McQuay. Unit Ventilators Self-Contained UAED, UAEQ, UAER, UARQ, UERQ, UAZQ, UAZR, UAZS, UAZU, UAZV Designs D (4), E (5)

Transcription

1 Replacement Parts List No Revision H 02/208 McQuay Unit Ventilators Self-Contained UAED, UAEQ, UAER, UARQ, UERQ, UAZQ, UAZR, UAZS, UAZU, UAZV Designs D (4), E (5) To find your Daikin Applied parts distributor, call or visit

2 Contents Parts List Revision History... 3 Nomenclature Serial Number... 4 Model Number... 5 Electrical Legend... 6 External Cabinetry... 7 Condenser Section & Final Sheet Metal UAZ_ UAE_ AR_, UER_... 4 Discharge Air Components Outdoor Air: 20% Maximum... 7 Outdoor Air: 00% Refrigeration Circuit UAZ_, UAE_ UAE_ UAR_, UER_ Electric Heat Hot Water or Steam Heat Coils UAZ_ UAZQ, UAZS Controls Controls Diagram... 3 Controls Components PC Board- Main Controllers Fuses- Main Control Box Actuators, Thermostats,and Room Sensors Field Installed Accessories Critical Parts List... CPL UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 2

3 Parts List Revision History Revision Date Description NEW 09/ New A 2/ Page 9 & 3- Bub #200 Delete from drawing. Pages & 6 - Ref. # 200, Delete grommet p/n EJ Page 7- Bub #45 Delete from drawing. Page 8 - Ref. #45, Delete grommet strip p/n EJ B 03/2 Cover Page- Changed design to Design D(4), E(5). ALL Pages- Delete UAZX or UAEX from header. Add UAZ_ and/or UAE_ to header. Page 32- Move the valves to Field Installed, page 43. Page 43- Add Page - Move valves from page 32. Page CPL- Add CPL models UAZ_ and/or UAE_. C 0/3 Remove UGRQ from document. Formatted Drawings to CS6. Page 5- Code & 2 Add models UARQ and UERQ. CPL-2 Delete UGRQ. Change CPL Master. Add Reversing Valves, Solenoid and Exp Valves. D 02/3 Numerous changes were made to this RPL that are not listed. Page 9- Change fan shaft sizes 024, 030 p/n GC8505 TO GC8506 & to Sizes 036, 040 Delete p/ns GC8506 & and add p/n GC0729. Sizes Delete p/ns GC06 & and add p/n GC997. Pages 9-0- Rearrange and remove p/ns from sheet metal and insert footnote #. Pages 2-4- Rearrange and remove p/ns from sheet metal and insert footnote #. Page 6- Ref #s 3 to 300 & damper stops- remove sheet metal p/ns and insert footnote #. Page 8- Ref #s 3,4,5 & access door Remove sheet metal p/ns and insert footnote #. Page 20- Change dwg Crank Bub# from 3 to 09. Page 23- Change reversing valve p/n to then to Change reversing valve p/n to then to Change reversing valve, solenoid p/n to then to Change footnote *** to reference WS-SB Page 24 Delete compressor mounting Bub #s 05, 07 & 08. Page 25- Delete compressor mounting Ref #s 05, 07 & 08. Page 36- Sensor Assy change Sensors only- S,S2,S3,S4 p/n to Add Sensor Assy S5 p/n with sensor p/n Add Sensor S6 p/n Change Sensor Assy S7 p/n to Add Sensor S8 p/n Add gasket p/n CPL2- Delete page. E 05/4 Rebrand to Daikin. Remove sheet metal and add footnote. Pages 9&2- Ref #98 Change Fan Wheel p/n to GC0677. F 03/7 Page 36- Change Sensor Only for S, S2, S3 from p/n to CPL- Update revision. G 09/7 Delete pg 7 "Unit Ventilator, Self-Contained, Diagram" and pg 4 sheetmetal-uae units (n/s). Page 4- Combine diagram & components on one page for sheet metal UAR_ & UER_ Page 30- Change hot water coil description "Low Capacity" to - Row & "High Capacity" to 2- Row. CPL- Delete Exp. Board & Interface Board, and Sensor sections. H 02/8 Page 33- Change MTII control board p/n to for all models 03/04 & later. CPL- update revision. Daikin Applied, 3600 Industrial Park Blvd., P.O. Box 55, Minneapolis, MN (763) UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 3

4 Nomenclature Serial Number AUB U Plant Identification AUB = Auburn U= Unit Serial Number (build sequence) Week of Manufacture Year of Manufacture 02= = = 2004 etc. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 4

