Daikin McQuay. Pathfinder Air Cooled Chiller Screw Compressor Two Circuit. AWS Vintage A

Transcription

1 Replacement Parts List No Revision P 05/2017 Daikin McQuay Pathfinder Air Cooled Chiller Screw Compressor Two Circuit AWS Vintage A For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors, Check Valves, Economizers, Evaporators and Suction Piping Components. To find your Daikin Applied parts distributor, call or visit

2 Contents Parts List Revision History... 3 Nomenclature Serial Number... 4 Unit Model Number- Dataplate... 4 Unit Model Number- Complete Electrical Legend - Units with Wye Delta or SS Starter Electrical Legend - Units with VFD Starter Unit Layout Refrigeration Section Compressor Charts Compressors Compressor Components Suction Lines, Discharge Lines, Liquid Injection Lines Suction Shut Off Valves Liquid Lines- Standard Efficiency Units Liquid Lines with Economizer- High & Premium Efficiency Units Condenser Coils and Fans Total Fans per Unit Evaporator Diagram Evaporator Components Coil and Base Frame Grilles Coil Louvers Base Frame Louvers Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Box Locations and Label Detail Control Panel Detail Power Panel Detail Solid State Starter Panel Wye-Delta Starter Panel Power Factor Correction Capacitors (PFCC) Units with VFD Starters (Code 9 = VE or VF) Box Locations and Label Detail Control Side Power Side Control Box Exhaust and Intake Fans Terminal Box Accessories Units with Wye-Delta or Solid State Starter (Code 9 = WD or SS) Isolator Kits - Rubber-In-Shear Isolator Kits - Spring Units with VFD Starter (Code 9 = VF or VE) Isolator Kits - Rubber-In-Shear Isolator Kits - Spring Flow Switch Sound Enclosure Kit Alarm Bell Inlet Strainer Field-Installed Fan VFD Kits High Ambient Exhaust Fan Kit Rapid Restore Base and Coil - Grille and Louver Kits Base Grille Kits Coil Louver Kits Base & Coil Louver Kits BACnet MS/TP Communications Module BACnet with IP/Ethernet MODBUS Communications Module LonMark Communications Module Remote Display Kit Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 2

3 Parts List Revision History Revision Date Description Athru E Revision History archived for revisions A through E. F 04/12 Page 21: Changed ST1 & 2 Sensor-Suct Temp. to two choices, Straight and Bent. Added length description "20 ft." to WD1 & 2 Sensor- Discharge Temp. Pages 23 & 25: Changed part # for Ref. 113 Filter Drier Core, was Page 27: Added length description "20 ft." to WAA Sensor- Outdoor Air. Changed Motor part #s, were , 02, 03, 04. Added info for Condenser Coil location and identification. Page 30: Added length description "60 ft." to WIE & WOE Sensor- Evap. G 07/12 Page 6: Corrected Code 29 nomenclature to SL= SD + LL Solenoid, was DS + LL Solenoid. Pages 18 & 19: Changed part # for Ref. 14 Slide Indicator from to Page 21: Added Gasket- Discharge Shut-Off Valve to Dischg Line groups. Added Gasket- Discharge Shut-Off Valve to footnotes 1 and 2. Page 26: Corrected titles to say Economizer, Circuit 1 and 2 (was Compressor). Corrected Ckt. 2 codes: Size 230 Prem Eff to C (was A), Size 280 Prem Eff to B (was C), Size 320 Prem Eff to E (was B). Page 27: Corrected Ref. 5 Fan Motor, 460V to , was -74; Fan Motor 575V to , was -04. Pages 34-36: Corrected title to Code 28= B, was Code 28= B, C, L. Page 38: Added Advanced Web Module and footnote 2. Page 43: Corrected description of where used for to AWS , Std Eff, Ckt 2 (was ). Page 50: Added Advanced Web Module and footnote 2. Changed description for EEXV1,2 to Code 29 = LD or SL and Code 29 = ND or SD, was With or Without UPS. Page 53: Corrected description for CT4,5,6 to Current Transformer, was Current Sensor. Page 60: Removed "Prem" from description for F2, Sizes 380, 405. Page 62: Expanded Terminal Plate information to include Type A and Type B. Page 68: Corrected Rapid Restore (without VFD starter) to , was Page 70: Removed LonMark Comm. Module Only from Ref H 09/12 Pages 18 & 19: Corrected descriptions for Liq Injection Fittings. Added Liq Inj Fitting- Rotolock to Copper and Liq Inj O-Ring. J 03/13 Pages 18 & 19 Added Bubble 55 to drawings. Page 21: Corrected descriptions for Ref. 104 & 204; "Bent" and "Straight" were reversed. Page 51: Re-arranged page for better grouping of components. No changes to part #s. K 06/13 Pages 19, 19, 20, 33, 70: Replaced diagrams that were difficult to read. Page 27: Replaced diagrams for clearer information. Page 30: Corrected part no. for Ref. 5 Sensor Well to E , was L 06/14 Pages 5, 10, 18, 19: Added "Linear Transducer" to description for "Slide Indicator". Page 42: Corrected chart alignment. M 05/2016 Pages 18 & 19: Added Oil Filter Gasket Kit. N 10/2016 Page 18: Added Ref. 14A Cables for Linear Transducer. Page 45: Corrected heading, was Compressor Circuit Breakers. P 05/2017 Pages 7 and 11: Added "MMP" to description. Page 53: Updated description for F0-1,2; was Crankcase Heater MSP. Daikin Applied, Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN (763) Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 3

4 Nomenclature Serial Number STN U Plant Identification STN = Staunton, VA U= Unit Year of Manufacture 09= = = 2011 etc. Serial Number (build sequence) Month of Manufacture 01= January 07= July 02= February 08= August 03= March 09= September 04= April 10= October 05= May 11= November 06= June 12= December Unit Model Number- Dataplate AWS 300 A D S 27 Number of Compressors (circuits) D= 2 Vintage Nominal Tonnage ex. 300= 300 Tons Voltage 27= 460/60/3 12= 208/60/3 29= 230/60/3 46= 380/60/3 37= 575/60/3 Platform S= Standard Efficiency H= High Efficiency P= Premium Efficiency Unit Type: AWS= Air- Cooled Screw Compressor Chiller Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 4

5 Nomenclature Unit Model Number- Complete AWS 300A D SE NN ST S A WD Y 27 WN V N N N LM N G Y N N VL S R Code L F G ND YNNNNNNN N N NNYNNNNNNNN Code ENDSUDPLYNNNNNNNNNNNRA1D00 NN M 6 NN Y S 00 Code Size (in nominal tons) 150A= 150 Tons 'A' Vintage 280A= 280 Tons 'A' Vintage 175A= 175 Tons 'A' Vintage 300A= 300 Tons 'A' Vintage 190A= 190 Tons 'A' Vintage 320A= 320 Tons 'A' Vintage 210A= 210 Tons 'A' Vintage 350A= 350 Tons 'A' Vintage 230A= 230 Tons 'A' Vintage 380A= 380 Tons 'A' Vintage 250A= 250 Tons 'A' Vintage 405A= 405 Tons 'A' Vintage 03 Number of Compressors D= 2 04 Platform SE= Standard Package- Standard Efficiency HE= Standard Package- High Efficiency PE= Standard Package- Premium Efficiency 05 Construction NN= Standard 06 Sound ST= Standard Sound LN= Low Noise- Sound Enclosure 07 Unit Operation S= Standard (40-60 F LWT) A= Lower Operation (34-39 F LWT) B= Brine Operation (20-33 F LWT) 08 Condenser Coil Fins A= Aluminum Fin (Standard) C= Copper Fin B= Aluminum Fin w/prefab Black Fin Coating E= Aluminum Fin w/electro Fin Coating F= Copper Fin w/electro Fin Coating 14 Meters N= None A= Meters: Unit Amp & Volt 15 Control Box Ambient N= None H= With Exhaust Fans 16 Compressor Capacitor N= None C= Power Correction Capacitors 17 Communication NN= None LM= LonMark MB= Mod Bus BN= BACnet w/ MSTP BE= BACnet w/ Ethernet 18 Display Options N= On Controller Only U= Unit Remote Display 19 Ground Fault N= None G= Ground Fault Protection for the Unit 20 Always Y 21 Unit Options N= None C= 115V Convenience Outlet L= Slide Indicator/ Linear Transducer B= C + L 09 Compressor Starter WD= Wye- Delta w/compressor Overloads SS= Solid State VF= VFD without EMI Filter VE= VFD with EMI Filter 10 Always Y 11 Voltage 27= 460/60/3 12= 208/60/3 29= 230/60/3 46= 380/60/3 37= 575/60/3 12 Power Connection PC= Single Point Power Block & Circuit Breakers DC= Single Point Disconnect & Circuit Breakers DH= High Short Circuit Current Rating + DC WN= Multiple Point Disconnect- No Circuit Breaker WH= High Short Circuit Current Rating + WN 13 Phase Voltage V= Phase & Under/Over Voltage Protection w/led N= None 22 Water Flow N= None A= Water Flow Indication on Evaporator Only 23 Evaporator Connection VL= Victaulic/ Left Hand VR= Victaulic/ Right Hand 24 Evaporator Insulation S= Standard Evaporator- Single Layer D= Standard Evaporator- Double Insulation 25 Relief Valve R= Single Valve 26 Fans L= Standard Low Noise Fan Motors 27 Head Pressure F= Fantrol Only (35 F Minimum) V= VFD (First Fans/ Circuit) Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 5

