACTURER'S STANDARD PRODUCT. MEET MINIMUM EFFICIENCY SCHEDULED. COORDINATE EQUIPMENT GAS LOAD WITH PLUMBING CONTRACTOR IF DIFFERENT FROM THAT SCHEDULED. K. PROVIDE WITH FIELD INSTALLED ACCESSORY CONDESATE OVERFLOW SWITCH, FOR COMPRESSOR TURN OFF IF THE DRAIN TRAP BECOMES PLUGGED. GRILLE, REGISTER AND DIFFUSER SCHEDULE MARK MANUFACTURER MODEL FACE MOUNTING FACE SIZE MAX. MAX. PRESS. NOTES TYPE LOCATION (IN) NC DROP (IN. W.C.) CD-1 PRICE AMD LOUVERED LAY-IN 24x A-E CD-2 PRICE AMD LOUVERED GYP. 12x A-F CD-3 PRICE RCDE ROUND DUCT A-D RG-1 PRICE 80 EGG CRATE LAY-IN 24x A,D,E RG-2 PRICE 80 EGG CRATE GYP. 12x A,D,E RG-3 PRICE 530 LOUVERED DUCT NECK + 1-3/ A,C,D NOTES: A. NECK SIZE SHOWN ON DRAWINGS. PROVIDE NECK FOR DUCT CONNECTION. B. 4-WAY THROW PATTERN UNLESS OTHERWISE SHOWN ON DRAWINGS. C. BRANCH DUCT SIZE SHALL BE SAME AS NECK SIZE UNLESS OTHERWISE SHOWN ON DRAWINGS. D. BAKED ENAMEL FINISH, WHITE TO MATCH CEILING COLOR. E. FRAME TYPE TO MATCH CEILING CONSTRUCTION, COORDINATE WITH ARCHITECTURAL RCP. F. PROVIDE WITH OPPOSED BLADE DAMPER ADJUSTABLE FROM DIFFUSER FACE. FAN SCHEDULE MARK SERVICE MANUFACTURER MOUNTING MODEL CFM ESP DRIVE MIN. FAN ELECTRICAL NOTES (EA, RA, SA) (IN) (BELT/DIRECT) HP RPM V/PH FLA EF-1 EXHAUST GREENHECK CEILING SP-B DIRECT 80W /1 - A-C EF-2 EXHAUST GREENHECK CEILING SP-B DIRECT 80W /1 - A-C EF-3 EXHAUST GREENHECK STRUCTURE SP-B DIRECT 172W /1 - A,B,D NOTES: A. MANUFACTURER TO PROVIDE 8" HIGH ROOF CURB AND MODEL GRS-08 SPUN ALUMINUM ROOF CAP WITH INTEGRAL BIRDSCREEN AND BACKDRAFT DAMPER. B. PROVIDE RUBBER IN SHEAR ISOLATION AND ALL-THREAD HANGING RODS. C INTERLOCK FAN OPERATION WITH RESTROOM LIGHT SWITCH. D. INTERLOCK FAN OPERATION WITH THERMOSTAT TO ENERGERIZE FAN WHEN THE SPACE TEMPERATURE REACHES 90 F. OUTSIDE AIR REQUIREMENTS AREA GROSS CODE OUTSIDE AIR SYSTEM ACTUAL PURPOSE FLOOR REQUIREMENTS NUMBER OUTSIDE AIR AREA (CFM PER UNIT) (SQ. FT) CFM PER CFM CFM PER NO. OF CFM RTU SQ. FT REQD. PERSON PEOPLE REQD. RTU DINING SERVICE PREP TOTAL = TOTAL = 360

5 WATER & WASTE FIXTURE CALC D.F.U. TOTAL HOT COLD COMBINED TOTAL TOTAL TOTAL FIXTURE TYPE QTY (EA) D.F.U. S.F.U. S.F.U. S.F.U. S.F.U. S.F.U. SERVICE (EA) (EA) (EA) (HOT) (COLD) S.F.U. PUBLIC LAVATORY SERVICE SINK (MOP BASIN) FLOOR DRAIN PUBLIC WATER CLOSET (1.6 GPF FLUSH TANK) SPECIALTY KITCHEN EQUIP. SINK (HAND OR DUMP) PREP SINK SINK (3 COMPARTMENT) ICE MACHINE WATER SPIGOT TOTAL UNITS: LOW PRESSURE GAS PIPE SIZING CHART PIPE