5 Nomenclature Model Number UAZQ K G 65 Z 9 AL 22 G I B 2 Code Codes 0-02: Model Number UAED= SC- a/c AirSource HP, Drainless, Ultra Quiet UAEQ= SC- a/c AirSource HP, Drain Req'd, Ultra Quiet UAER= Floor SC- Air to Air, Ultra Quiet, Reheat UAZQ= SC- a/c, Face & Bypass Heating, Ultra Quiet UAZR= SC- a/c, Valve Reheat UAZS= SC- a/c, Face & Bypass Heating UAZU= SC- a/c, Valve Heating, Ultra Quiet UAZV= SC- a/c, Valve Heating UARQ= SC- 60% EWT, Ultra Quiet UERQ= SC- 60% EWT, Ultra Quiet Code 03: Design (Vintage) 4= Design D 5= Design E Code 04: Size (cfm) 024= 24,000 Btuh 030= 30,000 Btuh 036= 36,000 Btuh 040= 40,000 Btuh 044= 44,000 Btuh 048= 48,000 Btuh 054= 54,000 Btuh Code 05: Unit Voltage B= 200/60/3 C= 208/60/ D=208/60/3 G= 230/60/ H= 230/60/3 J= 265/60/ K= 460/60/3 Code 06: Cooling Options G= Direct Expansion (DX) H= Direct Expansion (DX) w/refrigerant Relief Valve Code 07: Heating Coil 00= None 2= Low Electric (3 elements) 3= High Electric (6 elements) 65= -Row HW 66= 2-Row HW 67= 3-Row HW 68= Low Capacity Steam 69= High Capacity Steam Code 08: Hand Orientations E= LH Heating, RH Cooling Z= Not Applicable Code 09: Controls 44= Electromech w/2-pos Damper for Remote T'Stat 45= Electromech w/2-pos Damper w/unit Mtd. ACO 46= Electromech w/2-pos Damper w/unit Mtd. MCO 47= Electromech w/ra/oa Damp w/o Actuator for Remote T'Stat Basic Stand- Alone Controls B= w/o TC B2= Master w/o TC B3= Slave w/o TC B4= BACnet MS/TP w/o TC B5= LonMark SCC w/o TC B6= Metasys N2 open w/o TC B7= with TC B8= Master with TC B9= w/o TC w/co2 Code 09: Controls, Continued BA= Master w/o TC w/co2 BB= Slave w/o TC w/co2 BC= BACnet MS/TP w/o TC w/co2 BD= LonMark SCC w/o TC w/co2 BE= Metasys N2 w/o TC w/co2 BF= w/tc w/co2 BG= Master w/tc w/co2 Expanded Stand- Alone Controls E= w/o TC E2= Master w/o TC E3= Slave without TC E4= BACnet MS/TP w/o TC E5= LonMark SCC w/o TC E6= Metasys N2 open w/o TC E7= with TC E8= Master with TC E9= w/o TC w/co2 EA= Master w/o TC w/co2 EB= Slave w/o TC w/co2 EC= BACnet MS/TP w/o TC w/co2 ED= LonMark SCC w/o TC w/co2 EE= Metasys N2 w/o TC w/co2 EF= w/tc w/co2 LG= Master w/tc w/co2 Leading Stand- Alone Controls L= w/o TC L2= Master w/o TC L3= Slave without TC L4= BACnet MS/TP w/o TC L5= LonMark SCC w/o TC L6= Metasys N2 open w/o TC L7= with TC L8= Master with TC L9= w/o TC w/co2 LA= Master w/o TC w/co2 LB= Slave w/o TC w/co2 LC= BACnet MS/TP w/o TC w/co2 LD= LonMark SCC w/o TC w/co2 LE= Metasys N2 w/o TC w/co2 LF= w/tc w/co2 LG= Master w/tc w/co2 Code 0: Discharge AL= 6-5/8" Unit, Top Bar Grille Discharge Code : Return Air/ O.A. 22= RA Bottom Front/OA Rear Duct Collar Code 2: Power Connection G= Box w/switch Code 3: Color B= Putty Beige I= Antique Ivory G= Soft Gray W= Off White Code 4: SKU B= Standard Delivery C= Extended Delivery Code 5: Product Style 2= 2nd Style Change UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 5

6 Electrical Legend Sch. Sym. Description Location A Actuator- OA/RA OA Damper A2 Actuator- Face & Bypass OA Damper CAP,3 Capacitor Control Box CEH Contactor- Electric Heat E.H. Control Box CH Heater- Crankcase Compressor Section DF Dead Front Switch Electric Heat Section EXP Expansion Board Control Box FA/FC Fuse- Compressor Damper Motor F2A/F3C Fuse- Electric Heat E.H. Control Box FA/FB Fuse- Control, Load Main Control Box FC/FD Fuse- Control, Line (460V) Main Control Box HP Switch- Pressure Compressor Section HTR-6 Electric Heaters Electric Heat Section HTR0 Heater Drain Pan Outdoor Coil Section M Motor- Room Fan Fan Motor M Motor- Compressor (2- Stage) Compressor Section M2 Motor- Outdoor Air Outdoor Coil Section MV Valve- Modulating Steam Coil OH Overheat Stat Electric Heat Section OH2 Overheat Stat Electric Heat Section OH-M Manual Reset Overheat Stat Electric Heat Section R Contactor, Compressor Control Box R2 Relay- Electric Heat E.H. Control Box R3 Relay- Interface Control Box R4 Relay- Fan Control Box R5 Relay- Night Setback Control Box R6 Relay- Ventilation Lockout Control Box R7 Relay- Reset E.H. Control Box R8 Relay- Changeover Control Box R9 Relay- Heat Interface (Changeover) Control Box R0,,2 Relay- Electric Heat E.H. Control Box R3 Relay- Interlack, Exhaust Fan Control Box R4 Relay- Cooling Lockout E.H. Control Box R5,6,7 Relay- Interlock (Condensate Disposal) E.H. Control Box R20 Relay- Interlock, Humidity Control Box R32 Relay- Drain Pan Heater Outdoor Coil Section R35 Relay- Discharge Air Fan Energizer Main Control Box RV Reversing Valve Compressor Section S Sensor- Room Air Indoor Coil Section S2 Sensor- Discharge Air Indoor Coil Section S3 Sensor- Outdoor Air Indoor Coil Section S4 Sensor- Indoor DX Coil Temp. Indoor Coil Section S5 Sensor- Outdoor DX Coil Temp. Outdoor Coil Section S6 Sensor- Indoor Humidity Left End Compartment S7 Sensor- CO2 Indoor Coil Section S8 Sensor- Outdoor Humidity Damper Motor SW Disconnect Switch Main CB or EH Control Box SW2 Switch- Unit Control & Motor Speed Control Box SW3 Tenant Override Switch Top Right of Unit SW4 Swich- Holiday Control Box SW5 Switch- Emergency Heat Control Box SW6 Switch- Occ. /Unocc. Control Box T2 Thermostat-Low Temp Control Box T4 Thermostat- Room Coil Low Temp Control Box T5 Thermostat- Defrost Control Box T6 Thermostat- Low Limit Hyd. Coil Left End Compartment TC Time Clock Top Right of Unit TDR Anti- Short Timer Main Control Box TDR2 Low Voltage Protector E.H. Control Box UVC Controller Control Box V Valve- End Of Cycle Coil X Transformer- Motor Speed Main Control Box X2 Transformer- Class 2 Main Control Box X3 Transformer- 75VA Main Control Box X4 Transformer- 460V Below Motor X5 Transformer- 460V EH E.H. Control Box UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 6