6 28 Guards G= Condenser Coil Grilles Only F= Condenser Coil & Base Frame Grilles L= Condenser Coil Louvers B= Condenser Coil Louvers & Base Guard Louvers C= Condenser Coil Louvers and Base Frame Grilles 29 Tubing Options ND= With Discharge Shut-Off Valve SD= With Suction and Discharge Shut-Off Valve LD= ND + Liquid Line Solenoid SL= SD + Liquid Line Solenoid Nomenclature Unit Model Number- Complete, Continued 46 Approvals E= ETL/CETL Approval & ARI T= ETL/CETL Approval & No ARI 47 CRN- Evaporator 1= CRN- BC 2= CRN- Alberta 3= CRN- Saskatchewan 4= CRN- Manitoba 5= CRN- Ontario 6= CRN- Quebec 7= CRN- New Brunswick 8= CRN- Nova Scotia 9= CRN- P.E.I. U= CRN- Yukon 0= CRN- NewFoundland N= None 30 Always Y 31 Water Pump NN= None 32 Pump Type NNNN= No Pump Package PPSS= Pump Package Air- Cooled Screw Single Pump PPSD= Pump Package Air- Cooled Screw Dual Pump 33 Pump Connection N= No Pump Package 6= 6" 8= 8" T= 10" 34 Pump Flow Actual 4 digit number based on conditions 35 Total Head Actual 3 digit number based on conditions 36 Pump Starter N= No Pump Package S= Pump Package Starter 37 Pump Gauges N= None G= Pressure Gauges 38 Pump Suction Valve N= None 39 Pump Discharge Valve N= None 40 Always Y 41 Impeller Trim NNNN= No Pumps 0000= Impeller Size 42 Expansion Tank NN= None 43 Buffer Tank NN= None 44 % of Glycol 000= None E**= Ethylene; **= % P**= Propylene; **= % 45 Pump Number All 0's= None 16 digit number= With Pumps 48 Unit Start DSU= Domestic Start Up CPL= Canadian Start Up ISU= International- No Start Up Provided 49 Standard Warranty DPL= Domestic 1st Year Standard CPL= Canadian 1st Year Standard Warranty TPN= International 1st Year Standard Warranty 50 Always Y 51 Extended Compressor Warranty NNNN= No Extended Compressor Warranty CPE*= Compressor Only- Parts Only (*= no. of years) CBE*= Compressor Only- Parts & Labor (*= no. of years) 52 Always NNN 53 Extended Unit Warranty NNNN= None EPE*= Ext. Unit- Parts Only (*= no. of years) EBE*= Ext. Unit- Parts & Labor (*= no. of years) DPE*= Ext. Unit w/dual Pumps- Parts Only (*= no. of years) DBE*= Ext. Unit w/dual Pumps- Parts & Labor (*= no. of years) SPE*= Ext. Unit w/single Pump- Parts Only (*= no. of years) SBE*= Ext. Unit w/single Pump- Parts & Labor (*= no. of years) 54 Refrigerant Warranty NNN= None RA*= Refrigerant 134a Warranty (*= no. of years) 55 Delayed Warranty Start D00= 0 months D**= Delayed Warranty Start (**= number of months) 56 Always NN 57 Brand Name D= DaikinMcQuay M= McQuay 58 Hertz 6= 60 Hertz 59 & 60 Always YY 61 Misc. S= Standard Unit X= Special 62 Major Unit Change Revision 00= No Revision Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 6

7 Electrical Legend - Units with Wye Delta or SS Starter Sch. Sym. Description Location AC Alarm Control Control Panel AM1 Ammeter Switch Box Door C1 PFCC Capacitor PFCC Enclosure C2 PFCC Capacitor PFCC Enclosure C10 EXV-1 Connector Starter Panel- Compressor 1 C20 EXV-2 Connector Starter Panel- Compressor 2 C101 Fan Harness Connector Condenser Fan Section C102 Fan Harness Connector Condenser Fan Section C103 Fan Harness Connector Condenser Fan Section C104 Fan Harness Connector Condenser Fan Section C105 Fan Harness Connector Condenser Fan Section C106 Fan Harness Connector Condenser Fan Section C107 Fan Harness Connector Condenser Fan Section C108 Fan Harness Connector Condenser Fan Section C109 Fan Harness Connector Condenser Fan Section C110 Fan Harness Connector Condenser Fan Section C111 Fan Harness Connector Condenser Fan Section C112 Fan Harness Connector Condenser Fan Section C201 Fan Harness Connector Condenser Fan Section C202 Fan Harness Connector Condenser Fan Section C203 Fan Harness Connector Condenser Fan Section C204 Fan Harness Connector Condenser Fan Section C205 Fan Harness Connector Condenser Fan Section C206 Fan Harness Connector Condenser Fan Section C207 Fan Harness Connector Condenser Fan Section C208 Fan Harness Connector Condenser Fan Section C209 Fan Harness Connector Condenser Fan Section C210 Fan Harness Connector Condenser Fan Section C211 Fan Harness Connector Condenser Fan Section C212 Fan Harness Connector Condenser Fan Section CC1 Control Compressor Cir. 1 Starter Panel- Compressor 1 CC2 Control Compressor Cir. 2 Starter Panel- Compressor 2 DP-1 Condenser Pressure Cir. 1 Discharge Line- Circuit 1 DP-2 Condenser Pressure Cir. 2 Discharge Line- Circuit 2 EEXV1 Expansion Valve Controller Cir. 1 Starter Panel- Compressor 1 EEXV2 Expansion Valve Controller Cir. 2 Starter Panel- Compressor 2 ESV-1 Economizer Solenoid Valve Cir. 1 Liquid Line- Circuit 1 ESV-2 Economizer Solenoid Valve Cir. 2 Liquid Line- Circuit 2 EXV-1 Electronic Expansion Valve Cir. 1 Liquid Line- Circuit 1 EXV-2 Electronic Expansion Valve Cir. 2 Liquid Line- Circuit 2 F0-1 Crankcase Heater 1 Fuses/ MSP/MMP Starter Panel- Compressor 1 F0-2 Crankcase Heater 2 Fuses/ MSP/MMP Starter Panel- Compressor 2 F1 Compressor 1 Circuit Breaker Power Panel- Right F2 Compressor 2 Circuit Breaker Power Panel- Right F5-1 Thermal Relay Starter Panel- Compressor 1 F5-2 Thermal Relay Starter Panel- Compressor 2 F12 Outlet Fuse Power Panel- Left F13 High Pressure Switch Cir. 1 Compressor 1 F23 High Pressure Switch Cir. 2 Compressor 2 F59 Evaporator Heater Fuse Control Panel F90 Thermostat Control Panel F100 Fan Circuit Breaker Cir. 1 Power Panel- Left F112 Phase Volt Monitor Cir. 1 Power Panel- Left Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 7

8 Electrical Legend - Units with Wye Delta or SS Starter Sch. Sym. Description Location F116 Evaporator Flow Switch Evaporator Outlet F120 Transformer T1 Protection Power Panel- Left F130 Phase Volt Monitor Fuse Cir. 1 Power Panel- Left F200 Fan Circuit Breaker 2 Power Panel- Left F212 Phase Voltage Monitor Cir. 2 Power Panel- Left F230 Phase Volt Monitor Fuse Cir. 2 Power Panel- Left FC Fans Control Control Panel FTB107 Fan Terminal Block Cir. 1 Power Panel- Left FTB110 Fan Terminal Block Cir. 1 Power Panel- Left FTB207 Fan Terminal Block Cir. 2 Power Panel- Left FTB210 Fan Terminal Block Cir. 2 Power Panel- Left FU1 PFCC Fuse PFCC Enclosure FU2 PFCC Fuse PFCC Enclosure GFR1 Ground Fault Relay Cir. 1 Power Panel- Left GFR2 Ground Fault Relay Cir. 2 Power Panel- Left K11 Emergency Stop Contactor Control Panel K16 Fan Stage 1 Power Panel- Left K26 Fan Stage 2 Power Panel- Left K2B-1 Contactor Starter Panel- Compressor 1 K2B-2 Contactor Starter Panel- Compressor 2 KLJ-1 Liquid Injection Relay 1 Starter Panel- Compressor 1 KLJ-2 Liquid Injection Relay 2 Starter Panel- Compressor 2 KM1-1 Compressor Contactor Starter Panel- Compressor 1 KM1-2 Compressor Contactor Starter Panel- Compressor 1 KM1-3 Compressor Contactor Starter Panel- Compressor 1 KM2-1 Compressor Contactor Starter Panel- Compressor 2 KM2-2 Compressor Contactor Starter Panel- Compressor 2 KM2-3 Compressor Contactor Starter Panel- Compressor 2 KM10-1 Contactor Starter Panel- Compressor 1 KM10-2 Contactor Starter Panel- Compressor 2 KM101 Fan Motor Contactor Power Panel- Left KM102 Fan Motor Contactor Power Panel- Left KM103 Fan Motor Contactor Power Panel- Left KM105 Fan Motor Contactor Power Panel- Left KM107 Fan Motor Contactor Power Panel- Left KM110 Fan Motor Contactor Power Panel- Left KM201 Fan Motor Contactor Power Panel- Left KM202 Fan Motor Contactor Power Panel- Left KM203 Fan Motor Contactor Power Panel- Left KM205 Fan Motor Contactor Power Panel- Left KM207 Fan Motor Contactor Power Panel- Left KM210 Fan Motor Contactor Power Panel- Left KT13 Time Delay Relay 1 Starter Panel- Compressor 1 KT23 Time Delay Relay 2 Starter Panel- Compressor 2 KT-1 Auxilliary Relay Cir. 1 Starter Panel- Compressor 1 KT-2 Aux. Relay Cir. 2 Starter Panel- Compressor 2 KT1-1 Delay Relay Starter Panel- Compressor 1 KT1-2 Delay Relay Starter Panel- Compressor 2 LJV-1 Liquid Injection Solenoid Cir. 1 Liquid Line/Starter Panel 1 LJV-2 Liquid Injection Solenoid Cir. 2 Liquid Line/Starter Panel 2 LP1 Low Pressure Switch 1 Compressor 1 LP2 Low Pressure Switch 2 Compressor 2 LR1 Line Reactor Cir. 1 Power Panel- Left Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 8

9 Electrical Legend - Units with Wye Delta or SS Starter Sch. Sym. Description Location LR2 Line Reactor Cir. 2 Power Panel- Left LSV-1 Liquid Line Solenoid Cir. 1 Liquid Line- Circuit 1 LSV-2 Liquid Line Solenoid Cir. 2 Liquid Line- Circuit 2 LT1 PFCC Lamp PFCC Enclosure LT2 PFCC Lamp PFCC Enclosure M1 Compressor Cir. 1 Base M2 Compressor Cir. 2 Base M10 Forced Ventilation Switch Box End M101 Fan Motor Power Panel- Left M102 Fan Motor Power Panel- Left M103 Fan Motor Power Panel- Left M104 Fan Motor Power Panel- Left M105 Fan Motor Power Panel- Left M106 Fan Motor Power Panel- Left M107 Fan Motor Power Panel- Left M108 Fan Motor Power Panel- Left M109 Fan Motor Power Panel- Left M110 Fan Motor Power Panel- Left M111 Fan Motor Power Panel- Left M112 Fan Motor Power Panel- Left M201 Fan Motor Power Panel- Left M202 Fan Motor Power Panel- Left M203 Fan Motor Power Panel- Left M204 Fan Motor Power Panel- Left M205 Fan Motor Power Panel- Left M206 Fan Motor Power Panel- Left M207 Fan Motor Power Panel- Left M208 Fan Motor Power Panel- Left M209 Fan Motor Power Panel- Left M210 Fan Motor Power Panel- Left M211 Fan Motor Power Panel- Left M212 Fan Motor Power Panel- Left MP1 Motor Thermal Protection Starter Panel- Compressor 1 MP2 Motor Thermal Protection Starter Panel- Compressor 2 MPR1 Motor Protection Relay Cir. 1 Starter Panel- Compressor 1 MPR2 Motor Protection Relay Cir. 2 Starter Panel- Compressor 2 OP-1 Oil Pressure Cir. 1 Compressor 1 OP-2 Oil Pressure Cir. 2 Compressor 2 P1 PFCC Contactor 1 PFCC Enclosure P2 PFCC Contactor 2 PFCC Enclosure PA1 PFCC Aux Contact 1 PFCC Enclosure PA2 PFCC Aux Contact 2 PFCC Enclosure PC1 Power Factor Correction PFCC Enclosure PC2 Power Factor Correction PFCC Enclosure Q0 Unit ON - OFF Switch Control Panel Q1 Pump Down Switch Cir. 1 Control Panel Q2 Pump Down Switch Cir. 2 Control Panel Q10 Main Power Block or Disconnect Switch 1 Power Panel- Right Q11 Emergency Stop Switch Control Box Door Q12 Automatic Circuit Breaker Control Panel Q20 Main Power Block or Disconnect Switch 2 Power Panel- Right Q101 Fan MSP Power Panel- Left Q102 Fan MSP Power Panel- Left Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 9