LOAD (CFH) SIZE 1/2" 45 3/4" 95 1" /4" /2" 549 2" 1, /2" 1,685 OPERATING PRESSURE OF 7"WC WITH A PRESSURE DROP OF 0.5"WC TOTAL DEVELOPED LENGTH = 120 FEET TOTAL CONNECTED LOAD = 209 CFH BASED ON NFPA 54 EQUATION 4-1 GREASE INTERCEPTOR SIZING FIXTURE TYPE GW GW QTY D.F.U. D.F.U. (EA) TOTAL SERVICE SINK (MOP BASIN) SINK (HAND) (1-1/2" IW) SINK (PREP / VEGGIE) (2" IW) SINK (3 COMPARTMENT) (2" IW) ESTIMATED TOTAL GREASE WASTE DRAINAGE FIXTURE UNITS: 11.0 PER TABLE 10-3 OF THE 2006 UPC, 11 DFU CAN BE PLUMBED TO A 1000 GALLON GREASE INTERCEPTOR Number of DFU's 11.0 TABLE 10-3 GRAVITY GREASE INTERCEPTOR SIZING DFU's (1) INTERCEPTOR VOLUME (2) gallons 21 (3) 750 gallons 35 1,000 gallons 90 (3) 1,250 gallons 172 1,500 gallons WATER HEATER SCHEDULE WATER PIPE SIZING CHART FIXTURE UNITS VS. PRESSURE LOSS IN PSI / 100 FEET FOR TYPE "L" COPPER TUBE COLD 6 PSI / 100' HOT 6.0 PSI / 100' PIPE FLUSH TANK FLUSH VALVE VELOCITY FLOW FLUSH TANK VELOCITY FLOW SIZE SFU SFU FEET / SEC GPM SFU FEET / SEC GPM 1/2" 2.4 N/A * * * 3/4" 7.9 N/A * * * 1" 19.8 N/A /4" /2" " /2" " " " SIZED WITH HAZEN WILLIAMS CONSTANT "C = 135" * UTILIZE COLD WATER SIZING CHART MANUFACTURER/ AREA TANK SIZE RECOVERY MARK MODEL# SERVED ENERGY SOURCE (GALLONS) INPUT 100 DEGREE RISE NOTES WH-1 RHEEM GPDV50-65 KITCHEN/ LAVS NATURAL GAS MBH 59 A, B NOTES: A. 100 F TEMPERATURE RISE WITH 140 F OPERATING TEMPERATURE. B. FURNISH WITH RHEEM FACTORY COMBUSTION AIR INTAKE AND EXHAUST KIT PLUMBING PIPE MATERIAL SCHEDULE PIPING SYSTEM ABBREVIATION PIPING MATERIAL SANITARY DRAINAGE & VENT (ABOVE GRADE) S, W OR V HUBLESS CAST IRON (PVC DWV OPTIONAL) SANITARY DRAINAGE & VENT (BELOW GRADE) S, W OR V SERVICE WEIGHT CAST IRON (PVC DWV OPTIONAL) POTABLE WATER (ABOVE GRADE) CW, HW OR HWR TYPE L HARD DRAWN COPPER WITH SOLDERED JOIUNTS POTABLE WATER - 2" & SMALLER (BELOW GRADE) CW, HW OR HWR TYPE K SOFT ANNEALED COPPER NATURAL GAS (ABOVE GRADE & ON ROOF) G SCHEDULE 40 BLACK STEEL NATURAL GAS (BELOW GRADE) G APPROVED 'PE' PIPE FOR GAS CONDENSATE DRAIN - 1" & SMALLER CD TYPE M HARD DRAWN COPPER (PVC DWV OPTIONAL) CONDENSATE DRAIN - 1-1/4" & LARGER CD TYPE DWV HARD DRAWN COPPER (PVC DWV OPTIONAL) INDIRECT DRAIN - 1"& SMALLER ID TYPE M HARD DRAWN COPPER INDIRECT DRAIN - 1-1/4" & LARGER ID TYPE DWV HARD DRAWN COPPER REFER TO SPECIFICATIONS FOR FITTINGS, INSTALLATION REQUIREMENTS AND FURTHER INFORMATION