7 External Cabinetry Front Access Panels, End & Center See Detail A-A 2 Detail A-A 6 5 2" "L" 24.80" 4 3 2" Ref. No. Description Qty. Unit Size N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. 2 Hardware is included with center panel. 3 Hardware quantities reflect total required per unit for 3 front panels. 024/ / /048/054 2" Front Panel, End 2,3,3,3 2 Front Panel, Center,2,3,2,3,2,3 3 Shaft Fastener Bushing 4 4GZB766 4GZB766 4GZB766 5 Retaining Ring Lockwasher, 5/6" 4 4WBA70 4WBA70 4WBA70 N/S Tinnerman 4 4NKE7968 4NKE7968 4NKE7968 UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 7

8 Condenser Section & Final Sheet Metal- UAZ_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Bearing, Coupling, Shaft, Drain Tube, Access Panels Diagrams Front View Side View UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 8

9 Condenser Section & Final Sheet Metal- UAZ_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Bearing, Coupling, Shaft, Drain Tube Components Ref. Description Part Qty No. Number Motor, 208/230/ Unit Sizes /3HP KQDQ5944 Unit Sizes /4HP Motor, 460/ Unit Sizes /3HP KVDQ5938 Unit Sizes /4HP MVCQ Condenser Coil Unit Sizes 024, Unit Sizes Fan Housing Unit Sizes 024, 030 GCF59 4 Unit Sizes GCF Fan Shaft Unit Sizes 024, 030 until 4/06 GC8506 Unit Sizes 024, 030 4/06 & later Unit Sizes 036, 040 GC0729 Unit Sizes GC Fan Wheel, Plastic Unit Sizes 024, 030 GC Unit Sizes GC Motor Coupling GC502C 0 Filter- Throwaway Unit Sizes 024, 030 GO280C Unit Sizes 036, 040 GO28C Unit Sizes GO279C 2 07 Clamp 4DCC Bearing- Ball 4AAD945A 203 Gasket- Foam Unit Sizes 024, ft Unit Sizes 036, ft Unit Sizes 044, ft 209 Gasket Unit Sizes 024, 030 BJ ft Unit Sizes 036, 040 BJ ft Unit Sizes 044, 048, 054 BJ ft. 232 Caster Wheel Swivel, 2" Rigid, 3" N/S Gasket- between front panels and cabinet Unit Sizes 024, ft Unit Sizes 036, ft Unit Sizes 044, ft N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 9

10 Condenser Section & Final Sheet Metal- UAZ_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Bearing, Coupling, Shaft, Drain Tube Components Ref. Description Part Qty No. Number 3 Blockoff, Bottom- RH 9 Tube, Drain Pan 6 Blockoff, Bottom- LH 8 Panel, Front 9 Cover 20 Angle 22 Blockoff- Fan Motor 24 Angle 25 Strap 5 26 Support 27 Top Condenser Section 28 Drain Pan- Metal N/S Triangular Blockoff, Condenser Coil Right-hand Left-hand 33 Cover 58 Insulation 59 Insulation 60 Insulation, Rear-Evap 62 Insulation, RH Partition 63 Insulation, Drain Pan 70 Frame Assembly 75 Condenser Bottom 76 Bulkhead Assy 77 Insulation, LH Partition 78 End Panel 79 End Panel 8 Drain Pan 88 Drain Tube 23 Caster Housing Assembly Bottom Blockoff 35 X4 Transformer Mount N/S Lower Damper Stop N/S Upper Damper Stop N/S Insulation, Top Cover Unit Sizes 024, 030 3/4 X 8.5X2.5" 2 Unit Sizes 024, 030 3/4 X 8.5X3.3" Unit Sizes 036, 040 3/4 X 8.5X2" 4 Unit Sizes 044, 054 3/4 X 8.5X4.2" 2 Unit Sizes 044, 054 3/4 X 8.5X5.25" 2 N/S Base Pan, Condenser N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 0

11 Condenser Section & Final Sheet Metal- UAE_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Access Panels Limit Switch, Drain Pan Heater, Bearing, Coupling, Shaft, Drain Tube Diagrams Front View Side View UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page

12 Condenser Section & Final Sheet Metal- UAE_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Access Panels Limit Switch, Drain Pan Heater, Bearing, Coupling, Shaft, Drain Tube Components Ref. Description Part Qty No. Number Motor- 208/230/ Unit Sizes 024, 030, 036, 040 KQDQ5944 Unit Sizes 044, 048, Motor- 460/ Unit Sizes 024, 030, 036, 040 KVDQ5938 Unit Sizes 044, 048, 054 MVCQ Condenser Coil, DX Unit Sizes 024, Unit Sizes 036, 040, 044, 048, Fan Housing Units Sizes 024, Units Sizes Fan Shaft Unit Sizes 024, 030 until 4/06 GC8506 Unit Sizes 024, 030 4/06 & later Unit Sizes 036, 040 GC0729 Unit Sizes GC Fan Wheel, Plastic Unit Sizes 024, 030 GC Unit Sizes GC Motor Coupling GC502C 0 Filter- Throwaway Unit Sizes 024, 030 GO280C Unit Sizes 036, 040 GO28C Unit Sizes 044, 048, 054 GO279C 2 07 Clamp 4DCC Drain Pan Heater Unit Sizes 024, 030 GE037 Unit Sizes 036, 040 GE038 Unit Sizes 044, 048, 054 GE362 6 Limit Switch, Auto Reset Bearing- Ball 4AAD945A 203 Gasket- Foam Unit Sizes 024, ft Unit Sizes 036, ft Unit Sizes 044, 048, ft 209 Gasket Unit Sizes 024, 030 BJ ft Unit Sizes 036, 040 BJ ft Unit Sizes 044, 048, 054 BJ ft. 232 Caster Wheel Swivel, 2" Rigid, 3" N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 2

