EXIST 54"x64"x3" CONCRETE HOUSEKEEPING PAD. RL RL RL RL RS RS RS RS ROUTE REFRIGERANT PIPING UNDER OVERHANG ABV.

Transcription

1 C ELECTRIC STAIR CONFERENCE PHOTO LAB ROOM RECEIVING MEN PROC. WOMEN EQUIP. REFERENCE C JAN MICROFILM OFFICE OFFICE STAIR C FILE STORAGE WATER METER ROOM C C EXIST 54"x64"x" CONCRETE HOUSEKEEPING PAD. EXIST 54"x64"x" CONCRETE HOUSEKEEPING PAD. CONNECT TO EXIST GAS PIPING ELECTRIC EXISTING PEERLESS BOILER HWS MIXING BOX ELECTRIC CONNECT 6"Ø FLUE TO EXISTING. M.C. TO VERIFY EXISTING FLUE Ø IN FIELD. B- SEE DETAIL "BOILER PIPING SCHEMATIC", SHEET M0 MIXING BOX PATCH EXISTING PENETRATIONS TO MATCH ADJACENT SURFACES & MAINTAIN FIRE RATINGS AS NECESSARY. ROOM HWS FILTER BYPASS DAMPER HEATING COIL RL RL RL RL RL RL RL RL RL RL RL RL RS RS RS RS RS RS RS RS RS RS RS RS DX COIL FAN RL RL RL RL RL RL RS RS RS RS RS RS RL RL RL RL RL RL FILTER RL RS RS RS RS RS RS RS SEE DETAIL "PUMP CONNECTION DETAIL", SHEET M0 ROOM P- M.C. TO FIELD FERIFY EXISTING COIL INFORMATION PRIOR TO ORDERING HWS BYPASS DAMPER HEATING COIL DX COIL FAN RL RS DX- RL RL RL RS RS RS RECEIVING RL RL RL RL RS RS RS RS RECEIVING & M0 PROC. CU- RL RS RL RS PROC. EXIST 74"x49"x" CONCRETE HOUSEKEEPING PAD. EXIST. TRANE CONDENSING UNIT ROUTE REFRIGERANT PIPING UNDER OVERHANG ABV. MEN WOMEN EXTEND HOUSEKEEPING PAD AS REQUIRED. MATCH EXISTING HOUSEKEEPING PAD ELEVATION. MEN WOMEN STAIR STAIR Copyright 05 Design Arhiteture, PC All Rights Reserved

2 EXIST. LOUVERS DEMO PNEUMATIC OSA VOLUME DAMPER DEMO PNEUMATIC RA VOLUME DAMPER M EXIST. FILTERS REPLACE CHW COIL (TYP OF STACKED) MCD- REPLACE ALL AIR FILTERS EXIST STEAM COILS STAIR D REPLACE CHW COIL (TYP OF STACKED) STAIR D EXIST. AHU # CHECK & INSPECT EXISTING FAN FOR WEAR & DEFECTS DEMO INLET GUIDE VANES (BOTH SIDES) 64x47 SA UP DEMO COOLING COILS & DRAIN PANS DEMO MOTOR, MOTOR SHEAVE FAN SHEAVE, AND BELTS EXIST 64.65x.5 RA EXIST 89x80.5 PAD DEMO AHU # M.C. TO FABRICATE & REPLACE ALL DRAIN PANS. SEE DETAIL, DWG. M0 FOR DETAILS. TRANE AIRFOIL FAN M/N: CF-44-A--DW--CCW-UB-S-H RPM: 96 REPLACE: SHAFT: 85-/4" x -7/6" Ø KEYWAY: 7/8" X 7/6" X 7-/4" SHEAVE: 4MVC80R BUSHING: R- X -7/6 V-BELT: (4) CX8 MS CWS CWS CWS CWS CWS CWS CW- CW- CWS CWS CWS CWS CWS CWS CWS CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR 9-/8" FROM BEARING FACE TO END OF SHAFT REPLACE: 75 HP VFD-RATED MOTOR RPM: 750 FRAME: 65T SHAFT: -/8" 460//60 VOLT SHEAVE: 4MVP85C07Q BUSHING: Q- X -/8 : P ENCL: DP CODE: G CWR CWR CWR CWR CWR PROVIDE & INSTALL CWS BUFFER TANK TACO M/N: BTH0450F-5N INSULATE TANK IN FIELD. CWR CWR CWR CWR CWR CWR CWR CWR CWS CWS CWS CWS DEMO EXISTING WATER-COOLED CONDENSING UNITS # & # EXIST. 96"x48" PAD EXIST 6x68 OA M.C. TO DETERMINE IF EXIST SHAFT IS WITHIN TOLERANCE. DEMO PILLOW BLOCK BEARINGS NOTE: SEE DWG'S M05 THRU M07 FOR ADDITIONAL WORK TO BE COMPLETED IN THIS AREA. MOUNT PUMPS ON EXISTING HOUSEKEEPING PAD. EXTEND HOUSEKEEPING PAD AS NECESSARY. VERIFY IN FIELD. CH- P- CWR CWR CWR CWR P- PROVIDE SKIDMORE X-POT WATER TREATMENT SYSTEM. MFG MODEL # CWR PROVIDE AIR SEPARATOR & EXPANSION TANK. SEE DETAILS & SCHEDULES CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CTR CTR CTR CTS CTS CTS HEAVY-DUTY PILLOW BLOCK BEARINGS. (ABMA L0 = 80,000 HOURS) CTR CTS EXTEND HOUSEKEEPING PAD AS REQUIRED. MATCH EXISTING HOUSEKEEPING PAD ELEVATION. EXISTING CONDENSER WATER SUPPLY. VERIFY LOCATION & SIZE IN FIELD. EXISTING CONDENSER WATER RETURN. VERIFY LOCATION & SIZE IN FIELD. & M0 DEMO EXIST BAROMETRIC DAMPERS REPLACE 48x5 BAROMETRIC DAMPERS STAIR B STAIR B EF- EF- DEMO EXIST BUILDING PRESSURE EQUALIZATION FANS BUILDING PRESSURE EQUALIZATION FANS NOTE: M.C. TO FIELD VERIFY ALL PART DIMENSIONS & SIZES PRIOR TO ORDERING AND INSTALLATION. NOTE: M.C. TO STEAM CLEAN AHU & STEAM COILS. Copyright 05 Design Arhiteture, PC All Rights Reserved