10 Electrical Legend - Units with Wye Delta or SS Starter Sch. Sym. Description Location Q103 Fan MSP Power Panel- Left Q105 Fan MSP Power Panel- Left Q107 Fan MSP Power Panel- Left Q110 Fan MSP Power Panel- Left Q201 Fan MSP Power Panel- Left Q202 Fan MSP Power Panel- Left Q203 Fan MSP Power Panel- Left Q205 Fan MSP Power Panel- Left Q207 Fan MSP Power Panel- Left Q210 Fan MSP Power Panel- Left R1 Compressor Crankcase Heater Cir. 1 Compressor 1 R2 Compressor Crankcase Heater Cir. 2 Compressor 2 R5 Evaporator Heater Evaporator Shell REC 1 115V Outlet Control Panel SL-1 Slide Indicator/ Linear Transducer, Cir. 1 Compressor 1 SL-2 Slide Indicator/ Linear Transducer, Cir. 2 Compressor 2 SP-1 Evap. Pressure Circuit 1 Suction Line- Circuit 1 SP-2 Evap. Pressure Circuit 2 Suction Line- Circuit 2 SS1 Selection Switch 1 Voltmeter SS2 Selection Switch 2 Ammeter ST-1 Suction Temperature Cir. 1 Suction Line- Circuit 1 ST-2 Suction Temperature Cir. 2 Suction Line- Circuit 2 T1 115V Transformer Power Panel- Left T2 24V Transformer Power Panel- Left T20-1 Transformer Cir. 1 Starter Panel- Compressor 1 T20-2 Transformer Cir. 2 Starter Panel- Compressor 2 TC Thermostat- Evaporator Heater Evaporator TXV-1 Thermal Expansion Valve Cir. 1 Economizer Liquid Line TXV-2 Thermal Expansion Valve Cir. 2 Economizer Liquid Line UC Unit Control- MicroTech III Control Panel VFD1 Fan VFD / SpeedTrol Near front of evaporator VFD2 Fan VFD / SpeedTrol Near front of evaporator VM1 Volt Meter Switch Box Door W1 Compressor Thermistor Cir. 1 Compressor 1 W2 Compressor Thermistor Cir. 2 Compressor 2 WAA Air Ambient Sensor Condenser Coil Header WD-1 Oil Discharge Temp. Sensor Cir. 1 Discharge Line- Circuit 1 WD-2 Oil Discharge Temp. Sensor Cir. 2 Discharge Line- Circuit 2 WIE Evaporator Entering Water Temperature Evaporator Inlet WOE Evaporator Leaving Water Temperature Evaporator Outlet Y2A-1 Non-Modulating Slide Load Sol. Valve Cir. 1 Compressor 1 Y2A-2 Non-Modulating Slide Load Sol. Valve Cir. 2 Compressor 2 Y2B-1 Modulating Slide Load Solenoid Valve Cir. 1 Compressor 1 Y2B-2 Modulating Slide Load Solenoid Valve Cir. 2 Compressor 2 Y3A-1 Non-Mod. Slide Unload Sol. Valve Cir. 1 Compressor 1 Y3A-2 Non-Mod. Slide Unload Sol. Valve Cir. 2 Compressor 2 Y3B-1 Mod. Slide Unload Solenoid Valve Cir. 1 Compressor 1 Y3B-2 Mod. Slide Unload Solenoid Valve Cir. 2 Compressor 2 YT-1 Turbo Solenoid Valve Cir. 1 Compressor 1 YT-2 Turbo Solenoid Valve Cir. 2 Compressor 2 Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 10

11 Electrical Legend - Units with VFD Starter Sch. Sym. Description Location AC Alarm Control Control Side AM1 Ammeter Control Box Door C10 EXV-1 Connector Outside Back of Control Side C20 EXV-2 Connector Outside Back of Control Side C101 Fan Harness Connector Condenser Fan Section C102 Fan Harness Connector Condenser Fan Section C103 Fan Harness Connector Condenser Fan Section C104 Fan Harness Connector Condenser Fan Section C105 Fan Harness Connector Condenser Fan Section C106 Fan Harness Connector Condenser Fan Section C107 Fan Harness Connector Condenser Fan Section C108 Fan Harness Connector Condenser Fan Section C109 Fan Harness Connector Condenser Fan Section C110 Fan Harness Connector Condenser Fan Section C111 Fan Harness Connector Condenser Fan Section C112 Fan Harness Connector Condenser Fan Section C201 Fan Harness Connector Condenser Fan Section C202 Fan Harness Connector Condenser Fan Section C203 Fan Harness Connector Condenser Fan Section C204 Fan Harness Connector Condenser Fan Section C205 Fan Harness Connector Condenser Fan Section C206 Fan Harness Connector Condenser Fan Section C207 Fan Harness Connector Condenser Fan Section C208 Fan Harness Connector Condenser Fan Section C209 Fan Harness Connector Condenser Fan Section C210 Fan Harness Connector Condenser Fan Section C211 Fan Harness Connector Condenser Fan Section C212 Fan Harness Connector Condenser Fan Section CC1 Control Compressor Cir. 1 Control Side CC2 Control Compressor Cir. 2 Control Side DP-1 Condenser Pressure Cir. 1 Discharge Line- Circuit 1 DP-2 Condenser Pressure Cir. 2 Discharge Line- Circuit 2 EEXV1 Expansion Valve Controller Cir. 1 Control Side EEXV2 Expansion Valve Controller Cir. 2 Control Side EMI-1 Electromagnetic Interference Filter 1 Power Side EMI-2 Electromagnetic Interference Filter 2 Power Side ESV-1 Economizer Solenoid Valve Cir. 1 Liquid Line- Circuit 1 ESV-2 Economizer Solenoid Valve Cir. 2 Liquid Line- Circuit 2 EXV-1 Electronic Expansion Valve Cir. 1 Liquid Line- Circuit 1 EXV-2 Electronic Expansion Valve Cir. 2 Liquid Line- Circuit 2 F0-1 Crankcase Heater 1 Fuses/ MSP/MMP Power Side F0-2 Crankcase Heater 2 Fuses/ MSP/MMP Power Side F1 Compressor 1 Circuit Breaker Power Side F2 Compressor 2 Circuit Breaker Power Side F10 Exhaust Fan Fuse Control Side F11 Unit Controller Fuse Control Side F12 Outlet Fuse Control Side F13 High Pressure Switch Cir. 1 Compressor 1 F23 High Pressure Switch Cir. 2 Compressor 2 F59 Evaporator Heater Fuse Control Side F90 Thermostat Control Side F100 Fan Circuit Breaker Cir. 1 Control Side F116 Evaporator Flow Switch Evaporator Outlet Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 11

12 Electrical Legend - Units with VFD Starter Sch. Sym. Description Location F120 Transformer T1 Protection Power Side F130 Phase Volt Monitor Fuse Control Side F200 Fan Circuit Breaker 2 Control Side FC Fans Control Control Side FTB107 Fan Terminal Block Cir. 1 Control Side FTB110 Fan Terminal Block Cir. 1 Control Side FTB207 Fan Terminal Block Cir. 2 Control Side FTB210 Fan Terminal Block Cir. 2 Control Side GFR1 Ground Fault Relay Cir. 1 Control Side GFR2 Ground Fault Relay Cir. 2 Control Side JFU1 HSCR Fuse 1 Control Side JFU2 HSCR Fuse 2 Control Side K1 Compressor VFD Run Relay 1 Power Side K2 Compressor VFD Run Relay 2 Power Side K11 Emergency Stop Contactor Control Side K13 Mechanical Hi Pressure Relay & Contactor Control Side K16 Fan Stage Cir. 1 Control Side K23 Mechanical Hi Pressure Relay & Contactor Control Side K26 Fan Stage Cir. 2 Control Side KLJ-1 Liquid Injection Relay 1 Control Side KLJ-2 Liquid Injection Relay 2 Control Side KM101 Fan Motor Contactor Control Side KM102 Fan Motor Contactor Control Side KM103 Fan Motor Contactor Control Side KM105 Fan Motor Contactor Control Side KM107 Fan Motor Contactor Control Side KM110 Fan Motor Contactor Control Side KM201 Fan Motor Contactor Control Side KM202 Fan Motor Contactor Control Side KM203 Fan Motor Contactor Control Side KM205 Fan Motor Contactor Control Side KM207 Fan Motor Contactor Control Side KM210 Fan Motor Contactor Control Side LJV-1 Liquid Injection Solenoid Cir. 1 Liquid Injection Line 1 LJV-2 Liquid Injection Solenoid Cir. 2 Liquid Injection Line 2 LP1 Low Pressure Switch 1 Compressor 1 LP2 Low Pressure Switch 2 Compressor 2 LR1 Line Reactor Cir. 1 Control Side LR2 Line Reactor Cir. 2 Control Side LSV-1 Liquid Line Solenoid Cir. 1 Liquid Line- Circuit 1 LSV-2 Liquid Line Solenoid Cir. 2 Liquid Line- Circuit 2 M1 Compressor Cir. 1 Base M2 Compressor Cir. 2 Base M10 Forced Ventilation Outside Wall of Power Side M11 Intake Fan Outside Wall of Control Side M12 Exhaust Fan Control Box Left Door M101 Fan Motor Condenser Fan Section M102 Fan Motor Condenser Fan Section M103 Fan Motor Condenser Fan Section M104 Fan Motor Condenser Fan Section M105 Fan Motor Condenser Fan Section M106 Fan Motor Condenser Fan Section M107 Fan Motor Condenser Fan Section Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 12