12 PANELBOARD: B (NEW) BUS AMPS: 125A AIC RATING: FULLY RATED MAIN SIZE/TYPE: MLO SERVES: VOLTS/PHASE: 208Y/120V, 3PH, 4W MOUNTING: SURFACE SECTION: 1 LOCATION: KITCHEN EQUIPMENT GROUND BUS CKT DESCRIPTION VOLTAMPS/PHASE WIRE BKR P P BKR WIRE VOLTAMPS/PHASE DESCRIPTION CKT NO. A B C NO. AMP AMP NO. A B C NO. 1 WALK-IN COOLER/FREEZER (1A) 1,200 ` ` (2)#12, (1)#12G (2)#12, (1)#12G 1,440 ` ` REFRIG PREP TABLE (28) 2 3 WALK-IN COOLER/FREEZER (1B) ` 1,728 ` (2)#12, (1)#12G (2)#12, (1)#12G ` 360 ` RECEPTACLE ROOF RTU 4 5 WALK-IN COOLER/FREEZER (1C) ` ` 780 (2)#12, (1)#12G (2)#12, (1)#12G ` ` 540 UNDERCOUNTER REFR (63) ` ` 1 20 (2)#12, (1)#12G 360 ` ` RECEPTACLE ROOF RTU 8 9 DRIVE-THRU MENU ` 1,200 ` (2)#12, (1)#12G (2)#12, (1)#12G ` 1,650 ` STEAMER PUMP (57) POS PRINTER & TERMINAL (52,54) ` ` 600 (2)#12, (1)#12G 20 1 ` ` 1, ` ` (2)#12, (1)#12G 1,650 ` ` STEAMER PUMP (57) ` ` 1 ` 1,650 ` ` ` 1 1 ` ` ` ` 1 1 ` ` ` ` 1 1 ` ` ` ` 1 1 ` ` 24 SUBTOTAL 1,980 2,928 1,380 3,450 3,660 2,190 SUBTOTAL TOTAL PHASE A - VA 5,430 LOAD CONN. VA DF LOAD CONN. VA DF AMPS 45 COOLING 1.00 REFRIGERATION 6, TOTAL PHASE B - VA 6,588 HEATING 0 SIGN/DISPLAY 1.25 AMPS 55 LIGHTING 1.25 KITCHEN 6, TOTAL PHASE C - VA 3,570 RECEPTACLES /.5 EXISTING 1.00 AMPS 30 MOTORS 1.00 LARGE MOTOR 1.25 TOTAL DEMAND TOTAL PNLBD - VA 15,588 SUPP HEAT 1.00 SHOW WINDOW ,588 VA AMPS 43 MISC EQUIP 1, LTG TRACK A PANELBOARD NOTES PROVIDE TYPE WRITTEN DIRECTORY GF: GFCI RATED CIRCUIT IG: ISOLATED GROUND LTG TRACK - TRACK LENGTH SIGN/DISPLAY - SIGNAGE & DISPLAY CASE PANELBOARD: A (RELOCATED) EQUIPMENT GROUND BUS BUS AMPS: 400A AIC RATING: FULLY RATED ISOLATED GROUND BUS MAIN SIZE/TYPE: 300A MCB SERVES: VOLTS/PHASE: 208Y/120V, 3PH, 4W MOUNTING: SURFACE SECTION: 1 LOCATION: KITCHEN CKT DESCRIPTION VOLTAMPS/PHASE WIRE BKR P P BKR WIRE VOLTAMPS/PHASE DESCRIPTION CKT NO. A B C NO. AMP AMP NO. A B C NO. 1 LIGHTING (DINING) 959 ` ` (2)#12, (1)#12G 20 1 (4)#3, (1)#8G 5,430 ` ` PNLBD B 2 3 LIGHTING (KITCHEN) ` 1,220 ` (2)#12, (1)#12G /4"C ` 6,588 ` 4 5 EXTERIOR SIGN ` ` 1,200 (2)#12, (1)#12G 20 1 ` ` 3, RECEPTACLE (SHOW WINDOW) 400 ` ` (2)#12, (1)#12G (2)#12, (1)#12G 800 ` ` RECEPTACLE DINING 8 9 RECEPTACLE DINING ` 800 ` (2)#12, (1)#12G (2)#12, (1)#12G ` 800 ` RECEPTACLE DINING MICROWAVE (25) ` ` 1,500 (2)#12, (1)#12G (2)#12, (1)#12G ` ` 200 KDS MONITOR (55) BLENDER BAR TYPE (37) 1,500 ` ` (2)#12, (1)#12G (2)#12, (1)#12G 200 ` ` POS SYSTEM (53) BLENDER BAR TYPE (37) ` 1,500 ` (2)#12, (1)#12G (2)#12, (1)#12G ` 400 ` GENERAL RECEPTACLE