3 MCD-4 HVAC EXIST. AHU # DEMO MOTOR, MOTOR SHEAVE FAN SHEAVE, AND BELTS DEMO PNEUMATIC RA VOLUME DAMPER DEMO EXISTING WATER-COOLED CONDENSING UNIT #4 EXIST. 4"x08" PAD DEMO MOTORIZED DISCHARGE DAMPER 8'-0" X 4'-0.7 DEMO INLET GUIDE VANES (BOTH SIDES) DEMO PILLOW BLOCK BEARINGS DEMO PNEUMATIC OA VOLUME DAMPER EXIST. FILTER RACK DEMO COOLING COILS & DRAIN PANS EXIST. 4"x08" PAD DEMO EXISTING WATER-COOLED CONDENSING UNIT # M.C. TO DETERMINE IF EXIST SHAFT IS WITHIN TOLERANCE. CHECK & INSPECT EXISTING FAN FOR WEAR & DEFECTS PROVIDE & INSTALL CWS BUFFER TANK TACO M/N: BTH000F-5N INSULATE TANK IN FIELD. REPLACE CHW COIL (TYP OF STACKED) PROVIDE AIR SEPARATOR & EXPANSION TANK. SEE DETAILS & SCHEDULES PROVIDE SKIDMORE X-POT WATER TREATMENT SYSTEM. MFG MODEL # MOUNT PUMPS ON EXISTING HOUSEKEEPING PAD. EXTEND HOUSEKEEPING PAD AS NECESSARY. VERIFY IN FIELD. REPLACE: 75 HP VFD-RATED MOTOR RPM: 750 FRAME: 65T SHAFT: -/8" 460//60 VOLT SHEAVE: 4MVP85C07Q BUSHING: Q- X -/8 : P ENCL: DP CODE: G CWR CWR CWR CWR P-4 P-5 CWR CWR CWR CWR CWR CWR CWR HVAC CW- HEAVY-DUTY PILLOW BLOCK BEARINGS. (ABMA L0 = 80,000 HOURS) 64.5x47.5 CW- CWS CWS CWS CWS CWS CWS CWS CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR REPLACE: SHAFT: 85-/4" x -7/6" Ø KEYWAY: 7/8" X 7/6" X 7-/4" SHEAVE: 4MVC80R BUSHING: R- X -7/6 V-BELT: (4) CX0 MS 9-/8" FROM BEARING FACE TO END OF SHAFT PROVIDE & INSTALL NEW MOTORIZED CONTROL DAMPER 8'-0" X 4'-0.7 CWS MCD- CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR CWR EXISTING CONDENSER WATER SUPPLY. VERIFY LOCATION & SIZE IN FIELD. EXISTING CONDENSER WATER RETURN. VERIFY LOCATION & SIZE IN FIELD. 6" CWS CWS CWS CWS CWS CWS CWS REPLACE ALL AIR FILTERS REPLACE CHW COIL (TYP OF STACKED) M.C. TO FABRICATE & REPLACE ALL DRAIN PANS. SEE DETAIL, DWG. M0 FOR DETAILS. CH- CWS TRANE AIRFOIL FAN M/N: CF-44-A--DW--CW-TH-S-H RPM: 96 EXTEND HOUSEKEEPING PAD AS REQUIRED. MATCH EXISTING HOUSEKEEPING PAD ELEVATION. M0 DEMO EXIST BUILDING PRESSURE EQUALIZATION FANS EF- SHOWN IN THIS AREA IS LOCATED ABV. MECH. ROOM ROOF LINE. EF- SHOWN IN THIS AREA IS LOCATED ABV. MECH. ROOM ROOF LINE. # DEMO EXISTING 48x48 BAROMETRIC DAMPERS # REPLACE 48x48 BAROMETRIC DAMPERS EXIST. LOUVER EF- EF- LOBBY EXIST 04x8 RA FROM BELOW LOBBY NOTE: M.C. TO FIELD VERIFY ALL PART DIMENSIONS & SIZES PRIOR TO ORDERING AND INSTALLATION. NOTE: M.C. TO STEAM CLEAN AHU Copyright 05 Design Arhiteture, PC All Rights Reserved