13 Electrical Legend - Units with VFD Starter Sch. Sym. Description Location M108 Fan Motor Condenser Fan Section M109 Fan Motor Condenser Fan Section M110 Fan Motor Condenser Fan Section M111 Fan Motor Condenser Fan Section M112 Fan Motor Condenser Fan Section M201 Fan Motor Condenser Fan Section M202 Fan Motor Condenser Fan Section M203 Fan Motor Condenser Fan Section M204 Fan Motor Condenser Fan Section M205 Fan Motor Condenser Fan Section M206 Fan Motor Condenser Fan Section M207 Fan Motor Condenser Fan Section M208 Fan Motor Condenser Fan Section M209 Fan Motor Condenser Fan Section M210 Fan Motor Condenser Fan Section M211 Fan Motor Condenser Fan Section M212 Fan Motor Condenser Fan Section MP1 Motor Thermal Protection Control Side MP2 Motor Thermal Protection Control Side MPR1 Motor Protection Relay Cir. 1 Control Side MPR2 Motor Protection Relay Cir. 2 Control Side OP-1 Oil Pressure Cir. 1 Compressor 1 OP-2 Oil Pressure Cir. 2 Compressor 2 Q0 Unit ON - OFF Switch Control Side Q1 Pump Down Switch Cir. 1 Control Side Q2 Pump Down Switch Cir. 2 Control Side Q10 Main Power Block or Disconnect Switch 1 Power Side Q11 Emergency Stop Switch Control Box Left Door Q12 Automatic Circuit Breaker T1 Transformer Q101 Fan MSP Control Side Q102 Fan MSP Control Side Q103 Fan MSP Control Side Q105 Fan MSP Control Side Q107 Fan MSP Control Side Q110 Fan MSP Control Side Q201 Fan MSP Control Side Q202 Fan MSP Control Side Q203 Fan MSP Control Side Q205 Fan MSP Control Side Q207 Fan MSP Control Side Q210 Fan MSP Control Side R1 Compressor Crankcase Heater Cir. 1 Compressor 1 R2 Compressor Crankcase Heater Cir. 2 Compressor 2 R5 Evaporator Heater Evaporator Shell REC 1 115V Outlet Control Side SP-1 Evap. Pressure Circuit 1 Suction Line- Circuit 1 SP-2 Evap. Pressure Circuit 2 Suction Line- Circuit 2 SS1 Selection Switch 1 Voltmeter SS2 Selection Switch 2 Ammeter ST-1 Suction Temperature Cir. 1 Suction Line- Circuit 1 ST-2 Suction Temperature Cir. 2 Suction Line- Circuit 2 T1 115V Transformer Power Side T2 24V Transformer Control Side Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 13

14 Electrical Legend - Units with VFD Starter Sch. Sym. Description Location T20-1 Transformer Cir. 1 Control Side T20-2 Transformer Cir. 2 Control Side TC Thermostat- Evaporator Heater Evaporator UC Unit Control- MicroTech III Control Side VFD1 Fan VFD / SpeedTrol Control Side Left Wall VFD2 Fan VFD / SpeedTrol Control Side Left Wall VFD-1 Compressor VFD 1 Power Side VFD-2 Compressor VFD 2 Power Side VFU1 Compressor VFD Fuse 1 Power Side VFU2 Compressor VFD Fuse 2 Power Side VM1 Volt Meter Switch Box Door W1 Compressor Thermistor Cir. 1 Compressor 1 W2 Compressor Thermistor Cir. 2 Compressor 2 WAA Air Ambient Sensor Condenser Coil Header WD-1 Oil Discharge Temp. Sensor Cir. 1 Discharge Line- Circuit 1 WD-2 Oil Discharge Temp. Sensor Cir. 2 Discharge Line- Circuit 2 WIE Evaporator Entering Water Temperature Evaporator Inlet WOE Evaporator Leaving Water Temperature Evaporator Outlet Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 14

15 Unit Layout (Unit Size 300ADS Shown) Ref. No. Description Location 1 Compressors Refrigeration Section 2 Tubing (suction, discharge, liquid injection) Refrigeration Section 3 Liquid Line and Economizer Refrigeration Section 7 Evaporator Refrigeration Section 8 Condenser Coil Refrigeration Section 9 Condenser Fans Refrigeration Section 10 Unit Switch Box/Control Panel * Controls Section 11 Compressor Starter Panel (not on units with VFD Starters) Controls Section 12 Compressor Terminal Box Controls Section * Control Panel for units with Wye-Delta or Solid State Starters shown. Larger Panel used on units with VFD Starters. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 15

16 Refrigeration Section Compressor Charts For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors. Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Compressor, Circuit 1 Unit Size Starter Std Eff. High Eff Premium Eff (Code 9) 150 VE or VF A any A WD or SS A VE or VF C any C A A 230 any C A A 250 any B C C 280 any B C C 300 any E B B 320 any E B B 350 any D E E 380 any -- E any -- D -- Compressor, Circuit 2 Unit Size Starter Std Eff. High Eff Premium Eff (Code 9) 150 VE or VF A WD or SS A VE or VF C any C any C A A 230 any B C C 250 any B C C 280 any E B B 300 any E B B 320 any D E E 350 any D E E 380 any -- D any -- D -- See next page for Compressor part numbers. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 16

17 Refrigeration Section Compressors For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors. See previous page for Compressor Charts. Compressor A Units built before Sept may have the Original or New Compressor A. See diagrams at right to determine which you have. To replace an Original Compressor A, order the New Compressor A plus the corresponding Retrofit Kit. 208V - new V - new V - new (units w/ VFD Starters) V - new (units w/o VFD Starters) V - new (units w/ VFD Starters) V - new (units w/o VFD Starters) V - new Retrofit Kit - Circuit Retrofit Kit - Circuit Oil Filter Oil Filter Compressor A - New Compressor A - Original Compressor B 208V V V (units w/ VFD Starters) V (units w/o VFD Starters) V (units w/ VFD Starters) V (units w/o VFD Starters) V Compressor D 380V (units w/ VFD Starters) V (units w/o VFD Starters) V (units w/ VFD Starters) V (units w/o VFD Starters) V Compressor C 208V V V (units w/ VFD Starters) V (units w/o VFD Starters) V (units w/ VFD Starters) V (units w/o VFD Starters) V Compressor E 380V (units w/ VFD Starters) V (units w/o VFD Starters) V (units w/ VFD Starters) V (units w/o VFD Starters) V Units with VFD Starters: Code 9 = VE, VF. Units without VFD Starters: Code 9 = WD or SS Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 17

18 Refrigeration Section Compressor Components 15A 15B Y2A1 Y3A1 60A 60 60B 60A Y3B1 YT1 Circuit # 1 shown R1 2 2A 2B 13 13A 10 Y2B1 SL1 F See Compressor Charts to identify compressor. Ref. Sch. Description Compressor Compressor Compressor Qty No. Sym. A B C per compr 2 Compressor Heater, V Compressor Heater, 380V Compressor Heater, 460V Compressor Heater, 575V A Well- Heater B Bushing- Heater F13, 23 Switch- High Pressure Control, 290 psi OP1, 2 Transducer- Oil Pressure, 0 to 30 bar Relief Valve A Elbow- Relief Valve SL1, 2 Linear Transducer- Slide Indicator (C21= L, B) A Cable for Linear Transducer (16 ft) A Cable for Linear Transducer (32 ft) Discharge Shut-Off Valve A Screw, Hex B Washer, Lock Isolator, Compr. Mounting Screw, M8 x 2.5 C Washer, Plain, Washer, Lock, Screw, M12 x Washer, Lock, Y2*1-1, 2 Valve, Solenoid- Load A Y3*1-1, 2 Valve, Solenoid- Unload B YT-1, 2 Valve, Solenoid- Turbo NS Suction Gasket NS Oil Filter NS Oil Filter Gasket Kit NS Liq Injection Fitting- Compr (non-economizer) NS Liq Injection Fitting- Compr (with Economizer) NS Liq Injection Fitting- Rotolock to Copper NS Liq Injection O-Ring NS Kit, O-Rings and Gaskets Solenoids are comprised of: Valve Body & Adapter p/n ; Valve Coil p/n ; Valve Support Gasket p/n If unit has original Compressor A (see previous page), use: Relief Valve and Shut-off Valve NS = Not Shown Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 18

19 Refrigeration Section Compressor Components 15A 15B Y2A1 Y3A1 60A 60 60B 60A Y3B1 YT1 Circuit # 1 shown R1 2 2A 2B 13 13A 10 Y2B1 SL1 F Ref. Sch. Description Compressor Compressor Qty No. Sym. D E per compr 2 Compressor Heater, 208/230V Compressor Heater, 380V Compressor Heater, 460V Compressor Heater, 575V A Well- Heater B Bushing- Heater F13, 23 Switch- High Pressure Control, 290 psi OP1, 2 Transducer- Oil Pressure, 0 to 30 bar Relief Valve A Elbow- Relief Valve SL1, 2 Linear Transducer- Slide Indicator (C21= L, B) Discharge Shut-Off Valve A Screw, Hex B Washer, Lock Isolator, Compr. Mounting Screw, M8 x Washer, Plain, Washer, Lock, Screw, M12 x Washer, Lock, Y2*1-1, 2 Valve, Solenoid- Load A Y3*1-1, 2 Valve, Solenoid- Unload B YT-1, 2 Valve, Solenoid- Turbo 1 1 NS Suction Gasket NS Oil Filter NS Oil Filter Gasket Kit NS Liq Injection Fitting- Compressor (non-economizer) NS Liq Injection Fitting- Compressor (with Economizer) NS Liq Injection Fitting- Rotolock to Copper NS Liq Injection O-Ring NS Kit, O-Rings and Gaskets Solenoids are comprised of: Valve Body & Adapter p/n ; Valve Coil p/n ; Valve Support Gasket p/n NS = Not Shown See Compressor Charts to identify compressor. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 19

20 Refrigeration Section Suction Lines, Discharge Lines, Liquid Injection Lines 609 WD DP Discharge Line Detail Circuit # Fan Units shown Liquid Injection Detail Circuit # WD1 DP1 Discharge Liquid Injection LJV1 Discharge Line Detail Circuit # Fan Units shown Suction Suction Line Detail Circuit #2 Shown with Suction Shut-off Valve 202 Suction Line Detail Circuit #1 Shown with Suction Shut-off Valve ST2 ST LJV2 Liquid Injection Detail Circuit # Fan Unit Shown For units built after 8/1/11, contact Daikin Applied for part number identification of Suction Piping Components. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 20

21 Refrigeration Section Suction Lines, Discharge Lines, Liquid Injection For units built after 8/1/11, contact Daikin Applied for part number identification of Suction Piping Components. Ref Sch. Part Part No. Sym. Description Number Qty. Suction Line- Circuit #1 100 Valve- Relief 200 PSI Valve- Suction Shutoff see next page ST1 Sensor- Suction Temperature, Bent, 30 ft Sensor- Suction Temperature, Straight, 30 ft N/S SP1 Transducer- Suction -1 to 7 bar Suction Line- Circuit #2 200 Valve- Relief 200 PSI Valve- Suction Shutoff see next page ST2 Sensor- Suction Temperature, Bent, 30 ft Sensor- Suction Temperature, Straight, 30 ft N/S SP2 Transducer- Suction Pressure -1 to 7 bar Liquid Injection- Circuit #1 302 Fitting- Rotolock Valve- Schrader LJV1 Valve- Solenoid 120V Strainer Valve- Ball Cap- Valve Liquid Injection- Circuit #2 402 Fitting- Rotolock Valve- Schrader LJV2 Valve- Solenoid 120V Strainer Valve- Ball Cap- Valve Discharge Line- Circuit #1 500 Coupling * Kit- Flange * NS Gasket- Discharge Shut-Off Valve * Valve- Schrader Core- Valve DP1 Transducer- Discharge Pressure 0 to 30 bar Tube- Sensor WD1 Sensor- Discharge Temperature, 20 ft Discharge Line- Circuit #2 600 Coupling ** Kit- Flange ** NS Gasket- Discharge Shut-Off Valve ** Valve- Schrader Core- Valve DP2 Transducer- Discharge Pressure 0 to 30 bar Tube- Sensor WD2 Sensor- Discharge Temperature, 20 ft * Circuit 1 - On the following units, use Coupling/Adapter , Flange Kit , and Discharge Shut-Off Valve Gasket : 150ADS, 175ADS, 190ADS, 210ADH, 210ADP, 230ADH, 230ADP. ** Circuit 2 - On the following units, use Coupling/Adapter and Flange Kit , and Discharge Shut- Off Valve Gasket : 150ADS, 175ADS, 210ADH, 210ADP. NS= Not shown Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 21