13 Condenser Section & Final Sheet Metal- UAE_ Condenser Coil, Fan Assembly, Drain Pans, Motor, Access Panels Limit Switch, Drain Pan Heater, Bearing, Coupling, Shaft, Drain Tube Components Ref. Description Part Qty No. Number 3 Bottom Blockoff- RH 6 Bottom Blockoff- LH 8 Panel, Front 9 Cover 20 Angle 22 Blockoff- Condenser Fan Motor 23 Blockoff- Ice Screen Unit Sizes 024, Unit Sizes 036, Unit Sizes 044, 048, Angle 25 Strap Unit Sizes 024, Unit Sizes Support 27 Top Condenser Section 28 Drain Pan, Drain Pan, Drain Pan, N/S Triangular Blockoff, Condenser Coil 3 Bracket- Drain Pan Heater 2 32 Bracket- Limit Switch 33 Cover 58 Insulation 59 Insultation 60 Insulation 62 Insulation, RH Partition 63 Insulation 70 Frame Assembly 75 Condenser Bottom 76 Bulkhead 78 End Panel 79 End Panel 8 Drain Pan, Fan Bd, GCF532 8 Drain Pan, Fan Bd, GCF533 8 Drain Pan, Fan Bd, GCF Insulation, LH Partition 96 Tube ft 23 Caster Housing Bottom Blockoff 30 Condenser Drain Tube GC Plastic Tube 350 Nut 8 / 2 35 X4 Transformer Mount N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 3

14 Final Sheet Metal- UAR_, UER_ Panels, Blockoff, Filter, Insulation, Access Panels Front View Side View Ref. Description Part Qty No. Number N/S Gasket between front panels and cabinet Unit Sizes 024, ft Unit Sizes 036, ft Unit Sizes 048, ft 3 Bottom Blockoff- RH 6 Bottom Blockoff- LH 8 Front Compressor Panel 9 Cover, Compressor RH 20 Angle 24 Insulation, LH Partition 48 Insulation 49 Insulation 50 Insulation 52 Insulation, RH Partition 60 Frame Assy (includes compressor plate) 8 Filter Unit Sizes Unit Sizes 048, X4 Transformer Plate 300 Bottom Blockoff N/S Lower Damper Stop N/S Upper Damper Stop N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Cabinet/Chassis components. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 4

15 Discharge Air Components Fan Deck, Wheel, Motor, Bearing, Drain Pans Diagrams Top View Motor, and Bearing Detail UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 5

16 Discharge Air Components Fan Deck, Wheel, Motor, Bearing, Drain Pans Components Ref. Description Part Unit Size No. Number 024/ / /048/054 2 Discharge Grille Unit Sizes 024, Unit Sizes 036, Unit Sizes 044, 048, Top Cover 4 Top Panel 5 Front Moulding N/S Access Door- 2" 2 Blower Wheel & Housing until 4/ Blower Wheel & Housing 4/06 & later N/S Blower Wheel Screen N/S Fan Shaft until 4/06 GC8505 N/S Fan Shaft 4/06 & later N/S Fan Shaft until 4/06 GC8506 N/S Fan Shaft 4/06 & later N/S Fan Shaft until 4/06 GC06 N/S Fan Shaft 4/06 & later N/S External Retaining Ring N/S Access Door Prop Rod GC Motor Mounting Plate GC Motor Bolt Plate Sleeve Bearing 4ACE2556A 28 Indoor Fan Motor 2 /4 HP until 4/ /4 HP 4/02 to 3/ /4 HP 3/03 & later N/S Mount, Motor until 3/ N/S Motor Mount 3/03 & later N/S Coupling- Motor to Shaft GC502C N/S Gasket N/S Grommet N/S Grommet N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on Chassis components. 2 Motors are 5/60/ regardless of unit voltage. It is important that the correct X transformer be installed (see Code 5 for voltage). UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 6

17 Outdoor Air: 20% Maximum Damper, Bearing, Blockoff, Gaskets and Motor Components Ref. Description Part Qty No. Number N/S Outdoor Air Damper Unit Sizes 024, Unit Sizes 036, 040, Unit Sizes 044, 048, N/S Damper Blockoff Unit Sizes 024, 030 GC0005 Unit Sizes 036, 040, 042 GC0006 Unit Sizes 044, 048, 054 GC0007 N/S Damper Bearing 4ACN49 2 N/S Damper Gasket- Mohair Unit Sizes 024, 030 BY ft Unit Sizes 036, 040, 042 BY00000 ft Unit Sizes 044, 048, 054 BY ft N/S Damper Gasket- Vinyl Unit Sizes 024, 030 BJ ft Unit Sizes 036, 040, 042 BJ ft Unit Sizes 044, 048, 054 BJ ft N/S Motorized Damper Components Link GE24 Stop GE25 Spring until 6/07 WC /07 & later Crank Arm GEF294 Arm WCF806 Rocker Switch- SPDT until 9/0 4EAL7759 9/0 & later Actuator Motor WB08 N/S Manual Damper Components Bracket GE22 Crank GEF294 N/S Relay N/S = Not shown on diagram. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 7

18 Outdoor Air: 00% Dampers, Crank Arms, Linkage, Shaft, Gaskets Diagrams Left End View Front View Actuator Assembly (AR only) UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 8

19 Outdoor Air: 00% Dampers, Crank Arms, Linkage, Shaft, Gaskets Components Ref. Description Part Qty No. Number 0 Outdoor Air Damper Unit Sizes 024, Unit Sizes 036, 040, Unit Sizes 044, 048, Room Air Damper Unit Sizes 024, 030 until 4/ /03 & later Unit Sizes 036, 040, 042 until 4/ /03 & later Unit Sizes 044, 048, 054 until 4/ /03 & later N/S Damper Spring Linkage GC Crank Arm until 2/02 GCF5474 2/02 & later Crank until 3/04 GCF5000 Shaft * until 2/99 GC634 Shaft * 2/99 to 3/ Shaft * 3/04 & later Shaft * until 2/99 GC0024 2/99 to 3/ N/S Right-side Actuator Assembly * 2/99 to 3/ Bearing, Sleeve 4ACN Damper Gasket- Mohair Unit Sizes 024, 030 BY ft Unit Sizes 036, 040, 042 BY ft Unit Sizes 044, 048, 054 BY ft 9 Damper Gasket- Vinyl Unit Sizes 024, 030 BJ ft Unit Sizes 036, 040, 042 BJ ft Unit Sizes 044, 048, 054 BJ ft 202 Actuator Rod GE Damper Actuator Actuator/Controller Wire Assembly Crank Arm 4HFZ Swivel Hinge 4HEZ66 N/S Actuator Bracket GE033 N/S = Not shown * From February 999 to March 2004, a second "slave" actuator was added to the right side of the Room Air Damper. The new shafts (Ref.#, 2) were only used when this additional actuator assembly was present. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 9