BLENDER BAR TYPE (37) ` ` 1,500 (2)#12, (1)#12G (2)#12, (1)#12G ` ` 200 KDS MONITOR (55) BLENDER BAR TYPE (37) 1,500 ` ` (2)#12, (1)#12G (2)#12, (1)#12G 800 ` ` POS PRINTER & TERMINAL (52,54) BLENDER BAR TYPE (37) ` 1,500 ` (2)#12, (1)#12G (2)#12, (1)#12G ` 200 ` EXHAUST FAN EF BLENDER BAR TYPE (37) ` ` 1,500 (2)#12, (1)#12G (2)#12, (1)#12G ` ` 400 GENERAL RECEPTACLE SURVEILLANCE SYSTEM (10) 960 ` ` (2)#12, (1)#12G (2)#12, (1)#12G 372 ` ` JOLT PRINTER (12) ICE MAKER W/ BIN (21) ` 1,269 ` (2)#12, (1)#12G (2)#8, (1)#10G ` 2,850 ` MICROWAVE CONVECTION ` ` 1,269 ` ` 2,850 OVEN (27) GAS WATER HEATER 600 ` ` (2)#12, (1)#12G (2)#8, (1)#10G 2,850 ` ` MICROWAVE CONVECTION REFRIG PREP TABLE (30) ` 864 ` (2)#12, (1)#12G 20 1 ` 2,850 ` OVEN (27) REFRIG PREP TABLE (29) ` ` 1,440 (2)#12, (1)#12G (2)#12, (1)#12G ` ` 400 GENERAL RECEPTACLE ROOF TOP UNIT, RTU-1 2,880 ` ` (3)#10, (1)#10G (3)#10, (1)#10G 2,880 ` ` ROOF TOP UNIT, RTU MCA, 208V, 3PH ` 2,880 ` 3/4"C /4"C ` 2,880 ` 24 MCA, 208V, 3PH ` ` 2,880 ` ` 2, SUBTOTAL 8,799 10,033 11,289 13,332 16,568 10,500 SUBTOTAL TOTAL PHASE A - VA 22,131 LOAD CONN. VA DF LOAD CONN. VA DF AMPS 184 COOLING 17, REFRIGERATION 11, TOTAL PHASE B - VA 26,601 HEATING 0 SIGN/DISPLAY 1, AMPS 222 LIGHTING 2, KITCHEN 28, TOTAL PHASE C - VA 21,789 RECEPTACLES 4, /.5 EXISTING 1.00 AMPS 182 MOTORS -2, LARGE MOTOR 2, TOTAL DEMAND TOTAL PNLBD - VA 70,521 SUPP HEAT 1.00 SHOW WINDOW ,112 VA AMPS 196 MISC EQUIP 5, LTG TRACK A PANELBOARD NOTES PROVIDE TYPE WRITTEN DIRECTORY GF - GFCI TYPE CIRCUIT BREAKER IG - ISOLATED GROUND CIRCUIT LTG TRACK - TRACK LENGTH SIGN/DISPLAY - SIGNAGE & DISPLAY CASE TENANT ELECTRICAL SERVICE LOAD SUMMARY TENANT OCCUPANCY TYPE: A SERVICE DESCRIPTION: TENANT SQUARE FOOTAGE: 1, Y/120V, 3PH LOAD DESCRIPTION Connected Demand Demand KVA FACTOR KVA HVAC - SUMMER % HVAC - WINTER % 0.00 LIGHTING (PER NEC-220) % 3.38 RECEPTACLES %;50% 4.32 KITCHEN EQUIPMENT % MOTOR LOADS % LARGEST MOTOR LOAD % 3.11 MISCELLANEOUS EQUIPMENT % 5.33 REFRIGERATION EQUIPMENT % DISPLAY CASE/SIGNAGE % 1.50 SHOW WINDOW / TRACK LIGHTING 0.40 PER NEC 0.50 TOTAL LOAD KVA TOTAL AMPACITY AMPS SERVICE AMPACITY 400 AMPS SPARE CAPACITY AMPS 226

SHOE PALACE HUNTINGTON PARK M.200

SHOE PALACE HUNTINGTON PARK M.200 M.200 SPLIT SYSTEM CONDENSING UNIT SCHEDULE MARK SERVICE MODEL NO. COOLING DIMENSIONS ELECTRICAL REMARKS CAPACITY AMBIENT DB REFRIGERANT LENGTH WIDTH HEIGHT WEIGHT VOLT/PHASE MCA MOP (MBH) (DEG F) (IN)