22 Refrigeration Section Suction Shut Off Valves For units built after 8/1/11, contact Daikin Applied for part number identification of Suction Piping Components. Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Ref. 102: Suction Shut Off Valve, Circuit 1 Unit Size Standard Eff. High Eff. Premium Eff See Note below 280 See Note below See Note below See Note below 300 See Note below See Note below See Note below 320 See Note below See Note below See Note below 350 See Note below See Note below See Note below See Note below See Note below -- Ref. 202: Suction Shut Off Valve, Circuit 2 Unit Size Standard Eff. High Eff. Premium Eff See Note below See Note below See Note below See Note below See Note below See Note below See Note below See Note below See Note below See Note below See Note below -- Note: For units built after 8/31/10, use Valve part # For units built before 8/31/10, contact Daikin Applied with the unit GO # and Serial # to determine the correct Valve. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 22

23 Refrigeration Section Liquid Lines- Standard Efficiency Units (Code 04= S*) 102 Evaporator Circuit # Circuit # EXV1 124 LSV EXV LSV2 102 Ref Sch. Part Part Qty. No. Sym. Description Number per circuit 100 Valve- Schrader Core- Valve Cap- Valve Valve- Charge.37 x Valve- Ball Bracket- Drier Shell- Filter Drier Core- Filter Drier Kit- Drier Gasket Saddle- Sight Glass Cap- Sight Glass EXV1, 2 Valve- Electronic Expansion 12V/6W LSV1, 2 Valve- Liquid Line Solenoid C29= SD, SL Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 23

24 Refrigeration Section Liquid Lines with Economizer- High & Premium Efficiency Units (Code 04= H* or P*) Compressor Economizer Connection Detail From Economizer S4 Evaporator Liquid Line Tee To S To Compressor Representation of Circuit 1 Shown Configuration may vary (Circuit 2 has same components) Condenser to Economizer Detail From Condenser Line Between Economizer and Compressor Detail From Economizer S4 From ESV Equalization Tube Circuit 1 Circuit 2 From Liquid Line Tee ESV_ To Compressor 1 From Condenser TXV_ 2 S4 S1 Economizer S3 S2 Connects To Evaporator Economizer to Evaporator Detail EXV_ LSV_ From Economizer S2 To Evaporator For units built after 8/1/11, contact Daikin Applied for part number identification of Check Valves and Economizers. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 24

25 Refrigeration Section Liquid Lines with Economizer- High & Premium Efficiency Units (Code 04= H* or P*) For units built after 8/1/11, contact Daikin Applied for part number identification of Check Valves and Economizers. Ref Sch. Part Part Qty. No. Sym. Description Number per circuit 1 ESV1, 2 Valve- Economizer Solenoid TXV1, 2 Valve- Thermal Expansion see next page 1 6 Economizer- Brazed Plate see next page Valve- Schrader Core- Valve Cap- Valve Valve- Charge.37 x Valve- Ball Bracket- Drier Shell- Filter Drier Core- Filter Drier Kit- Drier Gasket Saddle- Sight Glass Cap- Sight Glass EXV1, 2 Valve- Electronic Expansion 12V/6W LSV1, 2 Valve- Liquid Line Solenoid C29= SD, SL Connector- Economizer see next page Fitting- Economizer see next page Valve- Check see next page O-Ring see next page O-Ring see next page 2 Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 25

26 Refrigeration Section Liquid Lines with Economizer- High & Premium Efficiency Units (Code 04= H* or P*) For units built after 8/1/11, contact Daikin Applied for part number identification of Check Valves and Economizers. High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Economizer, Circuit 1 Economizer, Circuit 2 Unit Size High Eff Premium Eff A A 230 A A 250 C C 280 C C 300 B B 320 B B 350 E E 380 E D -- Unit Size High Eff Premium Eff A A 230 A C 250 C C 280 C B 300 B B 320 B E 350 E E 380 E D -- Ref. # Part Number Qty. per circuit Economizer A (from chart above) 2 Thermal Expansion Valve Economizer Fitting, Economizer Rotolock Fitting Check Valve Gasket for Check Valve O-Ring Economizer B or C 2 Thermal Expansion Valve Economizer Fitting, Economizer Rotolock Fitting Check Valve Gasket for Check Valve P292C O-Ring O-Ring Economizer D or E 2 Thermal Expansion Valve Economizer Fitting, Economizer Rotolock Fitting Check Valve Gasket for Check Valve P292C O-Ring O-Ring Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 26

27 Refrigeration Section Condenser Coils and Fans Fan Detail 3 5 F2C1 F2C2 F2C4 F2C3 F1C1 F1C2 F1C4 F1C3 50 Ref Sch. Part Part Quantity No. Sym. Description Number 1 Panel- Fan Deck per fan - see next page 2 Grille- Fan per fan 3 Bracket- Fan Motor per fan 4 Blade- Fan per fan 5 M*** Motor- Fan, 208/230V 1.4 HP per fan 5 M*** Motor- Fan, 380V 1.4 HP per fan 5 M*** Motor- Fan, 460V 1.4 HP per fan 5 M*** Motor- Fan, 575V 1.4 HP per fan 50 WAA Sensor- Outdoor Air, 20 ft per unit Coils- Condenser 1 Mounted to Condenser Coil tubesheet behind the switch box. ***= Fan number Identify from diagram and Contact Daikin Applied Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 27

28 Refrigeration Section Fan Totals per Unit Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Starter Std. Eff. High Eff. Premium Eff. Size (Code 9) Ckt 1 Ckt 2 Total Ckt1 Ckt 2 Total Ckt 1 Ckt 2 Total 150 VF or VE 5 5 = WD or SS 5 5 = VF or VE 6 6 = WD or SS 6 6 = VF or VE 6 6 = any 6 6 = = = any 7 7 = = = any 7 7 = = = any 8 8 = = = any 8 8 = = = any = = = any = = = any = any = Code 9: VF = VFD Starter without EMI Filter VE = VFD Starter with EMI Filter WD = Wye Delta Starter with Compressor Overloads SS = Solid State Starter Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 28

29 Refrigeration Section Evaporator Diagram F A WOE WIE A A Liquid Connection End Suction Connection End 20 6 For units built after 8/1/11, contact Daikin Applied for part number identification of Evaporator Assemblies. All other Evaporator parts listed apply to all dates. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 29

30 Refrigeration Section Evaporator Components Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Ref. No. 1: Evaporator Assembly For units built after 8/1/11, contact Daikin Applied for part number identification of Evaporator Assemblies. All other Evaporator parts listed apply to all dates. Evap Description / Unit Sizes Starter Left-Hand Evap Right-Hand Evap Group (Code 9) Code 23 = VL Code 23 = VR Standard Efficiency Units A 150A VF or VE A 175A WD or SS A 175A VF or VE A 190A WD or SS A 190A VF or VE A 210A any A 230A any A 250A any B 280A any B 300A any B 320A any B 350A any High Efficiency Units A 210A any A 230A any A 250A any B 280A any B 300A any B 320A any B 350A any B 380A any B 405A any Premium Efficiency Units B 210A any B 230A any C 250A any C 280A any C 300A any C 320A any C 350A any Evap Ref Sch. Part Part No. Qty. Group No. Sym. Description All 4 WIE Sensor- Evaporator Inlet, 60 ft All 4A WOE Sensor- Evaporator Outlet, 60 ft All 5 Well- Sensor E All 7 F116 Switch- Evaporator Flow All Cable- for Evap Flow Switch All 19 Valve- Mini Ball, 0.50 NPT All 20 Pad- Vibration, 4" x 3.25" All Insulation as needed For more Evaporator components, determine Evap Group from above chart and see next page. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 30

31 Refrigeration Section Evaporator Components Evap Ref Sch. Part Part No. Qty. Group No. Sym. Description A, B 2 Ferrule- Liquid E C 2 Ferrule- Liquid E A, B 2A Flange- Liquid E C 2A Flange- Liquid E A 6 R5 Heater- Evaporator E B, C 6 R5 Heater- Evaporator E A 8 Gasket- Inlet Head E B 8 Gasket- Inlet Head E C 8 Gasket- Inlet Head E A 8A Gasket- Suction Head E B 8A Gasket- Suction Head E C 8A Gasket- Suction Head E A 9 Gasket- Distributor E B 9 Gasket- Distributor E C 9 Gasket- Distributor E A 10 O'Ring- Tube Sheet E B 10 O'Ring- Tube Sheet E A, B 12 Bolt- Liquid Ferrule E C 12 Bolt- Liquid Ferrule E A 14 Bolt- Suction Connection E B, C 14 Bolt- Suction Connection E A 15 O'Ring- Suction E B 15 O'Ring- Suction E C 15 O'Ring- Suction E A 18 Bolt- Head (M16 x 1.5 x 70) E B 18 Bolt- Head (M16 x 1.5 x 70) E B 18 Bolt- Head (M14-16 x 1.5 x 100) E B 18 Bolt- Head (M14-16 x 1.5 x 135) E C 18 Bolt- Head (M14-16 x 1.5 x 130) E C 18 Bolt- Head (M16 x 1.5 x 145) E C 18 Bolt- Head (M16 x 1.5 x 70) E Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 31

32 Coil and Base Frame Grilles Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Std. High Prem. Unit Starter Eff. Eff. Eff. Size (Code 9) Total Total Total Fans Fans Fans 150 VF orve WD or SS VF or VE WD or SS VF or VE any any any any any any any any any Coil Grilles Code 28=G, F 16 Fan Unit shown Ref Part Part Quantity No. Description Number 1 Grille- Coil per fan 1 Each coil louver is attached using six (6) screws p/n Base Frame Grilles Code 28=F, C 16 Fan Unit shown 4 1 Ref Part Part Quantity No. Description Number 1 Grille- Base per fan 2 Grille- Left Hand Rear per unit 3 Grille- Right Hand Rear per unit 4 Grille- Front per unit 1 Each base grille is attached using four (4) screws p/n Each front or rear grille is attached using six (6) screws p/n Front Grille not used on units with VFD Starters. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 32

33 Coil Louvers Code 28=L, B, C Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Std. High Prem. Unit Starter Eff. Eff. Eff. Size (Code 9) Total Total Total Fans Fans Fans 150 VF orve WD or SS VF or VE WD or SS VF or VE any any any any any any any any any Unit configuration will vary with number of fans. 2 Ref Part Part Quantity No. Description Number 2 Louvered Panel- Coil per fan 1 Each coil louver is attached using six (6) screws p/n Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 33