4 EF- 'x0' REMOVEABLE WALL TO BE REMOVED AND RECONSTRUCTED AFTER INSTALLATION OF NEW FAN. 'x0' REMOVEABLE WALL TO BE REMOVED AND RECONSTRUCTED AFTER INSTALLATION OF NEW FAN. 8.5x66.5 DUCT THRU WALL. TERMINATE W/ BIRDSCREEN. EXIST LOUVER TO REMAIN. DEMO DUCT WORK CONNECTING TO LOUVER EXIST. 0"x94" PAD DEMO EXIST TRANE CONDENSER M04 & M x0 DEMO EXIST DUCT 60x4 NOTE: DEMO REFRIGERATION PIPING AND PATCH WALL PENETRATIONS TO MATCH ADJACENT SURFACES & MAINTAIN FIRE RATINGS AS NECESSARY. Copyright 05 Design Arhiteture, PC All Rights Reserved

5 SEE /M07 & /M07 FOR ENLARGED VIEWS 0x 8x6 MAINTENANCE (OLD MAGISTRATE) 6x DEMO EXIST AHU- RA 8x x x8 RA 0x8 SA LUNCH ROOM 0x4 0x4 x M 50x4 UP AHU- 60x4 MAIL/MICROFILM 8x8 8x8 0x0 AHU- 50x4 SA AHU- 00x8 RA STAIR B 50x DN W TRASH ROOM x STAIR A PLANS ROOM EXIST RA DAMPERS ELEV. 54x40 SA RISER UP 8x 8x 8x EXIST VAV BOX ELEV. ELEV. WOMEN'S LOCKER 0x8 6x 6x x 79x44 RA RISER UP M06 LOADING DOCK x x COMMUNICATION CENTER PURCHASING 4x ELECTRICAL TELEPHONE x 6x 8x8 0x8 4x 4x 4x EXIST VAV BOX EXIST VAV BOX 0x4 0x6 COMMUNICATION CENTER x HOLDING CELL Copyright 05 Design Arhiteture, PC All Rights Reserved

6 NO DOCUMENTATION FOR SYSTEMS & DUCT WORK, THIS AREA. M.C. TO FIELD VERIFY LOCATIONS & SHOWN. SEE /M07 & /M07 FOR ENLARGED VIEWS 40 CFM 0"Ø NK 40 CFM 0"Ø NK 0x 5 CFM 0"Ø NK 40 CFM 0"Ø NK MAIL/MICROFILM 0 CFM 0 CFM 8x8 8x 6x 0 CFM 8x8 x x MAINTENANCE (OLD MAGISTRATE) 5 CFM 0 CFM 00 CFM T 0 CFM T AC- 0x0 CAP EXIST. DUCT & SEAL AIR TIGHT AC- 5 CFM 8"Ø NK 0x4 00 CFM T W AC- M CAP EXIST. DUCT & SEAL AIR TIGHT 85 CFM FULL-SIZE OPEN END LINED RA IN PLENUM ABV. TERMINATE W/ BIRD SCREEN. LUNCH ROOM 0x4 AHU- 50x4 SA 50x4 UP AHU- 00x8 RA STAIR B 50x DN AHU- 60x4 SA 0x8 TRASH ROOM x STAIR A 0 CFM 00 CFM "Ø NK NURSE STATION ELEV. 54x40 SA RISER UP 79x44 RA RISER UP 8x 8x ELEV. ELEV. 0 CFM LOADING DOCK x 6x x 6x PURCHASING 4x x FULL-SIZE OPEN END LINED RA IN PLENUM ABV. TERMINATE W/ BIRD SCREEN. 0 CFM COMMUNICATION CENTER 0 CFM AC- 8"Ø 0 CFM T AC-4 8x6 4"Ø T 0x4 WOMEN'S LOCKER 0 CFM 0x6 0x8 M07 0 CFM 5 CFM 8"Ø NK 0 CFM CAP EXIST. DUCT & SEAL AIR TIGHT COMMUNICATION CENTER 8"Ø CAP EXIST. DUCT & SEAL AIR TIGHT ELECTRICAL TELEPHONE x 6x 4x 4x 0 CFM 8x8 4x 0 CFM 0x8 6x0 TRANSFER DUCT. TERMINATE OPEN-ENDED IN PLENUM ABV AC- 0 CFM FULL-SIZE OPEN END LINED RA IN PLENUM ABV. TERMINATE W/ BIRD SCREEN. x 6x0 RG- NOTE: THE SPACE BETWEEN THE SUSPENDED CEILING AND UNDER SIDE OF THE TRUSSES IS TO BE USED AS A RETURN AIR PLENUM. NO MATERIALS ARE PERMITTED WITHIN THIS SPACE WHICH DO NOT COMPLY WITH THE RETURN AIR PLENUM CODES. T NOTE: M.C. TO FIELD VERIFY ALL EXISTING DUCTWORK AND CONDITIONS IN THE FIELD. SR- 50 CFM 0"Ø NK HOLDING CELL SR- 50 CFM 0"Ø NK NOTE: M.C. TO PROVIDE CONDENSATE PIPING FOR EACH AC-, AC-, AC-, & AC-4 FAN COIL. ROUTE CONDENSATE PIPING TO CODE APPROVED RECEPTOR. Copyright 05 Design Arhiteture, PC All Rights Reserved