20 Refrigeration Circuit- UAZ_, UAE_ Compressor, TXV, Evaporator Coil, Coil Frame, Reversing Valve, Strainer, Accumulator, Receiver, Reheat Coil, Check Valve Diagrams Compressor Mounting Detail 24 Cond. Coil- see Condenser/ Chassis Section Evaporator Coil Frame Detail (for AE Drainless Coil Frame, see the page following the next) Front View Side View Note: Hot Gas Reheat Units - See Form SB003, Service Bulletin "Rework Procedure for Hot Gas Reheat Units". UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 20

21 Refrigeration Circuit- UAZ_, UAE_ Compressor, TXV, Evaporator Coil, Coil Frame, Reversing Valve, Strainer, Accumulator, Receiver, Reheat Coil, Check Valve Components Ref. Description Unit Sizes Qty No. 024, , , 048, 054 Evaporator Coil- no reheat Assembly w/blockoff Coil Only Valve Assembly Strainer YL288 YL288 YL Expansion Valve Reversing Valve*** until 2/ Reversing Valve 2/05 to 3/ Reversing Valve 3/ & later Accumulator Solenoid, RV*** until 2/ Solenoid, RV 2/05 to 3/ Solenoid, RV 3/ & later Grommet 4RHD486 4RHD486 4RHD Compressor- see chart below 06 Grommet 4RHZ954* 4RHZ954 4RHZ Blockoff GC0564 GC0564 GC Drain Pan, Units w/electric Heat Drain Pan until 8/ Drain Pan 8/0 & later Blockoff Cover** GC82 GC82 GC82 20 Cover** GR2097 GR2097 GR RH Partition until 5/02 GCF5706 GCF5706 GCF5706 RH Partition 5/02 & later LH Partition w/e. H. until 5/02 GCF57 GCF57 GCF57 LH Partition w/e. H. 5/02 & later GCF570 GCF570 GCF570 LH Partition GCF5707 GCF5707 GCF Drain Pan GCF505 GCF506 GCF Grommet 4RHD896 4RHD896 4RHD896 N/S Compressor Pressure Switch 20% OA Units 4EMB547C 4EMB547C 4EMB547C 00% OA Units until /0 4EMB8937 4EMB8937 4EMB % OA Units /0 to 3/ % OA Units 3/02 & later N/S = Not shown on diagram. * Size 024 uses grommet pn YB69 until 6/06. 6/06 & later use **Units with Electric Heat Only. *** When replacing reversing valve and/or coil on Mark IV Control units refer to Service Bulletin WS-SB Compressors Ref. Unit Unit Voltage Qty No. Size 208/230/60/ 208/230/60/3 460/60/ , Note: Hot Gas Reheat Units - See SB003, Service Bulletin "Rework Procedure for Hot Gas Reheat Units". UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 2

22 Refrigeration Circuit- UAE_ Coil Frame Components- Drainless Units Diagrams Front View Side View Upper Partition Lower Partition RH Section: See Detail Below Right Hand Section Detail UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 22

23 Refrigeration Circuit- UAE_ Coil Frame Components- Drainless Units Components Ref. Unit Unit Sizes Qty No. Size 024, , , 048, 054 Plate- RH End GC625 GC625 GC625 3 Plate- RH End GC629 GC629 GC629 4 Cover- Heater, Limit Stat Drain Pan GCF5463 GCF Drain Pan Blockoff GC0564 GC0564 GC Coil Blockoff Panel Sensor Switch 4EMM7627 4EMM7627 4EMM Heater Element- Defrost 208V V 4EHH8807 4EHH8807 4EHH V 4EHH8808 4EHH8808 4EHH Limit Stat 4ELN8809 4ELN8809 4ELN RH Partition until 5/02 GCF5706 GCF5706 GCF5706 5/02 & later LH Partition until 5/02 GCF57 GCF57 GCF57 5/02 & later GCF570 GCF570 GCF Cover GC82 GC82 GC82 UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 23

24 Refrigeration Circuit- UAR_, UER_ Compressor, TXV, Evaporator Coil, Coil Frame, Reversing Valve, Strainer, Water Coil, Reheat Coil, Check Valve Diagrams Compressor Mounting Detail Evaporator Coil Frame Detail Front View Side View UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 24

25 Refrigeration Circuit- UAR_, UER_ Compressor, TXV, Evaporator Coil, Coil Frame, Reversing Valve, Strainer, Water Coil, Reheat Coil, Check Valve Components Ref. Description Unit Sizes Qty No. 024, , , 048, 054 Evaporator Coil- no reheat Assembly w/ blockoff N/A Coil Only Reversing Valve*** Valve Assembly Strainer YL288 YL288 YL Expansion Valve until 2/98 4FDV8933 4FDV8934 4FDV8935 2/98 & later Water Coil Solenoid Reversing Valve*** Compressor- see chart below 05 Compressor Mounting Sleeve WB044 WB044 WB Grommet 4RHZ954* 4RHZ954 4RHZ Screw 4SBA866 4SBA866 4SBA Washer 4WAA2257 4WAA2257 4WAA Blockoff GC0564 GC0564 GC Drain Pan Units w/electric Heat Units w/o Electric Heat until 8/ /0 & later Blockoff Cover** GC82 GC82 GC82 20 Cover** GR2097 GR2097 GR RH Partition until 5/0 GCF5706 GCF5706 GCF5706 5/02 & later LH Partition Units w/electric Heat until 5/02 GCF57 GCF57 GCF57 5/02 & later GCF570 GCF570 GCF570 Units w/o Electric Heat GCF5707 GCF5707 GCF Drain Pan GCF505 GCF506 GCF Grommet 4RHD896 4RHD896 4RHD896 N/S Compressor Pressure Switch 20% OA Units 4EMB547C 4EMB547C 4EMB547C 00% OA Units until /0 4EMB8937 4EMB8937 4EMB8937 /0 to 3/ /02 & later N/S = Not shown on diagram N/A = Not applicable * Size 024/030 uses grommet pn YB69 until 6/06. 6/06 & later use **Units with Electri c Heat Only. ***When these reversing valves are no longer available they are replaced by the following (a new solenoid must be ordered with a new style valve - the solenoids are not compatible with new style valves): the new style valve is p/n (sizes 024, 030) listed above or (sizes ); The new solenoid is p/n Compressors Ref. Unit Unit Voltage Qty No. Size 208/230/60/ 208/230/60/3 460/60/ UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 25