34 Base Frame Louvers Code 28= B Fan Units Std. High Prem. Unit Starter Eff. Eff. Eff. Size (Code 9) Total Total Total Fans Fans Fans 150 VF orve WD or SS VF or VE WD or SS VF or VE any any any any any any any any any Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Fan Unit Fan Unit Fan Unit # of Fans screws Ref Part Part per No. Description Number panel 2 2 Louvered Panel- Rear Bottom Louvered Panel- Rear Top Louvered Panel- Side Louvered Panel- Side Louvered Panel- Side Louvered Panel- Side Louvered Panel- Front Side Louvered Panel- Front Center Front Side and Front Center Panels not used on units with VFD Starters. Screw part number Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 34

35 Base Frame Louvers Code 28= B Fan Units Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Std. High Prem. Unit Eff. Eff. Eff. Size Total Total Total Fans Fans Fans Fan Unit Fan Unit # of Fans screws Ref Part Part per No. Description Number panel 2 2 Louvered Panel- Rear Bottom Louvered Panel- Rear Top Louvered Panel- Side Louvered Panel- Side Louvered Panel- Side Louvered Panel- Front Side Louvered Panel- Front Center Front Side and Front Center Panels not used on units with VFD Starters. 2 Screw part number Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 35

36 Base Frame Louvers Code 28= B Fan Units Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Std. High Prem. Unit Eff. Eff. Eff. Size Total Total Total Fans Fans Fans Fan Unit Fan Unit # of Fans screws Ref Part Part per No. Description Number panel 2 2 Louvered Panel- Rear Bottom Louvered Panel- Rear Top Louvered Panel- Side Louvered Panel- Side Louvered Panel- Side Louvered Panel- Front Side Louvered Panel- Front Center Front Side and Front Center Panels not used on units with VFD Starters. 2 Screw part number Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 36

37 Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Box Locations and Label Detail Control Panel Power Panel- Left Side Power Panel- Right Side Terminal Box (one per compressor) Circuit 2 Starter Box Fan VFD location Label Detail For all control components not detailed or for unit specific controls (i.e. main disconnect, solid state contactors), please contact Daikin Applied with the Control Box Serial Number and Control Box Part Number. These numbers are located on the Control box rating label (see example below). This label is found inside the panel. Control Box Serial Number S + Year + ##### + detail# Solid State Starter Panel (one per compressor) Circuit 2 shown or Wye- Delta Starter Panel (one per compressor) Circuit 2 shown Control Box Part Number Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 37

38 Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Control Panel Detail Q12 K11 F59 F12 AC REC1 UC FC Q0 Q1 Q2 Q11 Sch. Part Part Sym. Description Number Qty. AC Expansion Controller- Alarms AWM Advanced Web Module FC Expansion Controller- Fans F12 Fuse- Outlet F59 Fuse- Evaporator Heater Protection K11 Relay- Emergency Stop Q0 Switch- Unit Shut Off Q1 Switch- Pumpdown Circuit # Q2 Switch- Pumpdown Circuit # Q11 Switch- Emergency Stop Q12 Circuit Breaker REC1 Receptacle UC Controller- MicroTech III Mounted through the door. 2 This control board must be programmed in order to function correctly. When ordering a replacement, provide the unit model and serial number so that unit specific software code can be loaded before shipment. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 38

39 Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Power Panel Detail Q101 Q102 Q103 Q104 Q105 Q107 F130 F112 K16 KM 102 KM 103 KM 104 KM 105 KM 107 F100 LR1 Q201 Q202 Q203 Q204 Q205 Q207 UC F230 F200 F212 K26 KM 202 KM 203 KM 204 KM 205 KM 207 GFR1 GFR2 LR2 T2 AM1 VM1 T1 F120 Sch. Part Part Sym. Description Number Qty. AM1 Ammeter Code 14= A See next page 1 F100, 200 Circuit Breaker- Circuit #1 Fans 600V/100A F112, 212 Phase Voltage Monitor F120 Fuse- Control Transformer 208/230V F120 Fuse- Control Transformer 380V F120 Fuse- Control Transformer 460V, 575V F130, 230 Fuse- PVM GFR1, 2 Relay- Ground Fault K16, 26 Relay- Fan Motor KM Contactor- Fans Circuit # /fan KM Contactor- Fans Circuit # /fan LR1, 2 Line Reactor 460V Q MSP- Fans Circuit # /fan Q MSP- Fans Circuit # /fan T2 Transformer 24V T1 Transformer- Control 208/230/460V:120V T1 Transformer- Control 380V:120V T1 Transformer- Control 575V:120V VFD1, 2 Fan VFD 2 208/230V VFD1, 2 Fan VFD 2 380V, 460V VFD1, 2 Fan VFD 2 575V VM1 Volt Meter: 0-600V 1 Code 14= A Mounted on the outside of the power panel door. 2 Not shown - The Fan VFDs are located on the cross rail near the front of the evaporator. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 39

40 Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Power Panel Detail AM1: Ammeter Voltage Unit Size Part Number 208V, 230V all A V A V 280AS A V 280AH, 280AP 0-600A V A V, 575V A V, 575V A Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 40

41 Controls Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) Power Panel Detail M10 F1 or Q20 Q10 or P10 F2 GFR1 CT Single Point Connection (Code 12= PC, DC, DH) Shown Sch. Sym. Part Description Q10 Switch- Main Disconnect Units with Disc Switch: C12= DC, DH, WN, WH Q20 Switch- Main Disconnect Only on Multi-Point units: C12= WN, WH P10 Power Block- Main Units with Power Block: C12= PC F1, 2 Circuit Breaker- Compressor 1, 2, 3 Only on Single Point units: C12= PC, DC, DH To insure proper replacement part number for any of the items above, contact Daikin Applied with the Control Box Serial Number and Control Box Part number. See earlier Controls page for Label example. Sch. Sym. Part Description Part Number M10 Control Box Exhaust Fan GFR1 CT: Ground Fault Current Sensor Voltage Unit Size Part Number Multi-Point Units all all (Code 12 = WN, WH) 208/230V all V V 280AS Single Point Units (Code 12 = PC, DC, DH) 380V 280AH, AP V 300AS V 300AH, AP V V V 320AS V 320AH V 320AP V Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 41

42 Controls Solid State Starter Panel Code 09= SS KT-1 K2B-1 F0-1 LJV-1 MPR-1 EEXV1 KM1-1 CC1 MP1 T20-1 Sch. Part Part Qty per Sym. Description Number panel CC1, 2 Controller- Circuit EEXV1, 2 Controller- Expansion Valve F0-1, 2 MSP- Heater K2B-1, 2 Contactor- Turbo KLJ-1, 2 Relay- Liquid Injection KM1-1, 2 Contactor- Solid State see next page KT-1, 2 Relay- Turbo Solenoid MP1, 2 Motor Protector MPR-1, 2 Relay- Motor Protection T20-1, 2 Transformer- 120V to 24V Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 42

43 Controls Solid State Starter Panel Code 09= SS 7 MX2 Card KM1-1,2 Contactor Assy AWS , Std Eff, circuit 1 AWS , Std Eff, circuit used on: AWS , High Eff, circuit 1 AWS , High Eff, circuit 2 AWS , Prem Eff, circuit 1 AWS , Prem Eff, circuit 2 Sch. Part Part Qty per Sym. Description Number panel KM1-1, 2 Contactor - Solid State, complete assembly includes: ' 1 MX2 Low Voltage Motor Starter Card Contactor Bypass, 75A, 50HP, 120V Surge Suppressor SCR, 660A, 1800V Current Transformer Snubber Assembly KM1-1,2 Contactor Assy AWS , Std. Eff, circuit 1 AWS , Std Eff, circuit used on: AWS , High Eff, circuit 1 AWS , High Eff, circuit 2 AWS 350, Prem Eff, circuit 1 AWS , Prem Eff, circuit 2 Sch. Part Part Qty per Sym. Description Number panel KM1-1, 2 Contactor - Solid State, complete assembly includes: ' 1 MX2 Low Voltage Motor Starter Card Contactor Bypass, 85A, 60HP, 120V Surge Suppressor SCR, 660A, 1800V Current Transformer Snubber Assembly Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 43

44 Controls Wye-Delta Starter Panel Code 09= WD KT1-1 K2B-1 KT-1 FO-1 LJV-1 MPR-1 F5-1 EEXV1 MP1 CC1 KM3-1 KM2-1 KM1-1 T20-1 Sch. Part Part Qty per Sym. Description Number panel CC1, 2 Controller- Circuit EEXV1, 2 Controller- Expansion Valve F0-1, 2 Heater- MSP F5-1, 2 Overload- Thermal See next page K2B-1, 2 Contactor- Turbo Relay KLJ-1, 2 Relay- Liquid Injection KM1-1, 2 Contactor- Wye Delta See next page KM2-1, 2 Contactor- Wye Delta See next page KM3-1, 2 Contactor- Wye Delta See next page KT-1, 2 Relay- Turbo Solenoid KT1-1, 2 Time Delay- Starter MP1, 2 Motor Protector MPR-1, 2 Relay- Motor Protection T20-1, 2 Transformer- 120V to 24V Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 44

45 Controls Wye-Delta Starter Panel Code 09= WD Starter Label example. Refer to the Starter Label to identify the Starter Max RLA. Starter Compressor Contactors Thermal Max Unit KM1-1, 2 Overload RLA Voltage KM2-1, 2 KM3-1,2 F5-1, 2 142A all 105A A A A all 150A A A A all 180A A A A all 250A A A A all 250A A A A 208V 300A A A A 230V 300A A A A 380V w/o Economizer 300A A A A 380V w/ Economizer 300A A A A all 400A A A Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 45

46 Controls Power Factor Correction Capacitors (PFCC) Code 16= C 12 Fan unit shown. Configuration similar for Fan and 24 Fan units. For 22 Fan units, the PFCC panels are mounted on both sides of the evaporator. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 46

47 Controls Power Factor Correction Capacitors (PFCC) Code 16= C 208V 230V 460V 575V PFCC Part Number from label on panel»» Sch Description Part Number Quantity per PFCC panel Sym C1 Capacitor C1 Capacitor C1 Capacitor C1 Capacitor C1 Capacitor C1 Capacitor C1 Capacitor C2 Capacitor C2 Capacitor C2 Capacitor C2 Capacitor FU1,2,3 Fuse FU1,2,3 Fuse FU1,2,3 Fuse FU1,2,3 Fuse FU1,2,3 Fuse FU1,2,3 Fuse FU1,2,3 Fuse PC1 or PC2 Contactor PC1 or PC2 Contactor PC1 or PC2 Contactor PC1 or PC2 Contactor PC1 or PC2 Contactor PC1 or PC2 Contactor PC1 or PC2 Contactor PA1 or PA2 Aux Contacts PA1 or PA2 Aux Contacts LT1,2,3 Pilot Lights Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 47

48 Controls Units with VFD Starters (Code 9 = VE or VF) Box Locations and Label Detail Control Panel Power Panel Fan VFD location Label Detail For all control components not detailed or for unit specific controls (i.e. main disconnect, solid state contactors), please contact Daikin Applied with the Control Box Serial Number and Control Box Part Number. These numbers are located on the Control box rating label (see example below). This label is found inside the panel. Control Box Serial Number S + Year + ##### + detail# Control Box Part Number Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 48