7 AHU- 8x6 RA ABV. EXIST 6x6 OSA DUCT TO REMAIN DEMO 8x6 RA DUCT DEMO EXIST AHU- RA STAIR D 6X6 STAIR D EXIST 6x6 OSA DUCT DEMO OSA DUCT FROM AHU- TO ELBOW x8 CONNECT EXIST OSA DUCT TO EXIST SA DUCT IN LOCATIONS SHOWN AHU- 0x8 0x8 BC- 8x6 DEMO AHU # AHU- 0x4 0x4 UP AHU- 64.5x44 SA 0x4 DN AHU- 0x6 SA EXIST 89x80.5 PAD AHU- 0x4 0x4 UP AHU- 64.5x44 SA 0x4 DN 0x6 & M07 M07 NOTE: EXTEND GAURDRAIL AND BOLLARDS FROM NEARBY LIEBERT UNITS TO PROTECT VRF- VRF OUTDOOR UNITS TO BE DUCTED THRU WALL. TRANSITION TO EXISTING LOUVER. 4 EXISTING FIRE PROTECTION PIPING AT CEILING TO BE REMOVED & RE-ROUTED AROUND NEW VRF-. VRF- NEW FIRE PROTECTION PIPING Copyright 05 Design Arhiteture, PC All Rights Reserved

8 DATE: 5/4/08 0: AM MOD. BY: JONATHAN & M07 M07 PC 00 Oxford Drive Suite 0 Monroeville, PA 546 NOTE: EXISTING DOCUMENTATION, THIS SHEET, FOR REFERENCE ONLY. DRAWINGS ON THIS SHEET. Copyright 05 Design Arhiteture, PC All Rights Reserved TEL (4) 7-0 FAX (4) DWG. NAME: P:\07 CURRENT\0769 WESTMORELAND CTY MISC PROJECTS\69-M0-M05 4