26 Electric Heat Heater Assembly 8 25 Top View Side View Ref. Sch. Unit Unit Voltage Qty No. Sym. Size 208V 230V 460V Channel Element Seperator Unit Sizes GR2044 GR2044 GR Unit Sizes GR2044 GR2044 GR Channel HTR -6 Heater Element Unit Sizes 024, /6 Unit Sizes 036, 040, /6 Unit Sizes 044, 048, /6 N/S --- Gasket Unit Sizes 024, 030 BJ BJ BJ ft Unit Sizes 036, 040, 042 BJ BJ BJ ft Unit Sizes 044, 048, 054 BJ BJ BJ ft N/S --- Filter Stop Unit Sizes GC0574 GC0574 GC0574 N/S = Not shown on diagram UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 26

27 Electric Heat Controls C2 C C3 R6 R7 R5 OFF ON C6 Relays & X5 Transformer X5 Fuses C9 R4 or On/Off Switch R7 TDR2 Relays and X5 Transformer Sch. Unit Unit Voltage Qty Sym. Size 208V 230V 460V X5 Transformer On/Off Switch 4EAL2427 4EAL2427 4EAL Limit Thermostat 4ELN7697 4ELN7697 4ELN7697 Knob for Limit Thermostat 4EBZ755 4EBZ755 4EBZ755 C-9 Relay, Operating and Backup 30 Amp until 3/03 4EWJ8799 4EWJ8799 4EWJ8799 varies 30 Amp 3/03 & later varies Box of 6 (065000) R7 Relay 3 4EWJ7953 4EWJ7953 4EWJ7953 R4 Relay 4EWJ7953 4EWJ7953 4EWJ7953 R5 Relay R6 Relay 2 30 Amp until 3/03 4EWJ8799 4EWJ8799 4EWJ Amp 3/03 & later Box of 6 (065000) R7 Relay 2 4EWJ7953 4EWJ7953 4EWJ7953 TDR2 Time Delay Relay until 0/07 4EWS7798 4EWS7798 4EWS7798 Time Delay Relay 0/07 & later Used only on AE units with internal condensate disposal and 20% OA. 2 Used only on AE units with internal condensate disposal. 3 Used only on AE units with 20% OA. Ref. Part Unit Size Qty No. Description 024, , , 048, 054 N/S T-Stat, Overheat Manual* N/S Contactor, 60 Amp* N/S Fuse, 30 Amp 4EHG979 4EHG979 4EHG979 N/S Fuse, 60 Amp 4EHG4083 4EHG4083 4EHG4083 N/S = Not shown on diagram * These parts added to all electric heat units after 2/0/03. T-Stat, Contactor and Fuses UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 27

28 Coils Ref. Part Unit Size Qty No. Description 024, , , 048, 054 N/S Hot Water, Row N/S Hot Water, 2 Row N/S Steam- Low Capacity GRF04 GRF05 GRF06 N/S Steam- High Capacity GRF00 GRF002 GRF003 N/S Manual Air Vent N/S = Not shown on diagram Hot Water or Steam Heat- UAZ_ Code 07= 65, 66, 68, 69 Coils, Water Valves UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 28

29 Hot Water or Steam Heat- UAZ_ Code 07= 65, 66, 68, 69 Heating Coil Frame, Coils Coil Frame Assembly- Units with no Face & Bypass Damper Front View 6 Upper Partition Side View 2 3 Lower Partition Ref. Part Unit Size Qty No. Description 024, , , 048, 054 Blockoff Panel Blockoff GC0564 GC0564 GC Drain Pan Rear Damper Stop Front Damper Stop Coil Blockoff RH Partition until 5/02 GCF5706 GCF5706 GCF5706 5/02 & later LH Partition GCF5707 GCF5707 GCF Drain Pan GCF505 GCF506 GCF507 N/S Gasket FT Gasket FT Gasket FT N/S = Not shown on diagram UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 29

30 Hot Water or Steam Heat- UAZQ, UAZS Code 07= 65, 66, 68, 69 Heating Coil Frame with Face & Bypass Damper Front View 2 Side View Lower Partition Ref. Part Unit Size Qty No. Description 024, , , 048, 054 Blockoff GC0564 GC0564 GC Drain Pan Assy Rear Damper Stop Front Damper Stop Coil Blockoff End GC0044 GC0044 GC Counterweight GC0744 GC0745 GC RH Partition Assy until 5/02 GCF5706 GCF5706 GCF5706 5/02 & later LH Partition Assy GCF5707 GCF5707 GCF Drain Pan GCF505 GCF506 GCF507 7 Damper GCF5003 GCF5004 GCF Damper Counterweight GCF5203 GCF5203 GCF Arm GC0746 GC0746 GC0746 Shaft GC0747 GC0747 GC Grommet 4RHD896 4RHD896 4RHD896 3 Sleeve Bearing 4ACN49 4ACN49 4ACN49 2 N/S Damper Rod GE032 GE032 GE032 N/S Crank Arm 4HFZ443 4HFZ443 4HFZ443 N/S Actuator Motor N/S Actuator Bracket GE034 GE034 GE034 N/S = Not shown on diagram UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 30

31 Controls Diagram X2 NOT SW4 X3 SW3 SW2 X or SW6 Knob Receptacle R7 R8 R4 R5 R3 R6 X4 R3 R T5 T2 SW 5 R R 0 FD & FC FA & FB CAP CAP3 UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 3