49 Controls Units with VFD Starters (Code 9 = VE or VF) Control Side Q110 Q107 Q105 Q103 Q102 Q101 Q210 Q207 Q205 Q203 Q202 Q201 FUSES REC1 Q0 Q1 Q2 UC FC, FC2 K11 K13 K16 MPR1 KLJ-1 AC CC2 CC1 EEXV1 EEXV2 K23 K26 MPR2 KLJ-2 T20-1, T20-2 GFR1 T2 MP1, MP2 Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 49

50 Controls Units with VFD Starters (Code 9 = VE or VF) Control Side Sch. Part Part Sym. Description Number Qty. AC Expansion Controller- Alarms AWM Advanced Web Module CC1,2 Controller- Circuit EEXV1,2 Extension I/O for Electr. Exp. Valve (Code 29= LD or SL) EEXV1,2 Extension I/O for Electr. Exp. Valve (Code 29= ND or SD) F11 Fuse- Unit Controller, 10A Rejection Type F12 Fuse- Outlet F59 Fuse- Evaporator Heater Protection F120 Fuse- Control Transformer, 12A Rejection Type (380V) F120 Fuse- Control Transformer, 9A Rejection Type (460V) FC, FC2 Expansion Controller- Fans GFR1 Relay- Ground Fault * K11 Relay- Emergency Stop K13 Relay- Mechanical High Pressure, Circuit K16 Relay- Fan Motor, Circuit K23 Relay- Mechanical High Pressure, Circuit K26 Relay- Fan Motor, Circuit KLJ-1,2 Relay- Liquid Injection MP1,2 Motor Thermal Protection MPR1,2 Relay- Motor Protector Q0 Switch- Unit Shut Off Q1,2 Switch- Pumpdown Q11 Switch- Emergency Stop (Not shown - mounted through the door) REC1 Receptacle- Ground Fault Interrupter T2 Transformer- 100VA, 115V-24V T20-1,2 Transformer- 50VA, 115V-24V UC Controller- MicroTech III VFD1, 2 Fan VFD Not shown - Fan VFDs are located on the left wall of the Control Side on units with VFD Starters. 2 This control board must be programmed in order to function correctly. When ordering a replacement, provide the unit model and serial number so that unit specific software code can be loaded before shipment. *Qty = 1 on Std Short Circuit units (Code 12 = PC,DC,WN); Qty = 3 High Short Circuit units (Code 12 = DH, WH) Code 14=A Unit Size Efficiency Voltage Description Part Number Qty (Code 4) VM1 all all all Voltmeter V AM all all Ammeter A AM1 250 H 380V Ammeter A AM1 250 P 380V Ammeter A AM1 250 H, P 460V Ammeter A AM1 280 H, P 380V Ammeter A AM1 280 H, P 460V Ammeter A AM all all Ammeter A Mounted on the outside of the control box door. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 50

51 Controls Units with VFD Starters (Code 9 = VE or VF) Control Side Units with Standard Short Circuit Current Rating (Code 12 = PC, DC, WN) Sch. Part Part Sym. Description Number Qty. Units without Fan VFDs (Code 27 = F) Q MSP- Fans Circuit # /fan Q MSP- Fans Circuit # /fan Units with Fan VFDs (Code 27 = V) Q101 Manual Mtr Starter- Fans Circuit # /fan Q201 Manual Mtr Starter- Fans Circuit # /fan Q MSP- Fans, Low Short Circuit Circuit # /fan Q MSP- Fans, Low Short Circuit Circuit # /fan Units with High Short Circuit Current Rating (Code 12=DH,WH) Sch. Part Part Sym. Description Number Qty. Q MSP- Fans * NS JFU1,2,3 High Short Circuit Fuse, 30A, 600V ** 1 NS JFU1,2,3 High Short Circuit Fuse, 60A, 600V ** 1 NS JFU1,2,3 High Short Circuit Fuse, 100A, 600V ** 1 * Contact Daikin Applied. ** Contact Daikin Applied to determine which High Short Ckt Fuse is used in a specific unit. NS = Not Shown Sch. Part Part Sym. Description Number Qty. NS F10 Exhaust Fan Fuse, 10A NS F100 Circuit Breaker- Circuit #1 Fans Contact Daikin Applied NS F200 Circuit Breaker- Circuit #2 Fans Contact Daikin Applied NS F130 Fuse- PVM NS KM Contactor- Fans Circuit # /fan NS KM Contactor- Fans Circuit # /fan NS LR1, 2 Line Reactor NS SS1 Switch- Voltmeter NS SS2 Switch- Ammeter NS = Not Shown Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 51

52 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side VFD1 VFD2 VFU1 VFU2 K1 F01 F02 CT5 Q10 or PB1 F1, F2 CT6 CT4 GCT1 T1 Q12 Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 52

53 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Sch. Part Part Sym. Description Number Qty. F0-1,2 Manual Motor Protector MMP/MSP, PB (Code 12= PC, DC, or WN) F0-1,2 Manual Motor Protector MMP/MSP, Rotary (Code 12= DH or WH) K1,2 Relay- Crankcase Heater (Code 12= PC, DC or WN) K1,2 Relay- Crankcase Heater (Code 12= DH or WH) Q12 Fuse- Control Transformer, 20A Non-rejection Type T1 Transformer- Control, 1500VA, 380V-115V (380V units) T1 Transformer- Control, 1500VA, 460V-115V (460V units) T1 Transformers include the following: Finger Safe Cover for T Fuse Puller Kit for T Sch. Part Unit Efficiency Voltage Current Part Qty Sym. Description Size Code 4 Relay Number CT 4,5,6 Current Transformer S,H,P 380V, 460V 600:5A CT 4,5,6 Current Transformer 250 H 380V 600:5A CT 4,5,6 Current Transformer 250 P 380V 1200:5A CT 4,5,6 Current Transformer 250 H,P 460V 600:5A CT 4,5,6 Current Transformer 280 H,P 380V 1200:5A CT 4,5,6 Current Transformer 280 H,P 460V 600:5A CT 4,5,6 Current Transformer H,P 380V, 460V 1200:5A CT 4,5,6 Current Transformer 380, 405 H 460V 1200:5A Sch. Unit Part Sym. Size Number Qty Units with Single Point Pwr Blk or Disconnect (Code 12 = PC, DC or DH) GCT1 Ground Fault Current Sensor GCT1 Ground Fault Current Sensor Units with Multi Point Disconnect (Code 12 = WN or WH) GCT1,2,3 Ground Fault Current Sensor Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 53

54 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side VFD-1, VFD-2 Compressor VFD Starter Unit Voltage Circuit 1 Circuit 2 Size VFD-1 VFD-2 150A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V A 460V A 380V VFU1,2 Fuse EMI1,2 EMI Filter Used with Compressor VFD (250A) VFU1,2 Fuse- Semi-Conductor, 600A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Used with Compressor VFD (296A) VFU1,2 Fuse- Semi-Conductor, 700A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Used with Compressor VFD (362A) VFU1,2 Fuse- Semi-Conductor, 800A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Used with Compressor VFD (414A) VFU1,2 Fuse- Semi-Conductor, 800A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Used with Compressor VFD (515A) VFU1,2 Fuse- Semi-Conductor, 1000A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Used with Compressor VFD (675A) VFU1,2 Fuse- Semi-Conductor,1200A Fuse Block- Semi-Conductor EMI1,2 EMI Filter (Code 9 = VE) Note: EMI1,2 are not shown on diagram Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 54

55 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side PB1 - Single Point Power Block (Code 12 = PC) Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Power Block Power Block Safety Cover Size Part Number Part Number 150 Standard 380V 620A Standard 460V 380A Standard 380V, 460V 620A Standard 380V, 460V 620A High, Prem 380V, 460V 620A High, Prem 380V, 460V 620A High 380V, 460V 620A Premium 380V 760A Premium 460V 620A , 300 High 380V 760A , 300 High 460V 620A , 300 Premium 380V 760A , 300 Premium 460V 620A , 350 High 380V 1400A included with Pwr Blk 320, 350 High 460V 760A , 350 Premium 380V 1400A included with Pwr Blk 320, 350 Premium 460V 760A High 380V, 460V 1400A included with Pwr Blk 405 High 380V, 460V 1400A included with Pwr Blk Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 55

56 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Q10 - Main Disconnect (Code 12 = DC, DH, WN or WH) Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Disconnect Disconnect Handle Shaft Size Part Number Part Number Part Number 150 Standard 380V 600A Standard 460V 400A Standard 380V, 460V 600A Standard 380V, 460V 600A High, Prem 380V, 460V 600A High, Prem 380V, 460V 600A High 380V, 460V 600A Premium 380V 800A Premium 460V 600A High 380V 800A High 460V 600A Premium 380V 800A Premium 460V 600A High, Prem 380V, 460V 800A High 380V 1200A High 460V 800A Premium 380,460V 800A High 380V 1200A High 460V 800A Premium 380V 1200A Premium 460V 800A High 380V, 460V 1200A High 380V, 460V 1200A Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 56

57 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Units with Multi Point Disconnect and Standard Short Circuit Current Rating (Code 12 = WN) See next page for Multi Point Disconnect on units with High Short Circuit Current Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number F1 (Circuit 1) 150 Standard 380V, 460V WN 250A / 18KA Standard 380V, 460V WN 250A / 18KA Standard 380V WN 400A / 35KA Standard 460V WN 250A / 18KA , 230 High,Prem 380V WN 400A / 35KA , 230 High,Prem 460V WN 250A / 18KA , 280 High,Prem 380V, 460V WN 400A / 35KA , 320 High,Prem 380V, 460V WN 400A / 35KA High,Prem 380V WN 600A / 35KA High,Prem 460V WN 400A / 35KA High 460V WN 400A / 35KA High 460V WN 600A / 35KA F2 (Circuit 2) 150 Standard 380V, 460V WN 250A / 18KA Standard 380V WN 400A / 35KA Standard 460V WN 250A / 18KA Standard 380V WN 400A / 35KA Standard 460V WN 250A / 18KA High,Prem 380V WN 400A / 35KA High,Prem 460V WN 250A / 18KA , 250 High,Prem 380V, 460V WN 400A / 35KA , 300 High,Prem 380V, 460V WN 400A / 35KA , 350 High,Prem 380V WN 600A / 35KA , 350 High,Prem 460V WN 400A / 35KA , 405 High 460V WN 600A / 35KA Handle for 250A Circuit Breaker Handle for 400A and 600A Circuit Breaker Shaft for 250A, 400A and 600A Circuit Breaker Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 57