9 B- NOTES: WEIL-MCLAIN LGB--W-N-7WC ELECTRIC (V/PH/HZ) FUEL MINIMUM COMBUSTION EFF. (AFUE %) INPUT MAX (MBH). M.C. TO PROVIDE MCDONNEL-MILLER #6 LWCO WITH MANUAL RESET.. BOILER TO BE ASSEMBLED ON SITE BY M.C. INPUT MIN (MBH) MAX INPUT (MBH) EWT LWT MAX 0 F ΔT (GPM) NAT. 0//60 8.0,00,00, GAS FLUE DIAMETER (IN.) 6 SEE NOTES x0 DUCT SIZE (FIRST FIGURE IS SIZE SHOWN) FLEXIBLE CONNECTION EXISTING DUCT TO BE DEMOLISHED SPACE ABOVE CEILING WILL BE CRITICAL TO COORDINATE DUCTWORK AND PIPING WITH UTILITIES AND OTHER TRADES. FIELD VERIFY FOR CLEARANCE BEFORE INSTALLATION. COORDINATE FINAL LOCATION OF DIFFUSERS AND GRILLES WITH LIGHTING PLAN. VERIFY ALL REFRIGERANT PIPE SIZES WITH. ALL POWER WIRING BY ELECTRICAL CONTRACTOR. TACO P- B- FM BCAL0 PUMP BASE-MOUNT END SUCTION WATER TEMP GPM TDH (FT.) RPM HP V/PH/HZ //60 SEE NOTES AND DETAILS. EXISTING DUCT FLEXIBLE DUCT & DAMPER. SAME SIZE AS CD NK ALL CONTROL WIRING BY HEATING CONTRACTOR. DRAWINGS ARE DIAGRAMMATIC, CONTRACTOR TO FIELD VERIFY ALL DUCT ROUTING. ADDITIONAL OFFSETS TO BE EXPECTED. P- TACO CH- BASE-MOUNT END SUCTION //60 SEE NOTES AND DETAILS. P- TACO CH- BASE-MOUNT END SUCTION //60 SEE NOTES AND DETAILS. P-4 TACO CH- BASE-MOUNT END SUCTION //60 SEE NOTES AND DETAILS. DUCT TRANSITION ALL DUCT & PIPING THROUGH RATED WALLS & FLOORS TO HAVE SLEEVES, FIRE DAMPERS AND FIRE SAFED. HEATING CONTRACTOR TO VERIFY ALL POWER REQUIREME WITH THE ELECTRICAL CONTRACTOR. P-5 NOTES: TACO CH- BASE-MOUNT END SUCTION //60 SEE NOTES AND DETAILS.. COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH E.C. & BUILDING AUTOMATION & CONTROL SYSTEM CONTRACTORS.. MOTORS/STARTERS FURNISHED BY CONTRACTOR. TURNING VANES ELBOW, TURNED DOWN ALL DUCTWORK DIMENSIONS INDICATED ON DRAWINGS ARE FREE INSIDE DIMENSIONS. HVAC LOUVERS PROVIDED BY HEATING CONTRACTOR, LOUVER COLOR TO BE AS SPECIFIED BY THE ARCHITECT. CU- DX- TRANE TTA044C NOM. TONS COND. FAN # / # REFRIG. CIRCUITS / # COMP. 0 / PROP / // NOTES:. COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH E.C. M.C. SHALL FURNISH ALL MOTOR CONTROLLERS/STARTERS.. PROVIDE STARTER AND DISCONNECT.. PROVIDE DX EVAPORATOR COIL TO MATCH CU CAPACITY. EAT MCA MOCP V/PH/HZ EER OP. WT. (LBS.) SEE NOTES RL RS MVD ELBOW, TURNED UP REFRIGERATE LIQUID REFRIGERATE SUCTION MANUAL VOLUME DAMPER CEILING EXHAUST FAN. ALL DUCT RUNOUTS TO DIFFUSERS TO BE INSTALLED WITH MANUAL DAMPERS WITH LOCKING QUADRA. MAXIMUM LENGTH OF FLEXIBLE DUCT = 5'-0". FLEX SIZE = CD NECK SIZE.. THE HEATING CONTRACTOR SHALL FURNISH ALL MOTOR STARTERS AS REQUIRED. 4. THE HEATING CONTRACTOR SHALL FURNISH AND INSTALL ALL CONCRETE BASES AND MISCELLANEOUS SUPPORTING STEEL FOR EACH ITEM OF. 5. THE CONTRACTOR SHALL EXECUTE THE WORK IN STRICT ACCORDANCE WITH THE SPECIFICATION AND DRAWINGS. WHERE WORK IS SHOWN ON THE DRAWING AND NOT SPECIFIED OR SPECIFIED AND NOT SHOWN ON DRAWING, THE CONTRACTOR SHALL PROVIDE ALL SUCH WORK. DX- CU- SFI REFRIG. R-40A CFM 50 CAPACITY (MBH) TOTAL 9.7 EAT 60 4 NOTES:. COIL IS TO BE UNCASED. ALL COIL INFORMATION TO BE VERIFIED IN FIELD & W/ MFG PRIOR TO ORDERING. DX- CAPACITY TO MATCH CU-. SENS. 0. DB WB DB LAT WB WIDTH SIZE (IN.) HEIGHT ΔP (IN. W.G.) 0.5 ROWS 4 FPI N/A SEE NOTES CEILING DIFFUSER RETURN AIR GRILLE SUPPLY AIR DUCT IN THE EVENT OF A CONFLICT BETWEEN THE SPECIFICATIONS AND DRAWINGS, THE MORE STRINGENT CONDITION SHALL APPLY. SEE SPECIFICATION SECTION 5500 FOR ADDITIONAL REQUIREME AND INFORMATION. MAINTAIN PROPER CLEARANCES AS RECOMMENDED BY THE & ALL INDUSTRY STANDARDS. NO COMBUSTIBLE MATERIALS ALLOWED WITHIN THE RETURN AIR PLENUM INCLUDING PVC PIPING. REFER TO IMC 009 SECTION 60.9 FOR JOI, SEAMS & CONNECTIONS. CH- CH- NOTES: CW- EF- NOTES: M MCD- MCD- MCD-4 AHU- AHU-. PROVIDE SUCTION VALVES, Y-DELTA STARTER, & NON-FUSED DISCONNECT.. M.C. TO COORDINATE MOTOR CONTROLS/STARTERS WITH E.C.. MOTORS/STARTERS FURNISHED BY M.C.. UPPER PARKING GARAGE PAUL'S FANS 600 CENT CW DIDW TH AIRFOIL CFM OUTLET VELOCITY (FPM) ESP (IN. W.C.). COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH E.C.. M.C. SHALL FURNISH ALL MOTOR CONTROLLERS/STARTERS & NON-FUSED DISCONNECT.. MOTOR IS TO BE VFD RATED. 4. WALL MOUNTED VFD TO BE PROVIDED BY M.C. AHU- AHU- AHU- AHU- CARRIER 0HXC6RZ-6-KA CARRIER 0HXC6RZ-6-KA NOTES:. COIL IS TO BE UNCASED EF- QTY QTY AHU- AHU- NOM. TONS BUILDING PRESSURE RELIEF DESCRIPTION OUTSIDE AIR DAMPER OUTSIDE AIR DAMPER RETURN AIR DAMPER RETURN AIR DAMPER ACTUAL TONS EVAP. FOULING FACTOR GREENHECK VCD-4 GREENHECK VCD-4 GREENHECK VCD-4 GREENHECK VCD-4 COND. FOULING FACTOR BHP RPM MOTOR DATA HP RPM VOLT/PH/HZ ENCLOSURE FRAME 79,750, BELT //60 ODP 84-T FRAME SIZE 0x4 46x0 44x0 8x8 EVAPORATOR (FRESH WATER) GPM EWT LWT ΔP (FT.) FPS FRAME GALVANIZED CHANNEL GALVANIZED CHANNEL GALVANIZED CHANNEL GALVANIZED CHANNEL BLADE EXTRUDED ALUMINUM AIRFOIL EXTRUDED ALUMINUM AIRFOIL EXTRUDED ALUMINUM AIRFOIL EXTRUDED ALUMINUM AIRFOIL CONDENSER (0% PROPYLENE GLYCOL) GPM EWT LWT ΔP (PSI) R-4a // ,500 SEE NOTES AXLE MATERIAL LINKAGE MATERIAL 04 SS 04 SS 04 SS 04 SS STEEL STEEL STEEL STEEL FPS R-4a // ,500 SEE NOTES REFRIG. CFM CAPACITY (MBH) TOTAL SENS. DB EAT WB LAT WIDTH SIZE (IN.) HEIGHT ΔP (FT. HD.) SFI WATER 0, GREENHECK SCE-48-6-C75 DB WB ROWS FPI # COMP. REFRIG. SEE NOTES COMP. INPUT (kw) REPLACES EXIST. STACKED OSA DAMPERS. REPLACES EXIST. STACKED OSA DAMPERS. MIN. LOAD CONTROL (%) SEE NOTES & PROP 6,000, DIRECT //60 ODP SEE NOTES,,, & 4 BUILDING GREENHECK EF- PROP 6,000, DIRECT //60 ODP SEE NOTES,, & PRESSURE RELIEF SCE-48-6-C75 DRIVE CAPACITY CONTROL STEPS VOLT/PH/HZ MCA MOCP IPLV (kw/ton) OPER. WEIGHT (LBS.) T S SD RETURN AIR DUCT EXHAUST AIR DUCT OR REGISTER THERMOSTAT TEMPERATURE SENSOR FLOW DIRECTION FIRE DAMPER SMOKE DETECTOR POINT OF CONNECTION TO EXISTING BALANCE VALVE -WAY CONTROL VALVE DIFFERENTIAL PRESSURE CONTROL VALVE PUMP BALL VALVE APPROVED BACKFLOW PREVENTOR PRESSURE REDUCING VALVE STRAINER ABV AFF BDD B.O.D. ABOVE ABOVE FINISHED FLOOR BACKDRAFT DAMPER BOTTOM OF DUCT CEILING DIFFUSER CD CFM CUBIC FEET PER MINUTE CHW CHILLED WATER CU CONDENSING UNIT CWR CHILLED WATER RETURN CWS CHILLED WATER SUPPLY DB DRY BULB DIA DN. DWG DIAMETER DOWN DRAWING EA EAT EACH ENTERING AIR TEMPERATURE E.C. ELECTRICAL CONTR. EF ESP EWH EXHAUST FAN EXTERNAL STATIC PRESSURE ELECTRIC WALL HEATER EXIST F EXISTING FURNACE FD FIRE DAMPER FLEX FLEXIBLE G.C. H.C. GENERAL CONTRACTOR HEATING CONTRACTOR HP HZ HORSEPOWER HERTZ IN. INCHES L LAT LBS MAX LOUVER LEAVING AIR TEMPERATURE POUNDS MAXIMUM MBH 000 BRITISH THERMAL UNITS M.C. CONTRACTOR MCD MOTORIZED CONTROL DAMPER MVD MANUAL VOLUME DAMPER NK NECK OBD OPPOSED BLADE DAMPER OPER OSA P.C. OPERATING OUTSIDE AIR PLUMBING CONTRACTOR P.D. PRESS DROP PH PHASE R/A RG RTU RETURN AIR RETURN GRILLE ROOFTOP UNIT S/A SD SENS SUPPLY AIR SMOKE DETECTOR SENSIBLE SR SUPPLY REGISTER TYP. TYPICAL W/ WITH WB W.G. WT WET BULB WATER GAUGE WEIGHT Copyright 05 Design Arhiteture, PC All Rights Reserved