32 Controls Components Sch. Part Unit Model Qty Sym. Description UAZ_ UAE_ UAR_/UER_ X Transformer X2 Transformer 4EPC974 4EPC974 4EPC974 X3 Transformer X4 Transformer (460V units only) Unit Sizes EPC6552A 4EPC6552A 4EPC6552A Unit Sizes EPC7743 4EPC7743 4EPC7743 R Contactor- 00% Units 208/230/60/ Units 4EXJ6447 4EXJ6447 4EXJ /230/460/60/3 Units 4EXJ907 4EXJ907 4EXJ907 Contactor- 20% Units 4EXJ907 4EXJ907 4EXJ907 R3 Relay, Interface N/A R4 Relay, Fan 4EWJ9054 * N/A N/A R5 Relay, Night Setback 24V 4EWJ9054 4EWJ9054 4EWJ9054 5V 4EWJ9053 4EWJ9053 4EWJ9053 R6 Relay, Ventilation Lockout 24V 4EWJ9054 4EWJ9054 4EWJ9054 5V 4EWJ9053 4EWJ9053 4EWJ9053 R8 Relay- 20% OA Units Only R9** Relay- Changeover N/A R0 Compressor Start Relay Unit Sizes N/A Unit Sizes 030 4EWJ8484 4EWJ8484 N/A Units Sizes N/A N/A N/A R Relay, 5V N/A N/A R3 Anti- Short Relay (20% units) 3 Min. until 9/ Min. 9/07 & later SW** Switch, Main Disconnect, 00A 4EUL6509A 4EUL6509A 4EUL6509A SW** Switch, Main Disconnect, 225A 4EVQ9406 4EVQ9406 4EVQ9406 SW2 Switch Knob for SW SW3 Switch- Unit Mtd. Tenant Reset 4EAL726 4EAL726 4EAL726 SW4 Switch, Rocker- Time Clock 4EAL7260 4EAL7260 4EAL7260 SW5 Switch, SPDT Momentary 4EAL726 4EAL726 4EAL726 SW6 Switch 4EAL7759 4EAL7759 4EAL7759 TC Time Clock T2 Limit Switch (20%n units only) 4ELN702 4ELN702 4ELN702 T4 Tstat, Low Temp 4ELN7604 4ELN7604 4ELN7604 T5 Defrost Limit Timer 4ELN8872 4ELN8872 4ELN8872 T6 Tstat, Low Temp Units Sizes ELN978 4ELN978 4ELN978 Units Sizes FA/FB Fuse 4EHG7748 4EHG7748 4EHG FC/FD Fuse- 460V Units only 4EHG7664 4EHG7664 4EHG CAP Capacitor 024 4ERA8968 4ERA8968 4ERA CAP3 Capacitor- 208/230/ units only 4ERA8483 4ERA8483 4ERA8483 NOT Night Override Timer (20% only) RECEP. Receptacle GES9 GES9 GES9 * For units built prior to June 999, the harness connecting the R4 Relay needs to be field retrofitted with /4" terminals. ** Not shown in diagram. N/A= Not Applicable UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 32

33 Sch. Sym. PC Boards- Main Controllers Description Part Number Qty UVC Control Board, MicroTech UVC Standoff for MT Main Control Board, MicroTech II (until 03/04) (03/04 & later) Standoff for MicroTech II EXP Expansion Board, Modtac LUI Interface Board Main Control Box Fuse Fuse Fuses- Main Control Box Sch Part Unit Voltage Qty Sym. Description 208/230/60/ 208/230/60/3 460/60/3 FA/FB Fuse Unit Size 024 4EHG2220 4EHG229 4EHG8686 * Unit Size 030 4EHG979 4EHG2220 4EHG8686 * Unit Size 036 4EHG305 4EHG2220 4EHG8686 * Unit Size 040,042 4EHG992 4EHG4548 4EHG8686 * Unit Size 044,048 4EHG4548 4EHG4548 4EHG8686 * Unit Size 054 4EHG4548 4EHG979 4EHG8686 * *Single phase units use two (2); Three phase units use three (3). UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 33

34 Actuators, Thermostats and Room Sensors Sch. Part Unit Model Qty Sym. Description UAZ_ UAE_ UAR_ Actuators C3= 4 (Design D) A/A2 Actuator, OA & R.A. MicroTech Controls Actuators C3= 5 (Design E) A/A2 Actuator, OA & R.A. MicroTech II A Actuator, OA & R.A. DDC ctls A Actuator, Non-spring Return DDC ctls Thermostats Unit Mounted ACO Stat Toggle Switch 4EAL793 4EAL793 4EAL793 Terminal Block 4ECA7842 4ECA7842 4ECA7842 Knob for Stat ZAG25258A ZAG25258A ZAG25258A Room Sensors- MT325 C3= 4 (Design D) S Sensor Assy, Room w/tennant OR Sensor only S2 Sensor Assy, Discharge Air/Water Assembly Sensor only S3/S5 Outdoor Air Sensor Assembly GEF948 GEF948 GEF948 Sensor only N/S Humidity Sensor, Wall Mounted N/S Gasket ft. Room Sensors- MTII C3= 5 (Design E) S Sensor Assy, Room Sensor Only S2 Sensor Assy, Discharge Air Sensor Only S3 Sensor Assy, Outdoor Air, 80" Sensor Only S4 Sensor Assy, DE Coil, 78" Sensor Only S5 Sensor Assy, Outdoor Air, 80" Sensor Only S6 Sensor Assy, Humidity- Indoor Air, 30" Sensor only S7 Sensor Assy, CO2 until 8/ /0 & later S8 Sensor Assy, Humidity- Outdoor Air, 50" Sensor only N/S Gasket ft. Room Sensors- DDC C3= 5 (Design E) S Room Sensor S2 Room Sensor S3 Room Sensor N/S = Not shown on diagram These actuators look alike, but they are not and they DO NOT interchange. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 34