58 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Units with Multi Point Disconnect and High Short Circuit Current Rating (Code 12 = WH) See previous page for Multi Point Disconnect on units with Standard Short Circuit Current Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number F1 (Circuit 1) 150 Standard 380V, 460V WH 250A / 65KA Standard 380V, 460V WH 250A / 65KA Standard 380V WH 400A / 65KA Standard 460V WH 250A / 65KA , 230 High,Prem 380V WH 400A / 65KA , 230 High,Prem 460V WH 250A / 65KA , 280 High,Prem 380V, 460V WH 400A / 65KA , 320 High,Prem 380V, 460V WH 400A / 65KA High,Prem 380V WH 600A / 65KA High,Prem 460V WH 400A / 65KA High 380V WH 600A / 65KA High 460V WH 400A / 65KA High 460V WH 600A / 65KA F2 (Circuit 2) 150 Standard 380V, 460V WH 250A / 65KA Standard 380V WH 400A / 65KA Standard 460V WH 250A / 65KA Standard 380V WH 400A / 65KA Standard 460V WH 250A / 65KA High,Prem 380V WH 400A / 65KA High,Prem 460V WH 250A / 65KA , 250 High,Prem 380V, 460V WH 400A / 65KA , 300 High,Prem 380V, 460V WH 400A / 65KA , 350 High,Prem 380V WH 600A / 65KA , 350 High,Prem 460V WH 400A / 65KA High 460V WH 600A / 65KA High 460V WH 600A / 65KA Handle for 250A Circuit Breaker Handle for 400A and 600A Circuit Breaker Shaft for 250A, 400A and 600A Circuit Breaker Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 58

59 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Units with Single Point Circuit Breaker and Standard Short Circuit Current Rating (Code 12= PC or DC) See next page for Circuit Breaker on units with High Short Circuit Current Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number F1 (Circuit 1) 150 Standard 380V, 460V PC, DC 250A / 18KA Standard 380V, 460V PC, DC 250A / 18KA Standard 380V PC, DC 400A / 30KA Standard 460V PC, DC 250A / 18KA , 230 High,Prem 380V PC, DC 400A / 30KA , 230 High,Prem 460V PC, DC 250A / 18KA , 280, 300, 320 High,Prem 380V, 460V PC, DC 400A / 30KA High,Prem 380V PC, DC 600A / 35KA High,Prem 460V PC, DC 400A / 30KA High 460V PC, DC 400A / 30KA High 380V, 460V PC, DC 600A / 35KA F2 (Circuit 2) 150 Standard 380V, 460V PC, DC 250A / 18KA , 190 Standard 380V PC, DC 400A / 30KA , 190 Standard 460V PC, DC 250A / 18KA High,Prem 380V PC, DC 400A / 30KA High,Prem 460V PC, DC 250A / 18KA , 250, 280, 300 High,Prem 380V, 460V PC, DC 400A / 30KA , 350 High,Prem 380V PC, DC 600A / 35KA , 350 High,Prem 460V PC, DC 400A / 30KA , 405 High 460V PC, DC 600A / 35KA Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 59

60 Controls Units with VFD Starters (Code 9 = VE or VF) Power Side Units with Single Point Circuit Breaker and High Short Circuit Current Rating (Code 12 = DH) See previous page for Circuit Breaker on units with Standard Short Circuit Current Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number F1 (Circuit 1) 150 Standard 380V, 460V DH 250A / 65KA Standard 380V, 460V DH 250A / 65KA Standard 380V DH 400A / 65KA Standard 460V DH 250A / 65KA , 230 High,Prem 380V DH 400A / 65KA , 230 High,Prem 460V DH 250A / 65KA , 280, 300, 320 High,Prem 380V, 460V DH 400A / 65KA High,Prem 380V DH 600A / 65KA High,Prem 460V DH 400A / 65KA High 460V DH 400A / 65KA High 460V DH 600A / 65KA F2 (Circuit 2) 150 Standard 380V, 460V DH 250A / 65KA Standard 380V DH 400A / 65KA Standard 460V DH 250A / 65KA Standard 380V DH 400A / 65KA Standard 460V DH 250A / 65KA High,Prem 380V DH 400A / 65KA High,Prem 460V DH 250A / 65KA , 250, 280, 300 High,Prem 380V, 460V DH 400A / 65KA , 350 High,Prem 380V DH 600A / 65KA , 350 High,Prem 460V DH 400A / 65KA , 405 High 460V DH 600A / 65KA Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 60

61 Controls Units with VFD Starters (Code 9 = VE or VF) Control Box Exhaust and Intake Fans M12 M10 M11 Sch. Sym. Part Description Part Number Qty M10 Control Box Exhaust Fan Unit sizes , , M10 Control Box Exhaust Fan Unit sizes 250, 280, M11 Control Box Intake Fan Unit sizes 300, 320, M11 Control Box Intake Fan Unit sizes 380, M12 Control Box Exhaust Fan Unit size 405 only Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 61

62 Controls Terminal Box Type A Terminal Plate For more information, see Parts Bulletin PB Ref. Part Part No. Description Number Qty. 50 Motor Terminal Plate per compressor Motor Terminal Plate Gasket per compressor Motor Terminal Bolt, M per compressor Bus Bar per compressor Electrical Barrier per compressor Terminal Box Mounting Screw, M per compressor Type B Terminal Plate For more information, see Parts Bulletin PB P5 P3 50 P4 Ref. Part Part No. Description Number Qty. 50 Motor Terminal Plate per compressor Motor Terminal Plate Gasket per compressor P3 Terminal Plate Insulator per compressor Motor Terminal Bolt, M10 (Starter side) per compressor Lock Washer (Starter side) per compressor P4 Mounting Bolt, M8 (Plate mounting) per compressor P5 Terminal Box Screw, M per compressor Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 62

63 Accessories Units with Wye-Delta or Solid State Starter (Code 9 = WD or SS) Isolator Kits - Rubber-In-Shear Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Unit Std. High Prem. Unit Std. High Prem Size Eff. Eff. Eff. Size Eff. Eff. Eff. Total Total Total Total Total Total Fans Fans Fans Fans Fans Fans Use the chart above to determine the Total # of Fans. Use the chart below to identify the corresponding Isolator Group #. Then, see the last chart for the Complete Kit and component part numbers. Total # of Fans Units with Aluminum Fin Condenser Group # (Code 8 = A, B, E) Units with Copper Fin Condenser Group # (Code 8 = C, F) Complete RIS Isolator Part #s and Quantities Group Kit # Part # Charcoal Lime Brown Brick Red Purple Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 63

64 Accessories Units with Wye-Delta or Solid State Starter (Code 9 = WD or SS) Isolator Kits - Spring Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Unit Std. High Prem. Unit Std. High Prem Size Eff. Eff. Eff. Size Eff. Eff. Eff. Total Total Total Total Total Total Fans Fans Fans Fans Fans Fans Use the chart above to determine the Total # of Fans. Use the chart below to identify the corresponding Isolator Group #. Then, see the last chart for the Complete Kit and component part numbers. Total # of Fans Units with Aluminum Fin Condenser Group # (Code 8 = A, B, E) Units with Copper Fin Condenser Group # (Code 8 = C, F) Complete Spring Isolator Part #s and Quantities Group Kit # Part # Dark Green Dark Purple Red Gray Black White Housing CP Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 64

65 Accessories Units with VFD Starter (Code 9 = VF or VE) Isolator Kits - Rubber-In-Shear Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Unit Std. High Prem. Size Eff. Eff. Eff. Total Total Total Fans Fans Fans Use the chart above to determine the Total # of Fans. Use the chart below to identify the corresponding Isolator Group #. Then, see the last chart for the Complete Kit and component part numbers. Total # of Fans Units with Aluminum Fin Condenser Group # (Code 8 = A, B, E) Units with Copper Fin Condenser Group # (Code 8 = C, F) Complete RIS Isolator Part #s and Quantities Group Kit # Part # Lime Brick Red Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 65

66 Accessories Units with VFD Starter (Code 9 = VF or VE) Isolator Kits - Spring Standard Efficiency: Code 4 = S* High Efficiency: Code 4 = H* Premium Efficiency: Code 4 = P* Unit Std. High Prem. Size Eff. Eff. Eff. Total Total Total Fans Fans Fans Use the chart above to determine the Total # of Fans. Use the chart below to identify the corresponding Isolator Group #. Then, see the last chart for the Complete Kit and component part numbers. Total # of Fans Units with Aluminum Fin Condenser Group # (Code 8 = A, B, E) Units with Copper Fin Condenser Group # (Code 8 = C, F) Complete Spring Isolator Part #s and Quantities Group Kit # Part # Dark Green Dark Purple Black Housing CP Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 66

67 Accessories Flow Switch Description Part No. Flow Switch- Paddle Flow Switch Kit- Electronic Flow Switch Only Cable- Flow Switch Sound Enclosure Kit Description Part No. Sound Enclosure Kit, 2 Circuit (only available on units without VFD Starters) Alarm Bell Description Part No. Alarm Bell Kit Relay, SPDT, 30A, 120VAC Alarm Bell Transformer Inlet Strainer Description Part No. Inlet Strainer, Stainless Steel, Field Kit Standard Eff. units (Code 4 = S*): Sizes 150ADS- 250ADS Sizes 280ADS- 350ADS High Eff. units (Code 4 = H*): Sizes 210ADH- 250ADH Sizes 280ADH- 405ADH Premium Eff. units (Code 4 = P*): Sizes 210ADP- 230ADP Sizes 250ADP- 350ADP Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 67

68 Accessories Field-Installed Fan VFD Kits Description Part No. Field-Installed Fan VFD Kit for units without VFD Starters 208V / 60Hz V / 60HZ V / 60Hz V / 60Hz Field-Installed Fan VFD Kit for units with VFD Starters 400V / 50Hz V / 60Hz High Ambient Exhaust Fan Kit Description Part No. High Ambient Exhaust Fan Kit for units without VFD Starters Rapid Restore Description Part No. Rapid Restore Kit for units without VFD Starters Rapid Restore Kit for units with VFD Starters Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 68

69 Accessories Base and Coil - Grille and Louver Kits Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*, Premium Efficiency: Code 4 = P* Unit Std. High Prem. Size Eff. Eff. Eff. Total Total Total Fans Fans Fans Unit Std. High Prem. Size Eff. Eff. Eff. Total Total Total Fans Fans Fans Base Grille Kits* - Units with Wye-Delta or SS Starter (Code 8 = WD, SS) Total # of Fans Base Grille Kits* - Units with VFD Starter (Code 8 = VF, VE) Total # of Fans * Kit part numbers above include Grilles and hardware. For component details, see earlier pages concerning Coil and Base Frame Grilles and Louvers. Coil Louver Kits** Total # of Fans Base & Coil Louver Kits**- Units with Wye-Delta or SS Starter (Code 8 = WD, SS) Total # of Fans Base & Coil Louver Kits** - Units with VFD Starter (Code 8 = VF, VE) Total # of Fans ** Kit part numbers above include Louvers and hardware. For component details, see earlier pages concerning Coil and Base Frame Grilles and Louvers. Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 69

70 Accessories 650 BACnet MS/TP Communications Module Ref. Description Part Qty. No. Number 650 BACnet MS/TP Kit BACnet with IP/Ethernet Ref. Description Part Qty. No. Number 700 BACnet IP/Ethernet Kit MODBUS Communications Module Ref. Description Part Qty. No. Number 827 MODBUS Installation Kit LonMark Communications Module Ref. Description Part Qty. No. Number 920 LonMark Installation Kit Remote Display Kit 950 Ref. Description Part Qty. No. Number Remote Display Kit Control- Remote Keypad Air Cooled Screw Comp. Chiller, AWS Hz, 2-Ckt, Vint. A Rev. P 05/17 RPL / Page 70