10 VRF- AC- THRU AC-4 MITSUBISHI PURY-P44YKMU-A OUTDOOR UNIT QTY. COMPRESSOR # / / SCROLL REFRIG. SUMMER COOLING (MBH) EAT ( F DB) WINTER HEATING (MBH) EAT ( F WB) OUTDOOR UNIT QTY/SYSTEM MCA MOCP (PER UNIT) (PER UNIT) VOLT/PH/HZ IEER/EER HEATING 47 F OPER. WEIGHT (LBS.) R-40A //60 0.9/.7.8,00 SEE NOTES NOTE : COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH ELECTRICAL CONTRACTOR. CONTRACTOR SHALL FURNISH ALL MOTOR CONTROLLERS/STARTERS. AC- QTY MITSUBISHI PEFY-P6NMAU-E EQUIP. DUCTED FAN COIL SUPPLY FAN CFM ESP (IN. W.C.) CAPACITY (MBH) EAT F SENS. COOLING TOTAL DB WB HEATING CAPACITY (MBH) EAT F (DB) REFRIGERANT ELECTRICAL DATA VOLT/PH/HZ MCA MOCP R-40A 08// SEE NOTES AC- MITSUBISHI PEFY-P4NMAU-E DUCTED FAN COIL R-40A 08// SEE NOTES AC- MITSUBISHI PEFY-P08NMAU-E DUCTED FAN COIL R-40A 08// SEE NOTES AC-4 MITSUBISHI PEFY-P06NMAU-E DUCTED FAN COIL R-40A 08// SEE NOTES NOTE : COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH ELECTRICAL CONTRACTOR. CONTRACTOR SHALL FURNISH ALL MOTOR CONTROLLERS/STARTERS. : PROVIDE FILTER, SPEED MOTOR, LOW AMBIENT COMPRESSOR CONTROL, THERMOSTAT, LINE SETS, INTERNAL CONDENSATE PUMP, DISCONNECT/STARTER & MOUNTING BRACKET. QTY CFM MIN. OSA CFM CAPACITY (MBH) SENS. TOTAL CHILLED WATER COIL EWT LWT GPM ΔP (FT. HD.) COIL ROWS SENSIBLE CAPACITY (MBH) HOT WATER COIL EWT LWT GPM ΔP (FT. HD.) ROWS MOTOR SPEEDS ELECTRICAL DATA V/HZ/PH INPUT (WATTS) DIMENSIONS LENGTH DEPTH HEIGHT FCU- 5 CARRIER 4VBC-04E // SEE NOTES FCU- CARRIER 4VBC-06E // SEE NOTES FCU- 7 CARRIER 4VBC-08E // SEE NOTES FCU-4 7 CARRIER 4VBC-0E // SEE NOTES FCU-5 7 CARRIER 4VBC-E // SEE NOTES NOTE : COORDINATE REQUIREME FOR MOTOR CONTROLLERS/STARTERS WITH ELECTRICAL CONTRACTOR. CONTRACTOR SHALL FURNISH ALL MOTOR CONTROLLERS/STARTERS. NOTE : DISCONNECT AND RECONNECT POWER TO FAN COIL UNIT FROM EXISTING POWER SOURCE TO EXISTING FAN COIL UNIT. NOTE : REPLACE ISOLATION VALVES FOR FAN COIL UNITS. MIN. RELIEF ACCEPT. MIN. MFR. & SIZE WT. MODEL # LOCATION PRECHG. VALVE VOL. GAL. L. DIA. (IN) (IN) P.S.I. PRESS. (GAL.) (LBS.) CAP. ET- AS- BELL & GOSSETT D-XXX BELL & GOSSETT R-5 ROOM ROOM COOLING SYSTEM COOLING SYSTEM DESCRIPTION MODEL # FRAME SIZE FRAME OBD NOTE: ALL COURTROOM UNITS TO BE FACTORY PAINTED/FINISHED TO MATCH EXISTING UNITS SR- SUPPLY REGISTER PRICE 60 SURFACE YES SEE DRAWING FOR NECK SIZE RG- RETURN GRILLE PRICE 60 SURFACE NO SEE DRAWING FOR NECK SIZE Copyright 05 Design Arhiteture, PC All Rights Reserved