35 Field Installed Accessories Ventimatic Shutter Description Part Number 24" Shutter Grille Only GP256 36" Shutter Grille Only GP257 Louver for Ventimatic Shutter No Grille/No Flange- ½ Mesh Bird Screen on Room Side Description Part Number Horizontal Vertical Autumn Brown Clear Anodized Dark Bronze Unfinished Interior Steel Wall Grille for Ventimatic Shutter Description Part Number Antique Ivory Off White Putty Beige Soft Grey Grille, 2 3/8 X CFM Grille, 2 3/8 X CFM Grille, 2 3/8 X 5 000CFM Grille, 2 3/8 X CFM Grille, 2 3/8 X CFM Touch Up Paint Description Part Number Antique Ivory Off White GXA60208 Putty Beige GXA60203 Soft Gray GXA60204 Castors for Indoor Section Description Part Number Castor-2 Pack Spare Motors Description Unit Unit Voltage Size 208/230/60/ 208/230/60/3 460/60/3 Indoor Fan Motor /4 HP ALL Outdoor Fan Motor /3 HP 024, /4 HP 044, UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 35

36 Field Installed Accessories Louver- Vertical Heavy Gauge Aluminum w/vertical blades, ½ mesh bird screen on room side; bottom lip drains moisture Unit Size 024, 030 (Louver size 28"H x 84"L) Color Part No. w/o Grille w/o Grille with Grille with Grille No Flange w/ Flange no Flange with Flange Autumn Brown Dark Bronze Clear Anodized Unfinished Unit Size 036, 040 (Louver size 28"H x 96") Color Part No. w/o Grille w/o Grille with Grille with Grille No Flange w/ Flange no Flange with Flange Autumn Brown Dark Bronze Clear Anodized Unfinished Unit Size 044, 054 (Louver size 28"H x 08"L) Color Part No. w/o Grille w/o Grille with Grille with Grille No Flange w/ Flange no Flange with Flange Autumn Brown Dark Bronze Clear Anodized Unfinished Adapter Back Kits Description Part Number 024/ / /048/ /8 Open Tunnel, No OA /8 Closed Full Tunnel, OA Rear /8 Full Open Tunnel /8 Close Pipe Tunnel Remote Temperature Stats, T'stat Guards Description Part No. T'stat Guard w/ring Base, Lock & Key Day Programmable T'stat, 2-Heat/2-Cool, ACO Non-Programmable T'stat, 2-Heat/2-Cool, AC/DC Remote Wall Sensors and Sensor Guards Description Part No. Remote Sensor: ± Divisions Adjust, w/ tenant override and night setback Remote Sensor:55-85 F Adjust, w/ tenant override and night setback Remote Sensor: Blank Face w/o adjust, w/ tenant override and night setback 0480 Metal Sensor Guard Plastic Sensor Guard UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 36

37 Field Installed Accessories End Panels- " Description Part Number Antique Ivory Putty Beige Off White Soft Gray End Panels- " 6-5/8" Deep, Solid /8" Deep, Solid, w/acoustics /8" Deep, Solid, w/acoustics /8" Deep, Solid, w/acoustics " Deep, Solid " Deep, Solid, w/acoustics End Panels- 6" Description Part Number Antique Ivory Putty Beige Off White Soft Gray End Panels- 6" 6-5/8" Deep, Solid /8" Deep, Solid, w/acoustics /8" Deep, Solid, w/acoustics /8" Deep, Solid /8" Deep, Solid, w/acoustics " Deep, Solid " Deep, Solid, w/acoustics Wall Sleeves Description Part Number 024/ / /048/054 Wall Sleeves 0-3 & 6 Electric Heat Element 6 5/8" Cabinet Room Projection /8" Cabinet Room Projection /8" Cabinet Room Projection " Cabinet Room Projection Wall Sleeve Disconnect Switch, 00A GEA42407 GEA42407 GEA42407 Wall Sleeve Receptacle Wiring Filters Description Part Number 024/ / /048/054 Filter, Air- Permanent GO007 GO008 GO006 Box of Filter, Renewable GOF502 GOF503 N/A Box of N/A Filter, Air- Throwaway GO280C GO28C GO279C Box of Filter, Air- Media for Renewable KJ KJ KJ Box of 2 Rolls UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 37

38 Field Installed Accessories Valves 9 0 Ref. Description Part Qty. No. No. 9 Shutoff Ball Valve Way Valve Modulating Valves, N.O. /2", HW only,.73 CV /2", HW only,.8 CV /2", HW only, 4.6 CV /4", HW only, 7.3 CV Way, 2-Position EOC, 3/4", STM* Assembly (includes harness, terminals) Valve Only Way Modulating Valves, N.O. /2", HW or STM,.73 CV /2", HW or STM,.8 CV /2", HW or STM, 4.6 CV /4", HW or STM, 7.3 CV ", STM only,.6 CV ¼", STM only, 8.5 CV Way Modulating Valves, N.C. /2", CW,.73 CV /2", CW,.8 CV /2", CW, 4.6 CV /4", CW, 7.3 CV Way, 2-Position EOC, 3/4", STM * Assembly (includes terminals, housing) GEF2355 Valve Only 4FDV7958 * Used on 00% OA units with F & B Damper Control OR 20% OA units only. Communications Modules- MicroTech II Description Kit Card Only BACnet MS/TP, Programmable Mounting Spacer (until 03/04) N/A (4) (03/04 & later) (4) LonWorks SCC, Programmable (4) Metasys N2 Open (4) N/A= Not Applicable. UV; UAED,UAEQ,UAER,UARQ,UERQ,UAZR,UAZQ,UAZU,UAZV Des. D&E Rev. H 02/8 RPL / Page 38

39 Critical Daikin Applied OEM Parts Are What Your HVAC Unit Needs! McQuay Unit Ventilator- Self Contained UAZQ, UAZR, UAZS,UAZU, UAZV, UAED, UAEQ, UAER, UARQ, UERQ Designs D (4) & E (5) Critical Components Unit Sizes Voltage Part Number Control Control Board, MicroTech 325 ALL ALL Control Board, MicroTech II ALL ALL Compressor Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor 040, /60/ Compressor 040, /60/ Compressor 040, /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Compressor /60/ Condenser Motor Motor, /3HP /60/ KQDQ5944 Motor, /3HP /60/ KVDQ5938 Motor, 3/4HP /60/ Motor, 3/4HP /60/ MVCQ5978 Fan Motor Motor, Indoor, /4HP /60/ Condenser Housing & Wheel Fan Housing ALL N/A Fan Wheel N/A Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs. To Locate A Distributor, Go To or Call PARTS Rev. H 02/208 CPL Page of