11 EXPANSION VALVE REVERSE ACTING DX COIL FLEX CONNECTION " X GAUGE BAND EYE SCREW AUTO AIR VENT PIPE TO DRAIN -WAY TEMPERATURE CONTROL VALVE B&G CIRCUIT SETTER PETE'S PLUG SIGHT GLASS FILTER DRIER FLEXIBLE DUCT. FLEX SIZE SAME AS NECK SIZE. (MAX LENGTH = 5'-0") # WIRE CEILING DIFFUSER SEE PLANS AND SCHEDULE. COOLING COIL NO INDIRECT WASTE APPOLLO BALL VALVE TO DRAIN CHR CHS OIL TRAP TO DRAIN PIPE SLEEVES RL RS CONDENSING UNIT MINIMUM RADIUS EQUAL TO ONE DUCT DIAMETER CONNECT FLEXIBLE DUCT TO COLLAR WITH GAUGE CLAMP AND FOUR SHEET METAL SCREWS AND SEAL WITH DUCT TAPE CEILING CW MAKE-UP SEE PLUMB. PLANS FOR SIZE REDUCED PRESS. BACKFLOW PREVENTER CWS PRESSURE REDUCING VALVE (5-75 PSI) 75 PSI PRESS. RELIEF VALVE AUTO AIR VENT P PRESS. TO PSI BLADDER TANK-SEE PLANS FOR SIZE PIPE HANGERS (SPRING & NEOPRENE ) ISOLATION VALVE FROM SYSTEM TANK SADDLES TO SYSTEM STAINLESS STEEL BRAIDED CONNECTOR SPRING VIBRATION ISOLATOR AIR SEPARATOR RETURN SIDE OF HEAT / COOLING SYSTEM MOUNT TO RUN VENT DRAIN TO STRUCTURE W/ NEAREST F.S. (TYP.) SLOTTED CHANNEL & /" DIA. ALL REMOVABLE STRAINER THREAD ROD TO SUCTION SIDE OF PUMP SUPPORT WITH ALL THREAD ROD & CLEVIS HANGER OR ANGLE IRON FLOOR STAND STAINLESS STEEL BRAIDED CONNECTOR (INCREASER WHERE REQ'D.) MULTIPORT PRESSURE INDICATOR (4-PORT) OSHA/ANSI COUPLER GUARD BASE MOUNTED END SUCTION PUMP (LONG COUPLED) GROUTABLE FABRICATED STEEL BASE PLATE FINISH FLOOR Trerie TRIPLE DUTY VALVE (SIZED FOR - PSI P.D. AT THE DESIGN FLOW RATE) 9" INDUSTRIAL THERMOMETER W/ /4" NPT COPPER WELL /4" O.D. COPPER TUBING W/ COMP. FITTINGS SUCTION DIFFUSER WITH STRAINER FIELD FABRICATED SUPPORT LEG DRAIN: TERMINATE NEAR F.D. " HIGH CONCRETE HOUSE KEEPING PAD CHS & CHR BUTTERFLY OR GATE VALVE TEMP. GUAGE (TYP.) MOTORIZED VALVE NON-SLAM CHECK VALVE M H.B. '-0" MIN. FS CWS & CWR (SEE PLAN FOR CONT.) BUTTERFLY OR GATE VALVE (TYP.) TEMP. GUAGE (TYP.) NON-SLAM CHECK VALVE FLEX CONNECTION (TYP.) CONDENSER FLOW SWITCH (TYP.) FS CHS EVAPORATOR CHR CONNECT FLEXIBLE DUCT TO COLLAR WITH GAUGE "C" CLAMP.4 SHEET METAL SCREWS & SEAL WITH DUCT TAPE BRANCH DUCT, SEE PLANS FOR SIZE. 0 BRANCH DUCT, SEE PLANS FOR SIZE. FLEX CONNECTION (TYP.) FLEXMASTER STOD FITTING WITH DAMPER MAIN DUCT MAIN DUCT W W 4 MIN. AIR FLOW AIR FLOW FLEXMASTER STOD FITTING WITH DAMPER Copyright 05 Design Arhiteture, PC All Rights Reserved

12 PRESSURE RELIEF VALVE PIPE TO DRAIN BOILER NOTE: FOR ALL PIPE SIZES, SEE PLANS. PRESSURE REGULATOR AND CHECK VALVE AIR-X-TANK D PIPE HANGERS AIR VENT TEMPERATURE AND PRESSURE GUAGE GATE VALVE: OPEN TO PURGE GATE VALVE: CLOSE TO PURGE PRESSURE GAGE BALL VALVES BOILER PUMP BALANCING VALVE POT FEEDER DRAIN VALVE: OPEN WHEN PURGING OR TO DRAIN. MAKEUP WATER FROM BACKFLOW PREVENTER FLOW IN CHECK VALVE RETURN LINE STRAINER FLEX CONNECTION 6' " '-5 6 " 6'-7" 8" 6'-7" '- 5 6 " "Ø NIPPLE WELDED IN FLANGE OF PAN. 8'- 8 " 4" 6'-7" '- 8 " EQUAL EQUAL /4"Ø NIPPLE WELDED IN BOT. OF EACH DRAIN PAN Mitsubishi Eletri Diamond System Builder Copyright 05 Design Arhiteture, PC All Rights Reserved

13 VRF- ML-, STAIR D DISCONNECT EXISTING FAN MOTOR POWER, AND RECONNECT TO NEW. EXISTING FEEDER TO REMAIN. EF- MAINTENANCE (OLD MAGISTRATE) ML-5,7 AC- LUNCH ROOM AC- CH- MH-7,9, MH-,,5 AC- NEW PANEL MH M P- P- ML-7,9 NEW PANEL MH-7,9, ML W EF- EF- STAIR B STAIR A DISCONNECT EXISTING FAN MOTOR POWER, AND RECONNECT TO NEW. EXISTING FEEDER TO REMAIN. ELEV. NURSE STATION 50 KCMIL THHN AND #4 THHN GROUND IN " CONDUIT 4 # THHN AND #8 THHN GROUND IN /" CONDUIT ELEV. ELEV. EXISTING 00A FUSED BUSS PLUG FOR CHILLER - REPLACE WITH 00A FUSED BUSS PLUG TO FEED NEW PANEL EXISTING 600A 480/77 BUSS ML-, EXISTING 600A 480/77 BUSS COMMUNICATION CENTER ML-9, AC-4 PURCHASING EXISTING 00A FUSED BUS DISCONNECT FOR CHILLER. PROVIDE NEW 400A BUSS PLUG FUSED AT 00A AC- E0 E0 ML-,5 TELEPHONE AC- 05/5/8 - ADDENDUM ISSUE Copyright 05 Design Arhiteture, PC All Rights Reserved

14 C ELECTRIC STAIR CONFERENCE PHOTO LAB RECEIVING MEN ROOM PROC. WOMEN EQUIP. REFERENCE C JAN MICROFILM OFFICE OFFICE STAIR C FILE STORAGE WATER METER ROOM C MCD-6 ELECTRIC B- RE-FEED BOILER IGNITER WITH THE EXISTING 0V CIRCUIT. HVAC RE-FEED BOILER PUMP WITH THE EXISTING PUMP CIRCUIT. MIXING BOX FILTER P- BYPASS DAMPER # THHN AND # THHN GROUND IN /4" CONDUIT TO NEW 0/ BREAKER IN EXISTING 480/77V, 5A PANEL IN THIS ROOM DISCONNECT EXISTING FAN MOTOR POWER, AND RECONNECT TO NEW. EXISTING FEEDER TO REMAIN. CH- ROOM HEATING COIL DX COIL FAN # THHN AND # THHN GROUND IN /4" CONDUIT TO NEW 0/ BREAKER IN EXISTING 480/77V, 5A PANEL IN THIS ROOM P-4 P x47.5 E0 50 KCMIL THHN AND #4 THHN GROUND IN " CONDUIT RECEIVING EXISTING 00A FUSED BUS DISCONNECT FOR CHILLER. PROVIDE NEW 400A BUSS PLUG FUSED AT 00A EXISTING 600A, 480V BUSS CU- R EXISTING CU- FED WITH A 40A, 480V, PHASE CIRCUIT AND A 60A DISCONNECT. REPLACE EXISTING DISCONNECT SWITCH WITH A 0A NEMA R DISCONNECT SWITCH FUSED AT 5A. WIRING FROM DISCONNECT TO NEW CU- SHAL BE # THHN AND # THHN IN /4" CONDUIT. PROC. E0 # EF- EF- DISCONNECT EXISTING FAN MOTOR POWER, AND RECONNECT TO NEW. EXISTING FEEDER TO REMAIN. TOR BY EXISTING 5A, 480/77V PANEL 05/5/8 - ADDENDUM ISSUE Copyright 05 Design Arhiteture, PC All Rights Reserved